Hitachi Travelstar 5K160 User manual

Hitachi Global Storage Technologies
Quick Installation Guide
Hitachi Travelstar™(E)5K160
2.5-inch ATA/IDE & SATA Hard Disk Drive
Models:
HTS(E)541616J9AT00
HTS(E)541612J9AT00
HTS(E)541680J9AT00
HTS(E)541660J9AT00
HTS(E)541640J9AT00
HTS(E)541616J9SA00
HTS(E)541612J9SA00
HTS(E)541680J9SA00
HTS(E)541660J9SA00
HTS(E)541640J9SA00
Handling precautions
__________________________________________
• Wear a grounded wrist strap while handling the
drive to prevent damage from Electrostatic
Discharge (ESD).
• Set the drive down gently to prevent damage
from impact or vibration.
• Do not open the ESD bag containing the drive
until needed.
• Handle the drive carefully by the edges. Do not
touch the exposed printed circuit board or any
electronic components.
• Do not press on the top or bottom of the drive.
• Do not cover the drive’s breather hole.
Quick installation
__________________________________________
Installation of this Hitachi Travelstar drive in
some notebooks may require use of unique
hardware (such as mounting trays, connecting
cable, insulating material). If you are uncertain if
hardware is needed, consult your notebook
manufacturer as this operation may require a
qualified technician.
Back up all data before proceeding with
installation.
1. Set the jumpers (ATA/IDE only)
• Master drive. No jumper is required if the drive
is the only drive in a system or the Master
drive in a two-drive system.
• Slave drive. If this is the Slave drive in a
system, place a jumper in setting A2. (See
the A2 setting in the illustration.)
• Cable Select. Setting A3 in the illustration.
Consult the system manual to see if your
computer supports Cable Select.
Jumper settings (ATA/IDE only)
2. Attach the drive
For assistance on the physical installation of
the drive, consult your system manual.
3. Configure the computer
1. Turn on the computer.
2. Enter Setup.
Page 1 Travelstar (E)5K160

Hitachi Global Storage Technologies
3. Go to Hard Disk Drive Configuration.
4. Select Autodetect if it is available.
5. If Autodetect is not available, set to User and set to
appropriate parameters from the table below.
6. Save the settings and exit.
7. Reboot the system from a floppy disk.
Model Number Cylinders Heads Sectors/
Track Capacity (GB)
HTS(E)541616J9AT00 16,383 4 480-1272 160
HTS(E)541612J9AT00 16,383 4 480-1272 120
HTS(E)541680J9AT00 16,383 2 480-1272 80
HTS(E)541660J9AT00 16,383 2 480-1272 60
HTS(E)541640J9AT00 16,383 1 480-1272 40
HTS(E)541616J9SA00 16,383 4 480-1272 160
HTS(E)541612J9SA00 16,383 4 480-1272 120
HTS(E)541680J9SA00 16,383 2 480-1272 80
HTS(E)541660J9SA00 16,383 2 480-1272 60
HTS(E)541640J9SA00 16,383 1 480-1272 40
4. Partition and format
• FDISK.EXE and FORMAT.EXE (or a similar
partitioning software from the operating system)
Follow the instructions provided with your operating
system to partition the drive. If FDISK.EXE recognizes
only 8.4 GB of a drive, the BIOS may not support
Interrupt 13 Extensions.
Format the drive by following the instructions provided
with FORMAT.EXE. Formatting will verify the hard disk
media and create file allocation tables for the partition.
5. Boot up the computer
If the system does not boot up after the installation of
the drive, check all the settings. If the system still fails to
boot up, contact the Hitachi Global Storage
Technologies Support Center at
www.hitachigst.com/support.
© Copyright Hitachi Global
Storage Technologies
Hitachi Global Storage Technologies
3403 Yerba Buena Road
San Jose, CA 95135
Produced in the United States.
9/06
All rights reserved. Travelstar™ is a
trademark of Hitachi Global Storage
Technologies.
Microsoft, Windows XP, and Windows are
trademarks of Microsoft Corporation in the
United States, other countries, or both.
Other product names are trademarks or
registered trademarks of their respective
companies.
References in this publication to Hitachi
Global Storage Technologies products,
programs or services do not imply that Hitachi
Global Storage Technologies intends to make
these available in all countries in which Hitachi
Global Storage Technologies operates.
Product information is provided for information
purposes only and does not constitute a
warranty.
Information is true as of the date of publication
and is subject to change. Actual results may
vary.
This publication is for general guidance only.
Photographs may show design models.
20 September 2006
Page 2 Travelstar (E)5K160