Honeywell HCM-315T - QuietCare Advanced UV Tower User manual

COOL MOISTURE HUMIDIFIERS
Model HCM-300T
Model HCM-310T
Model HCM-315T
IMPORTANT SAFETY
INSTRUCTIONS
READ AND SAVE THESE SAFETY
INSTRUCTIONS BEFORE USING THIS
HUMIDIFIER
When using electrical appliances, basic
precautions should always be followed to
reduce the risk of fire, electric shock, and
injury to persons, including the following:
1. Always place this humidifier on a firm, flat
and level surface. This humidifier may not
work properly on an uneven surface.
2. Place this humidifier in an area where it is not
accessible to children.
3. Do not place the humidifier near any heat
sources such as stoves, radiators, and
heaters.
4. Do not use the humidifier outdoors.
5. Before using the humidifier, check the power
cord for any signs of damage. If the cord is
found to be damaged, DO NOT USE and
return the humidifier to the manufacturer
under the warranty agreement for repair.
6. This appliance has a polarized plug (one
blade is wider than the other). To reduce the
risk of shock, this plug is intended to fit only
one way in a polarized outlet. If the plug does
not fit securely in the outlet, reverse the plug.
If it still does not fit, contact a qualified
electrician. DO NOT attempt to defeat this
safety feature.
7. To disconnect the humidifier, first turn
controls to the OFF position, then grip the
plug and pull it from the wall outlet. Never
pull by the cord.
8. A loose fit between the AC outlet (receptacle)
and plug may cause overheating and a
distortion of the plug. Contact a qualified
electrician to replace loose or worn outlet.
9. The humidifier should always be unplugged
and emptied when not in operation or while
being serviced or cleaned.
10. Never tilt or attempt to move the humidifier
while it is operating or filled with water.
UNPLUG the humidifier before moving.
11. This humidifier requires regular cleaning.
Refer to the CLEANING instructions provided.
Never clean the humidifier in any manner
other than as instructed in this manual.
12. Do not direct moisture flow directly at
individuals, walls or furniture.
13. When a humidifier is used in a closed room or
small rooms, check periodically for proper
ventilation, as excessive humidity can cause
condensation stains on walls.
14. Turn the humidifier OFF if you notice moisture
on the inside of your windows. For proper
humidity reading use a hygrometer, which is
available in many hardware and department
stores, or by ordering one from the
manufacturer.
The sealed UV bulbs contain a small
amount of mercury. Dispose of these items
at household hazardous waste collection
sites only. If the UV bulb breaks, do not
vacuum or handle with your bare hands.
The Honeywell trademark is used by Kaz, Inc. under license from Honeywell Intellectual Properties, Inc.
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 1

HOW IT WORKS
Quiet Care Technology –
Dry air is pulled through the humidifier and the
QuietCare™fan blows out invisible, moisture-
balanced air. Unwanted minerals and bacteria
from the water are trapped inside the filter. When
the unit is running you WILL NOT see or feel a
“mist.” You will know your humidifier is putting
moisture into the air as the water level decreases
in the tank throughout the day.
Protec™Antimicrobial Treated Filter –
Your filter has been treated with Protec™
antimicrobial which helps prevent surface growth
and migration of mold, mildew, algae, fungus and
odor-causing bacteria in the filter for its life –
approximately 1-3 months*. Keep in mind,
depending on your water quality, mineral deposits
can still clog or discolor the filter, affecting its life
and that of the humidifier.
Air Washing Technology –
Unique air washing system which helps “wash the
air as it humidifies.” The unique pre-filter in
combination with an ionizer helps capture dust,
dirt, and pollen while freshening the air**.
UV Water Sanitizing Technology –
The UV germicidal bulb located inside the main
housing of the humidifier shines on the water
passing through the chamber. This technology
reduces the likelihood of harmful
microorganisms***.
HCM-300T



HCM-310T / HCM-315T




** The antimicrobial agent contained in the filter is intended to prolong filter life only by inhibiting the growth of unsightly mold, mildew
and algae, as well as controlling odor from odor causing bacteria. The antimicrobial in the filter does not protect the user or others
against bacteria, germs, viruses or other disease causing organisms. Always follow manufacturer’s instructions regarding cleaning,
maintenance and service of your humidifier.
** From the air that passes through the pre-filter. Also note the pre-filter may slightly decrease humidity output.
*** Based on independent testing, report 3095045-01. Results are based on microbial reduction rate testing performed using tap water
in the water tray. The following listed microorganism growth reduction was maintained after 2 hours of continuous exposure to the
ultraviolet light in the humidifier.
Bacteria: Escheria Coli - 99%
Pseudomonas fluorescens - 99%
Mold: Aspergillus niger - 99%
Fungus: Penecillium pinophilum - 99%
Virus: MS2 - 99%
2
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 2

SETTING UP YOUR HUMIDIFIER
WATER TANK
SEAL PAD
TANK CAP
FILTER
TRAY
MAIN
HOUSING
HCM-310T / HCM-315T HCM-300T
Your humidifier is made up of these parts:
It is recommended that you disinfect your humidifier prior to first use. See CLEANING Instructions.
33
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 3

Step 1
Step 3Step 2
Fill tank with cool
tap water.
Replace tank cap. Tighten
by turning clockwise .
Place tank back on
humidifier.
Remove the filter from
the holding basket.
Soak the filter in cool water.
DO NOT squeeze filter.
Place wet filter back in
the filter holding basket
and place back in unit.
SETTING UP YOUR HUMIDIFIER (CONT’D)
Placement
Soak Filter
Power
Fill Tank
Remove the water tank
and carefully set aside.
Turn tank upside-down.
Remove tank cap by
turning counter-
clockwise .
Once the filled water tank
has been placed on the
unit do not move
humidifier. Doing so
could cause leakage and
spills.
With the power switch in the OFF position, plug the filled
humidifier into a polarized 120V outlet. DO NOT FORCE
THE POLARIZED PLUG INTO THE OUTLET; it will only fit
one way.
DO NOT plug in humidifier with wet hands to avoid
electric shock.
Select a firm, level location at least 6” (15cm) from any
walls for proper airflow. Place the humidifier on a water-
resistant surface, as water can damage furniture and
some flooring.
Kaz will not accept responsibility for property damage
caused by water spillage.
4
Step 1 Step 2 Step 3
Step 1
Step 1
4
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 4

Step 1
OPERATING YOUR HUMIDIFIER
HCM-300T
HCM-310T/
HCM-315T
Model # Output/Fan Speed Control Set Humidity
Set fan speed to desired
output:
High ()
Fast Humidifying
Medium ()
Everyday moisture control
Low ()
Nighttime or
maintenance use
Turn the humidistat knob
clockwise to the
highest setting ( ).
Run on high for at least
1 hour or until room has
reached a comfortable
humidity level.
Then slowly turn the
humidistat knob counter-
clockwise until the
humidifier shuts off. The
desired humidity light will
illuminate.
Once set, the humidifier will
automatically cycle on and off
based on your setting.
Max: 55% Min: 35%
Use the (+) up or (–) down
button to set desired
humidity.
The unit will operate until the selected humidity is reached
or the unit is turned off. When desired humidity is reached,
the fan will shut off but LED will remain lit. The fan will turn
back on when the room humidity drops below the set
level.
NOTE: To go back to continuous run mode, turn your
unit off and on again.
NOTE: The UV bulb can be turned off and on using the
button.
Press power to start unit
in high speed.
Push (+) Up button or (–)
Down button to select the
output level.
Step 1 Step 2
Step 1 Step 1
Step 2
5
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 5

The UV bulb will operate for an average output of 10,000 hours. To replace UV bulb contact 1-800-477-0457
or [email protected].
CHANGING THE UV BULB
The filter should be changed every 1-3 months depending on your water quality. Keep in mind, depending
on your water quality, mineral deposits can still clog or discolor the filter, affecting it’s life and that of the
humidifier.
It is recommended you change your filter in the bathroom or kitchen. Keep in mind your filter may be
damp depending on your last usage.
To change the filter:
Step 2 Step 3
Uses replacement filter
HAC-504 or HAC-
504AW.
Turn off and unplug
your humidifier.
Remove the water tank
and carefully set aside.
Remove filter holding
basket and discard old
filter.
Step 1 Step 2 Step 3
Turn off and unplug
your humidifier.
Remove the water tank
and carefully set aside.
Press on the button located on the side of the UV
bulb. Carefully use your other hand to pull the UV
cartridge away from the unit.
Step 5 Step 6 Step 7
Soak new filter in cool
water.
Do not squeeze out.
Insert new filter into
holding basket and
place filter holding
basket back in unit.
Replace the water tank.
NOTE: It is recommended that all maintenance be done in the kitchen or bathroom on a water
resistant surface. Remove water tank from unit before moving.
CHANGING YOUR FILTER
Step 4Step 1
6
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 6

Step 7Step 6Step 5
7
CHANGING THE UV BULB (CONT’D.)
CLEANING
Cleaning involves two steps, SCALE REMOVAL and DISINFECTING. Be sure to perform these in the
proper order to avoid harmful chemical interactions.
SCALE REMOVAL
NOTE: REMOVE FILTER BEFORE CLEANING.
Failure to remove filter during cleaning will destroy the filter.
NOTE: Discard the old UV bulb cartridge at a household hazardous waste collection site. Bulb and
bulb housing are not intended for use with any other product or purpose.
Lamp contains mercury. Manage in accordance with disposal laws.
See www.lamprecycle.org or call 1-800-895-8842.
Step 4 Step 5
Place your replacement UV bulb in the unit by
pressing the UV bulb firmly into the opening. Be
certain the prongs locate on the back of the bulb
are lined up with the receptacle in the UV holder.
Place filter basket and replace the water tank in
the humidifier.
Step 1 Step 2 Step 3 Step 4
Turn off and unplug
your humidifier.
Remove the water tank
and carefully set aside.
Remove filter basket. Remove filter from
basket. Failure to do so
will destroy the filter.
Place basket in sink or
tub and fill the bottom
of the basket with
undiluted vinegar.
Let stand for 20
minutes.
With vinegar in the
basket, wipe surface
with a soft cloth or
brush.
Rinse the filter basket
thoroughly with water
to remove scale and
cleaning solution.
Step 8
Step 6
7
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 7

DISINFECTING
CLEANING (CONT’D.)
Step 2 Step 3
1
g
a
l
Step 4
Step 5
Remove the water tank
and carefully set aside.
Remove filter holding
basket.
Remove filter and set
aside. Failure to do so
will destroy the filter.
Fill water tank with 1
tsp. of household
bleach and 1 gallon of
cool water
Step 6 Step 7
Pour some solution into
the filter basket.
Let stand for 20
minutes.
Rinse with water until
the smell of bleach is
gone.
END-OF-SEASON CARE AND STORAGE
• Follow the CLEANING instructions when the humidifier will not be used for at least one week or more,
or at the end of the season.
• At the end of the season, remove and throw away the filter; do not store with a used filter.
• Dry the humidifier completely before storing. DO NOT store with water inside the Base or Water Tank.
• Pack the unit in its original carton and store in a cool, dry location.
• Before next use, remember to clean your humidifier and install a new filter.
CONSUMER RELATIONS
Mail questions or comments to: Kaz, Incorporated
Consumer Relations Dept.
250 Turnpike Road, Southborough, MA 01772
Please be sure to specify model number.
Call us toll-free at: 1-800-477-0457; E-mail: [email protected]
Or visit our website at: www.kaz.com
Purchase replacement filter part number HAC-504AW or HAC-504 and UV bulb part number
22LP300T000.
Step 1
NOTES: The use of
other water treatment
products and
chemicals may cause
deterioration of the
filter or damage the
humidifier, thereby
hindering the
humidifier’s
effectiveness.
8
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 8

ELECTRICAL RATINGS
The Honeywell QuietCare™Series models are rated at 120V, 60 Hz.
NOTE: IF YOU EXPERIENCE A PROBLEM, PLEASE RETURN THE HUMIDIFIER TO THE ORIGINAL PLACE
OF PURCHASE OR SEE YOUR WARRANTY. DO NOT ATTEMPT TO OPEN THE MOTOR HOUSING
YOURSELF. DOING SO MAY VOID YOUR WARRANTY AND CAUSE DAMAGE TO THE HUMIDIFIER OR
PERSONAL INJURY.
TROUBLESHOOTING
Q: I hear the fan turning, but I don’t see any mist. Is my humidifier operating properly?
A: Dry air is pulled through the system and a fan disperses invisible, moisture balanced air. There is no
“mist” emitted. When operating normally you will feel only cool air coming from the unit. Monitor the
water level in your Tank/ Base. If you notice a decrease in the Water Tank over 24 hours then the unit
is operating normally.
Q: My unit has been running for several hours. I hear the fan spinning, but I do not notice the
water level in the tank decreasing.
A: First, check the filter to ensure it is wet. If the pad appears dry, remove it from the Base and gently
rinse under cool water. Reposition wet filter in the Base. You may also want to note the current
moisture level in your home. If the humidity level is over 60% the unit will not put out much moisture
as your air is already saturated.
Q: The humidifier is not running (the fan is not even spinning), but all (or some) of the lights are
on. (Model HCM-300T)
A: If the Desired Humidity light is ON: The Advanced Mist™Humidistat knob may be set too low. Moving
the knob clockwise to the end should restart the unit.
Q: The Advanced Mist™Humidistat knob was set according to the manual, but the humidifier
never seems to turn back on. Is something wrong? (Model HCM-300T)
A: The Humidistat knob may be set too low. Moving the Humidistat knob to the end clockwise
should restart the unit.
Q: The Advanced Mist™Humidistat knob was set according to the manual, but the humidifier
never seems to turn off. Is something wrong? (Model HCM-300T)
A: The Humidistat knob may be set too high. Reset the Advanced Mist™Humidistat knob following the
instructions under FEATURES.
Q: My filter has turned light brown and rust colored. Do I need a new filter?
A: Probably not. Since your filter has been made with Protec™antimicrobial the change in color
indicates only a mineral deposit. Soak filter in a sink full of cool water to help break up deposits. The
discoloration may remain but will not affect the humidifier’s performance.
Q: My humidifier doesn’t appear to be as clean as when I first purchased and/or I’m smelling an
unpleasant odor. What should I do?
A: If you have been using your humidifier regularly for over 30 days, follow the cleaning instructions.
9
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 9

©2006 Kaz, Incorporated All Rights Reserved.
P/N: 31IM300T190
You should first read all instructions before
attempting to use this product.
A. This 3 year limited warranty applies to repair
or replacement of product found to be
defective in material or workmanship. This
warranty does not apply to damage resulting
from commercial, abusive, unreasonable use
or supplemental damage. It also does not
apply to the filter or Protec™Cleaning
Cartridge. Defects that are the result of
normal wear and tear will not be considered
manufacturing defects under this warranty.
KAZ IS NOT LIABLE FOR INCIDENTAL OR
CONSEQUENTIAL DAMAGES OF ANY
NATURE. ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE ON THIS PRODUCT
IS LIMITED IN DURATION TO THE DURATION
OF THIS WARRANTY.
Some jurisdictions do not allow the exclusion
or limitation of incidental or consequential
damages or limitations on how long an
implied warranty lasts, so the above
limitations or exclusions may not apply to
you. This warranty gives you specific legal
rights, and you also may have other rights
which vary from jurisdiction to jurisdiction.
This warranty applies only to the original
purchaser of this product from the original
date of purchase.
B. At its option, Kaz will repair or replace this
product if it is found to be defective in
material or workmanship. Defective product
should be returned to the place of purchase in
accordance with store policy. Thereafter, while
within the warranty period defective product
may be returned to Kaz.
C. This warranty does not cover damage
resulting from any unauthorized attempts to
repair or from any use not in accordance with
the instruction manual.
D. Return defective product to Kaz, Incorporated
with a brief description of the problem.
Include proof of purchase and a $10
US/$15.50 CAN check or money order for
handling, return packing and shipping
charges. Please include your name, address
and a daytime phone number. You must
prepay shipping charges. Send to
:
In U.S.A.:
Kaz, Incorporated
Attn: Returns Department
4755 Southpoint Drive
Memphis, TN 38118
USA
In Canada:
Kaz, Incorporated
Attn: Returns Department
510 Bronte Street South
Milton, ON L9T 2X6
Canada
3 YEAR LIMITED WARRANTY
HCM-300T_HCM-310T_OM.qxd 5/22/06 5:56 PM Page 10