KitchenAid KUIO18NNVS1 User manual

CABINET LINER AND DOOR PARTS
1
For Models: KUIO18NNVS1
(Stainless Steel)
5−09 Litho in U.S.A.(mjb)(eeb) Part No. W10252644 Rev.A
ICE CUBE
MAKER

CABINET LINER AND DOOR PARTS
2
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 Literature Parts
W10136912 Use & Care Guide
W10217947 Service &
Wiring Sheet
2 3400886 Screw 8−18 x 1 1/4
3 2208354 Bin, Door
4 2185678 Spacer
5 2217394 Cover, Wiring
6 489442 Screw
7 2208352B Panel, Exterior
8 2217298 Panel, Interior
9 2208136 Clamp−Tube
10 2208377 Insulation
11 2217227 Ballast−Back, I.M.
12 941839 Hole Plug
13 Bracket, Door
2217466 (Left Side)
2217465 (Right Side)
14 489503 Clamp
15
W10136896 Gasket, Door
16 3405028 Clip
17 2319107 Nameplate
18 Hinge
2208425 (Left Side)
2208426 (Right Side)
19 2208401 Shim, Hinge
20
W10129511 Trim− Magnet
21
W10129457 Handle, Bar
22
W10129444 Assembly,
Unit Cover
23 8534081 Screw, Handle
24 2208595B Grommet, Edge
Guard(2)
25 2217225 Pad, Foam
26 2185691 Channel, Wiring
27
W10129509 Endcap, Door
28 2208453 Tube, Drain
29 2208386 Scoop
30 3400884 Screw 8−18 x 5/8
31 692400 Nut, Push−In
32 2208382B Panel, Wrap Lower
33 2208487 Bracket, Spring
34 2208417 Pin, Hinge
35 489048 Screw, Ground
36
W10191920 Spring, Hinge
37
W10136906 Endcap, Panel
38 2208530 Dampener, Spring
39 8281265 Screw
40 2208449 Holder, Scoop
41 2208596B Grommet, Edge
guard(2)
42 2303615 Leg, Leveler (4)
43 2208384 Insulation
44
W10136884 Top
45 2185690 Shield, Electrical
46 2217296 Gasket, Top Panel
47
W10136904 Grill, Front
48 489474 Screw 8−18 x 1
49 Cabinet & Liner
(NOT SERVICED)
50
W10129483 Panel, Wrap
51 2208594S Panel, Lower
52 3400306 Nut,
Leg Leveler
53 2208434 Strike, Magnet
54 3400916 Washer
55 8281191 Screw
56 3400237 Screw
(Handle Bar)
57 8534081 Screw
58 488208 Screw
59
W10129515 Cover−Drain Pump
60 8281192 Screw

3
EVAPORATOR, ICE CUTTER GRID AND WATER PARTS
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644

EVAPORATOR, ICE CUTTER GRID AND WATER PARTS
4
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION
1 W10217917 Valve, Complete
Water
2 2217286 Tube, Plastic
3 488208 Screw
4 2185523 Dispenser, Water
5 Evaporator
6 2313705 Pump, Drain
7 2313851 Tube, Reservoir
Pump
8 2172593 Tube, Water Fill
9 488660 Nut, Speed
10 836667 Spacer
11 2208539 Fastener, Pushnut
12 489443 Screw
13 2185625 Reservoir,
Water Slide
14 2185626 Tube
15 2313890 Hose, Overflow
16 2217378 Bracket−Reservoir
17 2313603 Bracket, Front
and Rear
18 2313602 Bracket, Side
Left and Right
19 2185681 Harness, Grid
20 2208427 Support, Bracket
Evaporator/Grid
21 2313604 Guide, Ice Grid
22
W10136146 Tube
23 8281193 Screw
24 2310169 Wire Assembly
(Valve)
26 3400886 Screw 8−18 x 1 1/4
28 2313637 Grid Assembly
(Complete)
29 2174754 Wire, Grid Cutter
30 8281192 Screw
31 2208365 Cover, Grid
32 8281228 Thumbscrew
33 2324334 Reservoir, Water
34 3400884 Screw 8−18 x 5/8
35 2185696 Cap, Drain
36 3400909 Nut, Push−In
W10218037

PUMP PARTS
5
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION
1 2313628 Pump−Recirculating
2 3400884 Screw 8−18 x 5/8
3 2185677 Cover, Pump
4 2313844 Bracket, Connector
Assembly
5 2313627 Bracket−Pump
6 2313643 Sensor−Water Level
8 2310092 Wiring Harness
Main To Pump
9 2313702 Pump Assembly

6
CONTROL PANEL PARTS
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION
1 2185738 Box, Control
2 2310139 Transformer
3 2304122 Assembly, Switch
(ALSO ORDER #4)
4 2313693 Overlay
5
W10141364 Control Board
6 2149705 Switch, Plunger
Grid/ Light
7 2187585 Wire Assy−Active
Overlay Jumper
9 745362 Bulb
12 2313633 Thermostat, Bin
13 2185825 Clamp
15 3400884 Screw 8−18 x 5/8
18 3400850 Screw 8−16 x 3/8
20 2313635 Thermister,
Ice Control

UNIT PARTS
7
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644

UNIT PARTS
8
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION
1 2185532 Bracket, Fan Mtg.
2 2185675 Pad, Foam
3 2188935 Blade, Fan
4 2315558 Motor & Mounting
Plate Assembly
5
W10209471 Wiring Harness,
Complete Unit
(Includes
Power Cord)
6 8281244 Screw
7
W10136195 Compressor
(Includes
Illus. 11 & 23)
8 A201435 Clip, Mounting
9 A201441 Shim (4)
10 1115375 Clip−Wiring
11 Grommet (4)
2217318 Production
4387558 Service
12 2208415 Tube, Process
13 489420 Screw
14 489472 Screw
15
W10206473 Coil, Solenoid
16
W10129500 Hot Gas Valve Assy
17 2187629 Wiring Harness,
Condenser Fan
18
W10136197 Start Relay
& Overload
Combo Device
19 851095 Strap
23 Drier
W10183199 Production
4387019 Service
24
W10129494 Condenser−Shroud
Assembly
26 488500 Screw
27 2217397 Pad, Foam (2)
28 2185960 Clamp−Service Cord
29 8281197 Screw
30
W10122014 Base, Unit
31 8281196 Screw
32 304392 Screw
34 2319835 Grommet−Cond.(1)
REFRIGERANT CHARGE
6.5 OZ. (R134A)

OPTIONAL PARTS (NOT INCLUDED)
9
For Models: KUIO18NNVS1
(Stainless Steel)
W10252644
Illus. Part
No. No. DESCRIPTION
Parts Not Illustrated and
Optional Parts (Not Included)
503695 Sealer, Cork
(1/4 Pound)
797403 Cement, Insulation
(1 Oz.)
505587 Sealer, Mastic
(1 Qt.)
212643 Sealer, Gum
(22 Pcs. 3/16" x 7")
479976 Kit, Insulation
(5 Pcs. 3" x 24"
x 48")
8537055 Cleaner,
Stainless Steel
978025 Valve, Access
(1/4")
978026 Valve, Access
(5/16")
978027 Valve, Access
(3/8")
978028 Valve, Access
(1/2")
978029 Valve, Access
(5/8")
978030 Valve, Access
(3/4")
ACCESSORIES
Previous Architect
Series Handle Kit
2217442S Stainless Steel