JumpSport 230f Use and care manual

1
1-408-866-6036
www.fitnesstrampoline.com
Use trampoline only with mature, knowledgeable supervision.
WARNING
Read these materials prior to assembling
and using this rebounder trampoline
DO NOT attempt or allow
somersaults. Landing on the
head or neck can cause
serious injury, paralysis or
death, even when landing in
the middle of the bed.
DO NOT allow more than one
person on the trampoline.
Use by more than one person
at the same time can result in
serious injury.
 WARNING: Users should consult with a physician before beginning any exercise or conditioning program.
 If user feels faint or dizzy, immediately stop using the rebounder trampoline.
 Avoid bouncing when tired. Take breaks often.
 Use only in a well lit area by responsible, mature, non-intoxicated persons.
 Never use trampoline on an un-level surface. Only use when dry.
 Keep away from objects which could interfere with safe use. Clear obstructions underneath, above, or around the rebounder
trampoline. Check for adequate vertical clearance (avoid low ceilings, ceiling fans, light fixtures, etc.) and lateral clearance (avoid
furniture, lamps, walls, other trampolines, etc.).
 Inspect before each use. Replace or adjust any loose, worn, defective, or missing parts.
 Do not jump on and off the trampoline. Do not use the trampoline as a springboard to or from other objects. Do not step on the
frame when getting on and off the trampoline.
 Stop bounce by flexing knees as feet come in contact with the trampoline bed. Learn this skill before attempting other more ad-
vanced moves. Control is more important than bounce height.
 For information concerning skill training, contact a qualified fitness trampoline instructor.
 Store and protect trampoline from unauthorized use.
 For additional information, contact us at JumpSport.com or 1-408-866-6036.
It is the responsibility of the purchaser to become familiar with all of the information in this booklet,
to convey the warnings to all users, and to enforce JumpSport’s rules for safe use.
Straight Leg Fitness Trampoline™
User’s Manual
Folding and Non-Folding Models
Retain address information for future use.
JumpSport, Inc.
1680 Dell Ave.
Campbell, CA 95008 U.S.A.
Retain address information for future use.
To unfold/fold your trampoline:
 Lay the trampoline upside down and flat on the ground.
 Place one knee near the center of the mat without going past the center line, facing one of the hinges. Place one hand on the frame next to the
hinge (directly in front of you), place the other hand mid way between the two hinges on the middle of the frame, and slowly push the frame open,
or slowly pull it closed. Don’t wrap fingers completely around frame to avoid pinching them against the ground.
 If the trampoline is too difficult to open or close in a controlled manner, unhook some of the elastic cords adjacent to the hinges, fold the trampo-
line open or closed, and then re-attach the cords.
 After the trampoline is fully opened, lock the frame as shown below (page 2), then adjust the elastic cords to make sure they are all evenly spaced
around the frame.
Note: When folding the trampoline closed, be sure to remove the exercise handle bar and legs (if any are installed), following the instructions for
installing them in reverse order.
Patent info at: patents.JumpSport.com
Instruction Manual P/N: INS-P-20943-00M
Copyright © 2016, by JumpSport, Inc. All rights reserved.
** Unfolding/Folding the Model 230f Rebounder**
WARNING: When folding and unfolding the trampoline, keep head and face away from
frame at all times. Failure to do so can cause serious injury to head or face, or lead to other
serious injuries.

2
How to install folding legs found on the model 230f:
1) Pull a leg rotating up and away from the frame.
2) Align the leg with the frame stud, then gently guide it
into place over the socket until the leg rests against
frame.
3) The leg should now be secure in this new position. Re-
peat until you have unfolded all 6 legs, then rotate the
trampoline until all legs are on the ground.
To fold the legs, follow the instructions in reverse order.
Installing the Legs
CAUTION
How to install screw on legs found on the model 200:
1) Take a leg and screw it onto a threaded frame stud.
2) Rotate the leg until it is fully seated on the frame
stud and make sure it is tight
3) The leg should now be secure in this new position.
Repeat until you have tightened all 6 legs, then ro-
tate the trampoline until all legs are on the ground.
To remove the legs, follow the instructions in re-
verse order.
CAUTION
Avoid Injury.
Exercise handle bar (when at-
tached to the rebounder) is not
designed to support your entire
weight. It is to aid with balance
and provide exercise versatility.
Pinch Point.
Keep hands away from the
end of the leg that contacts
the frame to avoid getting
pinched as it pulls tight.
Lock hinges when using trampoline Unlock hinges to fold frame
Straight leg
LEG-A-20395-00
Straight leg with spring
SPR-A-20847-00

3
1) Remove two (2) of the existing trampoline
leg caps from the locations shown. If in-
stalling on a folding trampoline, make sure
that a hinge is between the legs of the caps
that are being removed.
2) Slide the HANDLE LEGS onto the 2 tram-
poline legs as shown.
3) Slide each end of the TOP HANDLE into
the SIDE HANDLES and secure with the
snap buttons forming a top assembly.
4) Lower this top assembly into the HANDLE
LEGS until the holes line up. You may have
to rotate the entire top assembly 180 de-
grees. Adjust to desired height
before securing with LARGE THUMB
SCREWS.
5) Place the trampoline leg caps back on their
respective legs.
6) Secure the handle legs with the SMALL
THUMB SCREWS in the positions shown.
Installing the Handle
Expected Cord Life
Elastic cords are wear items that
need to be replaced from time to
time. Their life expectancy is
determined by:
 The way the trampoline is being
used (jumping for height vs. con-
trolled, fitness-style bouncing vs.
jogging)
 The user weight and height
 Frequency of bouncing
 The type of cords used
(standard or extra-firm)
We are often asked how long your
cords will last. The answer is, it de-
pends. Some of our customers use
a set for 9 months, while most will
use a set for many years. Similar to
running shoes or car tires, the more
you use them and the harder you
use them, the faster they need to be
replaced.
Replacing Endurolast Cords
1
2
Replace your elastic cords when there is visible damage
or when the cords feel too soft.
1) Remove existing cord. Take the new cord and first
secure each knot into the respective openings as
shown.
2) Pull the loop end out and over the frame, securing it
in the top slot.
3) Be sure to center the cord along U-shaped mat con-
nector, to insure the cord tension is equal on both
sides of connector.
Hinge Location
Top handle
HAN-A-20841-00
Side handles
HAN-A-21051-00
Handle leg
HAN-A-20846-00
Small thumb screws
SCR-P-11706A
Leg cap
CAP-P-11678A
Large thumb screws
SCR-P-11707A
Snap Buttons
BUT-P-21049-00

4
Limited Warranty
What is covered by this warranty? This warranty covers any defects in materials or workmanship on all of the compo-
nents of a new JumpSport Fitness Trampoline system, and is extended exclusively to the original retail purchaser.
How long does this coverage last? Warranty coverage for each component of a new JumpSport® Fitness Trampoline
begins from the original date of purchase and lasts as follows
What will JumpSport do? If you return the defective part to JumpSport, as instructed below, JumpSport will either repair
or replace such part, at JumpSport’s discretion, and return it to you.
What is not covered by this warranty? This warranty covers new products purchased as a complete system; it does not
cover replacement parts. This warranty also does not cover expenses of on-site labor, shipping costs, travel, assembly or disas-
sembly, or other charges associated with the repair or replacement of covered components. Further, this warranty does not cover
any problem that is caused by abuse, misuse, commercial or public use of 200 Series models, ordinary wear and tear, outdoor
use, weathering, acts of God (such as wind and lightning), failure to follow directions, improper installation, improper maintenance,
or any silk screened graphics. Rust is a natural occurrence with any steel product and is likewise not covered by this warranty, to
the extent that it does not affect the structural integrity of the part.
JUMPSPORT IS NOT RESPONSIBLE OR LIABLE FOR INDIRECT, SPECIAL, OR CONSEQUENTIAL DAMAGES ARISING
OUT OF OR IN CONNECTION WITH THE USE OR PERFORMANCE OF THE PRODUCT OR OTHER DAMAGES WITH RE-
SPECT TO ANY LOSS, INCLUDING BUT NOT LIMITED TO ECONOMIC LOSS, LOSS OF PROPERTY, LOSS OF REVENUE
OR PROFITS, LOSS OF ENJOYMENT OR USE, COST OF REMOVAL, INSTALLATION OR OTHER CONSEQUENTIAL DAM-
AGES. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAG-
ES. ACCORDINGLY, THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
THE WARRANTY EXTENDED HEREUNDER IS IN LIEU OF ALL OTHER WARRANTIES AND ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN ITS SCOPE AND DURATION TO THE
TERMS SET FORTH HEREIN. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS. ACCORDINGLY, THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
How to get a defective part replaced:
1) Call the JumpSport Customer Service department at 1-877-507-1399 to obtain a Return Authorization number. All returns must
be pre-authorized.
2) Send the part(s) to the designated Service Center, along with a copy of your original sales receipt and a brief written descript
tion of the problem, including how it occurred. You must pay freight and insurance to return the part to JumpSport. At Jump
Sport’s sole discretion, we may ask you to send photographs in addition to or in lieu of returning the part.
3) After inspecting the returned part(s), JumpSport will make a final determination whether the part is covered by this warranty.
We reserve the right to examine photographs or physical evidence concerning parts claimed to be defective prior to making a
final determination concerning the claim. A repaired or replacement part will be returned to you. (Shipping charges may apply.)
Please allow 3 to 4 weeks for delivery."
This warranty gives you specific legal rights. You may also have other rights which vary from state to state.
*Only the models in our 300 and 500 Series of Fitness Trampolines are approved for commercial use. When used
in a commercial setting, the commercial warranty applies.
Private Use Commercial Use
(Series 300/500 Only)
Steel Frame & Legs Lifetime 5 years
Series 200 Jumping Surface and EnduroLast Cords* 2 years* n/a
Series 300 Jumping Surface and EnduroLast Cords* 3 years* 12 months* (Except the 370)
Series 300 PRO Jumping Surface and EnduroLast Cords* 4 years* 18 months* (Plus the 370) / 1 year on Jumping
Surface
Series 500 PRO Jumping Surface and EnduroLast Cords* 5 years* 18 months* / 1 year on Jumping Surface
All other components (including hinges) 1 year 1 year
*Mat and cord warranty are limited to only one (1) usage replacement during applicable period.
4