IEI Technology AFL3-W07A-BT-N1 User manual

AFL3-W07A-BT-N1 Panel PC
Page I
User Manual
AFL3-W07A-B
T
-N1
MODEL:
Flat Bezel Panel PC with Intel® Celeron
®
N2807 Dual-Core CPU,
Touchscreen, Dual USB 3.0, Dual GbE LAN, Dual RS-232,
HD Audio, Wi-Fi 802.11a/b/g/n/ac, IP 65 Rating and RoHS
Rev. 1.01 - November 11, 2014
User Manual

AFL3-W07A-BT-N1 Panel PC
Page II
Revision
Date Version Changes
November 11, 2014 1.01 Updated Wi-Fi specification to 802.11a/b/g/n/ac
July 22, 2014 1.00 Initial release

AFL3-W07A-BT-N1 Panel PC
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

AFL3-W07A-BT-N1 Panel PC
Page IV
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 FEATURES................................................................................................................... 3
1.3 FRONT PANEL............................................................................................................. 3
1.4 REAR PANEL............................................................................................................... 4
1.5 BOTTOM PANEL.......................................................................................................... 4
1.6 SYSTEM SPECIFICATIONS............................................................................................ 6
1.7 DIMENSIONS............................................................................................................... 8
2 UNPACKING................................................................................................................. 9
2.1 UNPACKING.............................................................................................................. 10
2.2 PACKING LIST............................................................................................................11
2.3 OPTIONAL ITEMS.......................................................................................................11
3 INSTALLATION ......................................................................................................... 13
3.1ANTI-STATIC PRECAUTIONS...................................................................................... 14
3.2 INSTALLATION PRECAUTIONS................................................................................... 14
3.3 INSTALLATION AND CONFIGURATION STEPS ............................................................. 15
3.4 MSATAMODULE INSTALLATION.............................................................................. 15
3.5AT/ATX MODE SELECTION...................................................................................... 18
3.5.1 AT Power Mode................................................................................................ 18
3.5.2 ATX Power Mode............................................................................................. 18
3.6 EXTERNAL PERIPHERAL DEVICE CONNECTION ........................................................ 19
3.6.1 LAN Connection............................................................................................... 19
3.6.2 Serial Device Connection ................................................................................ 20
3.6.3 USB Device Connection................................................................................... 20
3.7 MOUNTING THE SYSTEM .......................................................................................... 21
3.7.1 Wall Mounting.................................................................................................. 22
3.7.2 Panel Mounting................................................................................................ 25
3.7.3 Cabinet and Rack Installation ......................................................................... 26
3.7.4 Arm Mounting .................................................................................................. 29

AFL3-W07A-BT-N1 Panel PC
Page V
3.7.5 Stand Mounting................................................................................................ 31
3.7.6 V-Stand Mounting............................................................................................. 32
3.8 POWERING ON THE SYSTEM..................................................................................... 34
3.9 RESET THE SYSTEM.................................................................................................. 35
3.10 CLEAR CMOS........................................................................................................ 35
3.11 SOFTWARE INSTALLATION ...................................................................................... 36
3.11.1 Keypad AP...................................................................................................... 37
4 BIOS SETUP................................................................................................................ 38
4.1 INTRODUCTION......................................................................................................... 39
4.1.1 Starting Setup................................................................................................... 39
4.1.2 Using Setup...................................................................................................... 39
4.1.3 Getting Help..................................................................................................... 40
4.1.4 Unable to Reboot after Configuration Changes.............................................. 40
4.1.5 BIOS Menu Bar................................................................................................ 40
4.2 MAIN........................................................................................................................ 41
4.3ADVANCED............................................................................................................... 43
4.3.1 ACPI Settings................................................................................................... 44
4.3.2 F81866 Super IO Configuration...................................................................... 45
4.3.2.1 Serial Port n Configuration....................................................................... 45
4.3.2.1.1 Serial Port 1 Configuration................................................................ 46
4.3.2.1.2 Serial Port 2 Configuration................................................................ 46
4.3.3 F81866 H/W Monitor....................................................................................... 48
4.3.4 RTC Wake Settings........................................................................................... 49
4.3.5 Serial Port Console Redirection ...................................................................... 50
4.3.6 CPU Configuration.......................................................................................... 51
4.3.7 IDE Configuration........................................................................................... 53
4.3.8 USB Configuration........................................................................................... 54
4.4 CHIPSET ................................................................................................................... 55
4.4.1 North Bridge Configuration............................................................................. 56
4.4.1.1 Internal IGD Configuration....................................................................... 56
4.4.2 South Bridge Configuration............................................................................. 58
4.4.2.1 PCI Express Configuration....................................................................... 60
4.5 SECURITY................................................................................................................. 61
4.6 BOOT........................................................................................................................ 62

AFL3-W07A-BT-N1 Panel PC
Page VI
4.7 SAVE &EXIT............................................................................................................ 64
5 SYSTEM MAINTENANCE ....................................................................................... 66
5.1 SYSTEM MAINTENANCE INTRODUCTION.................................................................. 67
5.2ANTI-STATIC PRECAUTIONS...................................................................................... 67
5.3 TURN OFF THE POWER.............................................................................................. 68
5.4 REMOVING THE BACK COVER.................................................................................. 68
5.5 WLAN CARD REPLACEMENT .................................................................................. 69
5.6 REINSTALLING THE COVER....................................................................................... 71
6 INTERFACE CONNECTORS................................................................................... 72
6.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 73
6.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 74
6.2.1 Battery Connector (CN2)................................................................................. 74
6.2.2 LVDS Connector (LVDS2)............................................................................... 75
6.2.3 MCU Connector (JSPI2).................................................................................. 75
6.2.4 PCIe Mini Connector, Full-Size (M_PCIE1)................................................... 76
6.2.5 PCIe Mini Connector, Half-Size (M_PCIE2)................................................... 77
6.2.6 Power LED Connector (PW_LED1)................................................................ 78
6.2.7 Speaker Connector (CN3)................................................................................ 78
6.2.8 SPI Flash Connector (JSPI1)........................................................................... 78
6.2.9 Touch Panel Connector (TOUCH_USB1) ....................................................... 78
6.2.10 USB 2.0 Connector (HUB_USB1)................................................................. 79
6.2.11 VGA Connector (VGA_CON1)....................................................................... 79
6.2.12 Webcam Connector (CAM_USB1)................................................................. 79
6.3 EXTERNAL INTERFACE PANEL CONNECTORS............................................................ 80
6.3.1 Ethernet Connectors (LAN1 & LAN2)............................................................. 80
6.3.2 Power Connector (CN5)............................................................................... 81
6.3.3 RS-232 DB-9 Serial Ports (COM1) ................................................................. 81
6.3.4 RS-232 DB-9 Serial Ports (COM2) ................................................................. 81
6.3.5 USB 3.0 Connectors (USB_CON1).................................................................. 82
A SAFETY PRECAUTIONS......................................................................................... 83
A.1 SAFETY PRECAUTIONS ............................................................................................ 84
A.1.1 General Safety Precautions............................................................................. 84
A.1.2 Anti-static Precautions .................................................................................... 85

AFL3-W07A-BT-N1 Panel PC
Page VII
A.1.3 Product Disposal............................................................................................. 86
A.2 MAINTENANCE AND CLEANING PRECAUTIONS........................................................ 86
A.2.1 Maintenance and Cleaning.............................................................................. 86
A.2.2 Cleaning Tools................................................................................................. 87
B BIOS MENU OPTIONS............................................................................................. 88
C WATCHDOG TIMER ................................................................................................ 91
D HAZARDOUS MATERIALS DISCLOSURE......................................................... 94
D.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ....................................... 95

AFL3-W07A-BT-N1 Panel PC
Page VIII
List of Figures
Figure 1-1: AFL3-W07A-BT-N1 Flat Bezel Panel PC....................................................................2
Figure 1-2: Front View....................................................................................................................3
Figure 1-3: Rear View.....................................................................................................................4
Figure 1-4: Bottom Panel...............................................................................................................5
Figure 1-5: AFL3-W07A-BT-N1 Dimensions (mm).......................................................................8
Figure 3-1: Back Cover Retention Screws.................................................................................16
Figure 3-2: Open the Back Cover................................................................................................16
Figure 3-3: mSATA Module Slot Location..................................................................................17
Figure 3-4: mSATA Module Installation......................................................................................17
Figure 3-5: AT/ATX Switch Location...........................................................................................18
Figure 3-6: LAN Connection........................................................................................................19
Figure 3-7: DB-9 Serial Port Connector......................................................................................20
Figure 3-8: USB Device Connection...........................................................................................21
Figure 3-9: Wall-mounting Bracket.............................................................................................22
Figure 3-10: Chassis Support Screws........................................................................................24
Figure 3-11: Secure the Panel PC...............................................................................................24
Figure 3-12: Cutout Dimensions.................................................................................................25
Figure 3-13: Panel Mounting Kit Installation .............................................................................26
Figure 3-14: Rack/Cabinet Bracket Installation.........................................................................27
Figure 3-15: Rack Mounting Kit Installation ..............................................................................28
Figure 3-16: Install into a Rack/Cabinet .....................................................................................28
Figure 3-17: Arm Mounting Retention Screw Holes..................................................................30
Figure 3-18: Arm Mounting..........................................................................................................30
Figure 3-19: Stand Mounting (Stand-A/Bxx)..............................................................................31
Figure 3-20: Drill Pilot Holes for V-Stand...................................................................................32
Figure 3-21: Secure V-Stand to System .....................................................................................33
Figure 3-22: Secure V-Stand to Mounting Area.........................................................................33
Figure 3-23: Powering On the System........................................................................................34
Figure 3-24: Reset Button Location............................................................................................35
Figure 3-25: Clear CMOS Button Location.................................................................................35
Figure 3-26: Keypad AP ...............................................................................................................37

AFL3-W07A-BT-N1 Panel PC
Page IX
Figure 5-1: Back Cover Retention Screws.................................................................................69
Figure 5-2: WLAN Card Location................................................................................................70
Figure 5-3: Releasing the WLAN Card........................................................................................70
Figure 5-4: Removing the WLAN Card .......................................................................................71
Figure 6-1: Main Board Layout Diagram (Front Side)...............................................................73
Figure 6-2: Main Board Layout Diagram (Solder Side).............................................................73

AFL3-W07A-BT-N1 Panel PC
Page X
List of Tables
Table 1-1: System Specifications..................................................................................................7
Table 6-1: BIOS Navigation Keys................................................................................................40
Table 6-1: Peripheral Interface Connectors...............................................................................74
Table 6-2: Battery Connector (CN2) Pinouts .............................................................................74
Table 6-3: LVDS Connector (LVDS2) Pinouts............................................................................75
Table 6-4: MCU Connector (JSPI2) Pinouts...............................................................................76
Table 6-5: PCIe Mini Connector (M_PCIE1) Pinouts .................................................................76
Table 6-6: PCIe Mini Connector (M_PCIE2) Pinouts .................................................................77
Table 6-7: Power LED Connector (PW_LED1) Pinouts.............................................................78
Table 6-8: Speaker Connector (CN3) Pinouts............................................................................78
Table 6-9: SPI Flash Connector (JSPI1) Pinouts.......................................................................78
Table 6-10: Touch Panel Connector (TOUCH_USB1) Pinouts.................................................79
Table 6-11: USB 2.0 Connector (HUB_USB1) Pinouts..............................................................79
Table 6-12: VGA Connector (VGA_CON1) Pinouts ...................................................................79
Table 6-13: Webcam Connector (CAM_USB1) Pinouts ............................................................80
Table 6-14: Rear Panel Connectors............................................................................................80
Table 6-15: Ethernet Connectors (LAN1 & LAN2) Pinouts.......................................................80
Table 6-16: Power Connector (CN5) Pinouts.............................................................................81
Table 6-17: RS-232 DB-9 Serial Ports (COM1) Pinouts.............................................................81
Table 6-18: RS-232 DB-9 Serial Ports (COM2) Pinouts.............................................................81
Table 6-19: USB 3.0 Connectors (USB_CON1) Pinouts............................................................82

AFL3-W07A-BT-N1 Panel PC
Page XI
List of BIOS Menus
BIOS Menu 1: Main.......................................................................................................................41
BIOS Menu 2: Advanced..............................................................................................................43
BIOS Menu 3: ACPI Settings .......................................................................................................44
BIOS Menu 4: F81866 Super IO Configuration..........................................................................45
BIOS Menu 5: Serial Port n Configuration Menu.......................................................................45
BIOS Menu 6: F81866 H/W Monitor.............................................................................................48
BIOS Menu 7: RTC Wake Settings..............................................................................................49
BIOS Menu 8: Serial Port Console Redirection.........................................................................50
BIOS Menu 9: CPU Configuration...............................................................................................51
BIOS Menu 10: IDE Configuration...............................................................................................53
BIOS Menu 11: USB Configuration.............................................................................................54
BIOS Menu 12: Chipset................................................................................................................55
BIOS Menu 13: North Bridge Configuration ..............................................................................56
BIOS Menu 14: Internal IGD Configuration................................................................................56
BIOS Menu 15: South Bridge Configuration..............................................................................58
BIOS Menu 16: PCI Express Configuration ...............................................................................60
BIOS Menu 17: Security...............................................................................................................61
BIOS Menu 18: Boot.....................................................................................................................62
BIOS Menu 19: Save & Exit..........................................................................................................64

AFL3-W07A-BT-N1 Panel PC
Page 1
1 Introduction
Chapter
1

AFL3-W07A-BT-N1 Panel PC
Page 2
1.1 Overview
Figure 1-1: AFL3-W07A-BT-N1 Flat Bezel Panel PC
The AFL3-W07A-BT-N1 is a dual-core Intel® Celeron® processor N2807 powered flat
bezel panel PC with a rich variety of functions and peripherals. The compact design is
ideal for easy and simplified integration into kiosk and point-of-sales (POS) applications.
The Intel® Celeron® N2807 is a SoC (System-on-Chip) that ensures optimal memory,
graphics, and peripheral I/O support. The system comes with 2.0 GB of DDR3L on-board
memory ensuring smooth data throughputs with reduced bottlenecks and fast system
access.
Two serial ports and two external USB 3.0 ports ensure simplified connectivity to a variety
of external peripheral devices. Wi-Fi capabilities and two RJ-45 Ethernet connectors
provide the system with smooth connection to an external LAN.

AFL3-W07A-BT-N1 Panel PC
Page 3
1.2 Features
The AFL3-W07A-BT-N1 features are listed below:
7” flat-bezel LCD with LED backlight
1.58 GHz dual-core Intel® Celeron® processor N2807
On-board 2 GB DDR3L memory
Projected capacitive type touchscreen
Wi-Fi 802.11a/b/g/n/ac 2T2R high speed wireless
One built-in 2 W speaker
Optional RFID reader
IP 65 compliant front panel
1.3 Front Panel
The front side of the AFL3-W07A-BT-N1 is a flat-bezel panel with a 7” TFT LCD screen
surrounded by a PC/ABS plastic frame (4Figure 1-2).
Figure 1-2: Front View
There is a power LED indicator located on the front panel. The status descriptions of the
power LED indicator are listed below.
Off: power cord not attached or power supply failure
Solid amber: the system is connected to a power source and is ready to be
turned on.
Solid green: the system is turned on.

AFL3-W07A-BT-N1 Panel PC
Page 4
1.4 Rear Panel
The rear panel provides access to retention screw holes that support VESA mounting.
See 4Figure 1-5.
Figure 1-3: Rear View
1.5 Bottom Panel
The bottom panel of the AFL3-W07A-BT-N1 has the following connectors and switches
(4Figure 1-6):
1 x 9 V ~ 30 V DC input power jack
2 x RS-232 DB-9 connector
2 x GbE RJ-45 connector
2 x USB 3.0 connector
1 x AT/ATX switch
1 x Power button
1 x Reset button

AFL3-W07A-BT-N1 Panel PC
Page 5
Figure 1-4: Bottom Panel

AFL3-W07A-BT-N1 Panel PC
Page 6
1.6 System Specifications
The technical specifications for the AFL3-W07A-BT-N1 systems are listed in 4Table 1-4.
Specification AFL3-W07A-BT-N1
LCD Size 7" (16:9)
Max. Resolution 1024 (W) x 600 (H)
Brightness (cd/m2) 500
Contrast Ratio 700:1
LCD Color 262K
Pixel Pitch (H x V) (mm) 0.05 (H) x 0.15 (V)
Viewing Angle (H-V) 150° / 145°
Backlight LED backlight (MTBF: 20,000 hrs)
Touchscreen Projected capacitive type with USB interface
(Touch controller: EETI EXC7200)
CPU (SoC) 1.58 GHz dual-core Intel® Celeron® processor N2807
Ethernet Two Realtek RTL8111E PCIe GbE controllers supportASF2.0
Memory On-board 1066 MHz 2 GB DDR3L memory
Storage One full-size PCIe Mini card slot for mSATA module installation
Audio Realtek ALC892 HD Audio codec
Speaker AMP 2 W (built-in stereo speaker, left channel output)
Wireless One 802.11a/b/g/n/ac 2T2R wireless LAN module (half-size PCIe
Mini card)
RFID Reader MIFARE 13.56 MHz card reader (optional)
OSD Function Controlled by OSD software

AFL3-W07A-BT-N1 Panel PC
Page 7
Construction Material PC+ABS plastic front frame
Mounting VESA 75 mm x 75 mm (panel, wall, rack, stand or arm mounting)
Front Panel Color Black
Net Weight 700 g
Dimensions (W x H x D) 191 mm x 127 mm x 43 mm
Operating Temperature -10ºC ~ 50ºC
Storage Temperature -20ºC ~ 60ºC
Humidity 10% ~ 95% (non-condensing)
IP Level IP 65 compliant front panel
Power Supply 36 W power adapter
Input: 90 V AC ~ 264 VAC @ 50 Hz/ 60 Hz
Output: 12 V DC
Power Requirement 9 V ~ 30 V DC
Power Consumption 25 W
Safety/EMC CE, FCC
I/O Ports and Switches 2 x RS-232 (DB-9 connector)
2 x GbE LAN (RJ-45 connector)
2 x USB 3.0 connectors
1 x Power button
1 x AT/ATX switch
1 x Reset button
1 x 9 V ~ 30 V DC input jack
Table 1-1: System Specifications

AFL3-W07A-BT-N1 Panel PC
Page 8
1.7 Dimensions
The AFL3-W07A-BT-N1 dimensions are shown below.
Width: 190.9 mm
Height: 127.3 mm
Depth: 43.4 mm
Figure 1-5: AFL3-W07A-BT-N1 Dimensions (mm)