LCSI IES-M162C User manual

1
16 10/100TX + 2 10/100/1000T/Mini-GBIC Combo
Managed Industrial Redundant Ring Switch
IES-M162C and IES-M162CE
User Manual
www.lcsi.com.tw

IES-M162C User’s Manual
2
The contents of this manual are based on the table below listing
firmware version, software kernel version, and hardware version.
If the switch functions are different from the description of
contents of manual, please contact the local sale dealer for more
information.
Firmware Version
V1.07
Kernel Version
V2.07
Hardware Version
----------
Notice

FCC Warning
This Equipment has been tested and found to comply with the limits for a
Class-A digital device, pursuant to Part 15 of the FCC rules. These limits
are designed to provide reasonable protection against harmful interference
in a residential installation. This equipment generates, uses, and can
radiate radio frequency energy. It may cause harmful interference to radio
communications if the equipment is not installed and used in accordance
with the instructions. However, there is no guarantee that interference will
not occur in a particular installation. If this equipment does cause harmful
interference to radio or television reception, which can be determined by
turning the equipment off and on, the user is encouraged to try to correct
the interference by one or more of the following measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to
which the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
CE Mark Warning
This is a Class-A product. In a domestic environment this product may cause
radio interference in which case the user may be required to take adequate
measures.

IES-M162C User’s Manual
1
Content
Introduction................................................................ 1
Features................................................................... 1
Software Specification ............................................. 3
Package Contents.................................................... 5
Hardware Description ............................................... 6
Physical Dimension.................................................. 6
Front Panel .............................................................. 6
Top View.................................................................. 7
LED Indicators ......................................................... 8
Ports......................................................................... 9
Cabling................................................................... 12
Wiring the Power Inputs......................................... 16
Wiring the Fault Alarm Contact.............................. 17
Mounting Installation .............................................. 18
DIN-Rail Mounting.................................................. 18
Wall Mount Plate Mounting.................................... 20
Hardware Installation .............................................. 21
Installation Steps.................................................... 21
Network Application................................................ 22
X-Ring Application ................................................. 23
Coupling Ring Application...................................... 24
Dual Homing Application........................................ 25
Central Ring Application ........................................ 26

Console Management ............................................. 27
Connecting to the Console Port............................. 27
Pin Assignment...................................................... 27
Login in the Console Interface ............................... 28
CLI Management ................................................... 29
Commands Level............................................................ 30
Commands Set List......................................................... 31
System Commands Set.................................................. 31
Port Commands Set........................................................ 34
Trunk Commands Set..................................................... 36
VLAN Commands Set..................................................... 38
Spanning Tree Commands Set....................................... 39
QOS Commands Set...................................................... 42
IGMP Commands Set..................................................... 43
Mac / Filter Table Commands Set................................... 43
SNMP Commands Set.................................................... 44
Port Mirroring Commands Set......................................... 46
802.1x Commands Set ................................................... 47
TFTP Commands Set..................................................... 49
SystemLog, SMTP and Event Commands Set................ 50
SNTP Commands Set..................................................... 52
X-ring Commands Set..................................................... 53
Web-Based Management........................................ 55
About Web-based Management ............................ 55
Preparing for Web Management............................ 55
System Login ......................................................... 56
System Information................................................ 57

IP Configuration ..................................................... 57
DHCP Server –System configuration.................... 58
DHCP Client –System Configuration.................... 60
DHCP Server - Port and IP Bindings..................... 60
TFTP - Update Firmware ....................................... 61
TFTP –Restore Configuration............................... 62
TFTP - Backup Configuration ................................ 62
System Event Log –Syslog Configuration............. 63
System Event Log - SMTP Configuration.............. 64
System Event Log - Event Configuration............... 65
Fault Relay Alarm .................................................. 68
SNTP Configuration............................................... 68
IP Security.............................................................. 71
User Authentication................................................ 72
Port Statistics......................................................... 73
Port Control............................................................ 74
Port Trunk .............................................................. 75
Aggregator setting .......................................................... 76
Aggregator Information................................................... 77
State Activity................................................................... 78
Port Mirroring ......................................................... 79
Rate Limiting.......................................................... 81
VLAN configuration................................................ 83
VLAN configuration - Port-based VLAN.......................... 83
802.1Q VLAN.................................................................. 87
Rapid Spanning Tree............................................. 91

RSTP - System Configuration......................................... 91
RSTP - Port Configuration.............................................. 92
SNMP Configuration.............................................. 94
System Configuration...................................................... 94
Trap Configuration.......................................................... 95
SNMPV3 Configuration................................................... 96
QoS Configuration ................................................. 99
QoS Policy and Priority Type.......................................... 99
Port-based Priority........................................................ 100
COS Configuration........................................................ 101
TOS Configuration........................................................ 101
IGMP Configuration ............................................. 102
X-Ring.................................................................. 103
Security................................................................ 106
802.1X/Radius Configuration........................................ 106
MAC Address Table...................................................... 109
Factory Default..................................................... 112
Save Configuration .............................................. 112
System Reboot .................................................... 113
Troubles shooting ................................................. 114
Technical Specification......................................... 115

1
Introduction
The 16 10/100TX + 2 10/100/1000T/Mini-GBIC Combo w/ X-Ring L2 Managed Industrial
Switch is a cost-effective solution and meets the high reliability requirements demanded
by industrial applications. Using fiber port can extend the connection distance that
increases the network elasticity and performance.
Features
System Interface/Performance
RJ-45 ports support Auto MDI/MDI-X Function
SFP (mini-GBIC) supports 100/1000 Dual Mode
Store-and-Forward Switching Architecture
Back-plane (Switching Fabric): 7.2Gbps
1Mbits Packet Buffer
8K MAC Address Table
Supports Wide Operating Temperature (-40oC ~ 75oC)*
Case/Installation
IP-30 Protection
DIN-Rail and Wall Mount Design
Power Supply
Wide Range Redundant Power Design
Power Polarity Reverse Protect
Overload Current Protection
Spanning Tree
Supports IEEE 802.1d Spanning Tree
Supports IEEE 802.1w Rapid Spanning Tree
VLAN
Port Based VLAN
Support 802.1 Q Tag VLAN
GVRP
Double Tag VLAN (Q in Q)*

2
Private VLAN**
X-Ring
X-Ring, Dual Homing, Couple Ring, and Central Ring Topology
Provide redundant backup feature and the recovery time below 20ms
Port Trunk with LACP
Support IEEE802.1ab LLDP**
QoS (Quality of Service)
Support IEEE 802.1p Class of Service
Per port provides 4 priority queues
Port Base, Tag Base and Type of Service Priority
Bandwidth Control
Ingress Packet Filter and Egress Rate Limit
Broadcast/Multicast Packet Filter Control
Port Mirror: Monitor traffic in switched networks
TX Packet only
RX Packet only
Both of TX and RX Packet
System Event Log
System Log Server/Client
SMTP e-mail Alert
Relay Alarm Output System Events
Security
Port Security : MAC address entries/filter
IP Security: IP address security management to prevent unauthorized intruder
Login Security: IEEE802.1X/RADIUS
SNMP Trap
Device cold start, Power status
Authentication failure
X-Ring topology change
Port Link up/Link down
IGMP with Query mode for Multi Media Application
TFTP Firmware Update and System Configure Restore and Backup
Provides EFT protection 3,000 VDC for power line
Supports 6,000 VDC Ethernet ESD protection

3
Software Specification
Management
SNMP v1, v2c and v3 management
Web interface management
Telnet interface management
Command Line Interface (CLI) management
SNMP MIB
RFC 1215 Trap
RFC 1213 MIBII
RFC 1157 SNMP MIB
RFC 1493 Bridge MIB
RFC 2674 VLAN MIB
RFC 1643
RFC 1757
RSTP MIB
Private MIB
VLAN
Port based VLAN
IEEE802.1Q Tag VLAN (256 entries)/VLAN ID (up to 4k in
number which can be assigned from 1 to 4096)
GVRP (256 groups)
Double Tag VLAN (Q in Q)*
Private VLAN**
Port Trunk with
LACP
LACP Port Trunk: 4 Trunk groups/Maximum 4 trunk
members
LLDP**
Supports LLDP that allows the switch to advertise its
identity and capabilities on the LAN
Spanning tree
IEEE802.1d spanning tree
IEEE802.1w rapid spanning tree.
X-Ring
Supports X-Ring, Dual Homing, Couple Ring, and Central
Ring
Provides redundant backup feature and the recovery time
below 20ms
Quality of service
The quality of service determined by port, Tag and IPv4