JNE Caroline's Cart Maintenance and service guide

SAFETY AND OPERATING
RECOMMENDATIONS FOR CAROLINE'S CART

2JNE REtail Equipment | 4433 Manitoba Rd SE | Calgary, AB T3E 6N4
Important Safety Information
Introduction...
The age and weight restrictions for the seat occupant of a
Caroline's Cart is over 48 months and 35 lbs to 250 lbs.
Apply front two wheel brakes and rear center brake before
seating or removing occupant.
Only place occupant in the seat area. (One occupant per cart).
Strap the occupant into the seat using the 5 point safety
harness seatbelt. Please read the instructions that are sewn
into the strap of the seatbelt.
Release all brakes before moving the cart after the occupant is
safely seated and the safety harness is buckled.
Do not permit children to ride in the basket or on the lower
platform of Caroline’s Cart.
Do not allow children to climb on the cart platform or into the
cart basket.
Do not leave the occupant unattended.
Caroline’s Cart should only be pushed by an adult and the
occupant should only be seated as illustrated in this safety
brochure.
Caroline’s Cart should not be overloaded and the load should
be properly distributed as you shop.
Educate your employees when and how to intervene if they
observe unsafe use of a Caroline’s Cart.
Educate the customer on how to use Caroline’s Cart
before use.
Prior to use and to reduce risk Technibilt strongly recommends that it is the obligation of the owner and user to
read and follow consistently, all safety and operating instructions published in this brochure.
INTRODUCTION/SAFETY
The intended use of a Caroline’s Cart is for transporting a special needs individual
while shopping for retail goods. The following safety suggestions are recommended.
WARNING
!
ONLY USE CART SEAT FOR SPECIAL NEEDS OCCUPANT
AGE OVER 48 MONTHS AND 35-250 LBS
OCCUPANT CAN FALL OUT OF CART AND SUFFER SERIOUS INJURY
ALWAYS lock
ALL
3 brakes before seating and removing occupant •
ALWAYS rotate handles upright when seating or removing occupant •
ALWAYS buckle up occupant in cart seat and fasten securely •
ALWAYS rotate handles down when pushing the cart •
STAY
with your occupant at all times
DO NOT
use your own personal
infant carrier
DO NOT
allow children to ride in
basket or on platform
Warning Statements Located on Cart
WARNING
!
APPLY FRONT TWO WHEEL BRAKES
& REAR BRAKE BEFORE SEATING
AND REMOVING OCCUPANT. DO
NOT STEP OR STAND ON
PLATFORM.
Caroline’s Cart should be located and stored inside the store at a designated area.
Caroline’s Cart storage area should be clean and dry.
Parking lots and access ramps should be properly maintained and free of debris at all times.
Caroline’s Cart should not be dropped or pushed off of curbs.
Customers and employees should always use the access ramp from the parking lot to the store
when operating this cart
CART STORAGE AND STORE ACCESS

3
www.jneretail.com | Ph: 403-243-2705 | Fax: [phone]
INSTRUCTONS FOR PROPER OCCUPANT SEATING AND
OPERATION OF CAROLINE'S CART
1. Apply front two wheel brakes
& rear brake before seating the
occupant. Do not step or stand on cart
cart platform.
2. Turn up handles to open. 3. Place occupant into seat. Do
not stand or step on platform.
4. Buckle up occupant in cart seat and fasten securely. See seatbelt instructions below.
Secure the chest belt by inserting
one end into the other.
Secure the belt between the legs by
inserting the two ends of the chest
harness into the buckle.
Pull the red loops for a snug t.
5. Place handles down. 6. Release front two wheel
brakes and rear brake before
moving the cart.
7. Cart is ready for shopping.
Apply all brakes
Turn handles up
Unbuckle the occupant
Remove the occupant
Unload your purchased items from the cart
Release all brakes
Turn handles down
Return the cart to the store for storage
When the shopping experience is complete and you are ready to remoVe the occupant and
unload your cart you must:

JNE Retail Equipment. | 4433 Manitoba Road SE | Calgary, AB T3E-6N4
www.jneretail.com.com | Ph: 403-243-2705 | Fax: [phone]
Customer Service
JNE Retail Equipment Inc.
4433 Manitoba Rd SE.
Calgary, AB
T3E 6N4
We recommend that a copy of the Safety
and Operating Brochure be kept on le or
displayed within your facility. Technibilt is not
responsible for aftermarket additions to carts,
maintenance performed by outside contractors or
for refurbishment work performed on carts by any
refurbishment company.
Maintenance & Safety Inspection Recommendations
Daily Visual Inspection
Checklist
Periodic Physical Inspection
by Service Company
Seat Belts: Damaged or missing.
Wheels/Casters: Damaged or missing.
Cart condition: Bent or broken parts.
Plastic accessories: Damaged or missing.
Brakes: Damaged or missing. See photo
below.
Check warning stickers. (See page two)
A qualied service company will have a specic procedure for
inspecting and repairing shopping carts. The procedure should
include, but not be limited to, the following recommendations. Parts
should be repaired or replaced as required. All carts should show
proof of inspection. (i.e. inspection sticker)
Check the overall cart condition. Check for broken welds, bent
parts, and missing parts. Assure that all moving parts are working
properly.
Check seat belts. Assure all seat belts are working correctly and are
properly secured to carts. Replace belts every 3 years.
Check wheels and casters. Casters and wheels should swivel and
turn freely. Assure casters and wheels are properly secured to carts.
Keep carts clean.
Check for missing or damaged accessories.
Check and test all three brakes to ensure all are working properly.
Due to normal wear and tear of Caroline's Carts, it is imperative that routine inspections and preventative maintenance
be performed to assure continued safe operation of your carts. We recommend Caroline's Carts be inspected, cleaned,
and if necessary, repaired a minimum of every six months by a qualied service company. Simple visual inspections
by store personnel should be performed daily on all carts. Remove Caroline's Cart from service, if it is found
to be damaged or if it fails one or more safety inspection criteria until repair or replacement can be made.
CART MAINTENANCE
Phone:
403-243-2705
Fax:
403-243-1433
E-Mail:
[email protected]
www.jneretail.com.
Your satisfaction is important.
If you have any comments or questions:
Rear Brake
Front Wheel Brakes