Home Decorators Collection SUNBURY 2333FP-1 User manual

SUNBURY 48 IN. STEEL LOW PROFILE TILE TOP LP GAS FIRE PIT
WITH TANK HOLDER SIDE TABLE
USE AND CARE GUIDE
THANK YOU
continually create quality products designed to enhance your home. Visit us online to see our full line of products available for your home
We appreciate the trust and condence you have placed in Home Decorators Collection through the purchase of this re pit. We strive to
improvement needs. Thank you for choosing Home Decorators Collection!
Questions, problems, missing parts? Before returning to the store,
call Home Decorators Collection Customer Service
8 a.m. - 7 p.m., EST, Monday – Friday, 9 a.m. – 6 p.m., EST, Saturday
1-800-986-3460
HOMEDEPOT.COM/HOMEDECORATORS
Item #1007 497 565/1007 497 281/1007 497 576/1007 497 578
1007 497 562/1007 497 572/1007 497 563/1007 497 574
Model # 2333FP-1/2333FP-2
2333FP-3/2333FP-4

2
Table of Contents
Table of Contents .................................. . 2
Safety Information ................................ . . 2
Specications ..................... . . . . . . . . . . . . . . . 4
About propane (LP) gas . . ...........................
4
Warranty . . . . . . . . . . . . . ..............................
4
Planning assembly . . ..............................
5
Pre-assembly ......................................5
Hardware included . . ..............................
5
Package contents . . ...............................
5
Flame characteristic . . . ............................
10
Lighting .................................. . . . . . .
10
Before lighting . . . .................................
10
Shutdown ............................. . . . . . . . . . .
10
Operation ............................... . . . . . . . . . . 10
Care and Maintenance ..................... . . . . . . . . . .11
Assembly......................................... . 6
Leak check ..................................... . 11
Safety Information
Stop! Please read these instructions carefully before assembly.
Make sure you have all the parts and hardware as identified on the hardware and contents lists.
Keep these instructions for future reference.
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to the appliance.
Extinguish any open ame.
If odor continues, leave the area immediately.
After leaving the area, call your gas supplier or re department.
WARNING: Improper installation, adjustment alteration, service or maintenance can cause injury or property damage.
Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment.
DANGER:
WARNING: Do not store or use gasoline or other ammable vapors and liquids in the
vicinity of this or any other appliance. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other appliance.
WARNING: If the information in this manual is not followed exactly, a re or explosion
may result causing property damage, personal injury, or loss of life.
WARNING: For Outdoor Use Only,Installation and service must be performed by a
qualied installer, service agency, or the gas supplier.
NOTICE: Installer, leave this manual with the appliance.
NOTICE: Consumer, retain this manual for future reference.
This appliance can produce carbon monoxide which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an en closed space such as a camper, tent,
car or home.
DANGER CARBON MONOXIDE HAZARD
Failure to follow these instructions could result in fire or explosion, which could cause
property damage, personal injury, or death.

Safety Information (continued)
3 HOMEDEPOT.COM/HOMEDECORATORS
Please contact 1-800-986-3460 for further assistance.
WARNING: Use factory approved replacement parts and accessories only. Use of unapproved parts or accessories can void the warranty
on this product and result in a hazardous condition. Please contact us for information regarding replacement hoses, electrodes,
ignition modules, re glasss, logs, etc.
CAUTION: The propane gas pressure regulator provided with this appliance must be used. This regulator is set for an outlet
pressure of 11 inches water column.
CAUTION: Keep this compartment away from combustible materials and operated appliance minimum clearances 25.6in(65 cm)!
The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code,ANSI Z223.1/NFPA 54;
International Fuel Gas Code; Propane Installation Code, CSA B149.1; or Propane Storage and Handling Code, B149.2, as applicable.
The appliance area must be kept clear and free from combustible materials, gasoline and other ammable vapors and liquids.
The appliance must be isolated from the gas supply piping system by closing its equipment shut off valve during any pressure testing
of the gas supply system at test pressure equal to or less than 1/2 psi (3.5 kPa).
Do not use this appliance if any part has been under water. Immediately call a qualied service technician to inspect the appliance and
to replace any part of the control system and any gas control which has been under water.
Children and adults should be alerted to the hazards of high surface temperatures and kept at a safe distance to avoid burns or clothing
ignition.
Young children should be carefully supervised when they are anywhere near the appliance.
Clothing or other ammable material should not be hung from the appliance, or placed on or near the appliance.
Any screen or guard removed for servicing the appliance must be replaced prior to operating the appliance.
Installation and repair should be done by a qualied service person. The appliance should be inspected before use and at least annually
by a professional service person. More frequent cleaning may be required as necessary. It is imperative that the control compartments,
burners and circulating air passageways of the appliance be kept clean.
Do NOT burn solid fuels in this gas replace.
Do NOT ignite the burner before pouring all of the burner media (re glass) into the burner pan.The media must be evenly distributed
over the burner.
During initial ring of re pit, please stay away from the re pit for 20 minutes as re media (re glass) may pop and hit someone on
the face or eyes.
The maximum inlet gas supply pressure is 250 psi. The minimum inlet gas supply pressure is 25 psi.
Do NOT ignite or use the re pit if the burner media (re glass) are wet. Ensure the burner media are completely dry before igniting as
intense heat could cause the media to crack and pop.
Do not use this appliance for cooking.
This outdoor gas appliance is not intended to be installed in or on recreational vehicles and/or boats.
Keep the fuel supply hose away from any heated surfaces.
Very hot while in operation! Never lean over the appliance while it is in use.
In order to protect the burner system, when the re is not in use and on rainy days, the cover should be used.
Do not use cover immediately after use, wait until the appliance has cooled down.
Do not sit or stand on this table.
Retain these assembly instructions for future reference.
Before each use of this gas appliance, open the LP (liquid propane) tank drawer and inspect the LP hose. If there is evidence of excessive
abrasion or wear, or the hose is cut, it must be replaced prior to the gas appliance being put into operation. Use only the replacement hose
assembly specied in this manual. Inspect the burner before each use of the appliance. The burner must be replaced prior to the appliance
being put into operation if it is evident that the burner is damaged. Use only the burner listed in these instructions.

Safety Information (continued)
4
The cylinder supply system must be arranged for vapor withdrawal.
The cylinder used must include a collar to protect the cylinder valve.
This appliance shall be used only outdoors in a well-ventilated space and shall not be used in a building,
garage or any other enclosed space.
When this appliance is not in use, the gas must be turned off at the supply cylinder.
Storage of this appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance.
Cylinders must be stored outdoors in a well-ventilated area out of the reach of children. Disconnected cylinders must have threaded valve
plugs tightly installed and must not be stored in a building, garage or any other enclosed areas. CSA (Canadian Standards Association)
certied to ANSI Z21.97·CSA 2.41-2017 “Outdoor Decorative Gas Appliances”.
A self contained LP gas cylinder for use with this appliance must have a capacity of 20 lb. and must be equipped with a Type 1 connector
and an OPD (overll protection device). See Figure 1.
The LP gas supply cylinder to be used must be constructed and marked in accordance with the specication for LP gas cylinders of the
U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinder, Sphere and Tubes for the
Transportation of Dangerous Goods.
ABOUT PROPANE (LP) GAS
Figure 1
WARNING: Fuels used in liqueed propane gas appliances, and the products of combustion of such fuels, can expose you to chemicals
including benzene, which is known to the State of California to cause cancer and cause birth defects or other reproductive
harm. For more information go to: www.p65warnings.ca.gov.
Warranty
This warranty is for the original purchaser and applies to defects in materials and workmanship of your re pit, provided your unit is
maintained with care and used only for personal, residential purposes.
Frames are warranted to be free from defects in material or workmanship for two (2) years.
Exclusions: Items used for commercial, contract or other non-residential purposes, display models, items purchased “as is,” or items
damaged due to acts of nature, vandalism, misuse or improper assembly are not covered. Discoloration or fading of the nish or fabrics
as a result of exposure to the elements, chemicals or spills is not covered. Table top breakage, corrosion or rusting of hardware and damages
to frames or welds caused by improper assembly, misuse or natural causes are not covered.
SPECIFICATIONS
INPUT 50,000 Btu/hr 30,000 Btu/hr Low re
Propane Regulator Pressure 11 inches water column
Sides: 24 in./61 cm Top: 60 in. / 152 cm
Clearances to
combustible surfaces

5 HOMEDEPOT.COM/HOMEDECORATORS
Please contact 1-800-986-3460 for further assistance.
Pre-assembly
PLANNING ASSEMBLY
NOTE: Read all instructions before assembly. To avoid damaging this product, assemble it on a soft,
non-abrasive surface such as carpet or cardboard.
NOTE: More than one person may be required to assemble this product.
HARDWARE INCLUDED
AA
EE FF GG HH II
BB CC DD
NOTE: Hardware not shown to actual size.
Part Description Quantity
AA Bolt 8
BB Gasket 12
CC Bolt 8
DD Gasket 8
EE Bolt 1
Part Description Quantity
FF Stator 1
GG Bolt 4
HH Bolt 2
II Allen key 1
WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specically approved with this
appliance may result in property damage or personal injury.
PACKAGE CONTENTS
Part Description Quantity Part Description
A Front panel 1
B Side panel 2
C Back panel 1
G Gas tank base
H Side tabletop
I
J
Side table left panel
Side table right panel
K
L
Side table back panel
Side table front panel
D
E
F
Tabletop 1
Fire glass ~
Lid 1
Quantity
1
1
1
1
1
1
MTrunking 1
A C DB E
G H
F
I KJ L M

6
4Installing tabletop
1Installing side panel on front panel 2Installing back panel
3Installing side panel
Assembly
BB
AA
B
A
□
□
Place parts on a soft, non-abrasive surface.
Attach the side panel (B) to the front panel (A) with bolts (AA) and
gaskets (BB).
□Do not tighten fully.
BB
AA
C
B
Attach the back panel (C) to the other side of the side panel (B)
with bolts (AA) and gaskets (BB).
□
BB
AA
B
C
A
Attach side panel (B) to front panel (A) and back panel (C)
with bolts (AA) and gaskets (BB).
□
CC
DD
D
C
□
□
Place the table top (D) upside down on a non-abrasive surface.
Align the back panel (C) with the switch side, attach the
table top (D) to the frame with bolts (CC) and gaskets (DD).

7 HOMEDEPOT.COM/HOMEDECORATORS
Please contact 1-800-986-3460 for further assistance.
6Installing gas tank
7Inserting battery
Assembly(continued)
FF
C
EE
G
□Open the battery cap on the control panel and install one AAA
battery (not included).
□
□
Connect the gas hose to the LP gas cylinder. Hand tighten
clockwise only.
To disconnect the gas hose from LP gas cylinder, loosen the
connector by turning counterclockwise by hand.
□Position the LP gas cylinder (not included) in the gas tank base (G)
of the re pit and fasten with an adjusting screw.
5Installing the stator
□Put the stator (FF) on the gas hose and attach the stator (FF)
to the back panel (C) with bolts (EE).
□With the help of other people, carefully turn the table over
to an upright position.
8Putting in re glass
E
NOTE: Maximum recommended amount of
re glass (E) for use in the re bowl is 5~5.5 kg.
□Add re glass (E) to the re bowl.

9Placing the lid 10 Installing left panel for side table
11 Installing back panel for side table 12 Installing right panel for side table
8
Assembly(continued)
F
BB
GG
L
I
BB
GG
K
IHH
K
J
□Place the lid (F) on the top of the re bowl to complete the
assembly.
□
□
Carefully turn the frame upside down.
Attach the side table right panel (J) to the side table back
panel (K) with bolts (HH).
□
□
Place parts on a soft, non-abrasive surface.
Attach the side table left panel (I) to the side table front panel (L)
with bolts (GG) and gaskets (BB).
□Do not tighten fully.
□Attach the side table back panel (K) to the other side of the
side table left panel (I) with bolts (GG) and gaskets (BB).

WARNING: Hose is a trip hazard.
CAUTION: Keep the gas tank xed in the tank base.
16 Installing trunking
13 Installing table top on side table
15 Installing gas tank
HOMEDEPOT.COM/HOMEDECORATORS
Please contact 1-800-986-3460 for further assistance.
Assembly (continued)
9
CC
DD
H
Place the side table top (H) upside down on a non-abrasive
surface. Attach the side table top (H) to the frame with
bolts (CC) and gaskets (DD).
□Put the gas tank inside the side table.
□Place the cross-bar down and close the door.
□Pull apart the top and bottom panels of the trunking.
□
14 Preparing to install gas tank
□Open the door of side table and raise up the cross bar.
□Carefully turn the side table right side up.
M
□Put the gas hose in between the top and bottom panels of the
trunking and close the trunking.

10
Operation
Fire pit should be thoroughly inspected before each use and by a qualied service person at least annually.
If relighting a hot re pit, always wait at least 5 minutes.
Inspect the hose assembly for evidence of excessive abrasion, cuts, or wear. Suspected areas should be
leak tested. If the hose leaks, it must be replaced prior to operation. Only use the replacement hose assembly
specied by manufacturer. The burner must be replaced prior to the appliance being put into operation if it is
evident that the burner is damaged. The replacement burner should be specied by manufacturer.
Remove the cover before lighting.
Control knob must be in the OFF position.
Connect and open propane cylinder (see manual).
Push and turn control knob counterclockwise to LOW.
Press the igniter button repeatedly to light burner.
Press and hold control knob for 45 seconds after ame lights.
If re pit doesn’t ignite within a few seconds, push and turn the control knob clockwise to OFF,
Fan with newspaper or magazine to ensure there is no propane gas in the re bowl and inside of re pit,
Wait 5 minutes, repeat the lighting steps as outlined above.
Adjust ame to desired level with the control knob.
Lighting operations should comply with Lighting Instruction section.
Improper lighting operations will cause serious injury and explosion.
Normally the burner ame is yellow.
If the burner ame is blue and very small, please check the gas cylinder, as it may be low gas pressure or
empty. If there is enough gas in the cylinder, please contact customer service to change the burner of the
gas re pit.
If ames lift away from burner or backre happens, or if the ames
produce black smoke, the re pit should be turned off immediately.
The re pit should not be operated again until the unit is serviced
and/or repaired by a qualied service technician.
Push in and turn control knob clockwise to OFF position.
Turn LP cylinder gas valve clockwise to OFF position when appliance is not in use.
SHUTDOWN
BEFORE LIGHTING
LIGHTING
FLAME CHARACTERISTIC
Yellow Tip
Primarily blue
Flame