Kenwood KID60B16/A Service manual

Dishwasher
KID60B16/A
installation / instructions manual
KID60B16/A_IB_170428_grace.indd 1 28/4/17 3:42 pm

KID60B16/A_IB_170428_grace.indd 2 28/4/17 3:42 pm

contents
safety warnings .................................................................................................................. 5
unpacking............................................................................................................................ 8
Installation........................................................................................................................... 9
location ............................................................................................................................ 9
product overview.............................................................................................................. 16
front view ....................................................................................................................... 16
upper basket.................................................................................................................. 16
internal view .................................................................................................................. 16
rear view........................................................................................................................ 16
lower basket .................................................................................................................. 16
control panel.................................................................................................................. 17
wash cycle table ............................................................................................................... 18
before operating ............................................................................................................... 19
to open the door ............................................................................................................ 19
to close the door............................................................................................................ 19
items not suitable for use in the dishwasher ................................................................. 19
adding detergent powder or tablet ................................................................................. 20
adding rinse aid................................................................................................................ 21
adjusting the rinse aid reservoir .................................................................................... 21
adding salt ..................................................................................................................... 22
adjusting salt consumption ............................................................................................ 23
loading the dishwasher.................................................................................................... 24
before loading the dishwasher ...................................................................................... 24
upper basket.................................................................................................................. 25
- adjusting the upper basket ...................................................................................... 25
- loading the upper basket for 14 place settings........................................................ 25
- hinged cup rack....................................................................................................... 26
lower basket .................................................................................................................. 26
- hinged spikes .......................................................................................................... 26
- loading the lower basket for 14 place settings ........................................................ 27
cutlery basket ................................................................................................................ 27
- loading the lower basket with Cutlery Basket.......................................................... 28
cutlery drawer................................................................................................................ 28
starting a wash cycle ....................................................................................................... 30
changing a programme.................................................................................................... 30
at the end of a programme .............................................................................................. 30
KID60B16/A_IB_170428_grace.indd 3 28/4/17 3:42 pm

switching off the unit ....................................................................................................... 31
unloading the dishwasher ............................................................................................... 31
delay start.......................................................................................................................... 31
dual zone........................................................................................................................... 32
cleaning after use............................................................................................................. 32
external care.................................................................................................................. 32
- the door and the door seal ...................................................................................... 32
- the control panel...................................................................................................... 32
internal care................................................................................................................... 33
- ltering system ........................................................................................................ 33
- spray arms............................................................................................................... 33
frost precaution ................................................................................................................ 34
moving the dishwasher.................................................................................................... 34
maintenance after a prolonged period of non-operation.............................................. 34
hints and tips .................................................................................................................... 35
fault code....................................................................................................................... 35
helpful tips ..................................................................................................................... 35
disposal of the dishwasher ............................................................................................. 37
disposal of packing material ........................................................................................... 37
specications.................................................................................................................... 38
product che..................................................................................................................... 38
KID60B16/A_IB_170428_grace.indd 4 28/4/17 3:42 pm

5
safety warnings
For your continued safety and to reduce the risk of injury or electric shock,
please follow all the safety precautions listed below.
• Read all instructions carefully before using the dishwasher and keep them
for future reference.
• Retain the manual. If you pass the dishwasher onto a third party, make sure
to include this manual.
• Keep ventilation openings in the dishwasher enclosure clear of obstructions.
• Choose a location for your dishwasher away from heat sources such as
radiators or fires.
• Young children should be supervised to ensure that they do not play with
the dishwasher.
• Keep mains cable out of reach of children.
• This appliance can be used by children aged from 8 years and above
and persons with reduced physical, sensory or mental capabilities or
lack of experience and knowledge if they have been given supervision or
instruction concerning use of the appliance in a safe way and understand
the hazards involved. Children shall not play with the appliance. Cleaning
and user maintenance shall not be made by children without supervision.
• Keep the appliance and its cord out of reach of children less than 8 years
old.
• Keep children away from detergents and rinse aids. These may cause
chemical burns in the mouth, throat and eyes or asphyxiation.
• Keep children away from the dishwasher when the door is open.
• Switch off water and power and unplug before fitting or removing tools/
attachments, after use and before cleaning.
• Keep your fingers away from moving parts and fitted attachments.
• Never use a damaged machine.
• If the mains cable is damaged, it must be replaced by the manufacturer, its
service agent or a qualified technician in order to avoid a hazard.
• Keep the power unit, mains cable and plug away from water.
• Never exceed the maximum capacities.
• 2 people are required to lift this dishwasher.
• Only use the dishwasher for its intended domestic use.
KID60B16/A_IB_170428_grace.indd 5 28/4/17 3:42 pm

6
• This appliance is intended for indoor household use and similar applications
such as:
- farm houses and by clients in hotels, motels and other residential type
environment;
- bed and breakfast type environment;
- catering and similar non-retail applications.
WARNING
IT IS HAZARDOUS FOR ANYONE OTHER THAN AUTHORISED
SERVICE PERSONNEL TO CARRY OUT SERVICING OF REPAIRS
WHICH INVOLVE THE REMOVAL OF COVERS.
TO AVOID THE RISK OF AN ELECTRICAL SHOCK DO NOT
ATTEMPT REPAIRS YOURSELF.
• Do not sit or stand on the door or dish rack.
• Do not move your dishwasher by holding the door or its edges. Hold the
dishwasher around its sides or base when moving it.
• Do not touch the heating element during or immediately after use.
• Do not operate your dishwasher unless all enclosure panels are properly in
place. Open the door very carefully when there is a programme running, as
there is a risk of hot water spraying out of the appliance.
• Do not place any heavy objects on the open door. The appliance could tip.
• When loading items to be washed:
• Locate sharp items so that they will not damage the door seal;
• Warning: Knives and other utensils with sharp points must be loaded in
the basket with the points downwards or placed horizontally.
• Do not allow plastic items to come into contact with heating element.
• Check that the detergent receptacle is empty after completion of the wash
cycle.
• Do not wash plastic items unless they are marked dishwasher safe or
equivalent.
• Use only detergent and rinse aids designed for an automatic dishwasher.
• Other means for disconnection from the supply must be incorporated in the
fixed wiring with at least 3mm contact separation in all poles.
• The door should not be left in the open position since this could present a
tripping hazard.
KID60B16/A_IB_170428_grace.indd 6 28/4/17 3:42 pm

7
• For energy saving, always remember to switch the dishwasher off when you
have finished using it. The dishwasher should not be left unattended when
in use.
• Remove the door of the washing compartment when removing an old
dishwasher from service or discarding it.
• During installation, the power supply cord must not be excessively or
dangerously bent or flattened.
• Do not tamper with controls.
• The appliance is to be connected to the water mains using new hose sets.
• The maximum number of place settings to be washed is 14.
• The maximum permissible inlet water pressure is 1 MPa, and the minimum
permissible inlet water pressure is 0.04 MPa.
earthing instructions
WARNING: THIS APPLIANCE MUST BE EARTHED.
• This appliance is equipped with a mains cable having an equipment-
earthing conductor and an earthing plug.
• The plug must be plugged into an appropriate mains socket that
is installed and earthed in accordance with local standards and
requirements.
Improper connection of the equipment-earthing conductor could result in
a risk of electric shock.
• The wires in the cord are coloured as follows:
Green and Yellow = Earth,
Blue = Neutral,
Brown = Live.
• Check with a qualified electrician or service representative if you are in
doubt whether the appliance is properly earthed or the plug does not
fit correctly.
• Never modify the plug provided with the appliance.
KID60B16/A_IB_170428_grace.indd 7 28/4/17 3:42 pm

8
Thank you for purchasing your new Kenwood Dishwasher.
These operating instructions will help you use it properly and safely.
We recommend that you spend some time reading this installation/instruction
manual in order that you fully understand all the operational features it offers.
Read all the safety instructions carefully before use and keep this installation/
instruction manual for future reference.
unpacking
Remove all items from the packaging. Retain the packaging. If you dispose of it please do so
according to local regulations.
The following items are included:
The Main Unit
U-shape Hose Holder X 1
Salt Funnel X 1Detergent Measuring Spoon X 1
1 full spoon = 20g (approx.)
Instruction Manual x 1Door Template x 1cutlery basket x 1
ST3.5x45 Screw x 4
Toe Panel Mounting Bracket x 2
ST3.5x16 Screw x 2
Hole Cover x 2
Lower Hook X 2
Installation Hook x 2
ST3.5x25 Screw x 2Hop Hook X 2
Water Supply Hose X 1
ST4x14 Screw x 14
Measuring Cup X 1
60ml (approx.)
Condensation Strip X 1
This product has been wet tested to ensure correct operation. As a result some water
may remain inside the unit. This is normal and safe. Remove any water droplets from the
exterior if necessary.
If items are missing, or damaged please contact Partmaster (UK only).
Tel: [phone] for assistance.
Instruction
Manual
Installation
Door
Template
KID60B16/A_IB_170428_grace.indd 8 28/4/17 3:42 pm

9
installation
Installation
1. Please ensure the dishwasher is installed
by a qualified technician. Refer to the tools
required.
location
When selecting a position for your dishwasher
you should make sure the installation surface
is flat and firm, and the room is well ventilated.
Avoid locating your dishwasher near a heat
source, e.g. cooker, boiler or radiator. Extreme
cold ambient temperatures may also cause
the appliance not to perform properly. This
dishwasher is not designed for use in a garage
or outdoor installation.
Do not drape the dishwasher with any covering.
When installing, ensure that free space is left at
the sides.
2. Ensure there is clearance each side of the
unit to allow slight sideways movement
for servicing when required. The height
of the unit is 815 mm. The figure outlines
the minimum dimensions required to
accommodate the dishwasher within fitted
kitchen furniture units.
820
600
580
598
550
815
units in mm
The supplied door template also
contains installation steps which
will assist installation.
All parts removed must be saved to
do the reinstallation in the future.
Ensure the dishwasher is unplugged
and empty. We recommend that 2
people handle the dishwasher during
installation.
KID60B16/A_IB_170428_grace.indd 9 28/4/17 3:42 pm

10
installation
3. Do not connect the unit to the mains socket
before installation. Ensure you are not
installing the unit right in front of the mains
socket. This is to avoid potential damage to
the back of the unit.
4. The condensation strip must be fitted to
the underside of the worktop above your
dishwasher to protect it against any moisture.
Its purpose is to protect your worktop’s
underside from steam rising from the
dishwasher.
Remove the backing paper from the
condensation strip.
5. Stick the condensation strip to the underside
of the worktop.
Leave some space
Stick the Condensation
Strip under the worktop,
where you want to install
the dishwasher.
6. For Wooden Worktop Only
Place the Installation Hook to secure the unit
as shown.
Ensure the surface is clean prior to
sticking the condensation strip to
the underside of the worktop.
Failure to attach the condensation
strip could result in damage to the
underside of your worktop!
KID60B16/A_IB_170428_grace.indd 10 28/4/17 3:42 pm

11
installation
7. Position the dishwasher next to a water tap
and a drain. Ensure the water inlet and drain
hoses are not kinked or squashed. The unit
must not stand on the mains cable.
8. Good levelling is essential for correct closure
and sealing of the door. When the unit is
correctly levelled, the door should not catch
the inner liner on either side of the cabinet.
Adjust the levelling feet to obtain the optimum
levelling of the unit.
9. Tape the supplied Door Template to the
dishwasher door. Ensure the aesthetic door
weight is a minimum of 3kg and a maximum
of 7kg. Make sure the top of the template is
at the top of the door. Drill the required holes
following the depth and diameter shown on
the Door Template.
<7kg
Do not move the unit while the
levelling feet are extended.
KID60B16/A_IB_170428_grace.indd 11 28/4/17 3:42 pm

12
installation
10. Install the Aesthetic Panel onto the
dishwasher door. After the aesthetic panel
is installed, the tension of the dishwasher
door spring can be adjusted by rotating the
adjusting bolt. If the tension is right, the
door will remain horizontal in the fully open
position.
11. Remove the screws on both sides of the
dishwasher door and replace with ST3.5x45
screws. Ensure to tighten the screws and to
secure the Aesthetic Panel.
12. Adjust the bolt to loosen or tighten the
tension of the dishwasher door.
Hop hook
ST4*14
Countersunk
head screw
Lower hook
13. Adjust the levelling feet again to obtain the
optimum levelling of the unit.
Do not move the unit while the
levelling feet are extended.
KID60B16/A_IB_170428_grace.indd 12 28/4/17 3:42 pm

13
installation
14. To secure the dishwasher under the table
top, tighten the screws as shown. Note their
positioning for the different types of worktops.
15. Cut out a 589 mm wide plinth for toe panel.
Tape the supplied toe panel mounting
brackets to the toe panel as shown. Drill the
required holes.
16. Determine the correct position for the toe
panel mounting bracket, remove the bracket
and bend the metal tab. This ensures that the
toe panel won’t slide in further than you need.
589
545.4
36
56.2 100
Wooden Worktop
Synthetic / Ceramic
Worktop
ST3.5x16
Hole Cover
Installation Hook
ST4x14
Adjust Height
KID60B16/A_IB_170428_grace.indd 13 28/4/17 3:42 pm

14
installation
19. Make sure your plumbing is suitable for
use with the dishwasher. If in doubt contact
a qualified plumber. This unit MUST BE
connected to COLD WATER MAINS using
the new water inlet hose. OLD HOSE SETS
MUST NOT BE RE-USED. The water
pressure from the water mains needs to be at
a minimum of 0.04 MPa and a maximum of
1.00MPa.
• Connect one end of the safety water
supply hose to your dishwasher, and then
connect the other end of the hose to your
water mains. Please ensure the black
rubber seal is in place.
• After connecting the hose, turn on your
water mains and check for leaks.
• Connect the dishwasher to the mains
socket.
18. Insert the toe panel to the dishwasher.
17. Attach the toe panel mounting brackets to the
toe panel. Align the screw holes, then use the
4 screws ST4x14 to secure the toe panel.
Water mains
Y-Adaptor
(not included)
Connect
to another
appliance if
required.
Water supply hose
You may use a Y-Adaptor (not
included) for an additional water
feed for another appliance, for
example a washing machine. This
is only applicable for cold water
mains. A Y-Adaptor is available
from most DIY stores.
About the Safety Supply Hose
The safety supply hose consists
of the double walls. The hose’s
system guarantees its intervention
by blocking the flow of water in
case of the supply hose breaking
and when the air space between
the supply hose itself and the outer
corrugated hose is full of water.
KID60B16/A_IB_170428_grace.indd 14 28/4/17 3:42 pm

15
installation
• The waste pipe must only be
connected to the foul drains and
not the surface water drainage
system.
• The water drain hose should be
placed between 40 cm and 100 cm
from the floor level and must not
be extended, otherwise the unit
may not be able to expel the waste
water properly.
• Please close the hydrant after
using.
• Do not bend your drain hose.
• Secure the water drain hose to the waste
pipe to avoid it coming off during the
washing process.
U-shaped drain
hose holder water drain
hose
• You may use the U-shaped drain hose
holder to secure your drain hose and to
avoid bending it.
Before connecting to the waste pipe,
make sure to check the waste pipe
and remove any stopper or blockage
inside, otherwise the unit may not
be able to expel the waste water
properly.
KID60B16/A_IB_170428_grace.indd 15 28/4/17 3:42 pm

16
product overview
front view
upper basket
internal view
rear view
lower basket
cup racks spikes
spray arms
cutlery drawer
ltering system
upper basket
lower basket
rinse aid
dispenser
salt reservoir
detergent
dispenser
door handle
control panel
water inlet
(connect to
supply hose)
mains cable
drain hose
KID60B16/A_IB_170428_grace.indd 16 28/4/17 3:42 pm

17
control panel
1 2 3 4 5 6
1 display window
• to show the error code, delay time, etc.
rinse aid indicator
• indicates when the dispenser need to be refilled.
add salt indicator
• indicates when the dispenser need to be refilled.
delay time or error code indicator :
programme indicators :
dual zone indicators :
extra drying indicator :
2. extra drying function choose button
• to choose extra drying function. extra drying function only applies to intensive, normal, ECO,
glass and 90 min programme.
3 dual zone button
• dual zone wash function, to select either upper basket or lower basket loading and the
response indicator will light.
4. delay button
• to delay the wash starting time.
5. programme button
• to select a wash programme.
6. ON/OFF button
• to turn on/off the power supply.
KID60B16/A_IB_170428_grace.indd 17 28/4/17 3:42 pm

18
wash cycle table
programme cycle selection
information process detergent
running
time
(min.)
energy
consumption
(kwh)
water
consumption
(l)
rinse
aid
auto
• Auto sensing wash,
lightly, normally
or heavily soiled
crockery with or
without dried-on food.
• pre-wash
(45°C)
• auto-wash
(45-55°C)
• rinse
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(30g)
150 0.9-1.3 11-15
intensive • For heaviest soiled
crockery, and
normally soiled pots,
pans, dishes etc with
dried on soiling.
• pre-wash
(50°C)
• wash (60°C)
• rinse
• rinse
• rinse (70°C)
• drying
• pre-wash
(5g)
• main wash
(30g)
• or 3 in 1
175 1.6 17.5
normal • For normally soiled
loads, such as pots,
plates, glasses and
lightly soiled pans.
• pre-wash
(45°C)
• wash (55°C)
• rinse
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(30g)
• or 3 in 1
185 1.3 13.5
economy*
(EN50242)
• This is standard
programme, it is suitable
to clean normally
soiled tableware and
it is the most efficient
programme in terms of
its combined energy and
water consumption for
that type of tableware.
• pre-wash
• wash (45°C)
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(30g)
• or 3 in 1
195 0.935 10
glass • For lightly soiled
crockery and glass.
• pre-wash
• wash (40°C)
• rinse
• rinse (60°C)
• drying
• pre-wash
(5g)
• main wash
(30g)
• or 3 in 1
130 0.9 13
90 Min • For lightly soiled
crockery load that do
not need excellent
drying efficiency.
• wash (65°C)
• rinse
• rinse (65°C)
• drying
• main wash
(35g)
• or 3 in 1
90 1.35 12.5
rapid • A shorter wash for
lightly soiled loads
and quick wash.
• wash (40°C)
• rinse (50°C)
• rinse (55°C)
• main wash
(25g)
30 0.75 11
soak • To rinse dishes that
you plan to wash later
that day.
• pre-wash • N/A 15 0.02 4
* To comply with the Standards of Performance, i.e. EN50242, please ensure to use economy
washing cycle for the test.
Condensing dry technology
• Energy is saved by drying the dishes using the remaining heat after the last rinse cycle.
• Wash cycle times are extended due to this drying method.
• Some wash programmes do not have a drying function, please refer to the Wash Cycle
Table for more details.
KID60B16/A_IB_170428_grace.indd 18 28/4/17 3:42 pm

19
before operating
to open the door
• Pull the door handle.
• If the door is opened during operation, all functions are automatically interrupted.
to close the door
• After loading the dishes, push the baskets fully into the dishwasher.
• Lift the door upwards and push until it clicks into position.
• Do not slam the dishwasher door.
items not suitable for use in the dishwasher
When purchasing new crockery and cutlery, please make sure they are dishwasher-proof. Some
items are not suitable for dishwashers.
• Wooden cutlery and crockery or items with wooden parts may discolour and fade. The glue used
in these items is not dishwasher-proof and wooden handles may come loose after being washed
in a dishwasher.
• Craft items, antiques, valuable vases and decorative glassware are also not suitable for
dishwashers.
• Plastic items (e.g. tupperware) which are not heat-resistant may melt or loose shape due to the
high temperature in the dishwasher.
• Copper, brass, tin and aluminium items may discolour or become matt.
• Clouding may occur on glasses and delicate glassware after frequent washing. Do not wash
delicate glassware, or glassware containing lead crystal in a dishwasher. Wash delicate
glassware by hand instead.
• Silver and aluminium parts have a tendency to discolour during washing. Residues like egg
white, egg yolk and mustard often cause discolouring and staining on silver. Therefore, please
clean the residues from silver immediately after use.



the following items are not suitable
small plastic items
(milk bottle nipple)
plastic items that
are not dishwasher safe
crystal glasses
silverware
valuable vases
copper pots and pans
cast iron pans
cracked / chipped china
scratched non-stick cookware
towels and sponges
KID60B16/A_IB_170428_grace.indd 19 28/4/17 3:42 pm

20
adding detergent powder or tablet
Only use detergents specifically designed for use in dishwashers. To be more environmentally
friendly, please use no more than the correct amount of detergent. Fill the detergent dispenser with
detergent powder or tablet.
Please follow the steps below to fill the detergent dispenser.
1. Push the button on the lid of the detergent
dispenser to slide it open.
2. Fill the detergent dispenser with detergent
powder or detergent tablet. The marking
indicates the filling level.
Bleach and
Countertop detergent Irritant
3. Close the lid firmly so that it clicks into place.
• Keep out of the reach of children.
• Irritating to eyes.
• Avoid contact with eyes. In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice.
• If swallowed, seek medical advice immediately.
All programmes with pre-wash need
an additional detergent dosage. Just
place them on the dispenser or put
them inside the dishwasher. If using
tablets please check the detergent
manufacturers instructions. Please refer
to the wash cycle table. This detergent
will take effect during the pre-wash
phase.
or
KID60B16/A_IB_170428_grace.indd 20 28/4/17 3:42 pm