GORMAN-RUPP PUMPS PRIME-AIRE Series User manual

PUBLICATION NUMBER PL−04914−01
August 10, 1998
Use With: OM−04402
MR−04835
THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
PRIME-AIRETM SERIES
PUMP MODEL
PA4B60−4045T

The engine exhaust from this
product contains chemicals
known to the State of California to
cause cancer, birth defects or
other reproductive harm.

PL−04914 PA SERIES PUMP
PAGE A − 1PARTS LIST MANUAL
PERFORMANCE CURVE − SECTION A
RECORDING MODEL AND
SERIAL NUMBERS
Please record the pump model and serial number
in the spaces provided below and in the separate
Installation/Operation Manual accompanying your
pump. Your Gorman-Rupp distributor needs this
information when you require parts or service.
Pump Model:
Serial Number:
WARRANTY INFORMATION
The pump warranty is provided as part of
Gorman-Rupp’s support program for customers
who operate and maintain their equipment as
described in this manual and other accompanying
literature. Please note that should the equipment
be abused or modified to change its performance
beyond the original factory specifications, the war-
ranty will become void and any claim will be de-
nied.
PERFORMANCE CURVE
The performance curve on the following page is
based on 70 F (21 C) clear water at sea level,
corrected to 0.80 specific gravity, with minimum
suction lift. Since pump installations are seldom
identical, your performance may be different due
to such factors as viscosity, specific gravity, eleva-
tion, temperature, and impeller trim.
If your pump serial number is followed by an N",
your pump is NOT a standard production model.
Contact the Gorman-Rupp Company to verify per-
formance or part numbers.
Pump speed and operating condition
points must be within the continuous per-
formance range shown on the curve.

PA SERIES PUMP PL−04914
PAGE A − 2 PART LIST MANUAL
Performance Curve − Model PA4B60−4045T

PL−04914 PA SERIES PUMP
PAGE A − 3PARTS LIST MANUAL
This Page Intentionally Blank

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
1 of 11
Page 64.4 B5
08/10/98
ACDE
PARTSPAGE
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1

ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY
THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
2 of 11
Page 64.4 B5
08/10/98
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
ACDE
PARTS LIST
Pump Model PA4B60−4045T
If your pump serial number is followed by an N", your pump is NOT a standard production model. Contact the
Gorman-Rupp Company to verify part numbers.
1 PUMP END ASSEMBLY PA4B60−(SAE 4/10) 1
2 J D 4045T ENGINE 292224−114 −−− 1
3 REDUCER BUSHING AP1208 15079 1
4 MALE CONNECTOR 26525−020 −−− 2
5 4’ X 1/2" HOSE 18513−113 −−− 1
6 HOISTING BAIL 44714−049 −−− 1
7 POS BATTERY CABLE 47311−137 −−− 1
8 BATTERY BOX ASSY GRP40−08C −−− 1
9 −HEX HD CAPSCREW B0607 15991 2
10 −FLAT WASHER K06 15991 2
11 −FLANGED HEX NUT 21765−314 −−− 2
12 −GRND CABLE ASSY 47311−064 −−− 1
13 −BATTERY BOX LID 42113−012 24150 1
14 −12V BATTERY SEE OPTIONS LIST
15 −BATTERY TAG 38818−506 −−− 1
16 −BATTERY BOX 42431−030 −−− 1
17 −STUD MOUNT 24631−006 −−− 4
18 −FLANGED HEX NUT 21765−314 −−− 8
19 SKID ASSY 41565−577 24150 1
20 CARRIAGE BOLT AB0807 15991 8
21 HEX NUT D08 15991 8
22 LOCKWASHER J08 15991 8
23 FLAT WASHER K08 15991 8
24 HEX HD CAPSCREW B1006 15991 4
25 HEX NUT D10 15991 4
26 LOCKWASHER J10 15991 4
27 FLAT WASHER K10 15991 4
28 CABLE CLAMP 27111−346 −−− 1
29 HEX HD CAPSCREW B#10−03 15991 1
30 HEX NUT D#10 15991 1
31 LOCKWASHER J#10 15991 1
32 HEX HD CAPSCREW B1008 15991 8
33 HEX NUT D10 15991 8
34 LOCKWASHER J10 15991 8
35 FLAT WASHER K10 15991 16
36 FUEL TANK ASSY 46711−081 −−− 1
37 PIPE UNION AH08 11999 1
38 VENTURI 26817−002 −−− 1
39 45ELBOW AG08 11999 1
40 HOSE BARB 26525−021 −−− 1
41 REDUCER BUSHING AP0806 15079 1
42 PIPE TEE U08 11999 1
43 RELIEF VALVE 26662−028 −−− 1
44 MALE ADAPTOR 26351−065 −−− 1
45 HOSE ASSY 46341−422 −−− 1
46 SUPPORT 34534−025 15120 1
47 HEX HD CAPSCREW B0605 15991 2
48 HEX NUT D06 15991 2
49 LOCKWASHER J06 15991 2
50 FLAT WSHER K06 15991 2
51 PIPE ELBOW R08 11999 1
52 HOSE BARB 26525−020 −−− 1
53 CABLE CLAMP 27111−346 −−− 1
54 HEX HD CAPSCREW B#10−03 15991 1
55 HEX NUT D#10 15991 1
56 LOCKWASHER J#10 15991 1
57 5/8" x 1 1/4’ HOSE 18513−304 −−− 1
58 HEX HD CAPSCREW B1008 15991 2
59 HEX NUT D10 15991 2
60 LOCKWASHER J10 15991 2
61 FLAT WASHER K10 15991 2
62 DISCHARGE FLANGE 1756 10010 1
63 DISCH FLANGE GSKT 1676G 18000 1
64 HEX HD CAPSCREW B1012 15991 8
65 HEX NUT D10 15991 8
66 LOCKWASHER J10 15991 8
67 PRIMING CHAMBER BRKT 34535−010 15120 1
68 HEX HD CAPSCREW B0604 15991 3
69 HEX NUT D06 15991 3
70 LOCKWASHER J06 15991 3
71 FLAT WASHER K06 ‘15991 3
72 SUCTION FLANGE 1758 10010 1
73 SUCT FLANGE GSKT 1679G 18000 1
74 HEX HD CAPSCREW B1212 15991 8
75 HEX NUT D12 15991 8
76 LOCKWASHER J12 15991 8
77 HOSE BARB FITTING 26523−386 −−− 2
78 3’ TUBING 18523−366 −−− 1
79 HOSE CLAMP 26518−641 −−− 2
80 HOSE ASSY 46341−801 −−− 1
81 MALE CONNECTOR S1447 −−− 1
NOT SHOWN:
INSTRUCTION DECAL 38818−128 −−− 1
WARNING DECAL 38816−132 −−− 2
LUBE DECAL 38816−075 −−− 1
WARNING DECAL 38816−096 −−− 1
SUCTION STICKER 6588AG −−− 1
DISCHARGE STICKER 6588BJ −−− 1
LIFT DECAL 38816−175 −−− 1
LIFT DECAL 38816−218 −−− 2
PRIME-AIRE DECAL 38812−078 −−− 2
WARNING DECAL 2613FE −−− 1
RPM DECAL 2613FJ −−− 1
ENG START-UP TAG 38816−269 −−− 1
INSTR TAG PAPER 38817−017 −−− 1
NAME PLATE 38818−127 13000 1
DRIVE SCREW BM#04−03 17000 4
STRAINER S1529 −−− 1
OPTIONAL:
12V BATTERY 29331−506 −−− 1
INDICATES PARTS RECOMMENDED FOR STOCK

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
3 of 11
Page 64.4 B5
08/10/98
ACDE PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
4 of 11
Page 64.4 B5
08/10/98
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
ACDE
PARTS LIST
PA4B60−4045T Pump Assembly
ITEM
NO. PART NAME PART NUMBER
MAT’L
CODE QTY
1 PUMP END ASSY 64B60−(SAE4/10) −−− 1
2PUMP CASING GSKT 1679G 18000 1
3 STUD C1211 15991 8
4 HEX NUT D12 15991 8
5 LOCKWASHER J12 15991 8
6 CHECK VALVE ASSY 26642−124 −−− 1
−FLAPPER 26688−001 −−− 1
−COVER GASKET 26688−002 −−− 1
7 DISCHARGE FLANGE GSKT 1676G 18000 1
8 HEX HD CAPSCREW B1010 15991 6
9 HEX NUT D10 15991 6
10 LOCKWASHER J10 15991 6
11 PRIMING CHAMBER ASSY 46112−703 −−− 1
INDICATES PARTS RECOMMENDED FOR STOCK

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
5 of 11
Page 64.4 B5
08/10/98
ACDE PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1

ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY
THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
6 of 11
Page 64.4 B5
08/10/98
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
ACDE
PARTS LIST
64B60−(SAE4/10) Pump End Assembly
1 PUMP CASING 38218−017 10000 1
2IMPELLER ASSY 38628−547 10010 1
3SEAL ASSY 46512−048 −−− 1
4 PIPE PLUG P06 15079 1
5CASING GASKET SET 38684−502 18000 1
6 AIR VENT S1703 −−− 1
7 RED PIPE BUSHING AP1206 15079 1
8 SIGHT GAUGE S1471 −−− 1
9BRG ADJ SHIM SET 8548 15990 1
10 LUBE FITTING S194 −−− 1
11 CAP PLUG 25141−151 −−− 1
12 INTERMEDIATE 38264−703 10000 1
13 DRIVE ASSEMBLY 44162−119 −−− 1
14 SHAFT KEY N0608 15990 1
15 IMPELLER SHAFT 38515−585 1706H 1
16 PILOT BUSHING 8312A 15010 1
17 INTERMEDIATE GSKT 38683−446 18000 1
18 HEX HD CAPSCREW B0606 15991 3
19 LOCKWASHER J06 15991 3
20 RETAINING RING 24121−080 −−− 1
21 OIL CHAMBER PLATE 31255−009 15080 1
22 OIL CHMBR PLT O-RING 25152−278 −−− 1
23 BEARING RETAINER 38322−526 10000 1
24 RETAINING RING S720 −−− 1
25 DBL ROLLER BEARING 23421−414 −−− 1
26 RETAINING RING S720 −−− 1
27 OIL CVTY DRAIN PLUG P12 15079 1
28 OIL SEAL 25227−773 −−− 1
29 STUD C1009 15991 4
30 HEX NUT D10 15991 4
31 LOCKWASHER J10 15991 4
32 CASING DRAIN PLUG P06 15079 1
33 STUD C1009 15991 16
34 HEXNUT D10 15991 16
35 BALANCE RING 64H6 14000 1
36 WEAR RING 64H5 14000 1
37 FLAT WASHER K14 15991 1
38 NYLON LOCKNUT BC14S 15991 1
39 HEX HD CAPSCREW B0604 15991 2
40 IMPELLER KEY N0608 15990 1
41 PIPE PLUG P04 15079 1
42 SUCTION STICKER 6588AG −−− 1
43 SUCTION HEAD 38247−418 10000 1
44 SUCTION HEAD GSKT 7557G 18000 1
45 SHAFT SLEEVE 31163−018 17060 1
46 SHAFT SLEEVE O-RING 25152−026 −−− 1
47 SPRING HOLDER 31167−023 15000 1
48 IMP SHIM SET 5091 17090 1
NOT SHOWN:
OIL LEVEL DECAL 38816−123 −−− 1
STRAINER S1529 −−− 1
DRIVE SCREW BM#04−03 17000 2
NAME PLATE 38818−127 13990 1
DISCHARGE STICKER 6588BJ −−− 1
INDICATES PARTS RECOMMENDED FOR STOCK

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
7 of 11
Page 64.4 B5
08/10/98
ACDE PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
VALVE DETAIL
SEE VALVE DETAIL

ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY ITEM
NO.
PART NAME PART
NUMBER
MAT’L
CODE
QTY
THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
8 of 11
Page 64.4 B5
08/10/98
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
ACDE
PARTS LIST
46112−703 Peeler Type Priming Valve
1 PRIMING CHAMBER LID 38346−613 13000 1
2 PEELER VALVE NECK 38349−410 10000 1
3 LOCKWASHER J#10 17000 4
4 HEX NUT D#10 17000 4
5 STUD 21332−038 −−− 4
6NECK GASKET 38683−266 19020 1
7 VALVE BODY 38343−014 14000 1
8GASKET STRIP 4.06’ LG 18515−031 −−− 1
9 STUD C0406 1/2 17000 2
10 HEX LOCK NUT BC04 17000 2
11 HEX HD CAPSCREW B0403 17000 4
12 LOCKWASHER J04 17000 4
13 INDUCTOR GUARD ASSY 42381−066 24150 1
14 HEX HD CAPSCREW B0605 15991 4
15 LOCKWASHER J06 15991 4
16 CHAMBER GSKT 38687−552 18000 1
17 PRIMING VALVE FLOAT 38349−404 19220 1
18 PRIMING CHAMBER 38343−017 10000 1
19 GUIDE PLATE 33522−009 17000 2
20 FLAT HD CAPSCREW F#10−03 17000 6
21 LOCKWASHER J#10 17000 6
22 HEX NUT D#10 17000 6
23 VLV STRAP BRKT ASSY 41881−523 2415X 1
24 CLAMP PLATE 38349−406 14000 1
25 VALVE STRAP 33276−041 19000 1
26 CHECK VALVE ASSY 46411−112 −−− 1
27 −CHECK VALVE 38671−413 19020 1
28 −LOCKWASHER J#10 17000 1
29 −HEX NUT D#10 17000 1
30 −FLATWASHER 21161−810 −−− 1
31 −HEX HD CAPSCREW B#10−02 17000 1
32 −FLATWASHER 21161−811 −−− 1
33 −SEALING WASHER S1590 −−− 1
34 VLV STRAP PROTECTOR 33271−019 19000 2
NOT SHOWN:
HEX HD CAPSCREW B0807 15991 4
PIPE PLUG P04 15079 1
INDICATES PARTS RECOMMENDED FOR STOCK

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
9 of 11
Page 64.4 B5
08/10/98
ACDE PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
10 of 11
Page 64.4 B5
08/10/98
PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
ACDE
PARTS LIST
46181−903 Air Compressor Assembly
ITEM
NO. PART NAME PART NUMBER
MAT’L
CODE QTY
1 AIR COMPRESSOR MOUNTING PLATE 41881−584 −−− 1
2 MACHINE SCREW X#10−02 15991 4
3 HEX NUT D#10 15991 4
4 LOCKWASHER J#10 15991 4
5 FLAT WASHER K#10 15991 4
6 AIR COMPRESSOR COVER 38354−043 15120 1
7 ATLAS COPCO AIR COMPRESSOR 26813−111 −−− 1
8 SHEAVE 24226−003 −−− 1
9 BUSHING 24131−611 −−− 1
10 CAPSCREW 22645−164 −−− 3
11 SHAFT EXTENSION 31412−070 15000 1
12 PULLEY KEY 24113−601 −−− 1
13 PIPE CAP V06 15079 1
14 PIPE NIPPLE T0616 15079 1
15 STREET ELBOW RS06 11999 1
16 HEX NUT D06 15991 4
17 LOCKWASHER J06 15991 4
18 FLAT WASHER K06 15991 4
19 MALE ADAPTOR 25812−243 −−− 1
20 PUSHLOK ELBOW 26523−035 −−− 1
21 AIR COMPRESSOR KNOB 38429−501 19220 1

THE GORMAN-RUPP COMPANY MANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED ST. THOMAS, ONTARIO, CANADA Printed in U.S.A.
Copyright by the Gorman-Rupp Company
11 of 11
Page 64.4 B5
08/10/98
ACDE PA4B60−4045T
S/N 1149679 Up
PUMP ISSUE 1
44162−119 Drive Assembly
ITEM
NO. PART NAME PART NUMBER
MAT’L
CODE QTY
1 COUPLING KIT 48112−001 −−− 1
2 −BUSHING 24131−345 −−− 1
3 −COUPLING ASSY 44165−011 −−− 1
4 −LOCKWASHER 21171−536 −−− 8
5 −SOCKET HD CAPSCREW B0606 1/2 15991 8
6 HEX HD CAPSCREW B0605 15991 12
7 LOCKWASHER J06 15991 12

For U.S. and International Warranty Information,
Please Visit www.grpumps.com/warranty
or call:
U.S.: 419−755−1280
International: +1−419−755−1352
For Canadian Warranty Information,
Please Visit www.grcanada.com/warranty
or call:
519−631−2870
THE GORMAN-RUPP COMPANY DMANSFIELD, OHIO
GORMAN-RUPP OF CANADA LIMITED DST. THOMAS, ONTARIO, CANADA