Legacy Stoves TLC 2000 User manual
Installation and Operating Manual
Model(s): TLC 2000 Coal Stove
NOTICE: SAVE THESE INSTRUCTIONS
Report Number: 0536CS003S
Certified To: UL 1482-2011, UL 737-2011, ULC S627-00
Leg cy Stoves, A Division of:
Altern te He ting Systems
2393 Little Egypt Rd
H rrisonville, PA 17228
WARNING: HOT SURFACES!
To obt in French tr nsl tion of this m nu l, ple se cont ct your de ler or visit
www.leg cystoves.com
Pour obtenir une tr duction fr nç ise de ce m nuel, s’il vous pl ît cont cter votre
revendeur ou visite www.leg cystoves.com
⚠SAFETY NOTICE - CAUTION!
PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL OR USE YOUR NE ROOM
HEATER. RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE.
FAILURE TO FOLLO THESE INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY
INJURY, OR EVEN DEATH.
APPROVED FOR USE IN THE USA AND CANADA
IF THIS LEGACY STOVES PRODUCT IS NOT INSTALLED CORRECTLY, A HOUSE FIRE MAY
RESULT.
FOR YOUR SAFETY, FOLLO INSTALLATION DIRECTIONS PRECISELY. CONTACT LOCAL
BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSPECTION REQUIREMENTS
FOR YOUR AREA. CONTACT YOUR LOCAL AUTHORITY (SUCH AS THE MUNICIPAL BUILDING
DEPARTMENT, FIRE DEPARTMENT, FIRE PREVENTION BUREAU, ETC.) TO DETERMINE THE
NEED FOR A PERMIT. DO NOT INSTALL IN A MOBILE HOME
KEEP CHIMNEY AND CHIMNEY CONNECTORS CLEAN AND IN GOOD CONDITION.
Introduction
!" #$$$#!!"%
&'(!)&'$"*!$'!#
+'!!(",-$()
$!".!!($(!!'('$'/(!"
,01'!#)'$(!!('0".!!(
!$!(#!"
*!!'#)'!#!#)#2#!("
-3-
Table of Contents
Carbon Monoxide (CO) Awareness...........................................................................................................6
1.The Stove................................................................................................................................................9
1.1 Doors...............................................................................................................................................9
1.2 rates..............................................................................................................................................9
2. Fuels (USA)...........................................................................................................................................9
2.1 Coal.................................................................................................................................................9
2.2 Wood (Used for Coal Fire Startup).................................................................................................9
3. Fuels (Canada).......................................................................................................................................9
3.1 Coal.................................................................................................................................................9
4. Air Controls.........................................................................................................................................10
4.1 Coal...............................................................................................................................................10
4.2 Secondary Air Controls.................................................................................................................10
5. Building and Maintaining Fire.............................................................................................................10
5.1 Starting a Fire................................................................................................................................10
5.2 Building and Maintaining a Coal Fire...........................................................................................11
5.3 Refueling – Coal...........................................................................................................................11
5.4 Blower Use....................................................................................................................................11
5.6 Over Firing....................................................................................................................................12
5.7 Use of Optional Stainless Steel Cooking rill..............................................................................12
6.0 The Stove...........................................................................................................................................12
6.1 Surface..........................................................................................................................................12
6.2 Controls.........................................................................................................................................12
6.3 The Fire Chamber.........................................................................................................................12
6.4 Venting System – Chimney...........................................................................................................13
6.5 lass Replacement........................................................................................................................13
6.6 lass – Cleaning...........................................................................................................................13
6.7 askets..........................................................................................................................................14
6.8 Blower...........................................................................................................................................14
7.0 Assembly............................................................................................................................................15
7.1 Blower Option...............................................................................................................................15
7.2 Top Air rill Option......................................................................................................................15
7.3 Floor Protection.............................................................................................................................15
7.4 Clean out cover.............................................................................................................................16
7.5 Coal bars.......................................................................................................................................17
7.6 Shaker Handle...............................................................................................................................17
7.7 Clearances.....................................................................................................................................18
8.0 The Chimney System.........................................................................................................................19
8.1 Soot and Creosote Formation and Removal.................................................................................19
8.2 Draft..............................................................................................................................................19
8.3 Chimney Connectors.....................................................................................................................19
8.4 Wall Pass-throughs........................................................................................................................19
8.5 The Chimney.................................................................................................................................20
8.6 Existing Masonry Chimneys.........................................................................................................21
8.7 Venting to a Masonry Fireplace Chimney.....................................................................................22
8.8 Installing to a prefabricated Chimney...........................................................................................23
8.9 Barometric Damper Setup.............................................................................................................24
9.0 Service Parts TLC-2000.....................................................................................................................25
10. Warranty Information (2 Pages).........................................................................................................28
-4-
-5-
Addition l W rnings nd Notices
Carbon Monoxide (CO) Awareness
#'2$)$ 3)!!)$!$$$'#!$!" 3'
2$#!" !$'(!!$$'' 3$
'##1$'"$$##!)'!! 3
$"!))($(!!" 30!!!")#!!
$#!!!!!'$"
3$$'$!'' 3 3'
!('(2",!'$
" ,!#($($"
" $!$$!$"
" '!"
4" !!'"
5" 6!!2#!$!!'$$$7'$$"
THIS APPLIANCE IS ALSO APPROVED FOR INSTALLATION INTO A SHOP.
NEVER SLEEP IN THE SAME ROOM ITH ANY COAL BURNING STOVE!
CAUTION! NEVER USE GASOLINE,
GASOLINE-TYPE LANTERN FUEL,
KEROSENE, CHARCOAL LIGHTER FLUID,
OR SIMILAR LIQUIDS TO START OR
FRESHEN UP A FIRE IN THIS HEATER. KEEP
ALL SUCH LIQUIDS ELL A AY FROM THE
HEATER HILE IT IS IN USE
ARNING: DO NOT INSTALL A FLUE
DAMPER IN THE EXHAUST VENTING
SYSTEM OF THIS APPLIANCE. DO NOT
CONNECT THIS UNIT TO A CHIMNEY FLUE
SERVING ANOTHER APPLIANCE.
CAUTION! FAILURE TO FOLLO THE
INSTALLATION INSTRUCTIONS IN THIS
MANUAL, OR USING MAKESHIFT
COMPROMISES DURING INSTALLATION
MAY RESULT IN PROPERTY DAMAGE,
PERSONAL INJURY OR DEATH!
DO NOT CONNECT TO ANY AIR
DISTRIBUTION DUCT OR SYSTEM
DO NOT USE CHEMICALS OR FLUIDS TO
START A FIRE.
DO NOT BURN GARBAGE OR FLAMMABLE
FLUIDS SUCH AS GASOLINE, NAPTHA, OR
ENGINE OIL.
HOT HILE IN OPERATION. KEEP
CHILDREN, CLOTHING AND FURNITURE
A AY. CONTACT MAY CAUSE SKIN BURNS.
HEN INSTALLING IN A TIGHTLY
CONSTRUCTED HOME, A SOURCE OF
FRESH AIR TO THE ROOM MAY BE
NECESSARY FOR PROPER OPERATION OF
THE APPLIANCE.
DO NOT INSTALL IN A MOBILE HOME
IT IS RECOMMENDED TO ENSURE A
ORKING SMOKE DETECTOR IS IN THE
SAME ROOM AS THIS APPLIANCE.
-6-
Specific tions
%"""""""""""""""""""""""""""""""""""""""48!#
.!9"""""""""""""""""""""""""""""""""""""8,
.!:
;<:*)=)7#'!";($)2>
!?#$#!("
''$$"""""""""""""""""""""""8@(A@2
B;76,""""""""""""""""""""""""""""""""C)
D6 """""""""""""""""""""""""""""")E)-"
B!(9>3!?"""""""""""""""""""""""""""5'>#!$?
D6#$$!"!!$!!$'$#
$#$!'$'F"
-7-
Unit Overview
-8-
Oper tion
1.The Stove
1.1 DOORS
G!!1!$$!$$0()'!!$'$!$
$"!$)$!!($!!H!$)$!IJ!
$!(!$!!(8J!"$)!
$!$!!" !$#$$!!!($("!$$'
($#!$!$$($!!"
<!!$'#!$(!'!)$!2'$($!$(
"!$'#!$$((0!"K$$!
''!"3($)($$-!!$)!$
0$>$$!?"
=3*<%,636<=3=L333*=<<,
!$ '$2$$($0)#!!!!)'#
$(''$"=#!#!''$!(#/",
!#$'$)$!#!$"!#'#!!$!"
=#!$0$!!"
1.2 GRATES
-' (
!$'!!(2!
$!'$"'
!#$(!M(
#!"!$''
#+'!#$(!0#"
'!$#!#$(
"!!
",!$K!!(
!!#(!$"
3<33L,., <,3=3.6,K<G<G
<;<L<=K3;,;<,3=
2. Fuels (USA)
2.1 COAL
<!)9)'!(
$$"B'!'!##$#
!(!!$#'!'
"
2.2 OOD (USED FOR COAL FIRE STARTUP)
%$'##$ !#!"<#$#!'($
#!0"
3. Fuels (Canada)
3.1 COAL
<!)9)'!##$'! "B'!'!##$#
!(!!$#'!'".!!$#$$!)#!$"
N!$!!!"<!)!('!!'"
-9-
<;,3=O;3..;366<=63* ,.,L%,3,L6*3L; %<<=G<=L<G*3
<,N3*3=<6<6<=L<.G"**<K;<,3=) 3=,=;3;%33LB;=,=K,
*36,B,L<=L%,3,L63%<<=G"
Building & M int ining Fire
4. Air Controls
4.1 COAL
!''!#$$#"'
$$!!!#"<'!!'
!0($!$(
"'!!##!$
#+'$"!$#!$!'!!0"
!$#$'!0"%#
($$!0)#!$#!!(!)
!$"
4.2 SECONDARY AIR CONTROLS
%$#(#+'H()'$(
!'(#$!!$
!"(''$$!!#
$!!($#$
!"$!!$$(#"B
!!$#$/$-!!"<'!!$
!!"!$(!$'"%#!
!!$#$("%#!!(!!)'!!'$
''#"
<;,3=O6 3=L<G<, 3=3<63O;63<B6<N6<=L3K33
<LP;6 3=3O
<;,3=O63*<,3=<=K3.6<, 3=3<G=3B<L.3<=G<3=
<;,3=O<%<G%<.,1,<=K333*<63"6<, 3=3,63%6,,=
3*<,3="
5. Building and Maintaining Fire
5.1 STARTING A FIRE
'!2($!0#2"=2!$($74'2''$'
)=2!!@1@!$($)!!($#(@1@!"$
!'2''+)!!("*!##+'$!"+(!!!!(
!!#!$0"!#'#'$$#!'
$",$!!(0#!$!#$)@1@>5''1A''?'$"G'$!
$#!9!)#!+$$($"3!#$
#!$'$$!"
-10-
=;K<3,=)K<3,=1G*<==.;)N3=) 6< 3<,K6.;,L)3,,<
,Q;,L3<3R.6=;*S<.,,=6,6<"N*<; 6,Q;,L%<%<G.36
6<%6,,,,=;"
5.2 BUILDING AND MAINTAINING A COAL FIRE
.-!)#!'($9#@$'"<$$@($0#2M$
(#($"3'!$0)($!$($!$
!!"''M(-$!#"=2$$!
!($" #!!!$$",#!$#
$)#'0''"3($'0'(!!
0$'$'"=!+$$($"<!!
#)$!'#$$$"<$!#)'!'#$$$"L$$!#
0##"(!"N!$)!$(" '#"
<#')(!!RS!'!!H/
)$(!!$(0"<!(''#!!'##!)!$!)#$
$1-$!$>4A@5'';"")55''8@ $?"=!(
!$($)!$)$'!"
5.3 REFUELING – COAL
3!!'2''#!$
"<!!(0#!!'"
(!0$!!!
)O<$$!!#$",$!!(
'$!2$!'T
(!$$$!"#!!!'!"
!!'#$$$+"
5.4 BLO ER USE
!$!#!()$/
!'!(##!$#!($"
5.5 ASH REMOVAL
<!((!'"!$
$"*!!#$!"$!
!$!!" !
$(!$"0(!!
#+'$!$"!"
''0'#$!!#"
L)($##(#$$($H
)$!!$("=!#!$
@$"2#!$
2"<!$0!!"<#!$#(
$'$(
'!"
($$$(
$'$"%!)
$$'#!!($#$!"
!$#$$!"<
$''#!$"
(!!#!$$$!$!
$($0"
<!$#!$!(0+!$$
'$$''$!"!$!$#
!$'##!M$)(!!('!!
'##!'!)$0!$!",$$
##!!(!!!$$)!$#$
!$!!!$!!$"3(
!!#!$"
-11-
5.6 OVER FIRING
<$0"!!9$(!$'##!(!!
'!)$')$2')0"30$#:'M(
-!"G'$!!#+'$"3)=(')$
("''2$($)(#'$$#!!#'$'"30
!2!')$''!($",
0)$!0)$('!"L#!
'2''+",'2''-$$$)'!!"
,'0)!!!!0$'H'!"$
'#!!!"L((0H$'$
'$"6'!!!$$$#'#"
5.7 USE OF OPTIONAL STAINLESS STEEL COOKING GRILL
!!#$0!!"!!!!)!$!!!(!"!!(#
!$$$(#!(!" !$M'!
!!"M$$$($(!$"$'!$$"<(
!!0)'$''#2'$(#!"
M inten nce
6.0 The Stove
6.1 SURFACE
&2!$#$$$!!(!".'!)(!!
#$'!!#!'"
6.2 CONTROLS
$#!$1!)(!#$!')$'')
!$$("
6.3 THE FIRE CHAMBER
$0'#!$#2'$$'0#!'!)$",##
$'$)!'(!'"
-12-
=<63;=<=LL,.,66
<633<LL33,3*="3.,,=K<G;"
<;,3=O 33N,=KK,<GB63"<%<G%<K3%6=6<=L,=K6 33N,=KK,"
6.4 VENTING SYSTEM – CHIMNEY
1.'$$'!1%($#$!(!>$?$$)
('#(2!!$''"$!'!(#0"<
!)$'!M!"%$)'2'!0"'
$''#$!('$$'#!$1
$",0!'!$>'''?)'#'$$'0",
'0)!!!!0$'H'!"$
'#!!!"L((0H$'$
'$"6'!!!$$$#'#"
6.5 GLASS REPLACEMENT
!'!"5''U444''U''"!#!'$!",&!
$#)'!#"'!!"!!!(!$
!'!!H$#"!!!(!!$''$#
!.
!!!)(!!$'$"$)$)!$!"
!!'$'$!)'!)$!$$(!"!$(!!!'!"
$')('$'0"!$$$(
)$!!!$74@'!$!"
!$!$",!!!$$(!$(#!("!!$"
6.6 GLASS – CLEANING
''(!!#!'!$'!H!!('!!
$!RS$$"('!!!$#T$
0"=!!(!)$$##"%(!()$
!"G'(1#!0!!$$!",)$!#
!"
-13-
6.7 GASKETS
K$$$!$ "G'
''')$!'(
"'$0#!$T9
>##!'L!?$02$!(
''")0'
(0#!$!((#"<!!
'("*!
'!!#$'$)(
'!!H$!$"
0'!#!(#!H2'!)
$)!$"<!!('$
#"
K!!$:
•3$$!
•3!$
6.8 BLO ER
!#!( -!+!
'"G!$)()!$'
$$$",$')$''!
!"*!#!#!$1"
-14-
Inst ll tion
7.0 Assembly
7.1 BLO ER OPTION
B!#!(#+'((741#!"
#!)#$1"
#!($#$/$##!1
($"%00)#!(T"<
$#$!#!$)#!(
$$$"
($#!('#$$$
!)$'#$('!"
7.2 TOP AIR GRILL OPTION
!!'#!!$#'
!!$"
!!'!!!!M!$
(!",!$!#"
!!$$$$#
''"
7.3 FLOOR PROTECTION
,!!!!)$$$'#$'!!$!!";!$;8AM
"M'#7AS'''(!"$$'##!'!"
*M('!!">C"4 !?
K$!.!*
" '!!$$9!"M'2$'''@>5''?
#$$9!H
" A@>''?$$!H
" 8@>48''?$>;""?HA@>45C''?$> $?"
>$'2:C"4 !?
-15-
<;,3=OL3=3,=<,=<*,=K33
<!.!*
,#!0$2M!'#$"6('''-'$#'#
'$"<'$'$!M'-'!$!!(
$:
" 01!:
" 1!E$$"
" 1(-$>?:V72
" 1:V7
" L'1!$!M"
" ;'!>?!2$@@"
" .'!!!)$$1!!$'!!1!"
" ,!!1!'1!0$M)!
#!"
2'!:
0$M!$#741'!(1"A4"
$!4@#( 1"57A@'!#$(1"I"
>?: ;'!#01!"V72V7"A42"C5V"AI
>#?: !!$'"
4@# V"5)#V7 V7"5V"A
7A@'!#$V"I)'"#$"V7"I2"5V"4
!V#W'!#$V"AW"4V"
>?: '$'"0$"AI"$'-$)'
#!"
L0:
'!$V VBV%
>?>X?>Y.?>'X?>YN?
'!$VV>B?>?V%VB
>?>X?>Y.?>'?>YN?>?>?>Y.?
'!VV>X?>?>Y.?V>'X?>YN?
B %
7.4 CLEAN OUT COVER
!!$0#2$",'#!!!#!!$#$
3"%!!!$2$2")(!'$2
!!($#12"!!#'$!!(!2
".C!!"
-16-
7.5 COAL BARS
!B( #!$!$#'O '(!#!$$!
#"$(!$!!$$!#($$!$0#2",!$
!!$'!RS!$-!!$!$$
!$7($'"G'$!$(''R!S'!"=(!$!#
!!$!$$!!!$" #$( !B
#L3=30!!0#2!!(( !B"
7.6 SHAKER HANDLE
$!!$($$!$0#2",'!!$-!$
&#"$!'#!''$!$(#'"
-17-
7.7 CLEARANCES
!'-$#(''##!#/)
(!!)!)M)" !$'!#$$#'$$# <=7 <B85
$$> $?=.*<>;""? #!$'$$!
$$"
*!!! ,!!
<!!!!!(#$$!!!(!!#$$$"<
!!(#$$!!'"!!-
(!"
.!!!!!-$!$':A@>45C''?$(!!$8@>45''?#
(!!".''(!!'#A@>45C''?)$(!!C@>8A5''?$!)8@>I4''?"
.!!!'''!-'H0!!!!($!'!$'
!"
.!!)!$'@>5''?''$
'##!'!"%!$'(!!)''%!!.! (!!#
"=!-$'''!A"
.')!'##!'!))!)"):4A@>I''?;""$8@
>54''? $"
<!M$''#$!
''-'(#!(">C"?
''9M!!$
4A@24A@>;<3=G?"
-18-
Inches Millimeters
GSides – USA/C n d * 8 203
HFront – USA/C n d * 18 457
JRe r – USA 8 203
Floor Protection
Requirements
Parallel Installation Inches Millimeters
AB ck W ll to Unit 16 406
BSide W ll to unit 18 457
CB ck W ll to Flue Connector 18 457
DSide W ll to Flue Connector 27 685
Corner Installation Inches Millimeters
EW lls to Unit Body 12 305
FW lls to Flue Connector 18 457
Venting
8.0 The Chimney System
8.1 SOOT AND CREOSOTE FORMATION AND REMOVAL
%($#$!(!>$?$$)('#(2!!$''
"$$!!!'M!(#0"<!)
$'!M!"%$)!2'!0"
'$'!$#$!('$$'
#!$1$",'!$>'''?!$#'$$
'0" '$''-!)!!(!+$)
''$$"')!!";M!$')')$
'!"
!$')T(#$'!'#!"!
')!!$$#9$0!M)!!#!$'!"<
$)'2''')$$"
8.2 DRAFT
L($!'$$",'))!9$#!T)-"
$'$$)$&'"
L)$$#$'(+$",$#
')$T#($'$$",!!''#
)$2H(M()0(!!"
3)#')($)1')!$'!')'$
$2!!!'$-$",')($('
$#!)'$$)!!"(#')
!$'$2$$H($!($H$!'!!'!'
$$$$2!'2-!"
'$-$')$)$F!'0)$!("3$#$#
!!'''$$9)$0"$!$$!
')#!!(0)$'!($",'!!(
'$!'!)!$9))$$$#!'"
%!!$$$$'!) (!!$'('
$-$'$#!"!!!#'$'!'
'2''$"
8.3 CHIMNEY CONNECTORS
,!)!!($!(!!'!(!!!$!$H#
!!)(!!#!$$F!$$!!!!('M$$
!''"
'#!!$(4K)8$'>5''?'"9!$
$9M!!"'9!$#!''
1!M!!"L'''"=''+
)!!$)M!"%#!)$
'##!(!!H')$(!!1)$#$!"
<'#!#M!!)('$$($>$#$
M$'?"/)!$&M!!$'!!$#$(
!'!("('#'2''"<174@>''?!-$/)
!$M!!+'"='(I$!#(!$#$)$!!!$
2$>'?"<!!9!''''($!74@>8''?>'''?"
8.4 ALL PASS-THROUGHS
3!!''##!(!!'"L$!!
#!$$)$!!$)!'!!"B#
!!)!!F!)$!'$''0-'"
-19-
<,=<,= 6,=G<=L 6,=G 3== 3)N* <=<=L,=K33L 3=L,,3=O
$:'$$# $$$<"$'('$-A@
>45''?#($(!!",!!(($#$$'"(
'$$#$$! <=7 <B85)!$$"
;$:,;"")!$=.*<"%!'!!$$$)#(!!
##!!"
=.*<>=!.*<?''$'##!(!!"<''!$
'$(!!$!''!'''@>''?$')
$0!!(#'(!"5@>I''?"<0!!)'''7A@>I''?(!!'
#(!!'!>##$!?",'#'$!(
'"'$!!$".$!)'$=.*<$"
8.5 THE CHIMNEY
'#!!$'$
(!$1!!",;"") '#
$>?#$''!(
-'6.'$$
').1B!)$!$B!$6
<!);)>?$$''(
M!", $) !$(
#$'$$!$'
>85$ ?'$$); 18I)($
$''"
'''''$$'8>4"A'?
#M!!"<$M>'$
#$?)8@>5''?)C@>A''?A@>''?
'#$".-!'')'!
9A@2A@A@2@>''2'')''2''?
'#$"
B!$$-!$1!'2$>"I'?
#(2')$$
(')
''2$>8'?#(
>'?$",!'
')''2$>8'?
#(>'?$"
-20-
%<=,=KOL3=3,=<,=*,=K33O
L3=3 3== 6,;=,3< 6,=G.;,=K<=36<**,<= O
Other manuals for TLC 2000
2
Table of contents
Other Legacy Stoves Wood Stove manuals
Popular Wood Stove manuals by other brands
Majestic
Majestic Ashland Series installation manual
Storch Kamine
Storch Kamine CUADRADO SE user manual
Continental Fireplaces
Continental Fireplaces C1450 Installation and operating instructions
Quadra-Fire
Quadra-Fire Explorer III EXP-III-APAC Installation and Operating Instrucitons
barbas
barbas BOX 52 Installation instructions & manual for annual maintenance
Residential Retreat
Residential Retreat DWS-330293 owner's manual
chazelles
chazelles RUSTIQUE Installation instructions and operating manual
AGA
AGA Dorrington manual
Cadel
Cadel KOOK 60 4.0 Installation, use and maintenance manual
Quadra-Fire
Quadra-Fire 31M-ACC-GT owner's manual
Enerzone
Enerzone Solution 2.3 owner's manual
IronStrike
IronStrike Grandview GV230 Installation and operation manual
Drolet
Drolet Savannah DB03025 Installation and operation manual
Camina
Camina Art Supreme Instructions and assembly use
Waterford
Waterford Trinity Mk II Installation & operating instructions
Bullerjan
Bullerjan B4 Keramik installation manual
New Buck Corporation
New Buck Corporation 18 user guide
ADURO
ADURO 3 user manual