Gardeners Orchard Rack User manual

0662V Rev 08/1438-221, 38-524
Orchard Rack
Years ago, people stored “keeper” crops such as apples, winter squash, onions and potatoes on rustic wooden racks just like
this one. The drawers are slatted to ensure good air circulation and they slide out for easy access. For best results, put the rack in
a cool, dark cellar or outbuilding. It’s good for drying herbs, too. These instructions are for use with the 6-drawer and 9-drawer
Orchard Rack.
Tools Needed
Drill with bits
Phillips screwdriver
Note: Assembly is easier with a second person to help.
Tip: Drill pilot holes before inserting screws to prevent wood
from splitting.
Parts Included
Crossbars
Drawers
Bracing
Slats
Sides
Screws, includes extra
Figure 1
Assembly
Identify and organize all parts of the Harvest Rack on a hard
and level surface. Tip: Cut open the shipping box and use it as a
cushioned work surface to protect the wood during assembly.
Step 1. Position the Sides (Part 1) upright with the legs on the
ground. Note: If assembling without a helper, it may be
easier to assemble the Orchard Rack with it lying on its back
or front for this step. Attach the Bracing Slats (Part 3) to the
top and bottom of each Side as shown in Figure 1. Tip: Drill
pilot holes before inserting screws to prevent wood from
splitting. Place the screws through the predrilled holes in the
Slats. Do not fully tighten. Be sure the top Bracing Slats are
flush with the top of the Sides.
Step 2. Slide a drawer into each compartment (Figure 2). This
will help to square up the Rack and keep it stable for the next
step.
Step 3. Stand the Rack up on its feet, if necessary. Adjust
the entire Rack to make sure it’s square. Connect the two
Crossbars (Part 2) to form an "X." Attach the end of each
Crossbar to the upper and lower corners at the back of the
Rack (Figure 2). Fully tighten all screws on the Crossbars and
the Rack. Important: Do not overtighten the screws. Over
tightening the screws may cause the wood to split. The
assembly is now finished.
Figure 2

Phone Orders: 1-800-427-3363 • Customer Service: 1-800-876-5520
e-mail: inf[email protected]om • Web: www.gardeners.com
Storage Tips
The best place for extended storage of fruits and vegetables is usually an unheated basement or outbuilding. Many fruits and
vegetables keep longest in an area that is well ventilated and dark, and that stays above freezing, but below 65 degrees in winter.
Different types of fruit and vegetables require different levels of temperature and humidity for proper storage. Follow these
tips and the chart below to keep your food fresh as long as possible.
• Store fruits and vegetables separately. Some fruits, including tomatoes, give off ethylene gas, which speeds the aging
process of other stored foods and will make some vegetables, such as carrots, bitter.
• Timing of harvest and preparing your fruits and vegetables for storage is very important. Harvest fruits or vegetables
when they are neither too ripe, or under ripe. Leave root vegetables in the ground as long as possible, then dig and store
when storage temperatures are likely to remain consistently cool. Thoroughly cure crops, such as squash, potatoes, sweet
potatoes, onions and garlic, before placing in storage.
• Place fruits or vegetables in a single layer on each shelf, preferably not touching one another. Fruits may be wrapped
individually with paper towels or a food-grade tissue paper. See the chart below for conditions required for storing some of
the most common garden vegetables and fruits.
• Keep the storage area dark. Light deteriorates some storage vegetables and encourages sprouting in potatoes. Use a shade
to keep out both light and heat coming through any windows in your storage area.
• Check your storage crops periodically and remove any decaying produce immediately to prevent it from spoiling
surrounding fruits and vegetables.
Drying Herbs in the Orchard Rack
To dry herbs, line each shelf with food-grade paper, such as cut-open paper grocery bags or parchment baking paper. Harvest
herbs when the foliage is dry. Place individual stalks, branches or leaves in a single layer on each shelf. Keep the Rack in a dry
location and out of direct sunlight. To speed up the drying process, aim a fan toward the rack to create a gentle air flow. Check
the herbs and turn them over every 2 or 3 days to encourage uniform dryness and shape. When dry, place the herbs in air-tight
containers for longer-term storage and use.
Recommended Storage Conditions
Cool and Moist Storage:
 •40to50degreesFahrenheit
 •85to90percentrelativehumidity
Cucumber, watermelon, eggplant (50 to 60 degrees F), green beans, sweet peppers (45 to 55 degrees F), ripe tomatoes.
Cold and Moist Storage:
 •32to40degreesFahrenheit
 •80to90percentrelativehumidity
Tomatoes, cabbage, cauliflower (short term), apples, grapes, pears, quince, grapefruit.
Cold and Very Moist Storage:
 •32to40degreesFahrenheit
 •90to95percentrelativehumidity
Beets, carrots, celery, turnips, winter radishes, broccoli (short term), hardy greens such as kale and collards; leeks.
Cool and Dry Storage:
 •32to50degreesFahrenheit
 •60to70percentrelativehumidity
Garlic, onions.
Warm and Dry Storage:
 •50to60degreesFahrenheit
 •60to70percentrelativehumidity
Pumpkins, winter squash, dry hot peppers, potatoes, sweet potatoes, green tomatoes.
Approximate Storage Times:
Beets (4-5 months) Potatoes (4-6 months)
Broccoli (1-2 weeks) Pumpkins (5-6 months)
Cabbage (3-4 months) Radishes (2-3 months)
Cauliflower (2-4 weeks) Squash (4-6 months)
Eggplant (1-2 weeks) Turnips (4-6 months)
Tomatoes (1-2 months)