HP Kayak XA Manual

Mini-Tower
PC Workstations HP Kayak XU PC Workstation 1-1
1
1
HP Kayak XU PC Workstation
Models and Accessories
NOTE: All models are supplied with a 1.44 MB Flexible Disk
Drive, an integrated Ultra Wide 16-bit SCSI controller,
and an integrated IDE controller.
Product
Number
Processors Std.
RAM
Hard
Drive
Video Controller Multi-
media
LAN
Kayak XU 6/xxx PC Workstation
HP Kayak XU 6/350 MHz Series 0301 (CPL: 7/98 )
D5680N Single
Pentium II
with 512 KB
of L2 cache
memory
64 MB
SDRAM
ECC
4.5 GB
10k rpm,
SCSI
Matrox
Millennium II
AGP, 8 MB on
board,
upgradeable to
16 MB
32✕IDE
CD-ROM.
Audio chip
(AD1816) is
integrated
on the
system
board.
10BT/
100TX
HP Kayak XU 6/400 MHz Series 0301 (CPL: 6/98 )
D5682N Single
Pentium II
with 512 KB
of L2 cache
memory
64 MB
SDRAM
ECC
4.5 GB
10k rpm
SCSI
Matrox
Millennium II
AGP, 8 MB on
board,
upgradeable to
16 MB
32✕IDE
CD-ROM.
Audio chip
(AD1816) is
integrated
on the
system
board.
10BT/
100TX
D5683N Single
Pentium II
with 512 KB
of L2 cache
memory
2 ✕
4.5 GB
10k rpm
SCSI
with HP
FastRAID
D5684N Dual
Pentium II
with 512 KB
of L2 cache
memory
128 MB
SDRAM
ECC
9.1 GB
10k rpm
SCSI

HP Kayak XU PC Workstation
1-2 HP Kayak XU PC Workstation Mini-Tower
PC Workstations
1Supported Accessories
1. Not compatible with unbuffered ECC DIMMs.
2. Dual Processor Kits include: processor, voltage regulator module and heatsink.
SDRAM 32MB 72bit 100MHz main memory (non-buffered ECC) D6521A
SDRAM 64MB 72bit 100MHz main memory (non-buffered ECC) D6522A
SDRAM 128MB 72bit 100MHz main memory (non-buffered ECC) D6523A
SDRAM 256MB 72bit 100MHz main memory (registered ECC)1D6524A
4 MB memory upgrade for Matrox Millennium II AGP video controller D5487A
8 MB memory upgrade for Matrox Millennium II AGP video controller Available
from Matrox
HP FastRAID2 Accessory Kit D6690A
User’s Guide Manual D5699A
Dual Processor Kits2
Pentium II 350 MHz containing 512 KB internal L2 cache D6527A
Pentium II 400 MHz containing 512 KB internal L2 cache D6528A
Input Devices
HP mouse C3751B
HP SmartCard keyboard C4737A
Video Displays
All current HP Displays (see the HP Kayak Accessory Service Handbook)
Mass Storage
4.5 GB UW-SCSI hard disk 7.2k rpm D5368B
4.5 GB UW-SCSI hard disk 10k rpm D5481A
9.1 GB UW-SCSI hard disk 10k rpm D6520A
Flexible disk 3.5-inch 1.44 MB (1-inch high) D2035B
IDE 32✕CD-ROM drive D4384A

HP Kayak XU PC Workstation
Mini-Tower
PC Workstations HP Kayak XU PC Workstation 1-3
1
System Board, BIOS and Memory
Internal speak
e
Mic In
16-bit SCSI
Processor 1
Processor 2
AGP Slot
PCI Slots RAIDport
I/O Fan
Status Panel
Power
Disk Drive Fan
Switches
FDD
VRM 2 VRM 1
Memory Modules
ISA Slots
Processor Fan
Video Board
LAN + SCSI Board
UP
External Battery
LCD Panel
CD In Audio
Aux In Audio
IDE 1 Connect
Wake On LAN
External Start
4
3
2
1

HP Kayak XU PC Workstation
1-4 HP Kayak XU PC Workstation Mini-Tower
PC Workstations
1System Board Switches
Setup and BIOS History
For the latest BIOS, the flasher utility program, and the BIOS history refer to the
HP World Wide Web site. The BIOS is in the form HK11xxx.FUL, where xx is the
version number.
1. UP=OFF, DOWN=ON (refer to the diagram on page 3 of this chapter for switch positioning).
2. Refer to “Recovery Boot Active Procedure” in Appendix B for the detailed recovery procedure.
1. PCI Bus Frequency is 33 MHz
ISA Bus Frequency is 8.25 MHz
2. UP=OFF, DOWN=ON (refer to the diagram on page 3 of this chapter for switch
positioning).
Switch Function Default
1-5 — Processor frequency, see following table —
6UP
1Retain configuration in EEPROM, normal position UP
DOWN Clears EEPROM
7 UP Enables User and Administrator passwords UP
DOWN Clears User and Administrator passwords
8UP Disables power on using keyboard DOWN
DOWN Enables keyboard power on
9 UP Minitower package UP
DOWN Desktop package
10 UP Normal operation UP
DOWN Recovery boot active (force BIOS flashing)2
Processor
Frequency1
Local Bus
(FSB)
Frequency
Switch
12345
233 MHz 66 MHz UP2UP UP DOWN DOWN
266 MHz 66 MHz UP UP DOWN UP UP
300 MHz 66 MHz UP UP DOWN UP DOWN
333 MHz 66 MHz UP UP DOWN DOWN UP
350 MHz 100 MHz UP UP UP DOWN DOWN
400 MHz 100 MHz UP UP DOWN UP UP
450 MHz 100 MHz UP UP DOWN UP DOWN
500 MHz 100 MHz UP UP DOWN DOWN UP
http://www.hp.com/go/kayaksupport

HP Kayak XU PC Workstation
Mini-Tower
PC Workstations HP Kayak XU PC Workstation 1-5
1
Installing a Dual Processor / Replacing a Processor
HP Kayak XU PC Workstations are supplied with dual processor slots and either
one or two processors installed. Single processor models can be upgraded to
dual processor systems by installing the second processor accessory in the
vacant slot.
The second processor must be a Pentium II processor of the same speed and
level-2 cache memory capacity as the first. It is installed by gently sliding the
processor into the vacant processor connector slot until the two plastic clips at
the sides engage to lock the processor into place.
Every processor that is installed, or replaced, must be accompanied by the
voltage regulator module (VRM) that was supplied with it. Each VRM is specific
to the processor with which it was supplied, and should only be used with that
processor.
The following table explains how to perform supported processor upgrades.
NOTE: After installation of a second processor, the operating
system must be reinstalled.
1. Switch settings must be changed. Ensure that the latest BIOS version
has been installed.
2. Supplied processor must be removed.
Upgrade
to
2 ✕
350MHz
2 ✕
400M Hz
1 ✕
350MHz
Add D6527A1Remove 350MHz
processor2
Add 2 ✕D6528A1
1✕
400MHz
Add D6528A1
Plastic clips
Heat-sink
Bracket pillars

HP Kayak XU PC Workstation
1-6 HP Kayak XU PC Workstation Mini-Tower
PC Workstations
1Cache Memory
512 KB of level-two cache memory is integrated in the Pentium II processor
package.
Main Memory
The PC Workstation has four DIMM slots on the system board for installing
main memory; slots 1, 2, 3 and 4. Models are supplied with 64 MB or 128 MB of
main memory. If additional memory is required, up to 1 GB may be installed.
Memory upgrades are available in single 64 MB, 128 MB or 256 MB ECC SDRAM
modules. A serial EEPROM on each DIMM contains data on the memory speed.
This information is read at each power on, and access time settings are set
accordingly.
NOTE: 256 MB registered ECC SDRAM modules are not
compatible with non-buffered ECC SDRAM modules
(64 MB, or 128 MB). Therefore, memory can be
upgraded to a maximum of 1 GB using multiples of
256 MB registered ECC SDRAM modules, or up to
512 MB using any combination of 64 MB or 128 MB
modules.
Video Memory
There is 8 MB of video memory already supplied on the graphics controller
board. Memory may be upgraded to a maximum of 16 MB by installing a
memory module of 4 MB, or 8 MB onto the board. No switch or jumper settings
need to be changed (all jumpers should be left in the positions in which they
were set by the manufacturer).

HP Kayak XU PC Workstation
Mini-Tower
PC Workstations HP Kayak XU PC Workstation 1-7
1
Part Numbers
1
1h
1g
1f
2b
1c
7
5
6
78
10
1d
9
1a
11
14
13
12
15
16
17
18
19
1i
1k
1l
20a
20b
4
3
1b
1j
2a
1e
20c

HP Kayak XU PC Workstation
1-8 HP Kayak XU PC Workstation Mini-Tower
PC Workstations
1
Parts List for HP Kayak XU PC Workstation
Item Description Repl.
Part Number
Exchange
Part Number
1 Box assembly:
a I/O Guide + Fan + Speaker assembly
b Cover lock assembly
c LCD status panel kit
d Multimedia control panel
e Hard disk drive tray (5.25-inch)
f Filler panel 3.5-inch
g Filler panel 5.25-inch
h Multimedia bezel
i Hard drive fan
j Processor airflow guide
k Processor retainer airflow guide
l SCSI holder protection
Not shown:
Bumper foot
5064-3665
5064-6055
5062-5590
5064-3683
5064-3383
5002-1946
5042-1405
5042-1178
5042-1873
5064-6054
5064-3674
5042-3013
5042-3014
5042-2479
—
—
—
—
—
—
—
—
—
—
—
—
—
2 a Logo HP Kayak XU PC Workstation
b Logo HP
5042-3021
5042-3030
—
—
3 UW-SCSI Hard disk drive (standard)1:
4.5 GB, 10k rpm
9.1 GB, 10k rpm
D4625-63001
D6451-63001
D4625-69001
D6451-69001
4 Power supply unit 0950-2772 —
5 Flexible disk drive (bezel-less) D2035-60172 —
6 CD-ROM drive (standard):
32✕IDE D4384-63001 D4384-69001
7 Rail kit (3.5-inch and 5.25-inch) 5063-7922
8 Internal IDE cable2(for CD-ROM) 5183-2713 —
9 CD-ROM to audio cable 5182-1857 —
10 Internal LAN cable 5183-2786 —
11 Headset 5064-2673 —
12 HP 10/100 BT SCSI/PCI LAN Board 5064-3616 D5755-69001
13 Graphics board
Millennium II AGP (8 MB) 5064-6062 D5680-69501
14 FastRAID2 (Adaptec ARO2) card with
SIMM 16 MB memory
5064-3668 D6690-69001
15 2-button mouse with scrolling wheel C4736-60101 —
16 CPU holder 5042-1162 —
17 System board See system board parts list
18 Processor terminator 5064-6722
19 Flexible disk cable 5183-0746 —

HP Kayak XU PC Workstation
Mini-Tower
PC Workstations HP Kayak XU PC Workstation 1-9
1
1. For optional disk drive information, refer to the Accessories section of this Service
Handbook.
2. This is a specific IDE cable with the master connector on one end and the slave connector
in the middle of the IDE cable.
3. Adapter is connected between the end of the 8-bit SCSI cable and the add-on LAN/SCSI
board.
4. Where “xx” is the code for your national keyboard (refer to the Accessories section of this
Service Handbook.
20 SCSI cables
a) 16-bit SCSI
b) 8-bit SCSI
c) Wide to narrow3 SCSI adapter
5183-6019
5183-2179
1252-8186
—
—
Not
Shown
Keyboards:
Enhanced keyboard C4734-602xx4—
Power cable (European 220V) 8120-1689
I/O blank panel 45935-00004 —
Screw mach 6 x 32 2680-0311
Parts List for HP Kayak XU PC Workstation
Item Description Repl.
Part Number
Exchange
Part Number

HP Kayak XU PC Workstation
1-10 HP Kayak XU PC Workstation Mini-Tower
PC Workstations
1
1. Heat-sink is integrated in the Pentium II processor package.
2. Accessory only.
System Board Parts List for HP Kayak XU PC Workstation
Description Repl.
Part Number
Exchange
Part Number
System board: D5680-63001 D5680-69001
Processors1:
Intel Pentium II 350 MHz, 512 KB cache D6527-63001 D6527-69001
Intel Pentium II 400 MHz, 512 KB cache D6528-63001 D6528-69001
Voltage regulator module (VRM) 0950-2837 —
Main memory modules 100 MHz):
1 ✕32 MB main memory ECC SDRAM2
1 ✕64 MB main memory ECC SDRAM
1 ✕128 MB main memory ECC SDRAM
1 ✕256 MB main memory Registered ECC
D6521-63001
D6522-63001
D6523-63001
D6524-63001
—
D6522-69001
D6523-69001
D6524-69002
Manuals and Documentation for HP Kayak XU PC Workstation
User’s Guide D5699-90001 and
electronic file
Familiarization Guide electronic file -
D5699-90901
Technical Reference Manual electronic file only
Software for HP Kayak XU PC Workstation
Kayak XU & XW Drivers and documentation CD-ROM 5011-5270