Martin Yale StackWagon 500 User manual

Model 500/501 StackWagon
Assembly Inst uctions

A. Start by carefully unpacking all parts and checking with parts list. ( OTE: Diagram represents
Model 500. Model 501 is similar, but 12 inches wider.
B. Invert base assy. (8) and fasten Casters to the support channels on the bottom. Put Locking
Casters (1) in opposite corners. Use 1/4-20 x 1/2 Hex Head Bolts (4) and 1/4 Lock Washers (6)
provided.
C. Turn base assy upright and place Dividers (10) on top with holes aligned as shown. Insert 10-32
x 3/8 Phil Truss (12) from top side and attach Keps uts (5) from bottom (Finger tight only).
D. Place Divider Cap (11) on top of dividers and attach with 10-32 x 1/2 Pan Sems (3) (finger tight
only).
E. Place four Corner Ramps (9) in each section with corners inside base angle. Move dividers
around slightly to fit if necessary. ow tighten screws in divider cap. ( OTE: Model 500 ramps
are identical, Model 501 has two left and two right ramps.)
F. Remove one corner ramp covering screws in divider and tighten screws. Repeat on opposite
corner ramp.
G. Return (2) Corner Ramps back in place and secure all four ramps with 10-32 x 1/2 Pan Sems (3)
and #10 Flat Washers (7).
CAUTION:
When stacking paper on wagon, balance the load between the four corners or in two oppo-
site corners. This will help pre ent wagon from tipping.
PARTS LIST
Model 500
Fig. Pa t No. Desc iption Qty.
1 M-O050008 Caster w/Lock 2
2 M-O050011 Caster wo/Lock 2
3 M-S001023 10-32 x 1/2 Pan Sems 10
4 M-S003004 1/4-20 x 1/2 Hex/H 16
5 M-S007008 10-32 Keps ut 8
6 M-S008029 1/4 Intl. L/Washer 16
7 M-S008005 #10 Flat Washer 8
8 W-O050000 Base Assembly 1
9 W-O050003 Corner Ramp 4
10 W-O050006 Divider 2
11 W-O050026 Divider Cap 1
12 M-S001022 10-32 x 3/8 Phil Truss 8
Model 501
Fig. Pa t No. Desc iption Qty.
1 M-O050008 Caster w/Lock 2
2 M-O050011 Caster wo/Lock 2
3 M-S001023 10-32 x 1/2 Pan Sems 10
4 M-S003004 1/4-20 x 1/2 Hex/H 16
5 M-S007008 10-32 Keps ut 10
6 M-S008029 1/4 Intl. L/Washer 16
7 M-S008005 #10 Flat Washer 8
8 W-O050100 Base Assembly 1
9 W-O050108 Left Corner Ramp 2
9 W-O050109 Right Corner Ramp 2
10 W-O050106 Divider 2
11 W-O050026 Divider Cap 1
12 M-S001022 10-32 x 3/8 Phil Truss 10
251 Wedcor Avenue lWabash, I 46992
Phone: [phone] lFax: 260-563-4575
email: [email protected] lwebsite: www.martinyale.com
M-S027046 Rev. 3 3/14/13