Kenwood KDW60W15/A Service manual

Freestanding Dishwasher
KDW60W15/A / KDW60B16/A /
KDW60S16/A
installation / instructions manual
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 1KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 1 15/11/2019 12:05 PM15/11/2019 12:05 PM

KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 2KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 2 15/11/2019 12:05 PM15/11/2019 12:05 PM

Contents
safety warnings .................................................................................................................. 5
unpacking............................................................................................................................ 8
installation........................................................................................................................... 9
location ............................................................................................................................ 9
product overview.............................................................................................................. 13
front view ....................................................................................................................... 13
rear view........................................................................................................................ 13
internal view .................................................................................................................. 14
control panel.................................................................................................................. 15
before operating ............................................................................................................... 16
to open the door ............................................................................................................ 16
to close the door............................................................................................................ 16
items not suitable for use in the dishwasher ................................................................. 16
adding detergent powder or detergent tablet................................................................ 17
adding rinse aid................................................................................................................ 18
adjusting the rinse aid reservoir .................................................................................... 18
adding salt......................................................................................................................... 19
adjusting salt consumption ............................................................................................ 20
loading the dishwasher.................................................................................................... 21
before loading the dishwasher ...................................................................................... 21
upper basket.................................................................................................................. 22
- adjusting the upper basket ...................................................................................... 22
- loading the upper basket ......................................................................................... 22
- hinged cup rack ....................................................................................................... 23
lower basket .................................................................................................................. 23
- hinged spikes .......................................................................................................... 23
- loading the lower basket ......................................................................................... 24
cutlery basket ................................................................................................................ 24
operation ........................................................................................................................... 25
starting a wash cycle ..................................................................................................... 25
changing a programme ................................................................................................. 25
at the end of a programme ............................................................................................ 25
switching off the unit...................................................................................................... 26
unloading the dishwasher.............................................................................................. 26
delay start...................................................................................................................... 26
half load......................................................................................................................... 26
child lock........................................................................................................................ 26
wash cycle table ............................................................................................................... 27
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 3KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 3 15/11/2019 12:05 PM15/11/2019 12:05 PM

cleaning after use............................................................................................................. 28
external care.................................................................................................................. 28
- the door and the door seal ...................................................................................... 28
- the control panel...................................................................................................... 28
internal care................................................................................................................... 28
- ltering system ........................................................................................................ 28
- spray arms............................................................................................................... 29
frost precaution ................................................................................................................ 29
moving the dishwasher.................................................................................................... 29
maintenance after a prolonged period of non-operation.............................................. 30
hints and tips .................................................................................................................... 30
technical problems ........................................................................................................ 30
general problems........................................................................................................... 31
disposal of the dishwasher ............................................................................................. 32
disposal of packing material ........................................................................................... 32
specications.................................................................................................................... 33
product che..................................................................................................................... 34
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 4KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 4 15/11/2019 12:05 PM15/11/2019 12:05 PM

5
safety warnings
For your continued safety and to reduce the risk of injury or electric shock,
please follow all the safety precautions listed below.
• Read all instructions carefully before using the dishwasher and keep them
for future reference.
• Retain the manual. If you pass the dishwasher onto a third party, make sure
to include this manual.
• Keep ventilation openings in the dishwasher enclosure clear of obstructions.
The ventilation openings at the base of the dishwasher must not be
obstructed by carpet.
• Choose a location for your dishwasher away from heat sources such as
radiators or fires.
• Young children should be supervised to ensure that they do not play with
the dishwasher.
• This appliance can be used by children aged from 8 years and above
and persons with reduced physical, sensory or mental capabilities or
lack of experience and knowledge if they have been given supervision or
instruction concerning use of the appliance in a safe way and understand
the hazards involved. Children shall not play with the appliance. Cleaning
and user maintenance shall not be made by children without supervision.
• Keep the appliance and its cord out of reach of children less than 8 years
old.
• Keep children away from detergents and rinse aids. These may cause
chemical burns in the mouth, throat and eyes or asphyxiation.
• Keep children away from the dishwasher when the door is open.
• Switch off water and power and unplug before fitting or removing tools/
attachments, after use and before cleaning.
• Keep your fingers away from moving parts and fitted attachments.
• Never use a damaged machine.
• If the mains cable is damaged, it must be replaced by the manufacturer, its
service agent or a qualified technician in order to avoid a hazard.
• Keep the power unit, mains cable and plug away from water.
• Never exceed the maximum capacities.
• 2 people are required to lift this dishwasher.
• Only use the dishwasher for its intended domestic use.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 5KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 5 15/11/2019 12:05 PM15/11/2019 12:05 PM

6
• This appliance is intended for indoor household use and similar applications
such as:
- farm houses and by clients in hotels, motels and other residential type
environment;
- bed and breakfast type environment;
- catering and similar non-retail applications.
WARNING
IT IS HAZARDOUS FOR ANYONE OTHER THAN AUTHORISED
SERVICE PERSONNEL TO CARRY OUT SERVICING OF REPAIRS
WHICH INVOLVE THE REMOVAL OF COVERS.
TO AVOID THE RISK OF AN ELECTRICAL SHOCK DO NOT
ATTEMPT REPAIRS YOURSELF.
• Do not sit or stand on the door or dish rack.
• Do not move your dishwasher by holding the door or its edges. Hold the
dishwasher around its sides or base when moving it.
• Do not touch the heating element during or immediately after use.
• Do not operate your dishwasher unless all enclosure panels are properly in
place. Open the door very carefully when there is a programme running, as
there is a risk of hot water spraying out of the appliance.
• Do not place any heavy objects on the open door. The appliance could tip.
• When loading items to be washed:
- Locate sharp items so that they will not damage the door seal;
- Warning: Knives and other utensils with sharp points must be loaded in
the basket with the points downwards or placed horizontally.
• Do not allow plastic items to come into contact with heating element.
• Check that the detergent receptacle is empty after completion of the wash
cycle.
• Do not wash plastic items unless they are marked dishwasher safe or
equivalent.
• Use only detergent and rinse aids designed for an automatic dishwasher.
• Other means for disconnection from the supply must be incorporated in the
fixed wiring with at least 3mm contact separation in all poles.
• The door should not be left in the open position since this could present a
tripping hazard.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 6KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 6 15/11/2019 12:05 PM15/11/2019 12:05 PM

7
• For energy saving, always remember to switch the dishwasher off when you
have finished using it. The dishwasher should not be left unattended when
in use.
• Remove the door to the washing compartment when removing an old
dishwasher from service or discarding it.
• During installation, the power supply cord must not be excessively or
dangerously bent or flattened.
• Do not tamper with controls.
• The appliance is to be connected to the water mains using new hose sets.
• The maximum number of place settings to be washed is 12.
• The maximum permissible inlet water pressure is 1 MPa, and the minimum
permissible inlet water pressure is 0.04 MPa.
• Never place heavy or wet items directly on top of the appliance.
earthing instructions
WARNING: THIS APPLIANCE MUST BE EARTHED.
• This appliance is equipped with a mains cable having an equipment-
earthing conductor and an earthing plug.
• The plug must be plugged into an appropriate mains socket that
is installed and earthed in accordance with local standards and
requirements.
Improper connection of the equipment-earthing conductor could result in
a risk of electric shock.
• The wires in the cord are coloured as follows:
Green and Yellow = Earth,
Blue = Neutral,
Brown = Live.
• Check with a qualified electrician or service representative if you are in
doubt whether the appliance is properly earthed or the plug does not
fit correctly.
• Never modify the plug provided with the appliance.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 7KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 7 15/11/2019 12:05 PM15/11/2019 12:05 PM

8
unpacking
Remove all items from the packaging. Retain the packaging. If you dispose of it please do so
according to local regulations.
The following items are included:
The Main Unit
Detergent Measuring Spoon
(1 full spoon = 20g (approx.))
Instruction ManualU-shape Hose HolderSalt Funnel
Measuring Cup
(approx 60ml)
Water Supply Hose
Cutlery Basket
Condensation Strip
Thank you for purchasing your new Kenwood Dishwasher.
These operating instructions will help you use it properly and safely.
We recommend that you spend some time reading this installation/instruction
manual in order that you fully understand all the operational features it offers.
Read all the safety instructions carefully before use and keep this installation/
instruction manual for future reference.
This product has been wet tested to ensure correct
operation. As a result some water may remain
inside the unit. This is normal and safe. Remove
any water droplets from the exterior if necessary.
If items are missing or damaged please contact Partmaster (UK only).
Tel: [phone] for assistance.
Instruction
Manual
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 8KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 8 15/11/2019 12:05 PM15/11/2019 12:05 PM

9
installation
All parts removed must be saved to do
the reinstallation in the future. Ensure
the dishwasher is unplugged and empty.
We recommend that 2 people handle the
dishwasher during installation.
1. Please ensure the dishwasher is installed
by a qualified technician. Refer to the tools
required.
location
When selecting a position for your dishwasher
you should make sure the installation surface
is flat and firm, and the room is well ventilated.
Avoid locating your dishwasher near a heat
source, eg. cooker, boiler or radiator. Extreme
cold ambient temperatures may also cause
the appliance not to perform properly. This
dishwasher is not designed for use in a garage
or outdoors.
Do not cover the dishwasher. When installing,
ensure that free space is left at the sides.
2. Ensure there is clearance each side of the
unit to allow slight sideways movement for
servicing when required. Good levelling is
essential for correct closure and sealing of
the door. When the unit is correctly levelled,
the door should not catch the inner liner on
either side of the cabinet. The adjustable
feet may be loosened or tightened in order to
obtain the optimum levelling of the unit.
The figure outlines the minimum dimensions
required to accommodate the dishwasher
within fitted kitchen furniture units.
3030
level level
level
level
610
845
850 650
min.100
80
603
598
units in mm
installation
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 9KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 9 15/11/2019 12:05 PM15/11/2019 12:05 PM

10
installation
Failure to attach the condensation
strip could result in damage to the
underside of your worktop!
4. The condensation strip must be fitted to
the underside of the worktop above your
dishwasher to protect it against any moisture.
Its purpose is to protect your worktop’s
underside from steam rising from the
dishwasher.
• Ensure the surface is clean prior to
sticking the condensation strip to the
underside of the worktop.
• Remove the backing paper from the
condensation strip.
3. Do not connect the unit to the mains socket
before installation. Ensure you are not
installing the unit right in front of the mains
socket. This is to avoid potential damage to
the back of the unit.
• Stick the condensation strip to the
underside of the worktop. Leave some space
Stick the Condensation Strip
under the worktop, where you
want to install the dishwasher.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 10KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 10 15/11/2019 12:05 PM15/11/2019 12:05 PM

11
installation
• Do not bend your drain hose.
5. Position the dishwasher next to a water tap
and a drain. Ensure the water inlet and drain
hoses are not kinked or squashed. The unit
must not stand on the mains cable.
6. Make sure your plumbing is suitable for
use with the dishwasher. If in doubt contact
a qualified plumber. This unit MUST BE
connected to COLD WATER MAINS using
the new water inlet hose. OLD HOSE SETS
MUST NOT BE RE-USED. The water
pressure from the water mains needs to be at
a minimum of 0.04 MPa and a maximum of
1.00 MPa.
• Connect one end of the safety water
supply hose to your dishwasher, and then
connect the other end of the hose to your
water mains. Please ensure the black
rubber seal is in place.
• After connecting the hose, turn on your
water mains and check for leaks.
• Connect the dishwasher to the mains
socket.
water mains
Y-Adaptor
(not included)
safety water supply hose
Connect
to another
appliance
if required.
You may use a Y-adaptor (not
included) for an additional water
feed for another appliance, for
example a washing machine. This
is only applicable for cold water
mains. A Y-adaptor is available
from most DIY stores.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 11KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 11 15/11/2019 12:05 PM15/11/2019 12:05 PM

12
installation
• You may use the U-shaped drain hose
holder to secure your drain hose and to
avoid bending it.
U-shaped drain
hose holder water drain hose
• Secure the water drain hose to the waste
pipe to avoid it coming off during the
washing process.
• The waste pipe must only be
connected to the foul drains and
not the surface water drainage
system.
• The water drain hose should be
placed between 40 cm and 100
cm from the floor level and must
not be extended, otherwise the
unit may not be able to expel the
waste water properly.
• Please close the hydrant after
use.
Before connecting to the waste
pipe, make sure to check the waste
pipe and remove any stopper or
blockage inside, otherwise the unit
may not be able to expel the waste
water properly.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 12KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 12 15/11/2019 12:05 PM15/11/2019 12:05 PM

13
product overview
front view
rear view
1. control panel
2. door handle
2
3
1
5
4
3. mains cable
(connect to electrical mains outlet)
4. drain hose
5. water inlet
(connect to supply hose)
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 13KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 13 15/11/2019 12:05 PM15/11/2019 12:05 PM

14
internal view
6
10 11
12
13
7
8
9
14
7
7 12
9
6. cup rack
7. spray arm
(one under the upper
and one under the
lower basket)
8. upper basket
9. salt reservoir
10. rinse aid reservoir
11. detergent dispenser
12. filtering system
13. lower basket
14. cutlery basket
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 14KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 14 15/11/2019 12:05 PM15/11/2019 12:05 PM

15
Auto
Intensive
Normal
ECO
Glass
90 Min
Rapid
Soak
1. display window
• displays the remaining time, delay time
and error code.
2. on/off button
• turn the dishwasher on and off.
3. half load washing button
• press this button to select the half load
washing cycle.
4. delay button
• press to preset the wash timer and delay
the starting time by up to 24 hours.
• each press of this button increases the
delay start time by 1 hour intervals.
5. P programme button
• select your required washing programme.
• each press of this button switches from
one washing programme to another.
control panel
6. extra drying button
• press to choose extra drying function.
This only applies to Intensive, Normal,
ECO, Glass and 90 Min programme.
7. start/pause button
• confirm and start the selected washing
programme.
• pause the washing programme.
8. programme indicator
• displays the programme selected.
9. half load indicator
10. water tap indicator
11. child lock indicator
12. rinse aid refill indicator
13. salt refill indicator
14. extra drying indicator
5
6
7
1
2
3
4
88
9 10 11 12 13 14
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 15KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 15 15/11/2019 12:05 PM15/11/2019 12:05 PM

16
before operating
to open the door
• Pull the door handle.
• If the door is opened during operation, first open the door slightly to avoid water spillage.
When purchasing new crockery and cutlery, please make sure they are dishwasher-proof. Some
items are not suitable for dishwashers.
• Wooden cutlery and crockery or items with wooden parts may discolour and fade. The glue used
in these items is not dishwasher-proof and wooden handles may come loose after being washed
in a dishwasher.
• Craft items, antiques, valuable vases and decorative glassware are also not suitable for
dishwashers.
• Plastic items (e.g. tupperware) which are not heat resistant may melt or loose shape due to the
high temperature in the dishwasher.
• Copper, brass, tin and aluminium items may discolour or become matt.
• Clouding may occur on glasses and delicate glassware after frequent washing. Do not wash
delicate glassware or glassware containing lead crystal, in a dishwasher. Wash delicate
glassware by hand instead.
• Silver and aluminium parts have a tendency to discolour during washing. Residues like egg
white, egg yolk and mustard often cause discolouring and staining on silver. Therefore, please
clean the residues from silver immediately after use.
to close the door
• After loading the dishes, push the baskets fully into the dishwasher.
• Lift the door upwards and push until it clicks into position.
• Do not slam the dishwasher door.
items not suitable for use in the dishwasher



The following items are not suitable
Towels and
sponges
Small plastic
items
(Milk bottle
nipple)
Plastic items
that are not
dishwasher safe
Cast iron
pans
Scratched non-stick cookware
Copper pots and pans
Crystal
glasses
Silverware
Valuable
vases
Cracked / chipped china
If the door is opened during operation, all functions are automatically interrupted.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 16KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 16 15/11/2019 12:05 PM15/11/2019 12:05 PM

17
2. Fill the detergent dispenser with detergent
powder or detergent tablet. The marking
indicates the filling level.
3. Close the lid firmly so that it clicks into place.
adding detergent powder or detergent tablet
Only use detergents specifically designed for use in dishwashers. To be more environmentally
friendly, please use no more than the correct amount of detergent. Fill the detergent dispenser with
detergent powder or tablet. See the detergent manufacturers instructions for the correct amount to
use. If using tablets read the manufacturers recommendations on the tablet packaging in order to
determine where the tablet should be placed (e.g. cutlery basket, detergent compartment etc).
Please follow the steps below to fill the detergent dispenser.
1. Push the button on the lid of the detergent
dispenser to slide it open.
Irritant
Bleach and
Countertop
detergent
• Keep detergents and bleaches out of the reach of children.
• Irritating to eyes.
• Avoid contact with eyes. In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice.
• If swallowed, seek medical advice immediately.
All programmes with pre-wash need an
additional detergent dosage. Just place
them on the dispenser or put them inside
the dishwasher. If using tablets please
check the detergent manufacturers
instructions. Please refer to the wash
cycle table. This detergent will take effect
during the pre-wash phase.
or
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 17KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 17 15/11/2019 12:05 PM15/11/2019 12:05 PM

18
adding rinse aid
Rinse aid helps to ensure water does not cling and leave marks on crockery during the drying phase
and helps crockery dry faster after it has been washed. Only pour rinse aid that is for domestic
dishwashers into the reservoir. This model is designed to use liquid rinse aids only.
Please follow the steps below to pour the rinse aid into the storage reservoir, and the amount will
dispense automatically.
1. Turn the cap and open as indicated.
2. When the cap open marking is aligned, you
may lift the cap up.
3. Pour the rinse aid in until the rinse aid
indicator turns completely black in colour
and close the cap.
4. Be careful not to overfill the reservoir. Wipe
up any spills.
adjusting the rinse aid reservoir
The rinse aid reservoir has six settings. Both the recommended
setting and the factory setting is “3”. If the dishes are not drying
properly or are spotted, adjust the dial to the next higher number
until your dishes are spot-free.
• If the water hardness in your area is soft, you may not need rinse aid as it may cause
white film to develop on your dishes.
• If you decide to use a detergent tablet, you do not need to add rinse aid into the rinse
aid reservoir.
• Rinse aid warning indicator will illuminate when the reservoir is running out of rinse
aid and requires refilling.
• Alternatively, you can judge the amount of rinse aid by checking the rinse aid indicator
next to the reservoir cap. When the indicator is black, it means it is full. When it is
clear, it means it is almost empty.
• If there is some rinse aid residue left in the washing
compartment or your dishes, turn the rinse aid
dispenser dial to 1.
rinse aid indicator
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 18KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 18 15/11/2019 12:05 PM15/11/2019 12:05 PM

19
adding salt
If the water in your area is hard, deposits will form on your dishes
and utensils. This appliance contains a salt reservoir for you to
reduce the hardness of the water.
Please follow the steps below to pour the salt into the salt reservoir
and it must be set to correspond to the water hardness level in your
area.
1. Remove the lower basket and unscrew the reservoir cap.
2. Fill the reservoir with approximately 500ml of water (first
use only).
3. Place the funnel provided over the salt reservoir.
4. Pour in approximately 1.5 kg of dishwasher salt
depending on the brand used.
5. Clean any excess salt from around the reservoir opening
and then screw the cap on again firmly.
6. Run a short wash programme immediately (without any
crockery in the dishwasher) to remove any traces of salt
from the compartment.
• Salt refill warning indicator will illuminate
when the reservoir is running out of salt and
requires refilling.
• The salt refill warning indicator will cease to
illuminate within a few days, depending on
how quickly the salt dissolves.
• If you decide to use a detergent tablet, you
may not need to add salt, this depends
upon the water hardness in your area and
the type of tablet being used. Check with
your water supplier and the detergent tablet
manufacturer’s instructions.
open
open
open
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 19KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 19 15/11/2019 12:05 PM15/11/2019 12:05 PM

20
adjusting salt consumption
Salt consumption must be adjusted to correspond to the water hardness level in your area. If you
don’t know how hard the water in your home is, please ask the company that supplies water in your
area.
It is recommended that adjustments should be made in accordance with the following chart.
water hardness salt consumption
(gram/cycle)
german ˚dh french ˚fh british ˚clarke mmol/l
0-5 0-9 0-6 0-0.94 0
6-11 10-20 7-14 1.0-2.0 9
12-17 21-30 15-21 2.1-3.0 12
18-22 31-40 22-28 3.1-4.0 20
23-34 41-60 29-42 4.1-6.0 30
35-55 61-98 43-69 6.1-9.8 60
To optimise your dishwasher for the local water hardness, please follow the steps below and refer to
the table above.
1. Press the button to switch on the dishwasher.
2. Press and hold the button for 5 seconds until the salt refill warning indicator illuminates.
3. Press the button repeatedly to adjust the water hardness level: H1 / H2 / H3 / H4 / H5 / H6.
4. After adjusting the water hardness level, press the button to save the setting.
1 ˚dh (German degree) = 0.178mmol/l
1 ˚fh (French degree) = 0.1mmol/l
1 ˚Clark (British degree) = 0.142mmol/l
• Do not use everyday table salt or cooking salt as they contain insoluble
substances which could damage the dishwasher.
• Do not pour detergent into the salt container. This will damage the dishwasher.
KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 20KDW60W15/A-B16/A-S16/A_IB_RC_191115_grace.indd 20 15/11/2019 12:05 PM15/11/2019 12:05 PM