Host HOST1210SH User manual

Back Bar Chiller
Instruction manual
Model:
HOST1210SH
HOST1211DH
HOST1212DS
HOST1213TH
HOST1214TS
HOST1215DS
HOST1216SH
HOST1217DH
HOST1218TS
HOST1219TH
Read this instruction
manual carefully
before use
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 1HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 1 2022/8/16 16:032022/8/16 16:03

2
Safety Instructions
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- BS EN Codes of Practice
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
• DO NOT immerse in water, or use steam/jet washers to clean
the unit.
• DO NOT cover the appliance when it is operating.
• DO NOT store food in the appliance.
• Always carry, store and handle the appliance in a vertical
position.
• Never tilt the appliance more than 45° from the vertical.
• Not suitable for outdoor use.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a
recommended qualified technician in order to avoid a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 2HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 2 2022/8/16 16:032022/8/16 16:03

3
• HOST recommend that this product is connected to a circuit
protected by an appropriate RCD (Residual Current Device).
• HOST recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection, Polarity
Test, Earth Continuity, Insulation Continuity and Functional
Testing.
Caution: Risk of Fire
• Do not store explosive substances such as aerosol cans with
a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of obstruction.
Unit should not be boxed in without adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance.
Installation
Note:
Not for use in vans or trailers, food trucks or similar vehicles.
If the unit has not been stored or moved in an upright position, let it stand upright for
approximately 12 hours before operation. If in doubt allow to stand.
1. Remove the appliance from the packaging and the protective film from all surfaces.
2. Avoid positioning the appliance in direct sunlight or damp areas.
3. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between
the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE
NEXT TO A HEAT SOURCE.
4. Insert the slide-out shelf/shelves at the desired levels and place the smaller shelf/shelves on the floor
of the appliance.
5. If necessary, adjust the screw feet of the appliance to make it level.
Note: Before using the appliance for the first time, clean the shelves and interior with soapy
water then dry well.
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 3HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 3 2022/8/16 16:032022/8/16 16:03

4
Operation
Control Panel
The control panel is located below the doors on the
front of the appliance.
Defrost LightCooling Light
Turn On
1. Close the door of the appliance.
2. Connect the appliance to a mains power
supply.
3. Turn the light switches On [I] or Off [O] as
desired.
Note: The Cooling Light is illuminated when
the appliance is chilling the interior cabinet.
Set the Operating Temperature
1. Press the button. The display will flash.
2. Press the or buttons to display the
required temperature.
3. Press the button to store the temperature.
Manual Defrost
• HOST Back Bar Chillers feature an automatic
defrost. However, should the appliance require
an additional defrost period press and hold the
and button for 6 seconds.
• Automatic defrost cycles are every 6 hours and
last 20 minutes (factory defaults).
• To stop the Defrost press and hold the and
button for 6 seconds.
Note: If a manual defrost is started this resets
the automatic defrost timer. During defrost
periods the Defrost light is illuminated.
Cleaning, Care &
Maintenance
Switch off and disconnect from the power
supply before cleaning
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Always wipe dry after cleaning.
Condensation will form in refrigeration with
frequent opening of the doors and on hot
humid days, please ensure condensation is
allowed to drain properly or is wiped dry.
Cleaning the Condenser
Periodically cleaning the condenser can extend the
life of the appliance. The condenser is located at
the back of the appliance.
Note: Use a soft brush or vacuum cleaner to
clean the fins of the condenser, taking care
not to damage the fins.
Removing the Doors (Sliding Doors
only)
When cleaning the appliance or replacing the
lamp it may be necessary to remove the doors to
improve access.
To remove the doors:
1. Holding the sides of the first door, lift the door
into the upper runner.
2. Pull the bottom of the door out and down
simultaneously so the door clears the bottom
runner.
Note: The automatic door-closing system
means that the doors are attached to the
appliance by a cord. Do not break or remove
this cord.
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 4HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 4 2022/8/16 16:032022/8/16 16:03

5
3. Place the door to the side of the appliance.
4. Repeat for the remaining doors.
5. To replace the doors, slot them into the upper runner and then push the bottom of the door in and
down to slot it in to the bottom runner.
Troubleshooting
A qualified technician must carry out repairs if required.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug or lead is damaged Replace plug or lead
Fuse in the plug has blown Replace the fuse
Mains power supply fault Check mains power supply
The appliance turns
on, but the temperature
is too high/low
Condenser blocked with dust Clean Condenser
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a heat
source or air flow to the condenser
is being interrupted
Move the appliance to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Insufficient airflow to the fans Remove any blockages to the fans
Appliance is overloaded Reduce the amount stored in the appliance
The appliance is
unusually loud
The appliance is touching a
neighbouring object
Check installation position and change if
necessary
The appliance has not been
installed in a level or stable
position
Check installation position and change if
necessary
Service
Should your appliance have a fault, please visit the Service section of the HOST website.
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 5HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 5 2022/8/16 16:032022/8/16 16:03

6
Technical Specifications
Model Voltage Power Current Temperature
Range
Capacity
(Litres) Refrigerant Dimensions (H x W x D) (mm)
Weight
(kg)
Max. load
of each
shelf
HOST1210SH 230V 50Hz 180W 1.25A 2°C to 10°C 138 R600a 900 x 600 x 520 48 28kg
HOST1211DH 230V 50Hz 230W 1.66A 2°C to 10°C 208 R600a 900 x 900 x 520 62 25kg
HOST1212DS 230V 50Hz 230W 1.66A 2°C to 10°C 208 R600a 900 x 900 x 520 62 25kg
HOST1213TH 230V 50Hz 280W 1.66A 2°C to 10°C 330 R600a 900 x 1350 x 520 80 25kg
HOST1214TS 230V 50Hz 300W 1.76A 2°C to 10°C 330 R600a 900 x 1350 x 520 80 25kg
HOST1215DS 230V 50Hz 230W 1.66A 2°C to 10°C 198 R600a 850 X 900 X 520 62 25kg
HOST1216SH 230V 50Hz 180W 1.25A 2°C to 10°C 128 R600a 850 X 600 X 520 48 28kg
HOST1217DH 230V 50Hz 230W 1.66A 2°C to 10°C 198 R600a 850 X 900 X 520 62 25kg
HOST1218TS 230V 50Hz 300W 1.76A 2°C to 10°C 320 R600a 850 X 1350 X 520 80 25kg
HOST1219TH 230V 50Hz 280W 1.66A 2°C to 10°C 320 R600a 850 X 1350 X 520 80 25kg
Note: Due to our continuing program of research and development, the specifications herein may subject
to change without notice.
Optimal Storage temperature
for food storage:
4°C
Optimal ambient temperature
and humidity:
This appliance is intended to operate in climates where
the maximum temperature and humidity are 30°C and
60% respectively
Impact of temperature settings
on food waste:
This appliance shall be operated in its designated
operating range to reduce food waste from spoilage
Ordering spares parts: To order spare parts, please visit the link below:
www.host-appliances.com
Then type the relative item code and Spares
Minimum period of spares
parts to be available:
Door handles, door hinges, knobs, dials and buttons, door
gaskets, peripheral trays, baskets and racks for storage,
as appropriate to the appliance, will be made available
to both end users and professional users for a minimum
of eight years after the last unit of the model is placed on
the market. A broader selection of parts will also be made
available to Professional users for this period
To find the model information
on the product:
The location of the model No. is on the plate on the interior
right-hand wall (and on the rear) of the appliance
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 6HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 6 2022/8/16 16:032022/8/16 16:03

7
Electrical Wiring
The appliance is supplied with a 3 pin BS1363 plug and lead.
The plug is to be connected to a suitable mains socket.
The appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must not
be disposed of as household waste. To help prevent possible harm to human health and/
or the environment, the product must be disposed of in an approved and environmentally
safe recycling process. For further information on how to dispose of this product correctly,
contact the product supplier, or the local authority responsible for waste disposal in your
area.
HOST parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical,
photocopying, recording or otherwise, without the prior written permission of HOST.
Every effort is made to ensure all details are correct at the time of going to press, however, HOST reserve the right to change specifications
without notice.
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 7HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 7 2022/8/16 16:032022/8/16 16:03

We {Host} of {Host House,Newhouse Farm Industrial Estate, Mathern, Chepstow, NP16 6UP} hereby declare that the equipment is in
conformity with the requirements of the following Regulations:
Supply of Machinery (Safety) Regulations 2008
Electromagnetic Compatibility Regulations 2016
The Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment Regulations 2012
Ecodesign for Energy-related Products Regulations 2010 (as amended)
We hereby declare that:
Equipment Model number HOST1210SH - Back Bar Cooler with Single Hinged Door Black - 900mm
HOST1211DH - Back Bar Cooler with Double Hinged Doors Black - 900mm HOST1212DS -
Back Bar Cooler with Double Sliding Doors Black - 900mm HOST1213TH - Back Bar Cooler with
Triple Hinged Doors Black - 900mm HOST1214TS - Back Bar Cooler with Triple Sliding Doors
Black 900mm
HOST1215DS - Back Bar Cooler with Double Sliding Doors Black - 850mm
HOST1216SH - Back Bar Cooler with Single Hinged Door Black - 850mm
HOST1217DH - Back Bar Cooler with Double Hinged Doors Black 850mm HOST1218TS -
Back Bar Cooler with Triple Sliding Doors Black- 850mm
HOST1219TH - Back Bar Cooler with Triple Hinged Doors Black- 850mm
is in conformity with the applicable requirements of the following documents
Ref. No.
Edition/date
BS EN 60335-1
2012 +A11:2014 +A13:2017 +A1:2019 +A14:2019 +A2:2019 +A15:2021
BS EN 60335-2-89
2010 +A1:2016 +A2:2017
BS EN 62233
2008
BS EN IEC 55014-1
2021
BS EN IEC 55014-2
2021
BS EN IEC 61000-3-2
2019 +A1:2021
BS EN 61000-3-3
2013 +A1:2019 +A2:2021
I hereby declare that the equipment named above has been designed to comply with the relevant sections of the above referenced
specifications and is in accordance with the requirements of the Regulations:
Signed by:
Full Name Jess Attree
Title: General Manager
Location: Chepstow, Great Britain
Date: 9th August 2022
UKCA Declaration of Conformity
DocuSign Envelope ID: A041EEBA-EF35-4361-9E96-FD9EF75C521D
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 8HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 8 2022/8/16 16:032022/8/16 16:03

HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 9HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 9 2022/8/16 16:032022/8/16 16:03

HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 10HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 10 2022/8/16 16:032022/8/16 16:03

HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 11HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 11 2022/8/16 16:032022/8/16 16:03

HOST1210SH to HOST1219TH_EN_A5_v1_2022/08/16
www.host-appliances.com
HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 12HOST1210SH to HOST1219TH_EN_A5_v1_20220816.indb 12 2022/8/16 16:032022/8/16 16:03