HTC Blue Angel User manual

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 2 PAGE NO. 1
Service Manual
for Blue Angel
HTC Proprietary
Confidential Treatment Requested
Rev. A03
Jun 22, 2005
HTC Corp.
Engineering Mobility

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 3 PAGE NO. 2
TITLE: Service Manual
Revision Control Table
REV. DATE CONTENTS DEP. REVISED APP ´ DSTGE.PER.
AX01 Aug,16 2004 First Draft Technical
Support
Felix Lu
AX02 Sep,7 2004 Update Antenna Test Technical
Support
Felix Lu
A01 Sep,16 2004 Update Board Level & Labeling Plan Technical
Support
Felix Lu
A02 Jan,06 2005 Update Antenna Spec & Image
address for SD Card Backup Technical Support
Felix Lu
A03 Jun,22 2005
1. Repair notice for Keypad (Qwerty)
assembly (P.23).
2. Set screw driver torque to 0.9±0.05kgf-cm
for unit assembly (P.26)
3. Run In test for NFF unit verification.(P.29)
4. Unit SPL updated (P.54).
5. Main battery label identification (P.63).
6. Updated board level SPL (P.71).
Technical
Support
Henry_Dal

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 4 PAGE NO. 3
Table of contents
1. INTRODUCTION ······························································································4
2. PRODUCT SPECIFICATION···············································································4
3. EXPLODED DIAGRAM······················································································8
4. ASSEMBLING AND DISASSEMBLING ··································································9
4.1 DISASSEMBLING···························································································9
4.2 ASSEMBLING ·····························································································21
5. DIAGNOSTICS PROGRAM AND WINCE TEST ITEM ··········································28
5.1 TOOLS REQUIRED·······················································································28
5.2 HOW TO ENTER DIAGNOSTIC·······································································28
5.3 LIST OF DIAGNOSTICTEST /WIN CE TEST ITEM ···········································28
5.4 LIST OF RUN IN TEST ITEMS (DIAGNOSTIC MODE)·······································29
5.5 TEST ITEM OPERATION ···············································································30
6. MAIN BATTERY RE-CERTIFY PROCEDURE ······················································32
6.1 FLOW CHART·····························································································32
6.2 MEASUREMENT PROCEDURE ······································································33
6.3 BATTERY RUNDOWN TEST ········································································38
7. COSMETIC INSPECTION CRITERIA··································································40
7.1 DEFINITION OF COSMETIC STANDARD··························································40
7.2 VISUAL INSPECTION REQUIREMENTS ···························································40
7.3 DEFINITON OF INSPECTION DEFECTS AND AREAS ·········································40
7.4 COSMETIC CRITERIA TABLE········································································41
8. OS, GSM AND EXTENDED ROM IMAGE REFLASH PROCEDURE·······················42
9. FTA (FAULTY TREE ANALYSIS)·····································································48
10. SPARE PART LIST ······················································································53
11. PHOTO OF SPARE PART ·············································································55
APPENDIX …………………………………………………………………………..59
A. CUSTOMER,RETAILER MISJUDMENT ·····························································59
B. GENERIC LABELING PLAN·············································································62
C. RF ANTENNA TEST SPECIFICATION·······························································64
D. BOARD LEVEL 2.5 REPAIRS··········································································66
E. PROBLEM IDENTIFICATION &TROUBLESHOOTING ··········································68
F. BLUE ANGEL SPARE PART LIST FOR BOARD LEVEL REPAIR ···························71

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 5 PAGE NO. 4
1.Introduction
This manual provides the technical information to support the service activities of Harrier.
This document contains highly confidential information, so any or all of this document should not
be revealed to any third party.
2.Product Specification
Platform
•Microsoft Pocket PC 2003 Phone Edition – English, Korean, Spanish, Traditional Chinese, Simplified Chinese,
Italian, Portuguese, German
•Dimensions: Main unit 18.7mm(T) x 69.8mm(W) x 125mm (H)
•Weight (Main Unit) under 210g
Processor
•Low power, high performance 32-bit Intel PXA 263 CPU 400MHz (embedded 32MB NOR Flash)
•IT Calypso + IOTA, GSM/GPRS solution
Memory
•Flash ROM: 32/64/96MB
•Flash RAM: 64/128MB
LCD Module
•3.5” Transflective TFT-LCD with back-light LEDs, 240 x 320 x 64K Colors
•Sensitive touch screen
GSM/GPRS functional block
•GPRS/GSM (Tri-band) module
•GSM900: 880-915, 925-960MHz, GSM1800: 1710-1785, 1805-1880MHz, GSM1900: 1850-1910, 1930-1990MHz
•Internal antenna for tri-band GSM
•Call holding, waiting, forwarding, barring, Calling Line Identity (CLI)
•SMS (Short Message Service), MT, MO, SM reply, replace, acknowledgement, validity, 8 bit SMS data class 0/1 SMS
•Display own number, telephone number storage capability w/Mute feature, Network selection, Cell broadcast
•Explicit Call Transfer (ECT), Spool icon, Phase 2 Unstructured supplementary service data-MO/MT
•WAV Ring tone download/compose, Long message (640 characters), Network Lock
•AMR/EFR/FR/HR, EOTD, CPHS v4.2, PBCCH
•GPRS class B, Multi-slot standard class 10

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 6 PAGE NO. 5
•3V SIM operation, SIM Application Toolkit class 3, Release 00, Over the programming
•Security: Ciphering A5.1 & A5.2, PIN1 & 2 control
Stylus
•Lock type mechanism
Keyboard/button/switch
•One power button (Wake-up key)
•One voice recorder/voice command button (Wake-up key)
•One volume control button (up and down)
•One Camera capture button (Wake-up key)
•One 5-way navigation button (Wake-up key)
•Two phone buttons: SEND (Yes) & END (No) buttons (Wake-up keys) (with LED backlight)
•RESET switch
•Built-in 39 keys extractable QWERTY Keyboard (Wake-up key) (with LED backlight)
•Key lock
•6 programmable AP buttons (1. Contacts 2. Calendar. 3. Start 4. Inbox 5. Menu 6. Done/OK) (Wake-up key)
Notification
•One bi-color LED (Green and Red) LED in the first lens for GSM standby, GSM message, GSM network status, PDA
charging status, and PDA notification
•Two respective (Blue and Green) LEDs in the same second lens for Bluetooth/WiFi status
•Notification by Sound and Message on the display
•Vibrator for notification
Audio
•Built-in Microphone, receiver and speaker
•SW echo cancellation
•Loudspeaker
•SW echo cancellation, HW Full duplex
•Receiver
•16-bits with 8KHz, 11KHz, 16KHz, 22KHz, 44.1KHz, 48KHz sampling rate [TBD]
•WAV/WMA/MP3 stereo
CMOS Camera
•Color CMOS camera module
•Resolution: VGA/QVGA/CIF/QQVGA
•JPEG encoder
•Fix Focus Function

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 7 PAGE NO. 6
•Preview mirror on battery cover
•Operation in 5 Lux (min.)
•Video Light [TBD]
Power
•Battery
`Removable rechargeable Lithium Ion battery, 1400mAh (Typical)
`Separated backup battery (20mAh, rechargeable)
`Battery life: 15hrs of PDA only (without RF) [TBD]
`Talk time of 3~5 hours (at nominal RF Tx power level)
`Standby time: 200hrs
`Data Retention Time: 72hrs
•AC Adapter
`AC input: 100 ~ 240 Vac, 50/60Hz
`AC input current: 0.2 Aac (max.)
`Output voltage: 5Vdc (typical)
`Output current: 2Adc (typical)
Environment
•Operating temp: 0 ~50 degree C. Humidity : 90% RH
•Storage tem: -20 ~ 60 degree C. Humidity : 90% RH
Peripheral Interface
•Feature connector (22 pin)- Serial, USB Slave, power signals and Audio (support Car kit)
•Infrared Port IrDA CIR (including remote control controller)
•One Audio Jack (2.5ψ)
•One R-UIM card slot
•One SDIO/MMC card slot (B-Square SDIO driver)
•One External antenna connector
802.11b Wireless LAN
•Frequency Range: 2.4GHz to 2.4835GHz
•Standards: IEEE 802.11b Direct Sequence Spread Spectrum compliant
•Data Rates with Automatic Fallback:: 11Mbps_CCK, 5.5Mbps_CCK, 2Mbps_DQPSK, 1Mbps_DBPSK
•Operation Channels: 1-11 for North America, 1-13 for Europe, 1-14 for Japan, 10-11 for Spain, 10-13 for France
•Encryption: 64-, 128- bit WEP standard data encryption
•Media Access Control: CSMA/CA with ACK
•Network Architecture: Ad-Hoc Mode (Peer to Peer without Access point), Infrastructure Mode (Communications to wired

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 8 PAGE NO. 7
networks via Access Points with Roaming)
•Antenna: Internal antenna
Bluetooth
•Bluetooth 1.1 compliant
•Class 2 transmit power-support voice and data transmission
Accessories
•Sync. Cable (USB/Serial)
•Cradle (USB, Serial)
•AC adapter
•Car adapter
•Stylus
•AC adapter power plug
•Car Kit (capable of muting car stereo when incoming call or call proceeding)
•Stereo Wired headset-stereo earpiece with microphone
•Mono Wired headset-mono earpiece with microphone
•Mono Bluetooth headset-mono earphone with microphone
•Optional Battery (1400mAh)
•VGA/TV out kit (through USB interface, with AC input, remote control for presentation)
•Remote kit with FM Radio Tuner
•Remote Controller for VGA output
•WiFi SD card
•TTY Adapter
Regulatory
•NTSL, BQCF Certification, USB v1.1 Compliance test, JAVA TCK
•R&TTE : EMC/SAR
•CDG 1, 2, and 3
Applications
•JAVA Virtue Machine (J2ME, CLDC, MIDP 2.0, JAM)
•WAP 2.0 browser
•MMS (with video clip support)
•Camera Capture Utility (Resolution: VGA/QVGA/CIF/QQVGA)
•Image Viewer/Album, Voice Recognition, Text to Speech, Photo ID, SIM Manager, SD Backup, Wireless Modem, Universal
Remote Controller, Polyphonies MIDI ring tone, Instant Message

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 9 PAGE NO. 8
3. Exploded Diagram

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 10 PAGE NO. 9
4. Assembling and Disassembling
4.1 Disassembling
Tools needed for Assembling and Disassembling.
1. Lens Cleaning Tissue.
2. Philip Screw Driver 000X50
3. Philip Screw Driver 000X40.
4. Torex Screw Driver T6X40
5. Torex Screw Driver T5X40
6. Tweezers.(Suggest to use plastic made)
1. Pull up to release the Stylus.
2. Remove the SD Card Filler.
3. Remove the Antenna Insert Rubber.
Unlock the fixing lock, then take out the battery
as indicated on the left.
Warning: To reduce risk of fire or burns, do
not disassemble, crush, puncture, short external
contacts, or dispose of in fire or water. Replace only
with specified batteries. Recycle or dispose of used
batteries properly.
1 2 3 4 5 6
3
2 1

HTC confidential
© 2004, HTC Corporation. All rights reserved. TOTAL 71 CONT.ON. 11 PAGE NO. 10
There are 4 screws at the rear side of the unit.
Note that there is 2 types of screws are used.
The P/N would be as follows:
1. 72H00642- 00M
2. 74H00441- 00M
To open de case, remove 2 more screws
surrounding the side of the unit as indicated on the
left.
Note that screw P/N is 72H00642- 00M.
Once the 6 screws have been removed, Use fingers
to open the housing.
2
1