Jayco JAY FLIGHT BUNGALOW Towables 2021 User manual

Owner’s Manual
0190626.2021
2021
Towables
A subsidiary of Thor Industries, Inc.

Table of Contents

Factory Tours 9
Options and Equipment 9
Dealer Responsibility 9
Customer Relations 9
To Contact Us 11
About This Manual 11
Warranty Packet 12
Safety Alerts 12
Reporting Safety Defects 13
Customer Responsibility 14
Change Of Address/Ownership 14
Suggestions For Obtaining Service 14
Obtaining Service For Separately Warranted Items 15
Obtaining Service At Our Customer Service Facility 15
Parts and Accessories 15

Secondary Means of Escape (Exit Window) 23
Exit Window Label
Fire Safety 24
Fire Extinguisher 24
Smoke Alarm 25
Combination Carbon Monoxide /Propane Alarm 26
Formaldehyde 30
Extended Or Full Time Usage 30
Cold Weather Usage 30
Condensation 31

Tow Vehicle 33
Vehicle Labels 33
Weight Terms 33
Weight and Capacity Labels 33
OCCC Label (yellow)
Federal Certication Label
Tire and Loading Information
Loading Your Recreation Vehicle 35
Rear Bumper 35
Travel Trailer Hitch (customer supplied) 36
Travel Trailer Hitch Weight 36
Travel Trailer Hitch Height and Hitch Ball 36
Travel Trailer Hitching Procedure 37
Travel Trailer Safety Chains 38
Safety Chain Installation
Wire Harness/Connector Plug 39
Weighing Your Tow Vehicle and RV 39

Towing 41
RV Brake System 42
Electric Brakes 42
Brake Controller (customer supplied) 43
Travel Trailer Breakaway Switch 43
Hydraulic Brakes (if so equipped) 43
Towing Behind Your RV 44
2021 Jayco Jay Flight Bungalow Rev.A: Revise page 13

Table of Contents
Entrance Door Step(s) 44
Disc Brakes (if so equipped) 44
Stowable Entrance Door Step (if so equipped) 45
Entrance Door 46
Campsite Hook-Up 46
Stabilizer Jacks 47
Manual Stabilizer Jacks (if so equipped) 47
Electric Stabilizer Jacks (if so equipped) 47
Emergency Stopping 48
Emergency Towing 48
Wheel Lugs 48
Wheel Lug Nut Diagrams 49
Wheel Lug Nut Torque Values 50
Tires 51
Changing A Tire 55
Spare Tire Carrier (if so equipped) 56
Hoist Mount 56
Bracket Mount Travel Position
Hoist Mount Travel Position
Bumper Mount 57
Bumper Mount
Crank Access Port
 59
Awnings (if so equipped) 60
Awning Care 60
Electric Patio Awning with Remote Control 60
In Motion Detector if so equipped) 60

Electric Slide Room(s) (if so equipped) 61
Slideout Overlap-Outside
General Slideout Troubleshooting Checklist 62
Flush Floor Slideout 62
Schwintek In-Wall Slideout System 64
Norco Slideout System 67
Power Gear Slideout System 68
Fig.1 Slideout Controller
Power Gear Slim Rack Slideout System 70
Power Gear Ram Slideout System 74

The Electrical System 77
In Case Of An Electrical Fire 77
Command Center 78
Command Center Panel
Command Center Panel w/Switch Modules
GFCI Receptacle 79
Command Control System (If So Equipped) 79
BMPro MINI SYSTEM (If So Equipped) 80
LCI One Control® App(if so equipped) 82
Testing The Campsite Power Connection 84
Power Converter 85
Converter With Charge Wizard (if so equipped) 87
12-Volt DC System 87
12-Volt Fuse Panel 87

Table of Contents
Auxiliary Battery (customer supplied) 88
Replacing A Fuse 88
12-Volt DC Outlet 88
Dry Camping 89
Replacement and Maintenance 89
Battery Isolator For Your Tow Vehicle (customer supplied) 89
Battery Disconnect Switch (if so equipped) 89
Load Center 90
120-Volt Circuit Breakers 90
Typical Load Center Panel
Battery Disconnect Switches
Approximate Electrical Load Ratings 91
120-Volt 50 AMP AC Electric System (if so equipped) 92
50 amp Power Cord 93
Calculating 50 amp Electrical Load (if so equipped) 93
Solar Prep (if so equipped) 94
Replacing Light Bulbs 94
Solar Plug

Exhaust Gas Fumes 95
Propane Gas System 95
Propane Gas Container 96
Servicing or Filling 97
LP Gas Container Overll 98
Maintenance 98
Propane Cylinder Recertication 98
Hoses, Pipes, Tubes and Fittings 98
Propane Regulator 99
Propane Use and Safety 99
Propane System Label
Using the Propane System 100
Cooking With Propane Gas 101
Calculating Propane Gas Usage 101
Installing Propane Cylinder(s) 102
Single Cylinder
Traveling With Propane 102
Main Supply Hose
Double Cylinder
Two Propane Cylinders

Plumbing System 105
Plumbing System Maintenance 105
Monitor Panel 105
Monitor Panel
Command Center
Fresh Water System 107
Water Pressure Regulator (customer supplied) 107
Fresh Water Connections 108
City Water Fill with City Water Connection Label
Water Pump Strainer
Potable Water Label
Gravity Water Fill

Table of Contents
Draining the Fresh Water System 110
Sanitizing/Winterizing the Plumbing System (No Utility Center) 110
Exterior Fresh Water Drain
Low Point Drains
How To Sanitize 111
Winterizing the Plumbing System 113
Water Heater Drain Plug Location
Water Heater 118
Operating instructions 118
Water heater bypass 118
High altitude deration 119
Pressure and temperature relief valve 119
Draining and winterization 119
Outside Shower (if so equipped) 120
Faucets 120
Bathroom Tub / Shower 120
Black/Grey Water System and Tanks 121
Black and Grey Tank Drains 123
Black/Grey Tank Drain and Valves
Black Tank Flush (if so equipped) 124
Toilet (If So Equipped) 124
Tank Flush Inlet

Air Conditioner 127
Roof Mount (if so equipped) 127
Wall Mount (if so equipped) 127
Heat Pump Operation (if so equipped) 127
Power Roof Vent (if so equipped) 127
Attic Fan Control
Furnace 128

Microwave 131
Cooking Safety 131
In Case Of a Grease Fire 131
Cooktops, Range and Oven (if so equipped) 132
Cooking With Propane (if so equipped) 132
Range Hood (if so equipped) 134
Refrigerator 134
Range Hood Vent
Washer/Dryer Prep (if so equipped) 136
Dryer Vent Label
Water Heater – See Plumbing Section 137

HDTV Antenna 139
HDTV Antenna (if so equipped) 139
Antenna Power Supply (if so equipped) 139
Satellite (if so equipped) 139
Antenna Power Supply

Cleaning The Interior 141
Décor Glass (if so equipped) 141
Furniture Upholstery 141
Sofa and Dinette 143

Table of Contents
Hide-A-Bed Sofa or Sofa Sleeper 143
Jack Knife Sofa 143
Trifold Sofa 143
Cube Sofa 144
Booth Dinette (if so equipped) 144
Free-Standing Table and Chairs (if so equipped) 144
Pantry or Hutch (if so equipped) 145
Countertops 145
Laminate Countertops (if so equipped) 145
Solid Surface Countertops (if so equipped) 145
Flooring 146
Carpet 146
Vinyl Flooring 146
Bed Storage 146
Prop Rod (if so equipped) 146
Gas Struts (if so equipped) 147
Bunk Beds (if so equipped) 147
Bunk Bed Ladder (if so equipped) 147

Cleaning The Exterior 149
Frame 151
E-Z Lube or Super-Lube Axle (if so equipped) 151
Exterior Roof and Sidewall Vents 151
Windows 152
Exterior Ladder (if so equipped) 152
Sealants 153
Travel Trailers - Sealant Diagram 154

Travel Checklist 155
RV Storage 156

Featured Components Quick Reference Chart 159
Vehicle Maintenance Record 161
Ownership Notication 162

Table of Contents

7

         

This manual has been provided by your recreational vehicle manufacturer for the sole pur-
pose of providing instructions concerning the operation and maintenance of this recreational
vehicle. Nothing in this manual creates any warranty, either expressed or implied.

Please review the limited warranty and the limited warranties that apply
to specic components oered with this vehicle.
Instructions are included in the manual for operating various components which are optional
on some RV’s or may not be available on your particular model. 

 In addition, the owner should refer to individual manufac-
turer’s operating instructions contained in the owner’s packet.



8


