hestan ASPIRE AEB Series User manual
OUTDOOR KITCHENS
by
Warranties documentation
Aspire Double Side Burner���������������������������������������������������������������������������������������������������������������������������������� 13
Aspire Built-In Grill�������������������������������������������������������������������������������������������������������������������������������������������������� 44
Aspire Undercounter Refrigerator ������������������������������������������������������������������������������������������������������������������ 83
DEKTON warranty�������������������������������������������������������������������������������������������������������������������������� 06
Aspire by Hestan warranty
Urban Bonfire warranty���������������������������������������������������������������������������������������������������������������� 03
TABLE OF CONTENT
Warranty
Dekton
25 Years
DEKTON ® LIMITED 25-YEAR
TRANSFERRABLE RESIDENTIAL
WARRANTY
Subject to the terms and conditions contained
herein, Cosentino, S.A.U. (“Cosentino”) warrants to
the purchaser and residential owner-occupants of
installed Dekton® Ultracompact surfaces (“Dekton®
Surfaces”) that for a period of twenty-five (25) years
from the date of purchase of the Dekton® Surfaces
in the original customer’s residence, that the
Dekton® material will be free from manufacturing
defects and perform in service when properly
installed and maintained.
If a manufacturing defect occurs during the warranty
period, Cosentino will at its option, repair or replace
the defective Dekton® Surfaces.
This warranty is limited to the purchaser of Dekton®
Surfaces and is transferrable. This warranty is
valid only if the original purchaser of the installed
Dekton® Surfaces has registered the warranty within
6 months of purchasing of the Dekton® Surface, as
indicated below, and when said consumer submits
the original invoice or sales receipt (indicating
the purchase date and name of the dealer of the
Dekton® product).
The 25-year period established in this Letter of
Warranty is only applicable to those products that
are sold and registered aer 1 November 2018.
WHAT THIS LIMITED 25-YEAR
WARRANTY COVERS
• This limited warranty covers Dekton® Surfaces that
have been purchased from an Authorized Dekton®
Installer or Dealer (“Authorized Installer”) and
have been permanently installed in the original
purchaser’s residence by an Authorized Installer.
• Cosentino may repair or replace the defective
Dekton® product within the 25-year warranty
period, but such replacement products must
contain the same characteristics (same color,
thickness, etc.) as the defected products
purchased by the original consumer. Should this
product be discontinued or unavailable for any
reason, then the defected product will be replaced
by Dekton® product with similar characteristics.
• Subject to the limitations stated herein, this, this
limited warranty covers products that have been
maintained according to the Dekton® Surfaces Care
and Maintenance and set forth on www.cosentino.
com
• Cracking due to exposure to extreme hot and cold
temperatures, and cracking due to thermal shock.
• Staining against most common food, beverage,
and household products provided customers follow
proper care and maintenance guidelines.
• Fading due to exposure to direct Ultra Violet (UV)
sunlight in both indoor and outdoor applications.
• This warranty covers Dekton® products that are
applied to barbecues, chimneys, or any surface
where heat may be applied, conditional upon strict
adherence to the applicable installation manuals
found on www.cosentino.com.
• The Dekton XGloss® series are ultra-polished, high-
tech, ultra-compact surfaces with a crystalline
shine which require greater care due to their
high-gloss finish. In particular, the Dekton XGloss®
requires periodic maintenance and cleaning.
Please refer to the applicable Dekton® Cleaning
and Maintenance Guide, found on www.cosentino.
com for specific guidance on how to care for the
Dekton XGloss® products. This warranty only
covers Dekton XGloss® surfaces that have been
maintained pursuant to such Dekton® Cleaning and
Maintenance Guide.
WHAT THIS LIMITED 25-YEAR
WARRANTY DOES NOT COVER
• This warranty does not cover faulty or improper
fabrication or faulty or improper installation.
• Any damage caused by actions taken by third
parties not related to Cosentino, such as problems
caused by incorrect finish/preparation of the
product, by improper installation methods, or
other modification or manipulation of the original
DEKTON® product.
• Dekton® Ultracompact Surface cracking due to
an external force or interaction such as impacts,
uneven cabinets or flooring, structural settling
or movements, improper installation or other
conditions in the residence that may cause the
Dekton® Surfaces to shi. Therefore, cracks or
chipping due to impact from heavy objects, and
movement, shiing, settling of support structure
below the countertop or flooring surface (cabinets,
flooring, foundation etc.), are not covered by this
warranty.
• This warranty does not cover consequential or
incidental damage, loss or expense other than the
product itself, including but not limited to damage
to other products or installations, or additional or
supplementary repairs or modifications such as,
for example, any plumbing, electrical, tile or wall
surface modifications, masonry work, subfloor
repair or preparations that may be necessary to
repair or replace the Dekton® Surfaces covered
under this limited warranty; such other repairs
and modifications shall be the responsibility of the
customer.
• This warranty does not cover products that have
been treated or covered with an unapproved
chemical or coating. If Cosentino determines in
its discretion, that the application of unapproved
chemicals and/or coatings caused or contributed
to the defect(s) in the product, it shall have no
obligations under this Warranty.
• This warranty does not cover products that have
not been paid for in full.
• This warranty does not cover products exposed to
abnormal use or conditions or abuse in any way.
“Abnormal use or conditions” includes, but is not
limited to, damage from mishandling or misuse,
physical or chemical abuse, and failure to follow
proper care and maintenance instructions,
specifically maintenance or damage from chipping,
cracking, impact damage or breaking due to
customer abuse.
• Dekton® Surfaces are intended to have a natural
and non-uniform appearance, thus this limited
warranty does not cover any variances in color,
shade, particle structure or gloss level.
• This warranty does not cover products that
you, the customer, decide you do not like aer
installation due to color, edging styles or other
opinions based on personal preference.
• This warranty does not cover seam appearance or
performance.
• This warranty does not cover temporary marks on
the Dekton® products including but not limited
to metal marks, fingerprints or smudges or other
temporary marks made by household utensils.
• This warranty does not cover “commercial uses” of
the Dekton® products. “Commercial uses” include
but are not limited to use in commercial buildings
such as retail stores, restaurants, offices, hotels, or
apartment complexes.
• Cosentino is not responsible for damage or injury
caused in whole or in part by force majeure,
(including but not limited to earthquakes,
tornadoes, tropical storms, and hurricanes),
exposure to corrosive contaminants (including
but not limited to salt water or chemicals in storm
waters), fires, floods, explosions, improper storage
or handling, job site conditions, architectural
and engineering design, structural settling or
movement, acts of vandalism, accidents, or any
other cause beyond the control of Cosentino.
• This warranty excludes additional damage that
may have resulted from a covered defect, including
damage that occurs during the period the warranty
claim is being processed, as well as throughout
the period the product is being replaced. This
exclusion includes but is not limited to any harm
to commercial, industrial, professional or living
activities, which the purchaser of the product or
third party may suffer.
• Differences found between samples or
photographs of any Dekton® product and the
actual Dekton® product purchased are not covered
under this warranty.
• This warranty does not apply to repairs and/or the
handling of the Dekton® product without proper
verification by Cosentino.
• Damage arising from defects in a building structure
in which the Dekton® product is used.
• Chipping is not covered under this warranty.
Chipping does not occur because of defective
material; chipping is the result of the scraping
and bumping of objects against the edges of the
surface.
• Since Cosentino does not actually make worktops,
but supplies the material for the boards, in the
event the terms and conditions contained herein
are met, material required will be provided
to replace the worktop; however, the cost of
manufacturing and installing the product will not
be covered by Cosentino.
• Some Dekton® colors may only be available for
use on a particular application. Customer will be
informed of which colors Cosentino recommends be
used only for a particular application. For example,
for some colors, Cosentino does not recommend,
advise or approve their use on countertops,
worktops, flooring or any other horizontal
application, and the customer should not rely on
any other verbal or written representation that may
suggest otherwise. By purchasing those particular
colors, the customer agrees to waive all warranty
rights and claims against Cosentino should this color
be used or applied in contradiction to Cosentino’s
recommendations.
REGISTRATION
OF WARRANTY
To register for this warranty, you must fill out the
warranty registration online at www.cosentino.com
or call or write to Cosentino at the phone number
or address below to obtain a registration form. You
must register within six (6) months from purchase to
be eligible under this warranty.
HOW TO MAKE A
WARRANTY CLAIM
If you believe that there is a defect in your Dekton®
product, and wish to make a claim under this
warranty, you must do so by fax, email, letter or
by telephone by contacting Cosentino’s Customer
Service at:
Cosentino Central
Ctra. Baza a Huércal-Overa, km 59.
04850 Cantoria, Almería (Spain)
+34 950 444 175
To obtain service under this warranty, you must
permit Cosentino or its authorized agents, fabricators
or installers to inspect your Dekton® product at your
residence. Also, you must reasonably cooperate with
Cosentino and its agents in their efforts to service
this limited warranty.
All obligations of Cosentino under this warranty are
contingent upon Cosentino being provided proper
notice by the purchaser covered by the warranty and
a reasonable opportunity for Cosentino to perform.
Your failure to allow for an inspection will void this
warranty.
In no event shall Cosentino be liable in either tort
or contract for any loss of direct, consequential,
punitive or incidental damages, or any similar
damages, including but not limited to loss profits
damages, arising out of the use or inability to use
the product for residential applications covered by
this limited warranty.
Some states do not allow the exclusion or limitation
of incidental damages, so the above limitation or
exclusion may not apply.
Cosentino makes no other warranty, representation
or guarantee, express or implied, with respect
to Dekton® Surfaces for residential use, except
as expressly stated herein. This warranty gives
you specific legal rights, and you may also have
other rights which may vary from country to
country, state to state in the United States or, in
Canada, from province to province. This is the only
warranty offered by Cosentino for Dekton® Surfaces
for residential applications. No one other than
Cosentino is authorized to make any warranty or
promise with respect to Dekton® Surfaces.
Cosentino reserves the right to refuse this warranty
service if any of the requirements set forth above
are not met, or if the information provided by the
consumer is false, incomplete or illegible.
SPECIFIC WARRANTY
INFORMATION CONCERNING
DEKTON FINISHED PRODUCTS
DEKTON® by Cosentino® finished products in the
form of three-dimensional surfaces, such as kitchen
sinks, washbasin and shower trays are under
warranty against manufacturing defects of the
product for a period of FIVE (5) YEARS, all under the
terms, conditions and limitations described for all
other DEKTON® by Cosentino® products.
The warranty for DEKTON products with GRIP finish is
limited to FIVE (5) years under the terms, conditions
and limitations described for all other DEKTON® by
Cosentino® products.
Visit http://warranty.cosentino.com and follow
these steps to register your Dekton warranty.
Welcome, you are: Worktop requested by:
In the le box, please select who is
resgistering the warranty and, in the right
hand box, through what sort of provider it was
purchased.
Input the ID numbers provided by the
Store. Place the ID number of the fabricator
stonemason in the le box and the ID number
for the kitchen studio in the right box.
Fill in end user details and information about
the worktop. Its important to fill the email field
in order to receive the warranty confirmation.
Include the invoice/proof of purchase. It
should include: kitchen store data, customer
data, worktop brand, colour worktop and
invoice date.
Finally, Cosentino complies with its obligation
to protect your personal details.
Please tick to confirm these final boxes. Your
25-year Cosentino product warranty has
been registered!
1 4
5
2
3
1
2
Kitchen Studio Property developer / Contractor
Stonemason End User
Designer / Architect Designer / Architect
Kitchen Studio
End User
FABRICATOR / STONEMASON ID:
CHECK ID CHECK ID
STORE ID:
DE COMPRA:
3
3
SURNAME BRAND DEKTON
NAME COLOUR
ADDRESS THICKNESS
APPLICATION
PROOF OF PURCHASE
SELECCIONAR ARCHIVO NADA SELECCIONADO
P.C / ZIP
INVOICE DATE
TOWN
PROVINCE
PHONE
BUYER’S DETAILS &
INSTALLATION ADDRESS
WORKTOP DETAILS
**
Ctra. Baza a Huércal-Overa, km 59. 04850 Cantoria, Almería (Spain)
www.dekton.com DektonbyCosentino @Dekton
To obtain more information about colours with NSF certificate please visit the official website: www.nsf.org
FT
W
A
R
R
A
N
T
Y
25
YEAR
OUTDOOR COOKING
Outdoor Side Burner
AEB
Use & Care Manual
Installation & Operation
©2018 Hestan Commercial Corporation
1
EN
Message from Aspire by Hestan:
Outdoor cooking is a perfectionist’s pursuit, and with your new investment,
you’ve now taken the ultimate step forward. We sincerely welcome you to the
Aspire by Hestan Family. We’ve engineered and built our products so that
your guests will rave about your meal, but deep down, our customers know it
could’ve been just a little more tender, juicier – a pinch more salt in the rub or
a few seconds less on the ame. Yes, we’ve taken the time to know our Aspire
by Hestan customer and we’re excited to be on this journey with you. Aspire
by Hestan was born from this same perfectionist passion. Our engineers
experimented, innovated, tweaked and tinkered until they created the most
powerful, versatile and reliable outdoor products available.
We pride ourselves on restless innovation, superior engineering and purpose-
built designs, but also our in-depth understanding of our target consumer and
the interests and needs of the ultimate end-users we serve and covet. For many
consumers, cooking outdoors is much more than an act of food preparation. It’s
a lifestyle activity that encompasses culinary, leisure and social pursuits among
others.
We are thankful and proud that you have chosen Aspire by Hestan, and we
yearn to have you as a customer for life. We take your decision to choose Aspire
by Hestan most seriously, and we promise to deliver the very best to you.
Welcome to Aspire by Hestan
©2018 Hestan Commercial Corporation
2
EN
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Do not try lighting this appliance without reading the LIGHTING
INSTRUCTIONS section of this manual.
For outdoor use ONLY. This cooking appliance is not intended to be
installed in or on recreational vehicles, and/or boats.
Flammable Gas - disconnect all propane or natural gas supplies to this
unit before servicing.
Electrical Parts & Components – disconnect all power supplies and
batteries before servicing.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
DANGER
1. Do not store or use gasoline or
other flammable liquids or vapors
in the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING
YOUR SIDE BURNER TO REDUCE THE RISK OF FIRE, BURN HAZARD,
OR OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE.
©2018 Hestan Commercial Corporation
3
EN
3 MODEL NUMBERS
4 RATING LABELS
4 PRECAUTIONS
7 REGULATORY / CODE REQUIREMENTS
7 PORTABLE LP CYLINDERS
8 LOCATION AND ASSEMBLY
8 INSTALLATION
11 GAS AND ELECTRICAL CONNECTIONS
18 LIGHTING INSTRUCTIONS
19 USING YOUR SIDE BURNER
19 CLEANING AND MAINTENANCE
22 TROUBLESHOOTING
23 WIRING SCHEMATICS
27 PARTS LIST
27 SERVICE
27 WARRANTY
TABLE OF CONTENTS
BUILT-IN MODELS
Model No. Description
AEB121-NG / -LP 12” BUILT-IN SINGLE SIDE BURNER
AEB122-NG / -LP 12” BUILT-IN DOUBLE SIDE BURNER
AEB121 AEB122
MODEL NUMBERS
©2018 Hestan Commercial Corporation
4
EN
RATING LABEL
The rating label contains important information about your appliance such as the model and serial number,
gas type and manifold pressure, the BTU rating for each burner type, and the minimum installation
clearances.
PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER
When properly cared for, your Aspire side burner will provide safe, reliable service for many years.
However, extreme care must be used since the side burner produces intense heat, which can cause serious
injury or even death if the instructions are not followed carefully. When using this appliance, basic safety
practices must be followed as outlined below.
1. NEVER LEAVE THE SIDE BURNER UNATTENDED WHILE COOKING.
2. Children should not be left alone or unattended in an area where the side burner is being used. Never
allow them to sit, stand, or play on or around the side burner. Do not store items of interest to children
around or below the side burner.
3. Never operate the side burner while under the influence of alcohol or drugs.
4. Never use the side burner in windy conditions. If located in a consistently windy area, oceanfront,
mountaintop, etc., a windbreak will be required. Always adhere to the specified clearances as described in
the INSTALLATION section of this manual.
5. The side burner shall be used only outdoors and shall not be used in buildings, garages, sheds, breezeways,
or any enclosed areas. Do not operate the side burner under unprotected, combustible construction. Use
only in well-ventilated areas. See the INSTALLATION section of this manual.
6. Do not use the side burner unless a leak check has been performed on all gas connections. See the GAS
CONNECTIONS section of this manual.
7. If the side burner is installed by a professional installer or technician, be sure that they show you where
your gas supply shut-off is located. All gas lines must have a shut-off that is easily accessible. If you smell
gas, check for leaks immediately. Check only with a soap and water solution. Never check gas leaks with
an open flame. See the GAS CONNECTIONS section of this manual.
8. Check the regulator, hoses, burner ports, and venturi / valve section carefully. Always turn off gas at the
source (tank or supply line) prior to inspecting parts.
9. When lighting a burner, always pay close attention to what you are doing. Be certain you are turning the
correct knob labeled for the burner you intend to use. If any burner does not light, or goes out during
operation, turn off all gas control knobs, and wait five (5) minutes before attempting to re-light. See the
LIGHTING INSTRUCTIONS section of this manual.
Outdoor Side Burner rating label is located on the inside rear wall of the unit, behind
the control panel.
©2018 Hestan Commercial Corporation
5
EN
10. Portable LP cylinders - Always shut off the main valve on the liquid propane (LP) cylinder after each use.
Never use a dented or rusted LP cylinder. Never attach or disconnect an LP cylinder, or move or alter gas
fittings when the side burner is in operation or is hot.
11. Inspect LP gas supply hose prior to each use of the side burner. The hose must be kept away from heated
areas of the side burner. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be
replaced before using the side burner. The hose and LP regulator are supplied as a complete assembly
and must be replaced together. Do not attempt to repair or replace the hose itself. Contact your Hestan
dealer for genuine replacement P/N 014309.
12. Keep any electrical supply cord away from the heated areas of the side burner. The cord is provided with
a 3-prong grounding plug which should not be removed or altered. Do not use this appliance with an
ungrounded, 2-prong adapter. The cord must be plugged into a properly grounded GFCI-protected outlet.
See INSTALLATION section of this manual.
13. Spiders and insects like to nest in the burners, venturis, valves, and orifices of a side burner, disrupting the
gas flow in the burner. This very dangerous condition can cause a fire behind the control panel, damaging
the side burner and risking personal injury. If your side burner has been unused for a long time, inspect
and clean the burners, venturis, valves, and orifices. It is recommended you inspect your side burner at
least twice a year. See BURNER ADJUSTMENT section of this manual for details.
14. Keep the areas surrounding the side burner free from combustible materials, trash, or combustible fluids
and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion gases and
ventilation airways (front).
15. Never move the side burner when hot. When in use, portions of the side burner are hot enough to cause
severe burns.
16. Always have an “ABC” type fire extinguisher accessible – never attempt to extinguish a grease fire with
water or other liquids.
17. Avoid wearing loose-fitting garments or long sleeves while cooking with the side burner. They could
ignite. For personal safety, wear proper apparel while cooking. Some synthetic fabrics are highly
flammable and should not be worn while cooking.
18. Never let pot holders, covers, or other flammable materials come in contact with or too close to any
cooking grate, burner, or hot surface until it has cooled down sufficiently. Fabrics may ignite and result
in personal injury. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns
from steam. Do not use a towel or bulky cloth in place of potholders. Do not let potholders touch hot
portions of the cooking grates.
19. Never touch the cooking grates or immediate surrounding metal surfaces with your bare hands while
cooking with the side burner, as these areas become extremely hot and could cause burns. Use only the
handles and knobs provided for operation of the side burner.
20. Protect your hands with an insulated glove or mitt when operating the side burner. Always keep your
face away and open lids slowly on pots and pans to allow heat and steam to escape before fully opening.
Never lean over an open hot side burner.
21. The side burner metal cover must be removed while lighting. Leaving the cover in place while lighting
can result in an explosion and personal injury, or death. Never lean over a side burner or look directly
into the burner when attempting to light. See the LIGHTING INSTRUCTIONS section of this manual.
22. Do not heat unopened food containers (cans) as pressure build-up will cause the container to explode.
23. Do not use aluminum foil to line the burner bowl. This will alter the airflow to the burner or trap
excessive heat in the control area. This can melt control knobs, wiring, or igniters, and increase the risk of
personal injury. Such damage is specifically excluded from our warranty.
PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER
(continued)
©2018 Hestan Commercial Corporation
6
EN
24. Grease is extremely flammable. Let hot grease cool before attempting to handle or dispose of it. Avoid
letting excessive grease deposits collect by cleaning the burner bowl often. Never clean while the side
burner is on, or hot from recent use.
25. Cooking excessively fatty meats and oils will cause flare-ups or grease fires. Damage caused by them or by
the side burner being left unattended, are not covered under the terms and conditions of our warranty.
26. Only certain types of glass, heatproof glass-ceramic, earthenware, or other glazed utensils are suitable for
side burner use. However, these types of materials may break with sudden temperature changes. Use only
on low or medium heat settings, and according to their manufacturers’ directions.
27. Do not repair or replace any part of the side burner unless specifically recommended in this manual. All
other warranty and non-warranty service should be referred to and performed by a qualified technician.
28. For proper lighting and performance of the burners, keep the ports clean. It is necessary to clean them
periodically for optimum performance. The burners will operate only in one position and must be
mounted correctly for safe operation. See BURNER ADJUSTMENT section of this manual.
29. Clean the side burner with caution. Avoid steam burns - do not use a wet sponge or cloth to clean the
side burner while it is hot. Some cleaners produce noxious fumes or can ignite when applied to a hot
surface. Be sure all side burner controls are turned off and the appliance is cool before using any type
of aerosol cleaner on or around the appliance. The chemical that produces the spraying action could, in
the presence of heat, ignite or cause metal parts to corrode. Clean and perform general maintenance on
the side burner twice a year. Watch for corrosion, cracks, or insect activity. See the CLEANING AND
MAINTENANCE section of this manual.
PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER
(continued)
©2018 Hestan Commercial Corporation
7
EN
REGULATORY / CODE REQUIREMENTS
Installation of this cooking appliance must be made in accordance with local codes. In the absence of
local codes, this unit should be installed in accordance with the National Fuel Gas Code
ANSI Z223.1/
NFPA 54
, Natural Gas and Propane Installation code
CSA B149.1
, or Propane Storage and Handling Code
B149.2
.
All Electrical Components must be electrically grounded in accordance with local codes or in the absence
of local codes with the National Electrical Code
ANSI/NFPA 70
, or Canadian Electrical code
CSA C22.1
.
STATE OF MASSACHUSETTS
Massachusetts requires all gas be installed using a plumber or gas fitter carrying the appropriate
Massachusetts license. All permanently installed natural gas or propane installations require a T handle
type manual gas valve be installed in the gas supply line to this appliance. This does not apply to portable
propane installations using a 20lb. cylinder.
CALIFORNIA PROPOSITION 65 - WARNING
The burning of gas cooking fuel generates toxic by-products, which are on the list of substances which
are known by the State of California to cause cancer or reproductive harm. California law requires
businesses to warn customers of potential exposure to such substances. To minimize exposure to these
substances, always operate this unit according to the use and care manual, ensuring you provide good
ventilation when cooking with gas. This warning is issued pursuant to California Health & Safety Code
Sec. 25249.6.
PORTABLE LP GAS CYLINDERS
Use only a standard 20 lb. (9.1kg) liquid propane (LP) gas cylinder - 12.25” diam. X 18.25” H
(31cm X 47cm) which features an Overfill Protection Device. The cylinder must be installed in the
upright position. Do not use a dented or rusty LP cylinder as it may be hazardous and should be checked
by your LP supplier. Never use a cylinder with a damaged valve. Never move or alter the gas fittings.
Check the expiration date on the cylinder collar as well. Do not refill an expired cylinder, it must be
replaced. If you buy refilled (exchange) LP cylinders, check this date as well.
The LP gas cylinder must be constructed and marked in accordance with the specifications for LP gas
cylinders of the U.S. Department of Transportation (DOT). The cylinder must be provided with a shut off
valve terminating in an LP gas supply cylinder valve outlet specified, as applicable, for connection type
QCC1 in the standard for compressed gas cylinder valve outlet and inlet connections ANSI/CGA-V-I.
Certain liquid propane dealers may fill LP cylinders for use in the grill / side burner beyond cylinder
filling capacity. This “overfilling” may create a dangerous condition due to a build-up of excess pressure.
As a safety device, there is a pressure relief valve which will vent propane gas vapor to relieve this excess
pressure. This vapor is combustible and therefore can be ignited. To reduce this danger, you should take
the following safety precautions:
1. When you have your cylinder filled, be sure you tell the supplier to fill it to no more than 80% of its
total capacity.
2. If you own or use a spare cylinder, you should NEVER store it near or under the grill/cart unit or
burner box, or near any other ignition or heat source (like a water heater or furnace).
IF THE INFORMATION IN 1 AND 2 ABOVE IS NOT FOLLOWED EXACTLY, A FIRE CAUSING
DEATH OR SERIOUS INJURY MAY OCCUR.
3. The LP cylinder must be disconnected and stored OUTSIDE in a well-ventilated area, out of the reach
of children.
4. Do not store a full cylinder in direct sunlight.
This manual suits for next models
4
Table of contents
Other hestan Burner manuals
hestan
hestan HMB Series User manual
hestan
hestan AGPB24 User manual
hestan
hestan AGB122NGTQ User manual
hestan
hestan ASPIRE AEB121-NG User manual
hestan
hestan Aspire AEB121NGOR User manual
hestan
hestan Aspire AEB122LPOR User manual
hestan
hestan AGB122-LP-BK User manual
hestan
hestan AGPB24-LP User manual
hestan
hestan AGB Series User manual
hestan
hestan AGB121-NG User manual
Popular Burner manuals by other brands
Duluth Forge
Duluth Forge FDLT24-1 OWNER'S OPERATION AND INSTALLATION MANUAL
BiSolid
BiSolid GP XX R TSC Series Installation, operation and maintenance manual
RAMBO
RAMBO HP200LPB Installation & operating instructions
Ecoflam
Ecoflam MAX P 45 AB manual
CIB UNIGAS
CIB UNIGAS N1060A installation manual
Riello
Riello RLS 160/E MX Installation, use and maintenance instructions
