Karat K-17920X Assembly instructions
Installation and Care Guide
Pedestal Squat Flush with Tank
1224993-X2-A ©2013 Kohler Co.
K-17920X
1224993-X2-A 2 Kohler Co.
Important Information
Thank You For Choosing Karat
We appreciate your commitment to Karat quality. Please take a few minutes
to review this manual before you start installation. If you encounter any
installation or performance problems, please call 0-2204-6222 for Call Center
(Thailand) and our website are listed on the back cover.
All the information in this guide is based upon the latest product information
available at the time of publication. At Kohler Company, we strive to fulll
our mission of improving the level of gracious living for each person who is
touched by our products and services. We reserve the right to make changes in
product characteristics, packaging, or availability at any time without notice.
Thanks again for choosing Karat.
IMPORTANT NOTICE TO INSTALLERS!: Please leave these instructions for
the consumer. They contain important information.
In addition to installation procedures, this manual contains important care and
cleaning. Please retain for future reference.
NOTE: Some installation parts might not be provided.
NOTE: The toilet pictured in the installation steps may dier from the model
being installed.
Kohler Co. 3 1224993-X2-A
Before You Begin
• Observe all local plumbing and building codes.
• Carefully inspect the new toilet for damage.
• If the existing toilets does not have a supply shut-o valve below the tank,
install one before installing the new toilet.
• Ensure that the inlet and new drain has the correct roughing-in dimension.
• Fixture dimensions are nominal and conform to tolerances established by
Standards TIS 794.
CAUTION: Risk of hazardous gases. If the new toilet is not installed
immediately, temporarily place a rag in the closet ange.
CAUTION: Risk of personal injury or product damage.
Handle with care. Vitreous china can break or chip if the bolts and nuts
are overtightened, or if the product is handled carelessly.
CAUTION: Turn on the water and allow water to ow through the
supply pipe to ush the system of any debris before connecting ll valve
1224993-X2-A 4 Kohler Co.
Installation/
Tools/
1/2"
•
•
•
•
•
1
590
2
Mark the tank mounting holes on the wall. Drill the holes, and insert the anchors.
100
1030
200
500
3/8"
10 มม.
Kohler Co. 5 1224993-X2-A
Installation/
5
6
3
4
Insert the outlet pipe into
the tank and tighten the nut.
Insert outlet pipe to the bowl. Carefully position
until trapway insert into the waste pipe. Draw
outline of bowl and carefully remove
the bowl from the position.
Install the tank on the wall with bolt kit.Verify
the tank is level.
Slide the nut over the top of
inlet pipe and insert gaskets
to the pipe.
1224993-X2-A 6 Kohler Co.
Installation/
7
9
8
Install the bowl. Verify the bowl is level.
1/2"
Supply
สายนํ�าดี
+-
11 Attach the tank cover
Construct 20 mm thick of grout or
white cement along the outline
of bowl on the floor.
Connect supply
and turn on
the water
10
Turn here to adjust the water level.
20 mm/มม.
Kohler Co. 7 1224993-X2-A
Care and Cleaning
Kohler Co. shall not be responsible or liable for any tank ing damage caused
by the use of cleaners containing chlorine (calcium hypochlorite).
For best results, keep the following in mind when caring for your product:
• Use a mild detergent such as liquid dishwashing soap and warm water for
cleaning. Do not use abrasive cleaners that may scratch or dull the surface.
• Carefully read the cleaner product label to ensure the cleaner is safe for use
on the material.
• Always test your cleaning solution on an inconspicuous area before applying
to the entire surface.
• Do not allow cleaners to sit or soak on the surface.
• Wipe surfaces clean and rinse completely with water immediately after
cleaner application. Rinse and dry any overspray that lands on nearby surfaces.
• Use a soft, dampened sponge or cloth. Never use an abrasive material such
as a brush or scouring pad to clean surfaces.
WARNING: Risk of property or product damage. Do not use in-tank
cleaners in your toilet. Products containing chlorine (calcium hypochlorite)
can seriously damage ings in the tank. This damage can cause leakage
and property damage.
1224993-X2-A 8 Kohler Co.
•
•
•
•
•
•
Kohler Co. 9 1224993-X2-A
Symptoms Recommended Action
1. Poor ush. A. Adjust the tank water level to match the waterline.
B. Fully open the water supply shut-o valve.
C. Clear obstructions from the trapway, jet, or bowl rim
holes.
D. Clear obstructions from the waste line.
2. No ush. A. Reconnect the apper chain to the trip lever or ush
valve.
B. Adjust the apper chain assembly to remove
excessive slack.
3. The ll valve
turns on/o by
itself without
the toilet being
ushed, or it
runs, allowing
water to enter
the tank.
A. Adjust the apper chain for proper slack so the
apper closes.
B. Clean or replace the apper if it is worn, dirty, or
misaligned with the opening.
C. Clean the area around the opening to allow the
apper to seal.
D. Adjust the tank water level if it is too high.
E. Replace the ll valve if the valve oat sinks.
4. Tank takes
excessive time
to ll.
A. Fully open the water supply shut-o valve.
B. Check the exible supply line (if applicable) for
a kink. Remove the kink.
C. Clean the valve inlet, valve head, or supply line.
Flush the lines.
5.
There is excessive
noise when the
tank is lling.
A. Partially close the water supply shut-o valve if the
water pressure to the toilet is too high. Check the
toilet performance following any such adjustment.
B. Remove dirt or obstructions from the valve head.
Flush the lines.
6. Trip arm strikes
tank lid underside.
A. Adjust ush ball chain assembly to remove excessive
slack.
B. Adjust trip arm bracket and ange so they are parallel
with tank top.
Troubleshooting
1224993-X2-A 10 Kohler Co.
Kohler Co. 11 1224993-X2-A
E-mail: [email protected]
KOHLER (THAILAND) PUBLIC COMPANY LIMITED
16th FL. Jasmine City Bldg., 2 Soi Sukhumvit 23, Sukhumvit Road, Wattana, Bangkok 10110 Thailand
Call Center Tel. +(66) 2204 6222 Fax. +(66) 2204 6224
1224993-X2-A
Table of contents
Other Karat Bathroom Fixture manuals
Popular Bathroom Fixture manuals by other brands
Sussman
Sussman Mr.Steam 300 Series Installation, operation & maintenance manual
Signature Hardware
Signature Hardware Vilamonte 948600 quick start guide
Hans Grohe
Hans Grohe AXOR STARck 10715000 Assembly instructions
Tassili Supra
Tassili Supra Valeria installation guide
PEERLESS
PEERLESS P30LF quick start guide
BELLOSTA
BELLOSTA Aperio 2705/R/B/E Installation instruction
Franke
Franke Protronic-S AQUA131 2000067774 Installation and operating instructions
Lefroy Brooks
Lefroy Brooks M1-4402 Installation, operating, & maintenance instructions
Marbletrend
Marbletrend flinders installation guide
Dornbracht
Dornbracht 12 310 970 90 installation instructions
Gessi
Gessi 54019 Bath Mixing Program
Symmons
Symmons Duro 3600-TRM Installation & operation instructions