Marantz PM6003/N1SG User manual

修理の際は、必ず取扱説明書を準備し操作方法を確認の上作業を行ってください。
Please use this service manual with referring to the user guide (D.F.U.) without fail.
Service
Manual Integrated Amplier
PM6003 /N1SG/K1SG/N1B
TABLE OF CONTENTS
SECTION PAGE
1. TECHNICAL SPECIFICATIONS............................................................................................1
2. IDLING CURRENT ALIGNMENT..........................................................................................2
3. SERVICE MODE....................................................................................................................3
4. WIRING DIAGRAM ................................................................................................................5
5. BLOCK DIAGRAM .................................................................................................................7
6. SCHEMATIC DIAGRAM ........................................................................................................9
7. PARTS LOCATION ..............................................................................................................13
8. EXPLODED VIEW AND PARTS LIST..................................................................................21
9. MICROPROCESSOR AND IC DATA ...................................................................................25
10. ELECTRICAL PARTS LIST..................................................................................................28
11. ABOUT REPLACE THE MICROPROCESSOR WITH A NEW ONE .............................. 47
PM6003
Part no. 90M18DW855010
First Issue 2009.05
ecm
PHONES
MIN MAX
LOUDNESS
VOLUME
MUTE1AUX/DVD 2 RECORDER CDPHONO TUNER
INPUT SELECTOR
L R
BASS
POWER ON/OFF
TREBLE BALANCE
STANDBY
B
SOURCE DIRECT A
SPEAKERS
PM6003

MARANTZ DESIGN AND SERVICE
Using superior design and selected high grade components, MARANTZ company has created the ultimate in stereo sound.
Only original MARANTZ parts can insure that your MARANTZ product will continue to perform to the specications for
which it is famous.
Parts for your MARANTZ equipment are generally available to our National Marantz Subsidiary or Agent.
ORDERING PARTS :
Parts can be ordered either by mail or by Fax.. In both cases, the correct part number has to be specied.
The following information must be supplied to eliminate delays in processing your order :
1. Complete address
2. Complete part numbers and quantities required
3. Description of parts
4. Model number for which part is required
5. Way of shipment
6. Signature : any order form or Fax. must be signed, otherwise such part order will be considered as null and void.
SHOCK, FIRE HAZARD SERVICE TEST :
CAUTION : After servicing this appliance and prior to returning to customer, measure the resistance between either primary
AC cord connector pins ( with unit NOT connected to AC mains and its Power switch ON ), and the face or Front Panel of
product and controls and chassis bottom.
Any resistance measurement less than 1 Megohms should cause unit to be repaired or corrected before AC power is
applied, and veried before it is return to the user/customer.
Ref. UL Standard No. 60065.
In case of difculties, do not hesitate to contact the Technical
Department at above mentioned address.
080702MZ
NOTE ON SAFETY :
Symbol Fire or electrical shock hazard. Only original parts should be used to replaced any part marked with symbol
. Any other component substitution (other than original type), may increase risk of re or electrical shock hazard.
安全上の注意：
がついている部品は、安全上重要な部品です。必ず指定されている部品番号のものを使用して下さい。
USA
MARANTZ AMERICA, INC
100 CORPORATE DRIVE
MAHWAH, NEW JERSEY 07430
USA
EUROPE / TRADING
D&M EUROPE B. V.
P. O. BOX 8744, BUILDING SILVERPOINT
BEEMDSTRAAT 11, 5653 MA EINDHOVEN
THE NETHERLANDS
PHONE : +31 - 40 - 2507844
FAX : +31 - 40 - 2507860
KOREA
D&M SALES AND MARKETING KOREA LTD.
CHUNG JIN B/D., #1001,
53-5, WONHYORO 3 GA, YONGSAN-GU,
SEOUL, 140-719, KOREA
PHONE : +82 - 2 - 323 - 2155
FAX : +82 - 2 - 323 - 2154
CANADA
D&M Canada Inc.
5-505 APPLE CREEK BLVD.
MARKHAM, ONTARIO L3R 5B1
CANADA
PHONE : 905 - 415 - 9292
FAX : 905 - 475 - 4159
JAPAN
D&M BUILDING, 2-1 NISSHIN-CHO,
KAWASAKI-KU, KAWASAKI-SHI,
KANAGAWA, 210-8569 JAPAN
D&M Holdings Inc.
CHINA
D&M SALES AND MARKETING SHANGHAI LTD.
ROOM.808 SHANGHAI AIRPORT CITY TERMINAL
NO.1600 NANJING (WEST) ROAD, SHANGHAI,
CHINA. 200040
TEL : 021 - 6248 - 5151
FAX : 021 - 6248 - 4434

1
1. TECHNICAL SPECIFICATIONS
RMS Power output
(20 Hz – 20 kHz simultaneous drive of both channels)
....................................................... 45 W x 2 (8 Ω load)
....................................................... 60 W x 2 (4 Ω load)
Headphone rated output
(When speaker rated output set to 8 Ω load)
....................................................... 160mW (32 Ω load)
Total harmonic distortion
(1 kHz simultaneous drive of both channels, 8 Ω load)
........................................................................... 0.08 %
Output band width (8 Ω load, 0.08 %) ........10 Hz – 50 kHz
Frequency response (CD, 1 W, 8 Ω load)
.........................................10 Hz – 70 kHz +0 dB, -1 dB
Dumping factor (8 Ω load, 100 Hz – 10 kHz)................ 100
Input sensitivity/Input impedance
PHONO (MM).............................................2.2 mV/47 kΩ
CD, LINE, TUNER, AUX/DVD, RECORDER
............................................................200 mV/20 kΩ
Maximum allowable PHONO input level (1 kHz)
MM ...................................................................... 100 mV
RIAA deviation (20 Hz ~ 20 kHz) ........................ ±0.5 dB
S/N (IHF-A, 1 W, 8 Ω load)
PHONO (MM).................................... 84 dB (5 mV input)
CD, LINE, TUNER, AUX/DVD, RECORDER
................................................ 87 dB (500 mV input)
Tone control
Bass (100 Hz) ...................................................... ±10 dB
Treble (10 kHz) .................................................... ±10 dB
Power requirement ...............................AC 230 V 50/60 Hz
Power consumption (EN60065)................................ 150 W
Standby power consumption ..................................... 0.4 W
Accessories
Remote controller (RC003PM)...................................... 1
AAA batteries ................................................................ 2
Detachable AC power cable.......................................... 1
Dimensions (unit: mm)
PHONES
MIN MAX
LOUDNESS
VOLUME
MUTE1AUX/DVD 2 RECORDER CDPHONO TUNER
INPUTSELECTOR
L R
BASS
POWERON/OFF
TREBLE BALANCE
STANDBY
B
SOURCEDIRECT A
SPEAKERS
440 (17-3/8)
105 (4-3/16)
90.5 (3-5/8)
14.5 (5/8) 16 (11/16)
366 (14-7/16)
21.5 (7/8)
328.5 (12-15/16)
Weight : 7.5 kg

2
2. IDLING CURRENT ALIGNMENT
Adjust the Idling Current with the variable resistor VR31 and
VR32 on the PWB.
CONTROLS SETTING :
VOLUME : MINIMUM POSITION
SPEAKER OUT : NO LOAD
2. アイドリング電流調整
基板上(下図 )の半固定抵抗VR31とVR32でアイドリング電
流を調整します
セッティング :
VOLUME : MIN 位置
SPEAKER OUT : 接続しない
32:(5$03/,),(5$-8670(17
,GOLQJ&XUUHQW$OLJQPHQW
(DFKRIWKHPHDVXUHPHQWSRLQWVDUHSURYLGHGZLWKWKHWZRWHVWSRLQWV6HWDGLJLWDO9ROWDJHPHWHUWR'&YROWDJHLQSXW
FRQQHFWWKHPHWHUWRWKHWHVWSRLQWVDWERWKFRQWDFWSRLQWV
$IWHUWKHVHWXSDERYHWXUQRQWKHPDLQVZLWFK
$GMXVWYDULDEOHUHVLVWRUV9595DFFRUGLQJWRWKHGLJLWDOYROWPHWHUUHDGLQJV7KHWDUJHWVHWWLQJYDOXHLVWKH
IROORZLQJWDEOHIRUHDFKFKDQQHOV
6HWWLQJV
0DVWHU9ROXPH0LQLPXP
6SHDNHURXW1R/RDG
7RSOLG23(1
95
&13
&13
95
'&92/70(7(5


'&YROWPHWHU&RQQHFWWR&1[ 7LPH7DEOHRI,GOLQJ&XUUHQW5LVH
12
0HDVXUHPHW
3RLQW
$OLJQPHQW
3RLQW


&1
&1
95
95
&KDQQHO
)URQW/HIW
)URQWULJKW
$IWHU7XUQLQJ21
0HDVXUHPHQW9ROWDJH
&1&1
PLQ P9sP9
PLQ P9sP9
PLQ P9sP9
PLQ P9sP9
PLQ P9sP9
PLQ P9sP9
PLQ P9sP9
+($76,1.

3
3. SERVICE MODE
Microprocessor (IC61) version check
Operate by using the supplied Remote controller
(RC003PM).
1. Press the POWER button to turn on the unit.
2. Press TAPE (RECORDER 2) button and press 5, 0, 0, 3
button on the remote controller.
(Please each button within 5 seconds)
3. The rmware version is displayed on the front LED.
(Display time is only for 3 seconds.)
The rmware version is displayed in the lighting position
of LED.
Ex. :
Light up RECORDER-2 [1], Version : 1
Light up RECORDER-2 [1 ] and AUX/DVD [4], Version : 5
Light up RECORDER-2 [1] and CD [8], Version : 9
4. Each LED light up then all LED light up.
5. Turn off the power to quit Service Mode.
(The unit to the default status)
3. SERVICE MODE
Microprocessor (IC61) VERSION 確認
操作は付属リモコン(RC003PM)を使用します。
1. POWER ボタンを押し、本体の電源をいれます。
2. リモコンの TAPE (RECORDER 2), 5, 0, 0, 3 ボタンを順
に押します。
( 各ボタンは5秒以内に押してください)
3. FIRMWARE のバージョンがLED にて表示されます。
( 表示は 3秒間のみです)
LEDが点灯している箇所がバージョン表示です。
表示例：
点灯RECORDER 2 [1], Version ：
1
点灯RECORDER 2 [1] and AUX/DVD [4], Version ：
5
点灯RECORDER 2 [1] and CD [8], Version ：
9
4. フロントパネルの LEDが順次点灯し、その後全点灯します。
5. 電 源 を 切 る とSERVICE モ ードが 解 除 さ れ ま す。
(本機は、各種設定された内容が初期化され、工場出荷時
の状態に戻ります)
Version : 16 8 4 2 1
MUTE1AUX/DVD 2 RECORDER CDPHONO TUNER

4
Personal notes:

4. WIRING DIAGRAM
5 6
U-PRO &TONE PWB
POWER SW PWB
HEADPHONE
PWB
MASTER VOLUME PWB
SUB TRANSF. PWB
INPUT & AMPLIFIER PWB
TRANS
CN92(5P)
:2.5mm
CN95(15P):2.5mm
CN90(3P):3.96mm
CN33(5P):2.5mm
CN12(5P):2.5mm
CN55(3P):2.5mm
CUP12184Z
BN96(2P)
CN98(2P):3.96mm
TW91(2P):3.96mm
CN93(7P):2.5mm
CUP12183Z-2
CN96(2P):3.96mm
CUP12183Z-4
CUP12183Z-5
BN55(3P):2.5mm BN12(5P):2.5mm
CB52,7PIN HEAD
BN52,7PIN HEAD
BN95(15P):2.5mm
BN51(6P) => UPDAT E
BN93(7P):2.5mm
CUP12183Z-3
CUP12183Z-1
BN12
BN33
BN55
BN52
BN93
BN95
BN96
CB56,7PIN HEAD
BN56,7PIN HEAD
H.P JACK
BN33(5P):2.5mm
AC IN
BN56
CB52
CB56
CWZPM5003BN96
CWB1B01512058
CWB1B00725058
CJP07HA37ZM
CJP07HA37ZM
CJP07GF230ZB
CJP07GF230ZB
CWB1C00340058
CWB1B90512058001
CWB1B90518058001

7 8
5. BLOCK DIAGRAM
+15V
-
+
+
-
+5.6V
F MUTE
+
-
-
+
+
-
-
+
+
-
RIAA
-VCC
+VCC
PROTECT
SELECTOR
DETECT
-
+
PROTECT
-15V
CD
ST 5.6V
RY91
TRS1
AC 230V 50Hz
PHONO
TONE
AMP
AMP
SHORT DC
ROTECTP
RY32
SP CONTROL
Q393 ~ 394
IN
OUT
REMOTE
TONE
D911,D912,
RY33
TUNER
AUX/DVD
IC11
RY31
Q385 ~ 386
SP CONTROL
7915
7815
7805
7805
IC52
IC52
SOURCE DIRECT
IC53
IC53
LOUDNESS
SELECTOR
IC23
EQ AMP
FUNCTION,LED
1.SPK 1
IR ,EYE
CONTROL
IN/OUT
U-COM
MOTOR DRIVE
BALANCE
VOLUME
SUB TRANS
POWER TRANS
TRS2
F902
F901
EUR/CHINA: T2.5A L 250V
MOMS SW
SPK RELAY
SPK RELAY
M
INPUT
SELECTOR
IC23
Rch
Lch
LOUDNESS
Rch
HVILC78212 x 1
IN
OUT
RECORDER 1
RECORDER 2
OUT
IN
TONE DEFEAT
TONE
ON
OFF
MASTER
VOLUME
R CH
L CH
U-COM
POWER
SUPPLY
MAIN AMP
POWER
SUPPLY
VR55-1
VR55-2
VR54-1
VR54-2
TREBLE BASE
TREBLE BASE
IC61
RY92
AC RELAY
D901
KBU804F
D913,D914
=>11EQS10GT
=>1N4003
MAIN AMPLIFIER
SPK RELAY
(JAPAN VERSION ONLY)
(CVITMP86FH12MG)
RT01
RECEPTACLE
CONTROL
CONTROL
SOURCE DIRECT
IC62
(TC74HC4094)
PROTECTPER ATURETEM
DC OFF SET
DC BALANCE DETECT
IC22
Lch
REC,IN
AMP
AMP
R CH
L CH
PRE AMPLIFIER
+15
-15
-31.5V +31.5V
120 C TEMPERATURE
PROTECT
D932,D933
D930,D931
FLASHER IN FUNCTION,LED
(PHONO,CD,TUNER,
AUX/DVD,RECORDER1,
RECORDER2)
2.SPK 2
3.LOUDNESS ON/OFF
4.SOURCE DIRECT
KEY IN
IC41,IC42
(CLT5I009Z)
USA/JPN: T4.0A L 250V
=> CVIANAM1467A
OPTION
C911
V53
VR51
123
IC94
123
IC93
123
IC95
123
IC96
Q924
Q922 Q923
Q282
Q281
1
5
34
86
2
7
RY51
1
5
34
86
2
7
RY11
C102M
Q385
C2785Y
Q917
Q920
Q919
Q918
JK01 D102
D101
GND
Vcc
1 2 3
IC12
RPM6936
Q101
A102M
-15V
+15V
L-CH
L-CH
SPK SYSTEM 1
R-CH
R-CH
HEADPHONE
SPK SYSTEM 2
120 C HEAT
ROUT

9 10
6. SCHEMATIC DIAGRAM
!
!
!
!
!
!
!
!
!
!
!
!
!
** IMPORTANT SAFETY NOTICECOMPONENTS IDENTIFIED BY MARK HAVE SPECIAL CHARACTERISTICS.
IMPORTANT FOR SAFETY.WHEN REPLACING ANY OF THESE COMPONENTS
USE ONLY MANUFACTURER'S SPECIFIED PARTS.
CD IN
TUNER IN
AUX IN
IN
REC-1
IN
OUT
OUT
PHONO-L
CD-L
TUNER-L
R-OUT
R-OUT
REC IN-L
AUX-R
L-OUT
L CH
R CH
PROTECTOR AMP MUTE F MUTE
GND
+5.6V CLK DATA CE
L CH R CH
FROM TRANS
FROM TRANS
AC26V AC26V
AC15.5V
AC15.5V
-15V
PHONO-R
CD-R
TUNER-R
AUX-L
L-OUT
L-OUT
R CH
L CH
R-OUT
GND
B-15 B+15
R-OUT
L-OUT
-6
uF = 10 uF** THE UNIT OF CAPACITANCE IS MICROFARAD (uF)
** THIS SCHEMATIC DIAGRAM MAY MODIFIED AT ANY TIME WITH THE IMPROVEMENT OF PERFORMANCE.
K=1000 OHM, M=1000 KOHM.** THE UNIT OF RESISTANCE IS OHM.
R CH
L CH
REC1-L
REC-2
REC2-L
REC1-LOUT
REC1-R
REC2-R
REC IN-R
VEE VDD
CE
VSS
DATA
CLK
+15V
REC2-LOUT
REC1-ROUT
REC2-ROUT
120 degree Heat Detect
SET
RES
0V
0V
OVER CURRENT
DC OFFSET
HEAT
DC BALANCE DETECT
DC BALANCE
PHONO IN
P_RELAY SPK1 SPK2
FGND
FROM HEADPHONE PWB
C123
0.1
C124
0.1
R201 220
R221
1M
C221
150P
C201 0.022
C202 0.022
C222
150P
R222
1M
R202 220
R204 220
R224
1M
C224
150P
C204 0.022
C203 0.022
C223
150P
R223
1M
R203 220
R207 220
R227
1M
C227
150P
C207 0.022
C208 0.022
C228
150P
R228
1M
R208 220
R206 220
R226
1M
C226
150P
C206 0.022
C205 0.022
C225
150P
R225
1M
R205 220
R211 220
R231
1M
C231
150P
C211 0.022
C212 0.022
C232
150P
R232
1M
R212 220
R210 10
R230
1M
C230
150P
C210 0.022
C209 0.022
C229
150P
R229
1M
R209 10
R214 10
R234
1M
C234
150P
C214 0.022
C213 0.022
C233
150P
R233
1M
R213 10
R235 1K R236 1K
R237 1K R238 1K
C286
10/35V
L364
JUMPER
L363
JUMPER
R368
10(2W)
C368
0.047u(M)
C367
0.047u(M)
R364
0
R366
0
R365 0
R363 0
R367
10(2W)
R371
1K
R375
1.5K
R339
4.7(1/4W)
R337
4.7(1/4W)
Q371
KTC3199Y
C287
10/35V
R285
47K
R911
R912
D911
11EQS10G
D912
11EQS10G
D914
11EQS10G
D913
11EQS10G
C911
NC
C912
NC
C918
4700uF/25V
R920
22K
R919
22K
C919
47/25V
C920
47/25V
1
1
3
3
4
2
2
D901
KBU804F
R901
NC
C902
NC
C901
NC
C903
NC
R905
22K
R906
22K
Q921 C2316Y
R921
1.2K
R914
22K
D921 13V
D922
1SS133M
C914
3.3/50V
R915
47K
R913
4.7K
D915
1SS133M
C923
47/25V
R275 120
R274 120
R273 120
Q924 A107M
R927
10K
R923
33K
R929
10K
Q922
C3198
Q923
C3198
R926
22K
R925
22K
C926
22/50V
C927
47/25V
C928
0.047
D925
6.2V
D923 1SS133M
R922
1K
D924 1SS133M
R928
10K
C929
0.022
R924
22K
Q392
KTC3199Y
Q391
KTA1267Y
R392
18k
R391
33k
R394
47k
R393
10K
D391
1SS133M
D392
1SS133M
R395
10K
R396
47k R399
82
Q393
KTC3199Y
Q394
KTC3199Y
R400
82
R398
47k
R397
10K
C391
0.01uF(M)
C392
0.01uF(M)
C394
0.01uF(M)
C393
0.01uF(M)
D388
1SS133M
R385
10K
R386
10K
Q386
KTA1267Y
Q385
KTC3199Y
R388
33k
R387
10K
D383
1SS133M
R390
82
R389
33k
C385
0.01
R286
470
R287
470
Q282
C2874B
Q281
C2874B
R281
47K
R282
47K
R280
10K
C283
0.022
R283
1M
R279
330
R278
330
C921
100/25V
C922
100/25V
R382
33K
C905
10000UF/63V
C906
10000UF/63V
3
1
2
GND
OutIn
IC94
KIA7915
1
2
3IN
OUT
GND
IC93
KIA7815
JK12
JK13
JK14
10
9
8
7
6
5
4
3
2
1
-
+
-
+
+
-
-
+
JK31
Q355
2SC2837
R359
0.1(5W)
R361
0.1(5W)
C373
0.01uF(M)
Q351
C4883A
Q357
2SA1186
Q353
A1859A
R353
220(1/4W)
R355
10(1/6W)
R357
10(1/6W)
C345
47/25V
Q345
C3419Y
R343
4.7K
Q325
A1024Y
Q335
C3206Y
R335
150(1/4W) R327
150(1/4W)
R381
33K
Q379
KTA1267Y
R377
22K
R379
6.8K
C379
0.47/50V
R373
22K
D373
1SS133M
R383
6.8K
Q309
C3200GR
R307
33K
D305
1SS133M
R309
15K
Q315
A1268GR
R315
470(1/4W)
R313 15K
R321
470(1/4W)
R305
100
C305
47/16V
R317
22
R319
22
R318
22
R316
22
C304
47/16V
R304
100
R320
470(1/4W)
R312
15K
R314
470(1/4W)
Q312
A1268GR
R308
15K
D306
1SS133M
R306 33K
Q308
C3200GR
R328
150(1/4W)
R324
1M R322 1M
R336
150(1/4W)
Q336
C3206Y
Q326
A1024Y
R344
4.7K
Q346
C3419Y
C346
47/25V
R358
10(1/6W)
R356
10(1/6W)
R354
220(1/4W)
Q354
A1859A Q358
2SA1186
Q352
C4883A
R362
0.1(5W)
R360
0.1(5W)
Q356
2SC2837
R284
47K
R338 4.7(1/4W)
R340
4.7(1/4W)
D374
1SS133M
R374
22K
R378
22K
C374
0.01uF(M)
Q372
KTC3199Y
R376
1.5K
R372
1K
C289
330pF
C288
330pF
R341
1k
1
2
3IN
OUT
GND
IC95
KIA7805
12
CN37
12 CN38
C342
220/50V
C344
220/50V
C343
220/50V
C341
220/50V
C307
470pF
R323 1M
R325
1M
C306
470pF
R334
910
R333
910
JK15
JK11
GND1
R241
330
R242
330
C236
10/35
C235
10/35
R246
56K
R245
56K
1112345678910 11 12 13 14 15223 34 45 5
CN12
R243
47K
R244
47K
VR32
220 VR31
220
Q349
A1024Y
Q347
C3206Y
R351
47(1/4W)
R349
47(1/4W)
R345
100(1/4W)
R347
100(1/4W)
R352
47(1/4W)
R350
47(1/4W)
R342
1k
Q348
C3206Y
Q350
A1024Y
R348
100(1/4W)
R346
100(1/4W)
1.0(1/4W)
1.0(1/4W)
L102
320mH
L101
320mH
R247
4.7
C237
220/25V
C238
220/25V
R248
4.7
R691
330(1W)
R692
330(1W)
J101
J102
C395
0.022u(M)
C396
0.022u(M)
JW11-2
JW11-1
C917
4700uF/25V
13
24
5
6
RY33
13
24
5
6
RY32
C913
0.047u(M)
R294
470(1/2W)
R292
470(1/2W)
R290
470(1/2W)
R295
470(1/2W)
R293
470(1/2W)
R291
470(1/2W)
D307
1SS133M
D308
1SS133M
R311
1k(2W)
R299
1k(2W)
R310 1k(2W)
R298
1k(2W)
R300
22
D302
1SS133M
D304
1SS133M R301
22
R303
22
D301
1SS133M
D303
1SS133M
R289
100
R288
100
C309
100/25V
C311
100/25V
C310
100/25V
C312
100/25V
D309 16V
D311
16V
D310 16V
D312 16V
R943
15K
Q917
C3198YT
R940
2K
R942
10K
R941
15K
1 2
TH91
CN90
R103
100K
C105
10/50
R101
100
R105
100K
C109
220/25V R109
100
C121
220/25V
R111
82K
C111
0.039u(M)
C113
0.01uF(M)
C115
1000P(M)
R113
6.8K
C117
22/50V
R117
330
R119
100K
C119
2200P(M)
C120
2200P(M)
R120
100K
R118 330
C118
22/50V
R114
6.8K
C116
1000P(M)
C114
0.01uF(M)
C112
0.039u(M)
R112 82K
R110
100
C110
220/25V
R106 100K
R102
100
C106
10/50
R104
100K
C122
220/25V
R121 4.7
R122 4.7
R115 100
R116 100
C104
220P
C103
220P
V+
BOUTPUT
B-INPUT
B+INPUT
V-
A+INPUT
A-INPUT
AOUTPUT
- +
B
-+ A
8765
4321
IC11 NJM2068M
C102 220P C101
220P
C216
10/35
V+
B OUTPUT
B-INPUT
B+INPUT
V-
A+INPUT
A-INPUT
A OUTPUT
-+
B
-+
A
8765 1234
IC22
NJM2068M
C215
10/35
R217 330
R218
330
C218
10/50
C217
10/50 R216
56K
R215
56K
R219
47K
R220
47K
R239
4.7
C219
220/25V
C220
220/25V
R240
4.7
8
1234
765
RY31
CSL4A016ZU
Q305
A1268GR
Q313
C3200GR
Q311
A1268GR
Q307
C3200GR
Q303
C3200GR
Q301
A1268GR
Q306
A1268GR
Q310
C3200GR
Q314
C3200GR
Q304
C3200GR
Q302
A1268GR
R302
22
Q316
A1268GR
R297
0
R296 0
302928272625242322212019181716
2 1345678911 1012131415
151413121110987654321
IC21
LC78212
R251 10K
D251
1SS133M
C241
4.7/50V
C240
0.022
R249
4.7
C239
0.022 R250
4.7
D916
1N4003
D917
1N4003
V+
BOUTPUT
B-INPUT
B+INPUT
V-
A+INPUT
A-INPUT
AOUTPUT
- +
B
-+ A
8765
1234
IC31
NJM2114M
V+
B OUTPUT
B-INPUT
B+INPUT V-
A+INPUT
A-INPUT
A OUTPUT
B
-
-
+
+
A
8765
1234
IC32
NJM2114M
V+
B OUTPUT
B-INPUT
B+INPUT V-
A+INPUT
A-INPUT
A OUTPUT
-+
B
-+
A
4321
5678
IC23
NJM2114M
C242 1000P
Q920
C3198YT
Q919
C3198YT
Q918
A1267Y
R953 10K
C940
1000P
R947
10K
C939
47/50V
R952
33K
R948
15K
R950
15K
R944
22K
R945
22K
R946
22K
R949
15K
R951
15K
R918
180
J501
J601
J505
J502
J503
J602
D178
1SS133M
R939
4.7K
C300
100pF
C301
100pF
C243
470P
C244
470P
J504
J801
J401
C246
220/25V
C245
220/25V
CN33
123
CN55
CN95
J103 J201
12345 CN92
J537
2
J
1
J
+15V
LGND
RGND
+15V
RGND
LGND
LGND
RGND
LGND
RGND
LGND
RGND
+15V
LGND
RGND RGND RGND
LGND LGND LGND
RGND
+15V
RGND
LGND
LGND RGND
LGND
RGND RGND
LGND
LGND LGND
RGND
RGND
LGND
LGND LGND
LGND
RGND
LGND DNGRDNGL
DNG
RDNGLDNGRDNGLDNGL DNGRDNGRDNGLDNGRDNGLDNGR
RGND
RGND
LGND
LGND
LGND
LGND
RGND RGND RGND
RGND RGND
RGND
LGND
LGND
RGND
RGND
LGND
RGND
LGND
RGND
LGND
RGND
LGND
RGND
LGND
+15V
+15V
-15V
-15V
-15V
-15V
-15V
-15V
-15V
A
CLK
DATA
CE
LCH
F_MUTE
DC_DETECT
DC_DETECT
F_MUTE
CLK
DATA
CE
RCH
LCH
SPK1
SPK2
PHONO-L
PHONO-R
PHONO-L PHONO-R
SPK1
SPK2
RCH
U-PRO & TONE PWB U-PRO & TONE PWBMASTER VOLUME PWB
INPUT & AMPLIFIER PWB

11 12
** IMPORTAT SAFETY NOTICE.
COMPONENT IDENTIFIED BY MARK HAVE SPECIAL CHARACTERISICS.
IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS
USE ONLY MANUFACTURER'S SPECIFIED PARTS.
** THE UNIT OF RESISTANCE IS OHM.
K = 1000 OHM. M = 1000KOHM.
** THIS SCHEMATIC DIAGRAM MAY MODIFIED AT ANY TIME WITH THE
** THE UNIT OF CAPACITANCE IS MICROFARAD(uF)
IMPOROVEMENT OF PERFORMANCE.
pF = 10 uF
-6
!
!
!
!
!
!
!
!
22
11
11
7
10
9
8
6
5
4
PWR1
BALANCE
-15V
R IN
L IN
LOUDNESS
SELECTOR
HEAD PHONE
CE2
DATA
CLK
+5.6V
FGND
F_MUTE
AMP_MUTE
PROTECTOR
STAND BY
MUTE
CD-R
MD/TAPE
AUX/DVD
TUNER
CD
PHONO
VR UP
VR DOWN
R-OUT
L-OUT
L-IN
R-IN
20KMNX2
STBY_+ 5.6V
FGND
POWER ON
FGND
REMOTE IN
L-OUT
R-OUT
SPEAK B
SPEAK A
R CH
L CH
L-OUT
R-OUT
SOURCE DIRECT
RC
RIN
LC
LIN
VR DOWN
VR UP
NJM2068M
R CH
L CH
R IN
L IN
DATA
CLK
TX
RX
STBY_+5V
TEST
UPDATE
RESET
RM-IN
P.ON
STAND_BY
KEY0
REMOCON ON/OFF
VDD
TEST
X-IN
X-OUT
GND
MUTE
DC BALANCE DETECT
VSS
SOURCE DIRECT
LOUDNESS
SPEAKER A SPEAKER B
LOUDNESS ON
CLK
DATA
CE1
L IN
R IN
SPEAK A
SPEAK B
LOUDNESS ON
LOUDNESS ON
SOURCE DIRECT
L IN
R IN
CE2
DC BALANCE
L IN
R IN
SHIELD
ET01ET02
STOPPER
ST +5.6V
10K
10K
230V 50Hz : (EUR)
100V 50~60Hz:(JAPAN)
REMOTE IN POWER ON
FGND
ST +5.6V
REMOTE
MAIN -POWER S/W
F901
T 4.0A L 250V : JAPAN/USA
F1N/F1B (JAPAN) ONLY
T 2.5A L 250V : EUR/CHINA
RECEPTACLE
RT01
REMOTE IN
DC8.9V
AC7.6
+5.6V +5.6V
MD/TAPE
BACK UP
BACK.UP
POWER DOWN
BN96
-15V
+15V
RM-IN
INPUT SELECT
MASTER VOLUME
AGND AGND
NC
NC
L IN
R IN
SPEAK A
SPEAK B
LOUDNESS ON
SOURCE DIRECT
R-OUT
L-OUT
ELNA
ELNA
ELNA
ELNA
ELNA
ELNA
12
PWR_RELAY
PWR_RELAY
PWR_RELAY
Nissei
Nissei
AGND
TO CHASSIS
FGND
** THE TYPE OF RESISTOR & CAPACITOR.
(S): MEANS SMD 1608SIZE TYPE.100(S): 100 OHM_ 1608 SIZE
TONE
NC
TREBLE
10KMNX2
BASS
10KMNX2
Nissei
Nissei
Nissei
Nissei
DUMMY
R651 10K(S)
C619
10/50V
D651
D652
R652 10K(S)
D653
R653 10K(S)
D654
R654 10K(S)
D655
R656 10K(S)
D656
R655 10K(S)
D657
HVD342VCTB7T089
R659
220(S)
R658 220(S)
D675
R675 1.5K(S)
Q689
KRC107S
R619
10K(S)
R694
2.7K(S)
R695
1.8K(S)
R696
1.5K(S)
R660 10K
R697
1K(S)
C694
0.01uF(S)
Q691
KRC107S
1234567
BN93
Q631
KRA107S
Q634
KRA107S
C627
0.01uF
C693
0.01uF(S)
X621
16MHz
C625
22P(S)
C626
22P(S)
D621
1SS133MT
C621
0.01uF(S)
R622
100(S)
C622
1000/6.3V
R602 NC
R605
10K(S)
D601
1SS355(S)
R601
0(S)
R636
4.7K(S)
R635
4.7K(S)
R637
4.7K(S)
R608
0(S)
321
Vcc GND VOUT
RC61
CRVRPM6936V4
D613
1SS355(S)
R615
47K(S)
R626
22K(S)
R617
22K(S)
C613
220/16V
C617
100P(S)
R625
10K(S)
R624
22K(S)
R623
22K(S)
R611 100(S)
R607
10K(S)
C611
220/16V
C612
0.01uF(S)
C695
0.1uF(S)
R612
100(S)
C601
0.01uF(S)
Q635
KRA107S
Q636
KRA107S
Q683
KTC3204YT
Q687
KTA1272YT
Q688
KTA1272YT
R683
2.2K
R685
47K
R684
2.2K
R686
47K
Q684
KTC3204YT
R688
2.2K
R687
2.2K
C688
10/50V
C687
10/50V
R681
10
C681
220/16V
D623
1SS355(S)
R442
3.3K C418
0.001(M)
C420
0.1(M)
R444
5.6K
C417
0.001(M)
R441
3.3K
C419
0.1(M)
R443
5.6K
C507
47/25V
R505
4.7
C508
47/25V
R506
4.7
1
2
3
7
8
JK61
R698 47
R699 47
C692
0.01uF
C691
0.01uF
C423
0.01
CB52
7654321 7654321
BN52
SW31
CSR2A034Z
C520
10/35V
C519
10/35V
R521
56K
R522
56K
M
-
+
VR53
CVV9Y13B503Z
R439
330
R440
330
4321
5678
IC53
R502
100K
C504
100P
C502
10/50V
R504
2.7K
4321
5678
4321
5678
IC55
HVINJM2068MDTE1 IC54
HVINJM2068MDTE1
R503
2.7K
C501
10/50V
C503
100P
R501
100K
R507
2.7K
C509
100P
C510
100P
R508
2.7K
C505
22/50V
C506
22/50V
C512
4.7/50V
C514
0.033(M)
R512 1.2K
R514
33K
R513
33K
R511 1.2K
C513
0.033(M)
C511
4.7/50V
R518
33K
R516 1.2K
C516
0.015(M)
C518
220P
C517
220P
C515
0.015(M)
R515 1.2K
R517
33K
R509
100K
R510
100K
R520
220
R519
220
JW52-2
JW52-1
C901
470P
R627
120(S)
R628
1M(S)
C633
1/50V
Q692
KRC107S
D622
1SS355(S)
C631
0.1uF(S)
C623
10/50V
C630
0.01uF(S)
123456789101112131415
302928272625242322212019181716
IC61
CVITMP86FH12MG
=> CVIANAM1467A
R648
10K(S)
Q690
KRC107S
JW61
123456
BN51
C421
10/50V
D405
1SS133 Q413
C102M
R400
100
S104
S101 S102 S103
56
43
8
1
7
2
RY51
CSL4A016ZU
D502
1SS355(S)
R528
10K(S)
R527
10K(S)
Q502
KTA1267Y
R525
33K(S)
R526
10K(S)
D501
1SS355(S)
R524
100(S)
R523
33K(S)
C521
0.01uF(S)
12345678
161514131211109
910111213141516 IC62
HVITC74HC4094FN
R629
100(S)
R630
10K(S)
Q637
KRA107S
Q638
KRA107S
Q639
KRA107S
Q640
KRA107S
D641
CVD30BSBBCAA R641 2.7K(S)
D642
CVD30BSBBCAA R642 2.7K(S)
D643
CVD30BSBBCAA R643 2.7K(S)
D644
CVD30BSBBCAA R644 2.7K(S)
R401 56K
C401
10/35V
R403
330
R405
100
R406
100
R404
330
C402
10/35V
R402 56K
C404
100pF
C403
100pF
1234 1234
8765
IC41
NJM2114M
Q404
A1268GR
Q402
C3200GR
R410
22
R408
22
Q408
C3200GR
Q406
A1268GR
D404
1SS133
R418
470
R414
12K
C413
47/25V
R431
100
R422
22
R420
22
D402
1SS133
R416
470
R412
12K
R426
330
Q412
A1268GR
Q410
C3200GR
R424
330
8765
IC42
NJM2068M
C414
47/25V
R432
100
R430
33K
Q403
A1268GR
Q401
C3200GR
R409
22
R407
22
Q407
C3200GR
Q405
A1268GR
D403
1SS133
R417
470
R413
12K
R421
22
R419
22
D401
1SS133
R415
470
R411
12K
R425
330
Q411
A1268GR
Q409
C3200GR
R423
330
R434
220
R436
270
R428
1M
C406
470P
R429
33K
R433
220
R435
270
R427 1M
C405
470P
R438
4.7
C415
220/25V
C416
220/25V
R437
4.7
R446
0
R447
0
R448
220
R459
220
R450
100K
R451
100K
C407
22/50V
C408
22/50V
Q613
KRA102S
Q614
KRA102S
C656
0.01uF(S)
C655
0.01uF(S)
C654
0.01uF(S)
C653
0.01uF(S)
C652
0.01uF(S)
C651
0.01uF(S)
C629
0.01uF(S)
D102
SIR34ST3F
321
Vcc
GND
ROUT
IC12
RPM6936
C127
0.1uF
C128
100/10V
R124
100
Q101
A102M
R123
100
1
2
3
JK01
3P-3.5PHI-JACK
D101
1SS133
C930
4700P
C931
1000/25V
C933
NC
D927
1SS133
D931
1N4003
R931
4.7(1/4W)
C934
0.022
C932
220/16V
Q925
KTC3204YT
R932
47K
R930
10K
C936
100P
C925
0.1
R936
47
12
TW91
F901
T 2.5A L 250V
2
4
5
6
7
8
9
TRS1
CLT5I009ZE
D930
1N4003
D933
1N4003
D932
1N4003
3
2
4
1
RY92
CSL1E002ZE
C937
NC
C938
NC
GND4
NC
C935
0.1uF
D929
1SS133
SW91
KSH1A001ZV
1
2
3
OL92
KJJ7A011Z
C620
1000/6.3V
D620
1SS355(S)
J631
NC
C409
100pF
C410
100pF
R610
100(S)
R929
10 D934
1SS133
D602
1SS355(S)
F902
T2.5A L 250V
F903
T2.5A L 250V
D908
1N4003
D907
1N4003
C926
2.2/50V
R927
6.8K
D624
1SS355(S)
C690
0.01uF
C614
470P(S)
C615
470P(S)
C616
470P(S)
C411
220/25V
C412
220/25V
BN96-2 BN96-1
C624
0.01uF(S)
CB56
7654321 7654321
BN56
Q617
KTC3875S
Q501
KTC3875S
1234567CN93
12345 BN12
12345
BN33
1 2 3
BN55
CN98
12
CN96
1
2 3 4 5
JK91
CJJ4N036Z
123456789101112131415
BN95
56
4
3
8
1
7
2
RY41
CSL4A016ZU
Q604
KRC107S
Q605
KRC107S
C911
0.1
1
2
3
VOUT GND
VIN
IC96
NJU7223F50
C634
Dummy
C635
Dummy
C641
0.01uF(S)
C642
0.01uF(S)
C643
0.01uF(S)
1
2
3
4
5
6
VR54
CVV2X10B103Z
1
2
3
4
5
6
VR55
CVV2X10B103Z
1
2
3
4
5
6
VR51
CVV2X11M203Z
+15V
-15V
-15V
+15V
LGND
RGND
RGND
LGND
LGND
RGND
LGND
RGND
RGND
LGND
RGND
RGNDLGND
LGND LGND
LGND
RGND
LGND
LGND
TREBLE TREBLE
BASS VR BASS VR
RGND
LGND
RGNDLGND
RGND
LGND RGND
-15V
LGND
RGND
LGND
RGND RGND
-15V
+15V
-15V -15V
+15V
+15V
CHGND
LGND
RGND
RGND
+15V
F_MUTE
F_MUTE
AMP_MUTE
AMP_MUTE
SPKR_A
SPKR_B
SPKR_A
SPKR_B
FGND
FGND
FGND
FGND
FGND
FGND
FGNDFGND
FGND
FGND FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
FGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
FGND FGND
RGND
LGND
LGND LGND
FGND
FGND
FGND
FGND
ENGND
U-PRO & TONE PWB
POWER SW PWB
MASTER VOLUME PWB
SUB TRANSF. PWB
INPUT & AMPLIFIER PWB
INPUT & AMPLIFIER PWB
INPUT & AMPLIFIER PWB
INPUT & AMPLIFIER PWB
INPUT &
AMPLIFIER PWB
INPUT & AMPLIFIER PWB
TRANS
TRANS
INPUT & AMPLIFIER PWB
FLASHER IN
CE1
PROTECT
EN1
EN2
VR-UP
VR-DN
CD-R
AUX/DVD
TUNER
CD
PHONO
AMUT
FMUTE
RESET
BACK.UP

13 14
7. PARTS LOCATION
INPUT & AMPLIFIER A PWB
INPUT & AMPLIFIER PWB (A side)
鉛フリー半田
半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。
Lead-free Solder
When soldering, use the Lead-free Solder (Sn-Ag-Cu).

15 16
INPUT & AMPLIFIER B PWB
鉛フリー半田
半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。
Lead-free Solder
When soldering, use the Lead-free Solder (Sn-Ag-Cu).
INPUT & AMPLIFIER PWB (B side)

鉛フリー半田
半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。
Lead-free Solder
When soldering, use the Lead-free Solder (Sn-Ag-Cu).
17 18
U-PRO & TONE A PWB
U-PRO & TONE B PWB
U-PRO & TONE PWB (A side)
U-PRO & TONE PWB (B side)

19 20
SUB TRANSF. A PWB
POWER SW A PWB
HEADPHONE PWB (A side)
POWER SW PWB (A side)
HEADPHONE A PWB
MASTER VOLUME PWB (A side)
SUB TRANSF. PWB (A side)
MASTER VOLUME PWB (A side)
MASTER VOLUME B PWB
MASTER VOLUME A PWB
鉛フリー半田
半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。
Lead-free Solder
When soldering, use the Lead-free Solder (Sn-Ag-Cu).

21 22
8. EXPLODED VIEW AND PARTS LIST
POWER S/W PWB
RECEPTACLE, AC
PHONE
JACK PWB
U-PRO & TONE PWB
MASTER VOLUME PWB
SUB TRANSF. PWB
INPUT & AMPLIFIER PWB

23 24
POS.
NO.
VERS.
COLOR
PART NO.
(FOR EUR)
PART NO.
(MZ) PART NAME DESCRIPTION
1 421410006004M 421410006004M BADGE MARANTZ BADGE (AL) M1 MODEL CGB1A206
2 943416003900M 943416003900M WINDOW FUNCTION WINDOW CGU1A425A12
3 N1B 943412003910M 943412003910M KNOB BALANCE KNOB BL CBN1A224B37
3 K1SG nsp 943412003920M KNOB BALANCE KNOB SG CBN1A224RMD10
3 N1SG 943412003920M 943412003920M KNOB BALANCE KNOB SG CBN1A224RMD10
4 K1SG nsp 943422005690M PANEL, AL FRONT PANEL , AL FRONT CKM1A204WC62
4 N1SG 943422005690M 943422005690M PANEL, AL FRONT PANEL, AL FRONT CKM1A204WC62
4 N1B 943422005680M 943422005680M PANEL, AL FRONT PANEL , AL FRONT CKM1A204XC23
5 N1B 943402003950M 943402003950M CHASSIS PANEL SUB MOLD BL PM5003 CGW1A465
5 K1SG nsp 943402003960M CHASSIS PANEL SUB MOLD SG PM5003 CGW1A465RMD10
5 N1SG 943402003960M 943402003960M CHASSIS PANEL SUB MOLD SG PM5003 CGW1A465RMD10
6 N1B 943422005660M 943422005660M PANEL PANEL, SIDE L CGW3A467RNZB37
6 K1SG nsp 943422005670M PANEL PANEL, SIDE L CGW3A467ROYD10
6 N1SG 943422005670M 943422005670M PANEL PANEL, SIDE L CGW3A467ROYD10
7 N1B 943422003990M 943422003990M ESCUTCHEON ESCUTCHEON R BL CGW1A466RNZB37
7 K1SG nsp 943422004000M ESCUTCHEON ESCUTCHEON R SG CGW1A466ROYD10
7 N1SG 943422004000M 943422004000M ESCUTCHEON ESCUTCHEON R SG CGW1A466ROYD10
8 N1B 943412002830M 943412002830M ESCUTCHEON INPUT RING BL CGR1A456B37
8 K1SG nsp 943412002840M ESCUTCHEON INPUT RING SG CGR1A456RMD10
8 N1SG 943412002840M 943412002840M ESCUTCHEON INPUT RING SG CGR1A456RMD10
9 K1SG nsp 943412002820M KNOB INPUT KNOB SG CGK1A138YA
9 N1SG 943412002820M 943412002820M KNOB INPUT KNOB SG CGK1A138YA
9 N1B 943412002810M 943412002810M KNOB INPUT KNOB BL CGK1A138ZA
10 K1SG nsp 943412004020M KNOB VOLUME KNOB ASSY SG PM5003 CGK1A137YA
10 N1SG 943412004020M 943412004020M KNOB VOLUME KNOB ASSY SG PM5003 CGK1A137YA
10 N1B 943412004010M 943412004010M KNOB VOLUME KNOB ASSY BL PM5003 CGK1A137ZA
11 K1SG nsp 481510004047M WINDOW IR LENS CGU1A424
11 N1SG 481510004047M 481510004047M WINDOW IR LENS CGU1A424
11 N1B 481510004009M 481510004009M WINDOW IR LENS CGU1A424A12
12 481510003006M 481510003006M LENS LENS POWER INDICATOR CGL1A274
13 N1B 411510016027M 411510016027M BUTTON BUTTON POWER PUSH BL CBC1A166
13 K1SG nsp 943411001970M BUTTON BUTTON POWER SW SG CBC1A166RMD10
13 N1SG 943411001970M 943411001970M BUTTON BUTTON POWER SW SG CBC1A166RMD10
16 nsp nsp LENS INDICATOR FUNCTION CGL1A276
17 K1SG nsp 943412004060M BUTTON SPEAKER BUTTON SG CBT1A1085YA
17 N1SG 943412004060M 943412004060M BUTTON SPEAKER BUTTON SG CBT1A1085YA
17 N1B 943412004050M 943412004050M BUTTON SPEAKER BUTTON BL CBT1A1085ZA
20 nsp nsp FRAME FRAME, FRONT CUF2A004
21 nsp nsp CHASSIS CHASSIS BOTTOM CUA1A288
23 00M243W057210 00M243W057210 LEG LEG FOR SILVER CKL2A042H46
24 00M32CW107010 00M32CW107010 SHEET CUSHION FOOT CHG1A360
25 nsp nsp HOLDER HOLDER PWB CHE170
27 nsp nsp SUPPORT LOCKER SH08M790BO CRE1A037
28 943101005700M 943101005700M TRANS TRANS, POWER (TROIDAL) CLT5Z021ZE
29 nsp nsp HOLDER HOLDER PWB CHE1A030
31 nsp nsp COVER COVER SCREW CMD1A495
32 K1SG nsp nsp PANEL, REAR PANEL, REAR CKF2A391V
32 N1B nsp nsp PANEL, REAR PANEL, REAR CKF2A391W
32 N1SG nsp nsp PANEL, REAR PANEL, REAR CKF2A391W
33 nsp nsp TERMINAL GND TERMINAL KMA1A006
34 00MYJ04002640 00MYJ04002640 INLET ! R-301(21) AC INLET CJJ8A006ZW
36 nsp nsp WASHER WASHER GROUND CNW1A035
37 nsp nsp BUFFER RUBBER CHG1A113
POS.
NO.
VERS.
COLOR
PART NO.
(FOR EUR)
PART NO.
(MZ) PART NAME DESCRIPTION
38 nsp nsp CUSHION CUSHION, IR CHG1A448
39 N1B nsp nsp STOPPER STOPPER SHEET CGX1A436Z
K1SG nsp nsp STOPPER STOPPER SHEET CMH1A306Y
N1SG nsp nsp STOPPER STOPPER SHEET CMH1A306Y
40 N1B nsp nsp SHEET SHEET TOP CGX1A436Z
K1SG nsp nsp SHEET SHEET TOP CGX1A436Y
N1SG nsp nsp SHEET SHEET TOP CGX1A436Y
S1 nsp nsp SCREW SCREW CTB3+8JR
S2 nsp nsp SCREW COPPER PLATING CTB3+8JFB
S3 N1B nsp nsp SCREW SCREW CTW3+8JFZR
S3 K1SG nsp nsp SCREW SCREW CTW3+8JFC
S3 N1SG nsp nsp SCREW SCREW CTW3+8JFC
S4 nsp nsp SCREW SCREW CTW3+12JR
S5 nsp nsp SCREW CTW3+18JR CTW3+18JR
S6 nsp nsp SCREW SCREW CHD1A023R
nsp nsp LABEL LABEL, HOT CQB1A906Z
nsp nsp LABEL LABEL CQB1A908Z
nsp nsp CORD 2P WIRE ASSY 100MM CWZPM5003TW91
nsp nsp BUFFER H=9.5(15X20) CHG1A104
nsp nsp CLAMPER CLAMPER CHR301
nsp nsp PCB PM6003/N FRONT PCB ASS'Y COP12183N
nsp nsp PCB PM6003/N MAIN PCB ASS'Y COP12184N
nsp nsp CORD 2P WIRE ASSY 100MM CWZPM5003TW91A
90M-FS001540R 90M-FS001540R FUSE ! T 2.5A L 250V KBA2C2500TLEY
PACKING
307010030006M 307010030006M UNIT KIT REMOTE CONTROLLER RC003PM CARTPM5003
N1B 90M-ZC000320R 90M-ZC000320R MAINS CORD ! MAINS CORD 2WIRE 10A/250V CJA2B054Z
N1SG 90M-ZC000320R 90M-ZC000320R MAINS CORD ! MAINS CORD 2WIRE 10A/250V CJA2B054Z
K1SG nsp 90M-ZC000650R MAINS CORD ! MAINS CORD FOR K CJA2N075Z
K1SG nsp 943541005620M USER GUIDE USER GUIDE PM6003K1SG CQX1A1435Y
N1B 943541005630M 943541005630M USER GUIDE USER GUIDE PM6003N CQX1A1435Z
N1SG 943541005630M 943541005630M USER GUIDE USER GUIDE PM6003N CQX1A1435Z
NOT STANDARD SPARE PART
943531005650M 943531005650M CARTON BOX, OUT CARTON CPG1A892Z
943533002870M 943533002870M CUSHION PAD SNOW SR5023 CPS1A828
35 K1SG nsp 943401002860M LID TOP COVER SG CKC1A187D11
35 N1SG 943401002860M 943401002860M LID TOP COVER SG CKC1A187D11
35 N1B 943401002850M 943401002850M LID TOP COVER BL CKC1A187K117
nsp nsp BUFFER CUSHION SUPPORT CHG1A305
NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, D&M WILL NOT SUPPLY THESE PARTS.
NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, D&M WILL NOT SUPPLY THESE PARTS.

25
9. MICROPROCESSOR AND IC DATA
IC61 : TMP86FH12MG
PIN No NAME I/O ACTIVE DESCRIPTION
1 VSS - Digital GND Votage
2 XIN I Oscillator Input Port
3 XOUT O Oscillator Output Port
4 TEST I H Fixed to high
5 VDD - Power Supply Port (+5V)
6 P_AMUTE O L POWER AUDIO MUTE Control Port ("L")
7 P_FMUTE O L POWER FUNCTION MUTE Control Port ("L")
8 RESET I L Reset Input Port ("L")
9 BACK UP I L BACK_UP Mode Control Port ("L")
10 MD/TAPE_LED O H MD/TAPE_LED Control Port("H")
11 CD_R_LED O L CD_R_LED Control Port
12 AUX/DVD_LED O L AUX/DVD_LED Control Port
13 TUNER_LED O L TUNER_LED Control Port
14 CD_LED O L CD_LED Control Port
15 PHONO_LED O L PHONO_LED Control Port
16 CE 2 O L Chip Enable Function Switch
17 REMOTE(EXT) I L REMOTE Input Port
18 REMOTE(EXT) I L REMOTE Input Port
19 VR_UP O L VR_UP Control Port
20 VR_DOWN O L VR_DOWN Control Port
21 POWER_ON O H Unit Power On Control Port ("H")
22 PROTECT IN I L PROTECT Input Port("L")
23 KEY 0 I L KEY 0
24 STANDBY_LED O H STANDBY_LED Control Port ("H")
25 REMOCON ON/OFF O L REMOCON ENABLE
26 EN1(SCROLL_DN) I L Scroll Down Control Port
27 EN2(SCROLL_UP) I L Scroll Up Control Port
28 CE1 I H Chip Enable"1" Control Port
29 DATA I L Data Input Port
30 CLK O L Clock Output Port

26
IC21 : LC78212
Electrical Characteristics at Ta = 25°C, VSS = 0 V
Equivalent Circuit Block Diagrams
No. 4817-3/6
LC78211, 78212, 78213
Parameter Symbol Conditions min typ max Unit
I = 1 mA, VDD – VEE = 12 V:
RON1 L1 to L8, R1 to R8, LCOM1 to LCOM4, 150 Ω
Analog switch on resistance RCOM1 to RCOM4
I = 1 mA, VDD – VEE = 37 V:
RON2 L1 to L8, R1 to R8, LCOM1 to LCOM4, 70 Ω
RCOM1 to RCOM4
VIN = 1 Vrms, f = 1 kHz, VDD – VEE = 37 V:
THD1 L1 to L8, R1 to R8, LCOM1 to LCOM4, 0.0015 0.01 %
Total harmonic distortion RCOM1 to RCOM4
VIN = 0.1 Vrms, f = 1 kHz, VDD – VEE = 37 V:
THD2 L1 to L8, R1 to R8, LCOM1 to LCOM4, 0.01 0.05 %
RCOM1 to RCOM4
VIN = 0 dBV, f = 10 kHz, VDD – VEE = 37 V:
Feedthrough FTH L1 to L8, R1 to R8, LCOM1 to LCOM4, 55 dB
RCOM1 to RCOM4
VIN = 0 dBV, f = 10 kHz, VDD – VEE = 37 V:
Crosstalk CT L1 to L8, R1 to R8, LCOM1 to LCOM4, 75 dB
RCOM1 to RCOM4
Input high level current IIH VI= 18.5 V: DI, CL, CE, S, RES +10 µA
Input low level current IIL VI= 0 V: DI, CL, CE, S, RES –10 µA
Analog switch leakage current VI= VEE to VEE + 37 V:
(off state) IOFF L1 to L8, R1 to R8, LCOM1 to LCOM4, –10 +10 µA
RCOM1 to RCOM4
Current drain IDD VDD 1.0 mA
Continued on next page.
IC62 : TC74HC4094AFN

27
IC23, 31, 32, 41 : NJM2114M
PIN CONFIGURATION
1. A OUTPUT
2. A - INPUT
3. A + INPUT
4. V-
5. B + INPUT
6. B - INPUT
7. B OUTPUT
8. V+
NJM2114M
IC11, 21, 42, 53-55 : NJM2068M
PIN CONFIGURATION
1. A OUTPUT
2. A - INPUT
3. A + INPUT
4. V-
5. B + INPUT
6. B - INPUT
7. B OUTPUT
8. V+
NJM2068M

The suppliers and their type numbers of fusible resistors
are as follows;
1. KOA Corporation
Part No. (MJI) Type No. (KOA) Description
00MNH05 ×××140 RF25S × ×××ΩJ (±5% 1/4W)
00MNH05 ×××120 RF50S × ×××ΩJ (±5% 1/2W)
00MNH85 ×××110 RF73B2A × ×××ΩJ (±5% 1/10W)
00MNH95 ×××140 RF73B2E × ×××ΩJ (±5% 1/4W)
2. Matsushita Electronic Components Co., Ltd
Part No. (MJI) Type No. (MEC) Description
00MNF05 ×××140 ERD-2FCJ ××× (±5% 1/4W)
00MRF05 ×××140
00MNF02 ×××140 ERD-2FCG ××× (±2% 1/4W)
00MRF02 ×××140
Examples ;
*Resistance value
0.1Ω.... 001 10Ω....100 1kΩ.... 102 100kΩ....104
0.5Ω.... 005 18Ω....180 2.7kΩ.... 272 680kΩ....684
1
Ω.... 010 100Ω....101 10kΩ.... 103 1MΩ....105
6.8Ω.... 068 390Ω....391 22kΩ.... 223 4.7MΩ....475
PARTS INFORMATION
RESISTORS
1) 00MGD05 × × × 140, Carbon lm xed resistor, ±5% 1/4W
2) 00MGD05 × × × 160, Carbon lm xed resistor, ±5% 1/6W
Examples ;
Resistance value
0.1Ω.... 001 10Ω....100 1kΩ.... 102 100kΩ.... 104
0.5Ω.... 005 18Ω....180 2.7kΩ.... 272 680kΩ.... 684
1
Ω.... 010 100Ω....101 10kΩ.... 103 1MΩ.... 105
6.8Ω.... 068 390Ω....391 22kΩ.... 223 4.7MΩ.... 475
Note : Please distinguish 1/4W from 1/6W by the shape of parts
used actually.
CAPACITORS
CERAMIC CAP.
3) 00MDD1 × ×××370, Ceramic capacitor
Disc type
Temp.coeff.P350 ～N1000, 50V
Examples ;
Tolerance (Capacity deviation)
±0.25pF......0
±0.5pF......1
±5%......5
Tolerance of COMMON PARTS handled here are as follows :
0.5pF ～5pF.... ±0.25pF
6pF ～10pF.... ±0.5pF
12pF ～560pF.... ±5%
Capacity value
0.5pF.... 005 3pF .... 030 100pF.... 101
1pF.... 010 10pF .... 100 220pF.... 221
1.5pF.... 015 47pF .... 470 560pF.... 561
CERAMIC CAP.
4) 00MDK16 × × × 300, High dielectric constant ceramic
capacitor
Disc type
Temp.chara. 2B4, 50V
Examples ;
Capacity value
100pF.... 101 1000pF .... 102 10000pF ....103
470pF.... 471 2200pF .... 222
ELECTROLY CAP. ( )
5) 00MEA ××××××10, Electrolytic capacitor
One-way lead type, Tolerance ±20%
Examples ;
Capacity value
0.1µF ....104 4.7µF ....475 100µF ... 107
0.33µF ....334 10µF ....106 330µF ... 337
1µF ....105 22µF ....226 1100µF ... 118
2200µF ... 228
Working voltage
6.3V ....006 25V ....025
10V ....010 35V ....035
16V ....016 50V ....050
FILM CAP. ( )
6) 00MDF15 × × × 350 Plastic lm capacitor
00MDF15 × × × 310 One-way type, Mylar ±5% 50V
00MDF16 × × × 310 Plastic lm capacitor
One-way type, Mylar ±10% 50V
Examples ;
Capacity value
0.001µF (1000pF) ......... 102 0.1µF .... 104
0.0018µF ........................ 182 0.56µF.... 564
0.01µF ........................ 103 1µF .... 105
0.015µF ........................ 153
NOTE ON FUSE :
Regarding to all parts of parts code 00MFS20xxx2xx, replace
only with Wickmann-Werke GmbH, Type 372 non glass type fuse.

}
 
Capacity value
Tolerance

Capacity value
Resistance value
 
Working voltage
Capacity value
▲▲

Capacity value
NOTE ON SAFETY FOR FUSIBLE RESISTOR :
▲ ▲
▲▲
Resistance value Resistance value
(0.1 −10kΩ)
▲ ▲
Resistance value Resistance value
ANT. : ANTENNA BATT. : BATTERY
CAP. : CAPACITOR CER. : CERAMIC
CONN. : CONNECTING DIG. : DIGITAL
HP : HEADPHONE MIC. : MICROPHONE
µ-PRO : MICROPROCESSOR REC. : RECORDING
RES. : RESISTOR SPK : SPEAKER
SW : SWITCH TRANSF. : TRANSFORMER
TRIM. : TRIMMING TRS. : TRAMSISTOR
VAR. : VARIABLE X’TAL : CRYSTAL
NOTE ON SAFETY :
Symbol Fire or electrical shock hazard. Only original parts
should be used to replaced any part marked with symbol .
Any other component substitution (other than original type), may
increase risk of re or electrical shock hazard.
安全上の注意 :
がついている部品は、安全上重要な部品です。必ず指定
されている部品番号の部品を使用して下さい。
ABBREVIATION AND MARKS
}}}
}}
}
}
}
}
060522 MZ
28
10. ELECTRICAL PARTS LIST