Logic Controls CR3002 User manual

NOTICE
The manufacturer of the POS cash drawer makes no representations or
warranties, either expressed or implied, by or with respect to anything in
this manual, and shall not be liable for any implied warranties of fitness for
a particular purpose or for any indirect, special or consequential damages.
Information in this document is subject to change without notice and does
not represent a commitment on the part of the manufacturer.
FCC NOTICE
This equipment generates, uses, and can radiate radio frequency energy
and if not installed and used in accordance with this manual, may cause
interference to radio communications. It has been tested and found to
comply with the limits for a Class A digital device pursuant to Subpart J of
Part 15ofFCCRules, whicharedesignedtoprovide reasonableprotection
againstinterference whenoperatedinacommercial environment. Operation
of this equipment in a residential area is likely to cause interference in
which case the user at his own expense will be required to take whatever
measures may be required to correct the interference.
i
LOGICCONTROLS,INC.
355Denton Ave
NewHydePark,NY11040
TEL:[phone]
FAX:[phone]
Email:[email protected]
http://www.logiccontrols.com

TABLE OF CONTENTS
FEATURES................................................................................. 1
CARTON CONTENTS................................................................2
INTERFACE DESCRIPTION ......................................................2
INSTALLATION...........................................................................3
FUNCTIONAL TEST ................................................................…3
KEY LOCK OPERATION .........................................................…3
CONNECTOR PIN OUT ............................................................. .4
CONTROLLER BOARD JUMPERS ......................................... .4

FEATURES
•Low cost
•Small foot-print with efficient use of internal space
•Drawer opens from 9 pin communications port
•Adjustable bill and coin compartments
•Three-position lock for maximum cash security
•High security –no screws on the outside of the case
•Check slot for non-cash or large-bill transcation
•Rugged design with reinforced heavy gauge steel construction
•Contemporary style
•Advanced electronics that extend the MTBF ( Mean Time Between
Failure )
CARTON CONTENTS
CR3002
1. Cash drawer, pre-assembled
2. Com Port interface cable
3. Two keys
4. This User’s manual
INTERFACE DESCRIPTION
Model CR3002
Connect the drawer to the computer 9 pin commnication port.
Whenever the POS application software sends a bell (07 Hex)
Command to the communincations port, the drawer will be opened.

INSTALLATION
Your cash drawer has been pre-assembled to make the installation
as simple as possible.
Model CR3002
1. Remove the cash drawer from its shipping container.
2. Remove the keys and interface cable from its plastic bag.
3. Connect the DB9 connector of the interface cable to the
computer COM1(or COM2) port.
4. Connect the DB25 connector of the interface cable to the the cash
drawer.
FUNCTIONAL TEST
The following test sequence will verify that your cash drawer is working
properly.Before you start this procedure, you must install the cash drawer
correctly as outlined in the installation section.
NOTE: The actual key entries are enclosed within quotation marks (“ “). Do
not type the quotation marks as part of your entry.
1. From the C prompt type “MODE COM1 96,N,8,2” and press ENTER.
2. Type “TYPE CON>COM1” and press ENTER.
3. Type any alphanumeric character(s) and press ENTER. The cash drawer
will open.
4. To return to the C prompt press and hold the CTRL key while depressing
the letter C.

KEY LOCK OPERATION
All cash drawers have a three position key lock for maximum
security.The fully counter clockwise lock position offers
maximum security. The cash drawer can not be opened by
computer or an individual when the lock is in the full counter
clockwise position.With the lock in the center position, the drawer
will open when an electronic pulse is received from either the
printer or computer.The cash drawer is manually opened when the
lock is in the full clockwise position.
Model CR3002 Keylock Operation:
: Drawer securely locked.Can not be opened by computer
or manually.
: Opens the drawer with the supplied key.
: Automatically opens the drawer by computer control.
KEYLOCK
6

MECHANICAL:
Weight 14.3 lb. (6.5 kg)
Height 3.3 in. (8.5 cm)
Width 15.7 in. (40 cm)
Depth 16.1 in. (41 cm)
ELECTRICAL:
INPUT TO SOLENOID Amplitude 12VDC
SERIAL INPUT Baud Rate 300 to 9600
CONNECTION PIN OUT
(DB25M) -Serial Input From Computer
Pin # Function
1 No connection
2 Receive data from computer
3 Transmit data to computer
4RTS, Request To Send; from computer (tied to pin 5 internally)
5 CTS, Clear To Send; to computer (tied to pin 4 internally)
6 DSR, Data Set Ready; to computer (tied to pins 8 & 20 internally)
7 Ground
8 DCD, Data Carrier Detect; to computer (tied to pins 6 & 20)
9 No connection
10 No connection
11 No connection
12-17 No connection
18 No connection
19 No connection
20 DTR, Data Terminal Ready; from computer (tied to pins 6 & 8)
21-25 No connection