Koblenz DV-100 KG3 US User manual

WET DRY VACUUM CLEANER
MODELS:
DV-100 KG3 US
DV-110 KG3 US
KOBLENZ ELECTRICA S.A. DE C.V.
E-mail: [e-mail]
LP-DV100KG3-201307
1/ 6 Elaborated July 2013.
SERVICE MANUAL
SERVICE

INDEX
I.- OPERATING SYSTEM 2
II.- REPLACEMENT PROCEDURES 2
III.- TROUBLE SHOOTING CHART 3
IV.- USE WITH OPTIONAL PAPER BAG 3
V.- EXPLODED VIEW SCHEMATI 4
VI.- PARTS LIST 5
I. OPERATING SYSTEM
MODEL VOLTS AMPERES Hz.
DV-100 KG3 127 ~ 4 A. 60
DV-110 KG3 127~ 4 A. 60
There should be no abnormal noise or vibration, the carbon brushes spark should be small and uniform, and the com-
mutator must have a dark brown and uniform strip.
II.-REPLACEMENT PROCEDURES
1. - TO REPLACE MOTOR
1.1. - Pull release tab outward, at the same time pull cover up.
1.2. - Remove the four screws.
1.3. - Remove the cover.
1.4. - Disconnect the line cord.
1.5. - Remove the motor assy.
1.6. - Replace the motor, reconnect and reassemble.
NOTE: Do not attempt to repair the motor, send for service.
2. - TO REPLACE THE ON-OFF SWITCH
2.1. - Follow steps 1.1 to 1.3.
2.2. - Disconnect the two leads from the switch.
Remove the three screws and remove the cover top, replace the on-off switch, reconnect and reassemble.
3. - TO REPLACE THE LINE CORD
3.1. - Follow steps 1.1 to 1.3.
3.2. - Remove and replace the new line cord and reassemble as initially placed.
4. - TO REPLACE THE FLOAT
4.1. - Follow step 1.1
4.2. - Remove the cage.
4.3. - Remove and replace the float.
WHEN ORDERING, DO NOT FORGET TO SPECIFY:
PART NUMBER
DESCRIPTION
MODEL NUMBER
NOTE: Drawing numbers are for identification purposes only.
2/ 6 Elaborated July 2013.

III. - TROUBLE SHOOTING CHART
FAILURE CAUSE SOLUTION
DAMAGED MOTOR OR WRONG
WORKS
Not firmly plugged Check plug connection
Damaged on-off switch Replace switch
Damaged line cord Replace cord
Damaged motor Replace motor
LOW SUCTION
Full tank Empty tank
Closed hose or wand Clean obstruction
Slow motor Check carbon brushes
Filter is dirty Replace filter
IV.-USE WITH OPTIONAL PAPER BAG.
This vacuum cleaner may be used with an optional dust bag.
1. Slide bag into support frame.
2. Place rear of support frame into slots.
3. Lock in place by inserting front latch into tab pick up wet spills and liquids both the paper
bag and filter must be removed.
3/ 6 Elaborated July 2013.

V. - EXPLODED VIEW SCHEMATICS
4/ 6 Elaborated July 2013.

VI. - LIST OF PARTS.
5/ 6 Elaborated July 2013.
ITEM No, DE PARTE DESCRIPTION DV100 KG3 DV-110 KG3
1 46-3742-00-7 HANDLE ASSEMBLY 3 GAL. 3 GE. 1 1
2 13-3878-00-9 TOP COVER TAMP. BLUE 1
2 13-3878-02-5 TOP COVER TAMP. RED 1
2 13-3878-01-7 TOP COVER TAMP. PURPLE
3 10-0137-9 INSULATED CONNECTOR 2 2
4 00-3876-16-6 MOTOR ASSEMBLY 3 GAL. 3 GEN. 1 1
5 01-01-05-00-5 SCREW 8-18 x ¾ INOX. 2 2
6 13-3178-4 COVER COLLECTOR 1 1
7 01-0293-9 SCREW PHILLIPS AB10-16 x ¾ 1 1
8 13-3079-01-2 FLOAT GLASS INVERTED 1 1
9 13-3179-2 CAGE 3 GAL 2 GEN. 1 1
12 13-3879-00-7 BOAT 3 GAL 3 GEN WITH WHEELS 1
12 13-3879-01-5 BOAT 3 GAL 3 GEN WITH WHEELS RED 1
12 13-3883-01-9 BOAT 3 GAL 3 GEN WITH WHEELS PURPLE
14 13-3880-00-5 REAR WHEEL 3 GAL. 3 GEN. 2 2
15 13-3887-00-0 BAG SUPPORT 3 GAL. 3 GEN. 1 1
16 28-1871-00-4 ROCKER SWITCH ASSEMBLY 3 GAL. 3 GEN. 1 1
17 13-2289-01-8 PICK-UP TOOL GRAY 1 1
18 45-0602-8 COMBINATION FLOOR TOOL 1 1
19 45-0606-9 HOSE ASSEMBLY 67” 1 1
20 13-2293-01-0 EXTENSION WAND 2 2
21 13-2628-01-7 INFLATOR NOZZLE GRAY, TYPE A 1 1
22 13-2629-01-5 INFLATOR NOZZLE GRAY, TYPE B 1
23 13-3683-01-1 CREVICE TOOL 1
24 45-0851-00-1 FILTER BAG 3 GAL. 3 GEN. 1
** 17-5908-00-3 VACUUM LABEL MODEL 3 GAL. 3 GEN. RED 1
** 17-5916-05-5 ENERGY CONSUMPTION LABEL 0.5 Kwh 2 2
** 18-0808-03-3 CARDBOARD BASE 41 5/16 x 28 1 1
** 18-1176-9 CORNER CARBOARD 92x10 cm. 2 2
** 18-1318-00-7 PACKING BOX3 GAL. 3 GEN. 1 1
** 18-1338-00-5 INSIDE PACKAGE 1 1
** 19-0805-00-2 USER MANUAL 3 GAL. 3 GEN. 1 1
** 45-0389-2 PAQ. FILTER 2 GAL. VAC. (ITEM 10 Y 11) 1 1
** PARTS NOT ILLUSTRATED.

FACTORY AUTHORIZED SERVICE
Thorne Electric Company
610 Lanark Suite 205
San Antonio TX, 78218
Tel [phone]
Fax [phone]
1-800-548-57
FACTORY
KOBLENZ ELECTRICA S.A. DE C.V.
AV. CIENCIA NO.28
CUAUTITLAN IZCALLI
ESTADO DE MEXICO 54730
Web site: http://www.koblenz-electric.com LP-DV100KG3-201307
6/ 6 Elaborated July 2013.
SERVICE