KWIK GOAL 2D301 User manual

140 Pacific Drive Quakertown, PA 18951
(P) 215-536-2200 / (P) 800-531-4252 / (F) 215-536-4309 / (F) 800-778-8869
Visit our website @ kwikgoal.com
2003, Rev 2017 Kwik Goal Ltd.
ASSEMBLY INSTRUCTIONS FOR 2D301 COMBINATION FOOTBALL/SOCCER GOAL
1. Unpack all parts and check for damage that may have occurred during shipping. If damage has occurred,
notify trucking company immediately. Lay out all parts. Remove all cardboard and packaging immediately.
Wet or damp packaging may damage contents.
2. Read through entire instruction before beginning assembly and installation.
NOTE: Components may be packaged in one or more additional boxes.
NZ182 Rev. 07/17/17
Parts
Left Post (1)
(Part# UZ395)
Right Post (1)
(Part# UZ396)
Crossbar (1)
(Part# UZ834)
Upright (2)
(Part# UZ835)
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Ground Sleeve (2)
(Part# UZ65)
129-3/8”
129-3/8”
24”
286”
180”

IMPORTANT GOAL SAFETY INSTRUCTIONS
READ CAREFULLY
1. Check for structural integrity and proper connecting hardware before every
use. Replace damaged or missing parts or fasteners immediately.
2. Safety/Warning labels must be clearly visible.
3. Securely anchor moveable soccer goals at ALL times.
4. Always instruct players, managers, coaches, trainers, teachers, maintenance
workers and all other personnel who might come in contact with the goal,
on the safe handling of and potential dangers associated with moveable
soccer goals.
5. Always exercise extreme caution when moving goals and provide adequate
manpower to move goals of varied sizes and weights. Moveable soccer
goals should only be moved by authorized personnel.
6. NEVER allow anyone to climb on the net or goal framework.
7. Moveable soccer goals should only be used on LEVEL fields, NEVER on a
slope or hill area.
8. Remove nets when goals are not in use.
9. Most tip-over injuries occur when goals are unattended. Anchor or chain
one goal to another or to nearby fence posts, dugouts, or any other similar
sturdy fixture when not in use. If this is not practical, store moveable soccer
goals in a place where children cannot have access to them.
10. Fully disassemble goals for seasonal storage.
140 Pacific Drive Quakertown, PA 18951
(P) 215-536-2200 / (P) 800-531-4252 / (F) 215-536-4309 / (F) 800-778-8869
Visit our website @ kwikgoal.com
1998, Rev 2007 Kwik Goal Ltd.
NZ182 Rev. 07/17/17

NZ182 Rev. 07/17/17
Backstay Brace (2)
(Part# VZ328P2)
Backstay (2)
(Part# VZ328P1)
Net Strap (1)
(Part# 10B4406 Pack of 2)
Net (1)
(Part# 3B6826)
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Hardware
Note: Hardware may be packaged separately
in one or more boxes. Open all packages
before beginning assembly.
3/8“ x 1 1/4” Hex Bolt (Part# TZ59) (4)
3/8“ x 1 3/4” Hex Bolt (Part# TZ227) (4)
3/8" x 7/8" Hex Bolt (Part# TZ249) (6)
3/8“ Lock Washer (Part# TZ65) (10)
3/8“ Flat Washer (Part# TZ60) (14)
3/8” Lock Nut (Part# TZ197) (4)
3/8" Square Nut (Part# TZ247) (6)
5/16" Eyebolt (Part# TZ270) (2)
5/16" Flat Washer (Part# TZ269) (2)
5/16” Lock Nut (Part# TZ5) (2)
1/4” Set Screw (Part# TZ252) (2)
3/16” X 1” Spring Pin (Part#TZ253) (4)
7/16” X 2-1/2” Hex Bolt (Part# TZ41) (2)
7/16” Lock Nut (Part# TZ47) (2)
Assembly Tools
9/16
1/2”, 9/16” & 5/8”
Wrenches
Ratchet with
1/2”, 9/16” & 5/8”
Sockets
Scissors
AND
Net Clip (40)
(Part# 10B3101 Pack of 100)
Channel Spacer (2)
(Part# UZ812)
1/8” Hex
Wrench
T Spacer (2)
(Part# WZ442)
Post Ground
Sleeve Cap (2)
(Part# UZ66)

NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
3. Attach left post and right post to crossbar using channel spacers and 3/8” x 1-1/2” hex bolts. Note direction of
decals on crossbar before fastening. Be sure connections are pressed firmly together before tightening hex bolts.
Crossbar
Right Post
Left Post
3/8” X 1 1/4” Hex Bolt
Crossbar
3/8” Square Nut
Channel Spacer
Right Post
3/8” Flat Washer
3/8” Lock Washer
4. Insert two 3/8” square nuts and one T-spacer into left post and
right post. Lock T-spacer into position with 1/4” x 1/2” set screws.
Slide front post ground sleeves onto left post and right post.
Crossbar
Right Post
Left Post
3/8” Square Nut
Left Post
3/8” Square Nut
T Spacer
24”
T Spacer
1/4” X 1/2”
Set Screw
Left Post
Post Ground Sleeve
Post Ground Sleeve

5/16” X 1 1/2” Eyebolt
3/8” Locknut
Backstay Brace
3/8” Flat Washer
3/8” X 7/8” Hex Bolt
3/8” X 2” Hex Bolt
3/8” Flat Washer
3/8” Square Nut
Right Post
Crossbar
3/8” Square Nut
5/16” Flat Washer
5/16” Lock Nut
Backstay
3/8” Lock Washer
3/8” Square Nut
NZ182 Rev. 07/17/17
Ground Sleeve
Ground Sleeve
Crossbar
Right Post
Left Post
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
5. Attach backstays and backstay braces using 3/8” hex bolts. Attach 5/16” eyebolts to backstays.

NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Playing Field
Top View
288"
Face of goal NOT beyond this point
Center of Goal Line
Right Post
Left Post
6. Mark field location for posts and back poles.
7. Dig holes a minimum of 41 1/4" deep and 24" across. Fill bottom of holes with 1” diameter stone until the hole is
29 1/4" in depth, until the top of ground sleeve is 5” below field surface. The stone base allows water and NOTE:
small debris to flow through the hole located in the bottom of ground sleeve.
5“ Below Surface
Min. 41 1/4"
Min. 24"
Concrete
Ground Sleeve
Post/Poles
1” dia. Stone
for
Drainage
30
Approx.
29 1/4"

NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Down - Bow
Up - Arch Crossbar
Cause Bow in Crossbar
Left Post Right Post
Concrete
Field Surface
Ground Sleeve
Large Stone
Cause Bow in Crossbar
Cause
Arch
in
Crossbar
Cause
Arch
in
Crossbar
Front View
8. Set assembled goal posts with post ground sleeves into holes. Plumb and level goal, making sure the bottom of
crossbar is 8 feet from the field surface. Face of the goal post should not enter into playing field. Seal space
between left post and right post, and post ground sleeve with tape, or small bead of sealer. This will stop debris
from entering ground sleeves during construction.
9. Fill holes with concrete, flush to the top of ground sleeves. Be sure to level posts before concrete begins to cure.
After concrete has fully cured, see Step 18 for test procedures to ensure the goal has been anchored properly.

NZ182 Rev. 07/17/17
10. After concrete has fully cured attach uprights to crossbar using 7/16” hex bolts and lock nuts. Tighten hardware.
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Left Post
Right Post
Crossbar
Upright
Upright
Crossbar
7/16” X 2 1/2”
Hex Bolt 7/16” Lock Nut
Upright

Upright
Level
NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
11. Use a level to check plumb of uprights. If plumb of uprights is acceptable, proceed to step 16.

Backstay
Brace Bolt
Crossbar
Bolts
Drill
3/16” Hole
3/16” X 1”
Spring Pin
NZ182 Rev. 07/17/17
12. If plumb of uprights was not acceptable, loosen, but do not remove all four crossbar bolts and two backstay bolts.
Adjust plumb of uprights.
13. While keeping uprights plumb, drill a 3/16” hole through back of crossbar and corner sleeve. Install spring pin into
hole, leaving 1/8” - 1/4” of pin protruding out.
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.

3/16” X 1”
Spring Pin
Drill
3/16” Hole
2-1/2”
NZ182 Rev. 07/17/17
14. Drill a second hole in the front of the crossbar and install a second spring pin, leaving 1/8” - 1/4” of pin protruding
out.
15. Repeat steps 13 and 14 on opposite end of crossbar. Tighten all four crossbar bolts and two backstay brace bolts.
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.

Clip
Eyebolt
Net Strap
Pull
Backstay
Net Strap
Backstay
Clip
Eyebolt
NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
16. Attach net strap to the eyebolts in the backstays as shown. Pull net strap tight as shown. (NOTE: Do not over-
tighten net strap. Over-tightening may damage goal.) Excess strap can be trimmed to length. Leave
12” to 18” of excess strap for ease of removal and re-installation. (NOTE: to keep end of strap from fraying, ends
can be melted after being cut.) Tie all excess strap to itself to prevent from hanging in goal area.

Net Clip (I)
Net
Net Clip
NZ182 Rev. 07/17/17
17. To attach the net to goal, place base of net clip into channel and turn 90 degrees to lock into place. CAUTION:
DO NOT ATTEMPT TO CLIMB ON GOAL WHILE ATTACHING NET.
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
Go to kwikgoal.com for additional product information.

FOO
T
RA
-
D
0
IU
5
S
M
S
U
UR
M
R
I
N
O
I
U
M
N
D
A
IN
M
G
O
R
G
F
O
S
A
N
L
O
W
S
R
H
E
IL
P
E
L
T
L
E
A
S
R
TI
A
N
E
G
LC
NZ182 Rev. 07/17/17
***CAUTION***
This goal has been designed to be used for the game of football or soccer only. Goal posts must be anchored AT ALL
TIMES and shall be secured against overturning. Do not climb on the net or goal framework at any time! All
fastenings must be checked to insure they are fully tightened before and after each use of this product. Goal posts
not in use must be disassembled and properly stored in a safe, secure area (See included Guidelines for Moveable
Soccer Goal Safety.). Assembled goal posts should not be left unattended. Remove nets when goals are not in use.
Do not use this equipment during the threat of high winds. Goal posts should be checked for safety before and after
each use. All warning and safety labels included with this product must be visible at all times.
Any modifications to this or any Kwik Goal product will void any and all warranties.
ANCHOR TEST
1. Clear all persons from a minimum 50 foot radius surrounding the goal.
2. Verify goal is attached to anchors according to instruction.
3. Apply a horizontal pull force of 247 lbs. to the center of the crossbar for 60 - 70 seconds.
Full safety precautions must be taken while performing test.
4. If goal overturns during application of force or does not return to an upright position after removing force, an
alternate anchoring system must be used
18. After installing, test as described below to verify effectiveness of anchor system. If applicable, allow concrete
to fully cure before testing.