Mi-T-M Aluminum Series User manual

CA Electric Operator's Manual 1
©Copyright 2016 Form #37-1365-E/S/F-030923
CAUTION
RISK OF INJURY!
READ MANUAL BEFORE OPERATING!
This manual is an important part of the pressure washer and
must remain with this unit!
OPERATOR'S MANUAL FOR
PORTABLE/WALL MOUNT/HAND CARRY/ALUMINUM
ELECTRIC DRIVE/DIRECT DRIVE
COLD WATER PRESSURE WASHER
PARTS LIST

2 CA Electric Operator's Manual
WARNING: This product can expose you to
chemicals including Lead, which is known to
the State of California to cause cancer and birth
defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov
WARNING
TABLE OF CONTENTS
INTRODUCTION .............................................................................................................3
! IMPORTANT ! ................................................................................................................3
IMPORTANT SAFETY WARNINGS.................................................................................4
ELECTRICAL PRECAUTIONS: .................................................................................................................4
SPRAY PRECAUTIONS .............................................................................................................................5
MISCELLANEOUS SAFETY PRECAUTIONS ............................................................................................5
MISCELLANEOUS SAFETY PRECAUTIONS, CONT'D.............................................................................6
DETERGENT CLEANING PRECAUTIONS.................................................................................................7
! SAVE THESE INSTRUCTIONS ! ...................................................................................7
FEATURES SMALL CA ELECTRIC ................................................................................8
FEATURES LARGE CA ELECTRIC ................................................................................9
SAFETY DECALS & PLACEMENT ...............................................................................10
INSTALLATION & PREPARATION................................................................................11
ATTIRE: ....................................................................................................................................................11
SETUP: ....................................................................................................................................................11
WALL MOUNT OPTION: SEE PAGE 19. .................................................................................................11
POWER CORD CONNECTION:...............................................................................................................11
NOZZLE REVIEW: ..................................................................................................................................12
NOZZLE CONNECTION: .........................................................................................................................13
WATER SUPPLY:......................................................................................................................................13
UNLOADER: ............................................................................................................................................13
THERMAL RELIEF VALVE:.......................................................................................................................14
PRE-START INSPECTION PROCEDURES:.............................................................................................14
OPERATING INSTRUCTIONS ......................................................................................15
PRIMING THE PUMP:..............................................................................................................................15
START-UP: ...............................................................................................................................................15
CLEANING WITH DETERGENTS:............................................................................................................16
SHUTDOWN: ...........................................................................................................................................16
STORAGE & MAINTENANCE.......................................................................................17
SPECIFIC MAINTENANCE: .....................................................................................................................17
WINTERIZING:.........................................................................................................................................17
STARTING UNIT AFTER EXTENDED STORAGE: ....................................................................................18
WALL MOUNT OPTIONS..............................................................................................19
TROUBLESHOOTING...................................................................................................20
STATEMENT OF WARRANTY ......................................................................................22

CA Electric Operator's Manual 3
INTRODUCTION
Congratulations on the purchase of your pressure washer! You can be assured your pressure washer was construct-
ed and designed with quality and performance in mind. Each component has been rigorously tested to ensure the
highest level of acceptance.
This operator's manual was compiled for your benet. By reading and following the simple safety, installation, oper-
ation, maintenance and troubleshooting steps described in this manual, you will receive years of trouble free opera-
tion from your pressure washer. The contents of this manual are based on the latest product information available at
the time of publication. The manufacturer reserves the right to make changes in price, color, materials, equipment,
specications or models at any time without notice.
! IMPORTANT !
These paragraphs are surrounded by a "SAFETY ALERT BOX". This box is used to designate and empha-
size Safety Warnings that must be followed when operating this pressure washer.
Accompanying the Safety Warnings are "signal words" which designate the degree or level of hazard seri-
ousness. The "signal words" used in this manual are as follows:
DANGER: Indicates an imminently hazardous situation which, if not avoided, WILL result in death or serious
injury.
WARNING:Indicates a potentially hazardous situation which, if not avoided, COULD result in death or serious
injury.
CAUTION: Indicates a potentially hazardous situation which, if not avoided MAY result in minor or moderate
injury.
The symbols set to the left of this paragraph are "Safety Alert Symbols". These symbols are used to call
attention to items or procedures that could be dangerous to you or other persons using this equipment.
ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ ALL IN-
STRUCTIONS BEFORE OPERATING THIS PRESSURE WASHER AND ESPECIALLY POINT OUT THE
"SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE OPERATOR.
Once the unit has been removed from the box, immediately write in the serial number of your unit in the space pro-
vided below.
SERIAL NUMBER_________________________________
Inspect for signs of obvious or concealed freight damage. If damage does exist, le a claim with the transportation
company immediately. Be sure that all damaged parts are replaced and that the mechanical problems are corrected
prior to operation of the unit. If you require service, contact Customer Service at 800-553-9053.
Please have the following information available for all service calls:
1. Model Number
2. Serial Number
3. Date and Place of Purchase

4 CA Electric Operator's Manual
ELECTRICAL PRECAUTIONS:
RISK OF ELECTRIC SHOCK OR ELECTROCUTION:
WARNING: SERIOUS INJURY OR DEATH COULD OCCUR IF THE
PRESSURE WASHER IS NOT PROPERLY GROUNDED. YOUR
PRESSURE WASHER IS POWERED BY ELECTRICITY AND
MAY CAUSE ELECTRIC SHOCK OR ELECTROCUTION IF NOT
USED PROPERLY.
1. This product must be grounded. Make sure the pressure washer is
equipped with a GFCI built into the power supply cord. If this is not
available, the pressure washer must be plugged into a receptacle that is
protected by a GFCI. Disconnect when not in use.
2. If your unit is equipped with a GFCI, DO NOT drop the GFCI as damage
could result. If the GFCI is accidentally dropped, be certain to test the
GFCI before using to ensure it is working properly. (Follow instructions
on GFCI for test procedures.)
3. Always be certain the unit is receiving proper voltage. Disconnect when
not in use.
4. DO NOT modify the plug provided with the product. If it will not t the
outlet, have a proper outlet installed by a qualied electrician. DO NOT
use any type of adapter.
WARNING: ELECTRICAL SHOCK MAY OCCUR FROM
ELECTRICAL CORD.
5. Check power cord for signs of crushing, cutting or heat damage. If
replacement of plug or cord is needed use only identical replacement
parts
6. DO NOT use extension cords with this pressure washer.
7. Keep all connections dry and off the ground. Do not allow electrical cords
to lay in water or in such a position where water could come in contact
with them. Do not touch plug with wet hands.
8. DO NOT pull on the electrical cord to disconnect from the outlet.
WARNING: ELECTRICAL SHOCK MAY OCCUR IF PRESSURE
WASHER IS NOT OPERATED PROPERLY.
9. DO NOT direct spray on or into electrical installations of any kind! This
includes electrical outlets, light bulbs, fuse boxes, transformers, the unit
itself, etc.
10. DO NOT allow metal components of the pressure washer to come in
contact with live electrical components.
11. Never operate the pressure washer with safety guards/covers removed
or damaged.
WARNING: SERIOUS INJURY OR DEATH MAY OCCUR IF
UNQUALIFIED PERSONS ATTEMPT ELECTRICAL REPAIRS.
12. Any electrical wiring or repairs performed on this pressure washer should
be done by Authorized Service Personnel in accordance with National
and Local electrical codes.
13. Before opening any electrical enclosure, always shut off the pressure
washer, relieve pressure and unplug the pressure washer from the power
source. Allow the pressure washer to cool down. Never assume the
pressure washer is safe to work on just because it is not operating. It
could restart at any time! Service in a clean, dry, at area.
IMPORTANT SAFETY WARNINGS

CA Electric Operator's Manual 5
SPRAY PRECAUTIONS
RISK OF INJECTION OR SEVERE CUTTING INJURY:
DANGER: KEEP CLEAR OF NOZZLE. DO NOT DIRECT
DISCHARGE STREAM AT PERSONS OR PETS. WHEN USING
THIS PRODUCT, BASIC PRECAUTIONS SHOULD ALWAYS BE
OBSERVED, INCLUDING THE FOLLOWING:
1. Keep clear of the nozzle and spray! Never put your hand, ngers or
body directly over the spray nozzle.
2. Never point the high pressure spray at yourself or anyone else.
3. This product is to be used only by trained operators.
4. Always keep operating area clear of all persons.
5. Never allow children or adolescents to operate this unit.
6. SEEK EMERGENCY MEDICAL CARE if the spray appears to have
penetrated the skin! DO NOT TREAT AS A SIMPLE CUT!
7. High pressure hoses should be inspected daily for signs of wear. If
evidence of failure exist, promptly replace all suspect hoses to prevent
the possibility of injury from the high pressure spray. If a hose or tting
is leaking, NEVER PLACE YOUR HAND DIRECTLY ON THE LEAK.
8. NEVER operate the gun with the trigger wired in the open position. To
prevent accidental discharge, the trigger gun should be securely locked
when not in use.
9. Do not move the unit by pulling on the hose
10. Before removing the spray nozzle or servicing the unit, ALWAYS shut
off the unit and trigger the gun to release trapped pressure. (Even after
you shut off the unit, there is high pressure water left in the pump, hose
and gun until you release it by triggering the gun.)
11. Do not leave pressurized unit unattended. Shut off the pressure washer
and relieve trapped pressure before leaving.
MISCELLANEOUS SAFETY PRECAUTIONS
RISK OF EXPLOSION OR FIRE:
WARNING: SERIOUS INJURY OR DEATH MAY OCCUR FROM
NORMAL SPARKS IN THE MOTOR AND ELECTRICAL
SYSTEM.
1. DO NOT operate unit in an area where ammable gas vapors may be
present. An electric spark may cause an explosion or re.
2. DO NOT spray ammable liquids. Do not spray in an area containing
combustible dust, liquids or vapors.
RISK OF ASPHYXIATION:
WARNING: SERIOUS INJURY OR DEATH MAY OCCUR FROM
INHALING DANGEROUS VAPORS.
1. Followallsafetyinstructionsprovided with the materials you arespraying.
Use of a respirator may be required when working with some materials.
Do not use this pressure washer to dispense hazardous detergents.
IMPORTANT SAFETY WARNINGS

6 CA Electric Operator's Manual
MISCELLANEOUS SAFETY PRECAUTIONS, CONT'D.
RISK OF BURSTING:
WARNING: SERIOUS INJURY MAY OCCUR FROM A PRESSURE
WASHER MALFUNCTION OR EXPLODING ACCESSORIES IF
INCORRECT SYSTEM COMPONENTS, ATTACHMENTS OR
ACCESSORIES ARE USED.
1. Never make adjustments to the factory set pressures.
2. Never exceed manufacturers maximum allowable pressure rating of
attachments.
3. Use only manufacturer recommended repair parts for your pressure washer.
WARNING: SERIOUS INJURY OR DEATH MAY OCCUR IF
ATTEMPTING TO START THE PRESSURE WASHER WHEN THE
PUMP IS FROZEN.
4. In freezing temperatures, the unit must always be warm enough to ensure
there is no ice formation in the pump. Do not start the pressure washer
if it has been transported in an open or underheated vehicle without rst
allowing the pump to thaw.
RISK FROM MOVING PARTS:
WARNING: SERIOUS INJURY MAY OCCUR TO THE OPERATOR
FROM MOVING PARTS ON THE PRESSURE WASHER.
1. Never make adjustments to the unit while it is connected to the power
source.
2. Do not operate the unit without all protective covers in place.
3. Before servicing the pressure washer, turn the unit off, disconnect from the
power source, relieve the water pressure and allow the unit to cool down.
Service in a clean, dry, at area.
4. Follow the maintenance instructions specied in the manual.
RISK OF BODILY INJURY:
WARNING: SERIOUS INJURY CAN OCCUR FROM LOOSE DEBRIS
BEING PROPELLED AT HIGH SPEED FROM THE SPRAY GUN.
1. Always wear protective goggles when operating the unit to shield the eyes
from ying debris and detergents.
2. Do not direct spray toward fragile materials such as glass. Shattering could
result in serious injury.
WARNING: INJURY MAY OCCUR IF THE OPERATOR LOSES
BALANCE CAUSED BY THE THRUST OF WATER TRAVELING
THROUGH THE SPRAY NOZZLE.
1. Stay alert-watch what you are doing. Do not operate the unit when fatigued
or under the inuence of alcohol or drugs.
2. Never squeeze the trigger unless securely braced. DO NOT overreach or
stand on unstable support. Wet surfaces can be slippery, wear protective
foot gear and keep good footing and balance at all times. Never trigger
the gun while on a ladder or roof.
WARNING: INJURY MAY OCCUR FROM THE PRESSURE WASHER.
1. Always hold on rmly to the gun/lance assembly when starting and operating
the unit. Failure to do so can cause the lance to fall and whip dangerously.
2. Know how to stop the pressure washer and bleed pressures quickly. Be
thoroughly familiar with controls.
IMPORTANT SAFETY WARNINGS

CA Electric Operator's Manual 7
DETERGENT CLEANING PRECAUTIONS
RISK OF BODILY INJURY:
WARNING: SERIOUS INJURY OR DEATH MAY OCCUR FROM
DETERGENTS CONTACTING THE SKIN.
1. DO NOT use solvents, highly corrosive detergents or acid type cleaners
with this pressure washer. Use only mild detergents.
2. KNOW YOUR DETERGENTS! Be prepared to tell a physician exactly
what you are using in the event of an emergency. Read the Material
SafetyDataSheet(MSDS)providedwith your detergentandalldetergent
labels. Follow all appropriate instructions regarding preparation, use,
safety and transportation.
3. Protective equipment such as rubber suits, gloves and respirators are
advisable, especially when using cleaning detergents.
4. Keep all detergents out of the reach of children.
IMPORTANT SAFETY WARNINGS
! SAVE THESE INSTRUCTIONS !

8 CA Electric Operator's Manual
FEATURES SMALL CA ELECTRIC
DC-1502-A1E1G-W FEATURES 122122SMS
1. Quick Connect Nozzle
2. Gun Assembly
3. Detergent Hose
4. High Pressure Discharge Hose
5. Detergent Strainer
6. ON/OFF Switch
7. Motor
8. Pump
9. Water Outlet
10. Water Inlet
11. Adjustable Unloader Knob
12. GFCI
13. Power Cord
8
910 11
76
12 13
8
10911
6
7
12 13
3
5
2
4
1
910 11
8 67
12 13
WALL MOUNT OPTION

CA Electric Operator's Manual 9
FEATURES LARGE CA ELECTRIC
DC-2503_3004-A1E2G FEATURES 040222
1 Pump
2 Motor
3 Motor Overload
4 Water Inlet
5 Water Outlet
6 Adjustable Unloader Knob
7 On/Off Switch
8 Power Cord
9 GFCI
10 Detergent Strainer
11 Detergent Hose
12 High Pressure Discharge Hose
13 Gun Assembly
14 Quick Connect Nozzle
WALL MOUNT OPTION
1 2 3
4 5 6
78 9
10 1112
13 14
97
321
5
4 6
8
12 7
54 6
8

10 CA Electric Operator's Manual
SAFETY DECALS & PLACEMENT
DO NOT REMOVE SAFETY DECALS FROM UNIT UNLESS REPLACING WITH MOST CURRENT SAFETY DECAL!!
Decal: Warning-Risk of Electrocution
(Part #34-1471, 34-3398, or 34-3990)
RISK OF ELECTROCUTION.
DO NOT REMOVE THIS TAG.
FAILURE TO FOLLOW THE ABOVE
INSTRUCTIONS COULD RESULT 
IN A SEVERE ELECTRICAL SHOCK.
34-1035-E/F/S-111899-ENG

1. Connect only to a properly grounded outlet. Do not
remove ground pin.
2. Inspect cord before using.Do not use if cord is
damaged.
3. Keep all connections dry and off the ground. 
4. Do not touch plug with wet hands.
5.This unit may be provided with a Ground Fault Circuit
Interrupter (GFCI) built into the power cord plug. If
replacement of the plug or cord is needed, use only
identical replacement parts. If this unit is not provided
with a GFCI, this unit should only be connected to a
power supply receptacle protected by a ground fault
circuit interrupter.
6. Do not use an extension cord with this machine.
7. Read the operator's manual before using.

WARNING
RISK OF INJECTION OR SEVERE INJURY
Never put your hand, fingers or body directly
over the spray nozzle. 34-1253/07272012
RIESGO DE INYECCIÓN O LESIÓN SEVERA
Nunca coloque la mano, los dedos o el cuerpo
directamente sobre la boquilla de rocío.
WARNING ADVERTENCIA
CAUTION / PRECAUCION
34-1473/081712
1. Read operator's manual
carefully before using.
2. Spray gun can kick back. Hold
with both hands.
3. Risk of eye injury. Always wear
eye protection.
4. See the operator's manual for
proper chemical usage.
1. Lea cuidadosamente el manual
del operador antes de usar.
2. El revolver rociadora puede
retroceder violentemente.
Sujétela con ambas manos.
3. Riesgo de lesiones a los ojos.
Use siempre protección para
los ojos.
4. Para un uso químico apropiado
consulte el Manual del
Operador.
IMPORTANT / IMPORTANTE
• For indoor and outdoor use.
• Store indoors.
• Avoid pump damage. Protect
from freezing. Do not run for
more than 3 minutes with
spray gun not triggered.
• If connected to a circuit
protected by fuses,
use time-delay fuses only.
• Para uso interior y exterior.
• Almacene bajo techo.
• Evite daños a la bomba. Protéjala
contra la congelación.
No haga funcionar por más de 3
minutos sin accionar el gatillo de
la pistola.
• Si se conecta a un circuito
protegido por fusibles, use
fusibles con retardo solamente.
RIESGO DE LESIONESRISK OF INJURY
34-1471/081712
RISK OF ELECTROCUTION. DO NOT REMOVE THIS TAG.
FAILURE TO FOLLOW THE ABOVE INSTRUCTIONS
COULD RESULT IN A SEVERE ELECTRICAL SHOCK.
RIESGO DE ELECTROCUCION. NO RETIRE ESTA CALCOMANIA.
EL NO SEGUIR LAS INSTRUCCIONES DE ARRIBA PUEDE
RESULTAR EN UN CHOQUE ELECTRICO GRAVE.
ADVERTENCIA
WARNING
1.Conecte solamente a una toma corriente que está bien fundado. No
quite la pata de conexión de la tierra.
2. Antes de usar inspeccióne la cuerda. No use si la cuerda està dañando.
3. Mantenga los conexiones secos y apar tados de la tierra.
4.No torque el enchufe con manos mojados.
5.Este producto debe conectarse a tierra. Asegúrese de que la lavadora
a presión esté equipada con un Interruptor de circuito de falla a tierra
(Ground Fault Circuit Interrupter, GFCI) incorporado en el cordón de
alimentación. Si no lo tiene, debe conectarse la lavadora a presión
únicamente en un receptáculo que esté protegido por un Interruptor de
circuito de falla a tierra. Desconéctela cuando no esté en uso.
6.No use una cuerda extensión con la unidad.
7.Antes de usar lea y entienda todas las instrucciónes y el manual de
operación.
1.Connect only to a properly grounded outlet. Do not remove ground pin.
2.Inspect cord before using. Do not use if cord is damaged.
3.Keep all connections dry and off the ground.
4.Do not touch plug with wet hands.
5.This unit may be provided with a Ground Fault Circuit Interrupter (GFCI)
built into the power cord plug. If replacement of the plug or cord is
needed, use only identical replacement parts. If this unit is not provided
with a GFCI, this unit should only be connected to a power supply
receptacle protected by a ground fault circuit interrupter.
6.Do not use an extension cord with this machine.
7.Read the operator's manual before using.
34-1477/080612
WARNING/ADVERTENCIA
If connection is made to
a potable water system,
the system shall be
protected against backflow.
Si la conexión se hace a un
sistema de agua potable, el
sistema será protegido
contra la expulsión.
Hang Tag: Warning-Risk of Electrocution
(Part #34-1035)
Decal: Caution: Risk of Injury (Part #34-1015, 34-1473, or 34-4068)
Decal: Warning-Risk of Injection/Explosion
(Part #34-1017 or 34-4125)
Decal: Warning:
Potable Water (Part #34-1477 or 34-4126)
Decal: Warning-Risk of Injection (Part #34-1253)
WARNING ADVERTENCIA
RISK OF EXPLOSION: Do not
spray flammable liquids.
RISK OF ELECTROCUTION: Do
not spray electrical apparatus
and wiring.
RISK OF INJECTION OR
SEVERE CUTTING INJURY:
Keep clear of nozzle. Do not
direct discharge stream at persons.
RIESGO DE EXPLOSI ÓN : No
rocie liquidos inflamables.
RIESGO DE ELECTROCUCIÓN:
No rocíe el aparato y el cableado
eléctricos.
RIESGO DE INYECCI ÓN O LESIÓN
DE CORTE
: Manténgase alejado de la
boquilla. No dirija la corriente de descarga
hacia las personas.
34-1017/080612