Glen Dimplex Masport Geneva2 User manual

Distributed in Australia by
Glen Dimplex Australia Pty Limited
Unit 2, 205 Abbotts Road
Dandenong South, Victoria 3175
Phone: [phone] Fax: [phone]
Email: [e-mail]
Web: masportheating.com.au
Distributed in New Zealand by
Glen Dimplex Australasia
38 Harris Road, East Tamaki, Auckland
Phone: [phone] Fax: [phone]
Email: [e-mail]
Web: www.masportheating.co.nz
Revison 2 February 2008 Part No. 589016













 
- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the fire department.
Installation and service must be performed by a qualified installer, service agency or the
gas supplier.
WARNING: If the information in these instructions are not followed exactly, a fire or explosion
may result causing property damage and personal injury may result.

Masport Geneva2Owners Installation and Operation Manual
Page 2
Table Of Contents
Mail your warranty card TODAY, and SAVE your
RECEIPT. This card is included with the accessory
package inside each firebox.
In order to receive full warranty coverage and to
expedite service, Masport recommends that you
save your receipt and attach it to this page.
By doing this you will have all the necessary
information in the event that your stove may need
warranty service.
Your Masport gasfire serial number is located on the stove label inside the door on the left hand
side of the stove.
!

!!














"
!!# 

#!$% &
Description......................................................................................................Page #
Listing and Codes....................................................................................................................................................3
Copy of certification label ........................................................................................................................................4
Lighting Instructions ................................................................................................................................................5
Specifications..........................................................................................................................................................6
Warnings, Caution and Safety Notices....................................................................................................................7
Installation Instructions Safety.................................................................................................................................8
Planning Your Installation .........................................................................................................................8
Clearances To Combustibles....................................................................................................................9
Rear Vent—Snorkel Installation................................................................................................................9
Top Vent - Venting Diagrams.................................................................................................................10
Horizontal Termination Installation..........................................................................................................11
Vent Restrictor Use And Installation .......................................................................................................12
Vertical Termination Installation..............................................................................................................12
Basements Installations..........................................................................................................................12
Through Roof Termination ......................................................................................................................13
Seismic Restraint………………………………………………………………………………………………....14
45°Elbow Offset Information ..................................................................................................................14
Termination Location ..............................................................................................................................15
Gas Supply .............................................................................................................................................16
Aeration Adjustment................................................................................................................................17
Thermostat..............................................................................................................................................18
Logset Installation...................................................................................................................................18
Wiring Diagrams....................................................................................................................................................19
Operating Instructions Pre Check .........................................................................................................................20
Final Check.............................................................................................................................................21
Shut Down ..............................................................................................................................................21
Fan..........................................................................................................................................................22
Cold Weather Operation........................................................................................................................................22
Glass Cleaning—White Mineral Deposits..............................................................................................................22
Maintenance Gas Valve Replacement ..................................................................................................................23
Viewing Glass Replacement ...................................................................................................................24
Door........................................................................................................................................................24
Optional Conversion Kits.......................................................................................................................................25
Troubleshooting ....................................................................................................................................................26
Notes / Service History..........................................................................................................................................28

Masport Geneva2Owners Installation and Operation Manual
Page 3
The Masport gasfire Geneva2is listed and certified for installation in New Zealand under the following
standards:
- ANSI Z21.88b-2003/CSA 2.33b-2003, Vented Gas Fireplace Heater.
- CAN/CGA-2.17 M-91, Gas-Fired Appliances for Use at High Altitudes
- NZS5262:2003
- NZS 4553-3.5.1
Please contact Masport if you have any questions regarding the certification of this appliance.
This appliance, when installed must be electrically grounded in accordance with local codes
This appliance is for use only with the type of gas indicated on the rating plate. This appliance is not
convertible for use with other gases, unless a certified kit is used.
Thank you for purchasing a Masport gasfire and welcome to the Masport family. Your new Masport
gasfire will give you many hours of warmth and comfort. Please make sure you take a few minutes to
read this owner’s manual. It explains the steps required to safely assemble, install, operate, and maintain
your new appliance. Proper installation, operation and maintenance will keep your Masport gasfire
burning for years to come.
The Geneva2is one of the most advanced free standing gas stoves on the market. It is designed using
the latest technology and manufactured to our highest quality standards.
Some of the many features are:
♦ 
♦         
♦             
      
♦ !      
♦     "  
♦   #  Geneva2    $   
♦ %                      
♦ ! &     
♦    
Introduction
Listing & Codes

Masport Geneva2Owners Installation and Operation Manual
Page 4
Note: A copy of the certification label is provided here for your review. Due to constant up-
grades it is possible that the information shown here may not coincide with the label as at-
tached to the unit. In the event of a discrepancy between the labels, the label on the unit is con-
sidered as the correct one.

Masport Geneva2Owners Installation and Operation Manual
Page 5
Lighting Instructions

Masport Geneva2Owners Installation and Operation Manual
Page 6
Geneva2—Stove Dimensions
WIDTH 22” / 559mm
HEIGHT 29.5” / 749mm
DEPTH 18” / 457mm
MODEL Geneva2Natural Gas (NG) LPG
Manifold Pressure high 0.87 kPa 2.74 kPa
Manifold Pressure low 0.37 kPa 0.87 kPa
Min. Supply Pressure for
Purpose of Input Adjustment 1.2 kPa 3.0 kPa
Max. Supply Pressure for
Purpose of Input Adjustment 3.5 kPa 3.5 kPa
Orifice Size 37# DMS 53# DMS
Nominal Input Rating 29.5 MJ/h 28 MJ/h
Primary Air Opening 3mm (Minimum). 3mm (Minimum).
Electrical Rating 240 V.A.C. System 240 V.A.C. System
Circulating fan Variable Speed Variable Speed
Vent System 100 x 170 mm 100 x 170 mm
Specifications

Masport Geneva2Owners Installation and Operation Manual
Page 7
Safe installation and operation always require common sense.
INSTALLATION AND REPAIR SHOULD BE
DONE BY A QUALIFIED SERVICE PERSON.
THE APPLIANCE SHOULD BE INSPECTED
BEFORE USE AND AT LEAST ANNUALLY BY A
PROFESSIONAL SERVICE PERSON. MORE
FREQUENT CLEANING MAY BE REQUIRED
DUE TO EXCESSIVE LINT FROM CARPETING,
BEDDING MATERIAL, ETC...
IT IS IMPERATIVE THAT CONTROL
COMPARTMENTS, BURNERS AND
CIRCULATING AIR PASSAGEWAYS OF THE
APPLIANCE ARE KEPT CLEAN.
DUE TO HIGH TEMPERATURES, THE
APPLIANCE SHOULD BE LOCATED OUT OF
TRAFFIC AREAS AND AWAY FROM
FURNITURE AND DRAPERIES.
CHILDREN AND ADULTS SHOULD BE
ALERTED TO THE HAZARDS OF HIGH
SURFACE TEMPERATURES AND SHOULD
STAY AWAY TO AVOID BURNS OR
CLOTHING IGNITION.
YOUNG CHILDREN SHOULD BE CAREFULLY
SUPERVISED WHEN THEY ARE IN THE SAME
ROOM AS THE APPLIANCE .
CLOTHING OR OTHER FLAMMABLE
MATERIALS SHOULD NOT BE PLACED ON
OR NEAR THE APPLIANCE.
THE FLEXIBLE CORD PROVIDED MUST BE
CONNECTED TO A LINE VOLTAGE
ELECTRICAL SUPPLY.
ANY SAFETY SCREEN OR GUARD REMOVED
FOR SERVICING A ROOM HEATER MUST BE
REPLACED PRIOR TO OPERATING THE
APPLIANCE.
NEVER VENT THE APPLIANCE INTO OTHER
ROOMS OR BUILDINGS. THE APPLIANCE
MUST BE VENTED TO THE OUTSIDE ONLY.
THIS APPLIANCE MUST NOT BE CONNECTED
TO A CHIMNEY FLUE SERVING A SEPARATE
SOLID-FUEL BURNING APPLIANCE.
DO NOT USE THIS HEATER IF ANY PART HAS
BEEN UNDER WATER. IMMEDIATELY CALL A
QUALIFIED SERVICE TECHNICIAN TO
INSPECT THE HEATER AND TO REPLACE ANY
PART OF THE CONTROL SYSTEM AND ANY
GAS CONTROL WHICH HAS BEEN UNDER
WATER.
Warnings—Caution
IF THIS APPLIANCE IS NOT PROPERLY INSTALLED, A HOUSE FIRE OR EXPLOSION MAY
RESULT. FOR YOUR SAFETY, FOLLOW THE INSTALLATION DIRECTIONS. CONTACT LOCAL
BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION REQUIREMENTS IN
YOUR AREA. PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE YOUR
NEW APPLIANCE. FAILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR DEATH.
“WARNING” Do not operate appliance with
the glass front removed, cracked or
broken. Replacement of the glass should
be done by a licensed or qualified service
person.
Natural gas & LPG gas have odor additives for the
purpose of leak detection through smell. This odor
can fade with time. If the odor is reduced, it is possi-
ble to have a dangerous buildup of gas without your
being able to smell it. If you are using any gas appli-
ances in your home the manufacturer recommends
that you have one or more UL approved gas detec-
tors installed in your home. They should be in-
stalled by a qualified gas installer for safety pur-
poses.

Masport Geneva2Owners Installation and Operation Manual
Page 8
IMPORTANT: All clearances listed are the
MINIMUM required and must be strictly
followed.
This appliance is certified for installation on a
solid combustible surface, such as a wood floor,
vinyl or carpeting.
The following pages provide diagrams for safe
clearances to combustibles.
•
••
• To clean the stove, make sure the appliance
is off and cold. Remove the logs and embers.
The logs must be handled with extreme
care, they are fragile. Use a vacuum to
clean burner and air openings in the bottom
and back of the appliance. Carefully replace
the logs and embers.
• Fire Extinguisher: Every home should have at
least one fire extinguisher. An approved
Class A-B-C extinguisher should be mounted
on the wall near an exit and close to the
appliance, but not so close that accessibility
to the extinguisher could be blocked by a
fire. Your local Fire Department can advise
you concerning the most appropriate location.
•
••
• Smoke Detectors & Carbon Monoxide
Detectors: Install at least one smoke detector
on each floor of your home to ensure your
safety. It should be located away from the
gas appliance and close to the sleeping
areas. Follow the smoke detector
manufacturers placement installation and
maintenance instructions. Your local Fire
Department may provide assistance in
selecting smoke detectors and CO-detectors.
It is strongly recommended, for your family’s
protection, that a CO-detector be placed in all
homes that utilize gas in any form.
• The appliance vent should be enclosed when
installed in or passing through a living area,
where children may come in contact with it.
• Only vent terminations specified may be used
with this stove.
• Venting terminals shall not be recessed into a
wall or siding.
1) Wear gloves and safety glasses for
protection.
2) Exercise extreme caution when using ladders
or when on roof tops.
3) Be aware of electric wiring locations in walls
and ceilings.
4) Use a back support when doing any
heavy lifting.
GENERAL SAFETY (HOMEOWNER) VENTING SAFETY
Please note the following key points
regarding the location of your appliance:
• A sufficient gas pressure is required to supply
the unit with a minimum inlet pressure
• Allow adequate accessibility clearances for
servicing and proper operation.
• Allow adequate clearance to combustibles.
• Consider the termination location.
• A suitable power outlet is required to provide
power to the fan.
PLANNING YOUR INSTALLATION
CLEARANCES TO COMBUSTIBLES
Installation Instructions—Safety
FOR THE INSTALLER
Ensure, as in any installation, that structural
members are not cut or weakened during
installation .
When installing the appliance in a mobile or
manufactured home, it must be securely
anchored to the floor by means of the anchor
provided in the mobile home kit. Also ensure
that proper grounding is provided by using a
#8 grounding lug, wire and a star washer.

Masport Geneva2Owners Installation and Operation Manual
Page 9
CLEARANCES TO COMBUSTIBLES
Minimum clearances listed above must be
maintained. Also ensure that you have left
clearance for servicing and that that the proposed
termination location is correct.
LOCATING YOUR STOVE
IMPORTANT: This appliance's venting system
is room sealed, which means that there should
be no provision to allow room air to be used in
the combustion process.
VENTING
Note: Only approved venting systems may
be used with the Geneva2.
PLANNING YOUR VENT INSTALLATION
This type of direct vent system may terminate in
one of two ways: Vertical termination using a
vent cap, or Horizontally using a wall termination.
There are limitations to the vertical and/or
horizontal lengths. When calculating the length
of the vent pipe from the outlet of the appliance
to termination, allow for ceiling thickness,
vertical rise in the attic or second story and
sufficient vertical height above the roof.
Fire stops are required at each floor level the
vent passes through.
When carrying out vertical installations that
require 45° elbows add additional pipe to allow
for the offset.
Installation Instructions
MODEL Geneva2
A Side Wall to unit side 275mm
B Back wall to unit back 100mm
C Corner to side wall 50mm
REAR VENT—SNORKEL TERMINATION
'()('*'+,%#(-%(, ./ 0
'1('*'!2%(3 2)#-%*) 4005   ./ 0 
26/ 7     

(   400&
./ 0 
400
./ 0 
#
   
8  
9-
 :/ 08  
 ' 
 
                                    
                                  
/ 0 (&
 *&
  
                                 
                   

Masport Geneva2Owners Installation and Operation Manual
Page 10

Masport Geneva2Owners Installation and Operation Manual
Page 11
        8    5 
                 

   !                           "             "                           
#  
WARNING: A minimum clearance of 50mm to combustibles must be maintained around
the vent pipe on horizontal pipe runs and 25mm on vertical runs.
Installation Instructions
          
'                     .  
;00   $      ,"  .   $     8     
" 40
)2#,<--25()#!,+,)#=(=,#2-2=,>25)#25%>#!,+,)#
#,%'()#(2) 2*-> *, =22% 2'?*#(2) )>92% !(!
#,'=,%#*%, #!# '@ =%,,)#  A(%, !3 %> '   :/ 0 " 
:/ 08      
  "      (
            (         
   &      ;B 0         
Horizontal Wall Vent Terminations
#   $         ;/ 

C
L
C
L
Center of
hole
250mm square
        
      5             
            
   ? 
                     
  "      
    ,                    
 8  
(           &
 #   8  / C0;C0; )/ :C;

Masport Geneva2Owners Installation and Operation Manual
Page 12
Vent Restrictors
>  "   
                  
     
          
  # 
      
$  5    
8        
   
      
  = 
      
       
 
100mm Collar attached to unit
Restrictor
?               
       
   

                  
:/        
                   
 
Vertical Installations
     :/         
                 
     
>2)2#=D(%=,5(#!()*-#(2)
%         "        
 $ 
5    
       @ 
      6/ 7             
5       ?" 95  
 :/ 08       


Basement Installations
#     ./ 0400 
  5       
    8   
Drainage
Minimum 300mm
NOTE: ALWAYS CHECK YOUR LOCAL CODES
BEFORE INSTALLING VENTING. NECESSARY
CLEARANCES AND REQUIRMENTS MAY VARY
Installation Instructions
Restrictor Sizes

Masport Geneva2Owners Installation and Operation Manual
Page 13
Through Roof Framing
Maintain 250mm opening relative to the pitch
of the roof.
250mm square
Use a suitable round or square support
through the roof. Ensure adequate heat
shield protection is provided.
Consult local codes for minimum vent cap height
above the roof, vent must be a minimum 50mm
from any wall.
Termination Above Roof
To prevent water seepage install the flashing
with upper portion slid under the roofing material
and the lower portion over the roofing material.
Note: Do not fasten down until the final
adjustments to the vent have been made.
Installation Instructions

Masport Geneva2Owners Installation and Operation Manual
Page 14
Offset
Height
L
Offset Chart
Offset chart for 45°Elbows
Offset Pipe Length
(L)
                          
6.96 ;:; 0 0 ;.;96 ..E
4 ::4 C ;/ : ;E;9: 66/ 
;;;96 :B C 4 ::4 ;4;9: 64/ 
;.;96 ..E ;: .0/  :;.96 / / :
:;.96 / / : :6 C;0 .0;96 ECB 
.0;96 ECB  .C 4;6 .4 44;
.B  4C/  6B  ;:;4 6E ;;46
Height
Typical vent Installation
!   +
#
F 44;
A  
#  
G 
5  
&
6/ 7 
8   
 
Installation Instructions
Seismic Restraint
New Zealand Regulations require that flued gas heaters be secured to prevent shifting in
the event of an earthquake. This is done by fastening the heater to the floor right through
the floor protector if one is fitted. Fasten with two screws not less than 6mm diameter.

Masport Geneva2Owners Installation and Operation Manual
Page 15

Masport Geneva2Owners Installation and Operation Manual
Page 16
EXISTING GAS SUPPLY
?   "           

♦         "    
♦ ?                
      #      
 H   
♦                
♦    $          
= 8       
!    8        #   
$   #       &
     
5      "   ./   =               &       
            5      8        ./   =  
             &  A 
             H      $                             
        %      

        &    &   
           
#             ;:6  =       .00  =  -= '"    
     " ./  =    -=

' ( $ ) * ( + , + &- . + (  + . ( / * ( $ $ ) * ( + ! / $ ( + 0$  * ( 1 !  + ( *  . (  2 & - + . ( / * ( $ $ ) * (  . (  2 ! 3 3 
- ! $  ,   (  + &,  $  , * - ! $ 3 ( ! 2 $ 
GAS SUPPLY INSTALLATION
Installation Instructions (Gas Supply)
,  3 4 / ( * $ ,  $ 3 & (  $ ( 5 + , 1 , * 2 1 &+ . - ! $ / &/ & - 6 ! 4 6 ! 2 ( + . (  (  ( $ $ ! * 4 - ! $  ,   (  + &,  
+ , + . &$ ! / / 3 &!   ( 4 , ) ! * (  , 1 * ( ! 5 4 + , . , , 2 ) / + . ( - ! $ $ ) / / 3 4 ' ( $ ) * ( - ! $ / 3 ) 6 ' & - 
& $ + * )  + &,  $  !  5  ! 3 3  $ + ! + ( 7/ * , 8 &  &! 3  !  5  3 ,  ! 3   , 5 ( $  ! * (   ! * (  ) 3 3 4   , 3 3 , 1 ( 5  ) $ ( 
! / / * , 8 ( 5   3 ( 9 &' 3 (  - ! $   ,   (  + &,  $ , *  * &- &5  / &/ & -  5 ( / (  5 & -  ,   / * , 8 &  &! 3  !  5  3 ,  ! 3 
 , 5 ( $  + ,  ! + + !  .  ' ) *  ( *  + ,  - ! $  $ ) / / 3 4   ' (  $ ) * (  + ,  ) $ (  / * , / ( *  $ &: (  - ! $  $ ) / / 3 4  3 & ( 
 ! * (  ) 3 3 4  . (  2 ! 3 3  ,   (  + &,  $  , * - ! $ 3 ( ! 2 $ 1 &+ . $ , ! / !  5 1 ! + ( * $ , 3 ) + &,  
( !  .  & $ + ! 3 3 ! + &,   6 ) $ +   ,   , * 6  + ,  ! 3 3  3 ,  ! 3  $ + ! + ( 7/ * , 8 &  &! 3  !  5   ! + &,  ! 3   , 5 ( $ 
* (  ( * + , + . (  ! + &,  ! 3  ) ( 3 - ! $  , 5 ( 3 ,  ! 3 : ,  & - !  5  , 5 ( ! ) + . , * &+ &( $  , * 5 ( + ! &3 $ ,  
& $ + ! 3 3 ! + &,  * ( ; ) &* ( 6 (  + $ 
Pedestal Cover Removal
#          #  
   6           
  #  8        5       
    5          
                                 # 
 6   

Masport Geneva2Owners Installation and Operation Manual
Page 17
IMPORTANT: Always check for gas leaks with soap and water solution or gas leak detector.
Do not use open flame for leak detection.

)  ' ;:6 '"  ./ 0 
-= ' .00 '"  ./ 0 
- ! $ $ ) / / 3 4 / * ( $ $ ) * ( 
Installation Instructions
&6 / , * + !  +  !        #                      
            " "               "         
                                       #    
            , +                  
)<   
      
FACTORY SETTING
Natural Gas 3.0 mm Open
LP GAS 3.0 mm Open
CAUTION: Parts requiring adjustment
during operation may be hot.
Open -Soft blue flame Closed - tall yellow flame
!  #         <                = >
      

• %     
• - % 8     
        
•       
#      

• #   %      
• % 
AERATION ADJUSTMENTPIPING DETAIL
-           
♦ 

♦ #   ;9:I#  
   "  9
     9 
♦ A 8  )3 / :C;
♦ =             &
               
  
Flame Picture

Masport Geneva2Owners Installation and Operation Manual
Page 18
Installation Instructions
              
 A             ( 
           "   
%               
'      
               
OPTIONAL REMOTE
Note: When installing a remote control or
wall switch use the correct gauge of wire.
See table below.
Wire Size Max. Length
2.0mm 15m
1.6mm 10m
1.0mm 6m
0.9mm 4m
0.7mm 3m
See wiring diagrams for details on valve
connections.
 ! ) + &,  ,           " "                
                   " "      +          6 ) $ +    
                      
1 ! *  & -  5          "                       
           "           " "           &
                    "                    
 "     
# 'Geneva2     
- 
&                    
;=       , 
        
:-      
 
LOGSET INSTALLATIONTHERMOSTAT
WARNING: The gas valve of this appliance
operates on a millivolt system and is not
intended to be connected to any other
power source.
( 8            '
          *-  *-  
:/ 0&E/ 0 & 
  
(            
  
WARNING
Electrical Grounding Instructions
This appliance is equipped with a three prong (grounding)
plug for your protection against shock hazard and should be
plugged directly into a properly grounded three prong
receptacle . Do not cut or remove the grounding prong from this
plug.
Back Log
Front Log
Front Log
Pins

Masport Geneva2Owners Installation and Operation Manual
Page 19
240 VOLT CIRCUIT
Snap Disc
MILLIVOLT CIRCUIT
Chordset
Ground
Blower Control
Circulation Fan
,                "       3           "                                  1   
                                   
Wiring Diagrams
Pilot Assembly
Thermocouple Thermopile
Pilot Gas Line
Thermostat leads or leads to
optional remote thermostat
Thermostat
On/Off Rocker
Switch
TH
THTP
TP
Honeywell Gas Valve

Masport Geneva2Owners Installation and Operation Manual
Page 20
Pre– Start Up Checks
FOR YOUR SAFETY READ - BEFORE LIGHTING
WARNING
IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUSING PROPERTY AND/OR PERSONAL INJURY
DO NOT: Use tools to operate controls, only use your hand to push in and turn the controls.
DO NOT: Try to repair the appliance. Call a qualified service technician.
DO NOT: Use this appliance if any part has been under water. Immediately call a qualified
service technician to inspect the appliance and replace any part of the gas control
system which has been under water.
DO NOT: Use this appliance if you smell gas.
WHAT TO DO IF YOU SMELL GAS:
♦ OPEN WINDOWS.
♦ DO NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE THE PHONE IN YOUR
BUILDING.
♦ EXTINGUISH ANY OPEN FLAME.
♦ IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR’S PHONE AND
FOLLOW THE GAS SUPPLIER’S INSTRUCTIONS.
♦ IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.
Operating Instructions
WARNING—Do not operate appliance with the viewing glass
removed, cracked or broken. Viewing glass must be replaced /
repaired by MASPORT . For replacement please contact your local
dealer or Masport to make arrangements to have your viewing glass
replaced / repaired. Glass breakage due to slamming the viewing
door or abusing your unit, is not covered under warranty.