Motorola SYSTEMS SABER SECURENET User manual

whe
4
4
a
&
wh
>a
ae
a
sgt
me
co
whe
4
4
a
&
wh
>a
ae
a
sgt
me
co

Manual&Scan&
!
I hope this service manual is of use to you. Motorola does
not make this available as a PDF and all other available
copies are of poor quality.
Each page is captured at 600 DPI, and as 24-bit color, 8-
bit grayscale or black and white and at the proper page
size, up to 11x34 inches in many cases. OCR has been
preformed on the document, even on the large pages. The
document is condensed into one single PDF with text
overlay. You should be able to print the larger sheets on
11x17 or tile them onto 8.5x11 if needed.
Please do not charge for access to this, or put it on a
pay-wall site. Please don’t pay for access to any such
sites, they are against the ethos of hacking, and it only
encourages them to profit off the hard work of others which
has been shared openly. Please don’t change
this/recompress it; this defeats the point of capturing
this at high resolution.
If something is incorrect here, or unreadable please reach
out; I likely have the original lossless compressed images.
In the final PDF that’s color or grayscale will be JPEG
2000 format with highest quality selected. B&W images will
be compressed using CCITT Group 4. This is quite close to
the source material, but there may be some artifacts due to
lossy compression. If there’s a choice between file size
and image quality, image quality will win. It’s 2021 and
storage and bandwidth is cheap.
This was captured on a Canon DR-G2140 scanner which is ~
7500 USD unit circa 2021. You may note some artifacts and
lines in on the scans, these are due to scratches on the
sensor glass, and are minor. The replacement glass is
about 250 USD if you’re feeling generous :-)
If you have a hard to find/out of print manual and would
like to make it available please reach out, I may be able
to scan and return it to you.
Thank you,
Bryan Fields, W9CR
[email protected]

MANUAL REVISION
MOTOROLA for Service Manual
68P81066C95-0
SYSTEM SABER SECURENET
403-512 MHZ
This revision outlines changes that have occurred since the printing of your manual. Use this information to
supplement your manual. Installation of these changes in earlier equipment is not necessary except as
recommended in Motorola Service and Repair Notes (SRN's).
REVISION CHANGES
1. Remove and discard Main Board Schematic Diagram and Parts List pages 15, and 16 of your manual, and
replace with new Main Board Schematic Diagram and Parts List attached.
©1992 by Motorola., Radio Products Grou
8000 W. Sunrise Bivd., Ft. Lauderdale, FL 33322 FMR1625A-1
Printed in U.S.A. 8/92. All Rights Reserved. 18-3-92
5
RMG
OTOROLA MANUAL REVISION
for Service Manual
68P81066C95-0
SYSTEM SABER SECURENET
403-512 MHZ
This revision outlines changes that have occurred since the printing of your manual. Use this information to
supplement your manual. Installation of these changes in earlier equipment is not necessary except as
recomme nded in Motorola Service and Repair Notes (SRN's)
REVISION CHANGES
Remove and discard Main Board Schematic Diagram and Parts List pages 15, and 16 of your manual, and
replace with new Main Board Schematic Diagram and Parts List attached
Ft.
©Radio Products Grou1992 Motorola
FL FMR1625A-1
Printed in U.S.A. 8/92. All Rights Reserved 8-3-92
1
AMG

.22
c8 aes
FOR MODELS NOT EQUIPPED C5
4. 7UR
C31 op
WITH SECURENET MODULE #| REG 5V 680 64 .22 1500 RXRF
295R3 2ND IF IN JECT 3.3mV TO
7
IST IF INJECT 0.5mV TO U202 POWER AMPLIFIER
re RI tcs Ql OY |.5mV AT 73.35MHz FOR I2db SINAD 213
2U203 FILTER/DETECTOR/Swi TCH
ps
NT
CIO REG
SECURENET =
0.47 .018 RTI =SWITCH t
4
50 500mVAC COUPLER/RF
_ 12
3.5 VDC SO ic 250-500mVRMS L209 TO le DETECTOR 36,
06
||r 4.8 VDC UNSQ 19
wor 4.6 VDC 8l410 16
27
10°C OR 7.4 VDC RX
4¢
L208 2
R4 31
U2 L207 HIGHER, STD ENABLE RMT ENABLE H!
26
LED LOW BLED LOw
¢6805 TAIL CKT "LCONTROLLER 0voe $@ AT HIGH SIDE 73.8MHz 4POLE FILTER MIXER/ ]
2.5 VOC 104.5 WDC
C513 C516 C509 ¢RS CIS 925 e
4.7uF 018
== = joo 350°T 360nk 72 y
00 100 100 c525* ok 01 scas
==Rai0 cesices2ce53. ===VOC TX
=00.
0.1 VARIES g
tofis fig 9
BETWEEN 204
KEY/FAIL 6DECRYPTED RSS|
5OnH Ta LOW PWR >ZSR209 QQ208 'a
csl4 We 3AUDI
=
AND 7VDC Gi Nc ay
PTI 20 14SWe r= c508 =
R7
RX 5V Cals w2k 12k $
c5IT 10 C512 Tioo C20 cig} 49.94 cl? 6&4700 21100 7UNLESS OTHERWISE STATED:
issm] Tico +Live 8
RESISTANCES ARE IN OHMS (k=1000),
bata Tino 30.22 =It STANDARD ENABLE LOW
CAPACITANCES
5OR
GREATER
REYLOAD 58RESET 39 Ls. 438 25 627/29 100b¢3g 5VOC RX
Q2
20
REMOTE ENABLE ARE IN PICOFARADS (pF).
0FILTER 2\00 ©VDC TX +
look
nMUX AINTERFACE RIG
42RF DET NOTES:
ci4 130k
L3
C521 >y
VCO MOD U301 NT
1) TRANSMITTER VOLTAGES
=Ik
100 =
oo 5RK TTK
Zo REF MOD =\6.8MHz REMOTE ANTENNA
£506 1oy RF 3SwITCH 36 2MHz
Ne T
aaah
ANT iSELECTED,UNLESS
=0MIC AUDIO. 10k NC Tx [RX 37 wo Sg NC (4) T2 5
23 TX/RX 10 ca2z OTHERWISE STATED
>
=lOu 100 +
C5OI
RESET ia 2) ALL RF AC MEASUREMENTS
=x
47k 28
10k
Hi PWR 4.6 VDC 7Reale
C505 a13 34
25 .2k
£
Tio
023
40 ca
RX
s0507 4
73300 3] (LOW 7AUX RX IN U300 RX/TX 2l
14 AUX TXIN
aae pe 9AUTOMATIC 10k
0. 4
/NCO
AA A637 5VDC PULSED Low aad 14
LEVEL
0. WHEN ACTIVE
0.22 CONTROL 020
0.6 vac
_
38 41 fis 32 31 33 PL SAMPLE/CLK
Ree =R22
No Ne NG
5Rx svoc 31} 32/27 [22 47k =
MOD QUT
>
R/T TX OVDE =R219
DATA
20k
JUIOO xCLOCK
Sipe ibesles po TX DATA
5VDC UNLOCK B+
+LDIG VOD 22 4MOD OUT
1.5V PP c700 NC uc 12cS
MUX our 232) 390
INTERFACE TX/RX
+AUDIO IN FILTERS 9BIN DATA/TONE CLK R701 Ik CSWITCH 4LSB
C702
5
Ls BYPASS 27
6
TX CODED MODE >t
MICR
Rel4
R700 LIMITER 25 LIMITER OUT
OCOMPUTER 7MSB 100k
R437. INTERFACE 7
4U200 18 SC2
0703 NC
OV PP 0.47 HS BYPASS 26 5MDC REF
3°7CONVERTER
2
320uS j__VAG BYPASS 29
ONG
R703 =REGULATOR 3.3uF 0
RX WITH IMV CODED RESET 5
5VOC INT
=
Nc NC HIGH SPEED TX DATA 6234
Res NC $800
=a
I5 30 29 |13 13 9sSty a-1 R405
ON/OFF
AUDIO 7
OSW Bt
RX IN 10 »
S>a
aisot
aupio [PA ENABLE 23 Logic 40.1 39 u4q 13
MIC SELECT 20 INT/ EXT C26
mw 0TO um Tye ©ow pes 6lFS
SQUELCH 04 o> pe) [SSF
SUPPLY VOLTAGES Rel isk Cél" A22 EXT MI
ADAPT 45 PB7 paopts FO
®SwiTCHED B+VIA $800 2000 INT MIC Coe RII PAS
4.7uH
©REGULATED 5V
a|
ces
-039 2000 DIME
38 PAS pg2 50 LED RED Q405
C64 +100 ALERT TONE
loo +oF +
34 az 54 BATT VOLT 100k cr400 §
R430
(FROM UI03,PIN 2) MK\ a
EOS C30 c2a HANDSHAKE |40 PE4 +
"RED §150
.9 voc so 035
AFIC WDT.DISABLE pq, 56 VOL sense
OZ '00k R800
RX SY OLIN 12) SPKR AUDIO voc
MICROCOMPUTER PES
VOLUME.
R507 i
*PART NOT NORM
~
;
P/O P/O p4 R435 Ik 2MOD B/VPP
2.4-26 VDC XTAL 10 CO
=;
WM +*!!
2EXT SPKR R433 4150
2.5 VAC gR402 2.7pF 7
35
0.1 +3
8OPT Bt ?68 64 yay Voc uH cata
VR80 IRO 21 C401
4.7k
ON
it $80|
4EXT MIC
100 4.7uF 20 Y¥400 AA
5=STR
XIRQ =24 7.3728 MHz =-<2
AUX TX/KID 33100 R415 c4i2 1rate 24k 2.0
VR80 100k O.1 Tour 100K 0VDC EMER RB04:
PTT $805
-7 OPT SEL
+
UNIVERSAL +
OPT SEL 62 5¢7 60 §PTT 68k oo
6BUSY gpg BUSY ocs <C415 iSOk
100 R8Ol
PDO/RDI =
pata
VR809 2<402 RAIO Q401 $B2
05 DATA 27 anang 5! SW Bt
Ge)
=10k 10k 20k
@
r
A
RAI Tioopr
soaaeesd42q4457 sasi 3|jessq25
2PTO/PTI 3AAA RA! =
5NC
NC NC R403
JUI02 +VR80B
100k S3DBI066C96~A
TO J8 ON CONTROLLER BOARD
DEPF-20976-0
VIA INTERCONNECT FLEX
JU5O!*
2i
Q203 C2i6
00
2REGULATED 5V
©RX
I)
33 3.7 VOC UNSQ
MAIN BOARD SCHEMATIC DIAGRAM 15
Oo 0
33,

SYSTEMS SABER UHF SECURENET TPLF-3925-A
Electrical Parts List
SYSTEMS SABER Controller Board TPLF-3926-0
Electrical Parts List
SWITCH:
RPX4690A Kit, On/Of/Volume (includes R800)
$801/S804 4005221R01 Dual-Function, Clear/Code
RESISTOR, Fixed: 015%;1/8W
unless stated
R1 0660079V23 82k
C233 2362998B16 3.3+10%; 16V
C234 2113740A55 jOOpF+5%
C235. 236 Not Used
REFERENCE MOTOROLA
PART NO. DESCRIPTION
SYMBOL
REFERENCE MOTOROLA
SYMBOL PART NO. DESCRIPTION
NOTE:
I. For optimum performance, order replacement diodes, transistors, and
circuit modules by Motorola part number only.
C237 2160521H41 .22+80-20%
C251 thru 253 2113740A55 AOOpF+5%
C400,401 2113740A38 24
C402 2362998B73 410; 16V
pF+5%; 50V; NPO
.
C403 2362998B68 4.7; 10V
C404 Not Used
C405 2113741A45 °01
C406 Not Used
C407,408 2160521G37 0.1+80-20%
C409 2113740A13
C410
2.7pF
Not Used
C411,412 2160521G37 0.1+80-20%
C413 thru 415 2113740F51 100pF
C500 Not Used
C501 thru 514 2113740A55 100pF+5%
C515 Not Used
C516 thru 520 2113740A55 100pF+5%
C521 2113741F25 1000pF
C700,701 2160521G37 0.1+80-20%
C702 2362998B16 3.3410%; 16V
C703 2362998B05 A7+H10%
C704 2362998B68 4.7; 10V
C705 2160521G37 0.1+80-20%
Not Used
C706 thru 709
C710 21 13740A55 100pF+5%
C800 Not Used
C801 2113740A55 100pFt5%
DIODE: See Note |
CR200 Not Used
CR201 4805129M05 SOT
CR400 4805729G34 LED, Red
CR401 4805729G35 LED, Yellow
FUSE:
F900 01 05955P27 ASSEMBLY, 5Amp
FILTER:
FL1 Not Used
FL2 9105685005 Ceramic; 450kHz; 20kHz BW
FL3 9105685006 Ceramic; 450kHz; 1SkHz BW
JACK:
J1 0905287C05 Socket, Printed Circuit
(LCD Interconnect)(10 req'd)
J2 0905287C05 Socket, Printed Circuit
(PTT Controls Flex)(11 req'd)
J3 Socket, Printed Circuit 0905287C05
(Speaker/Mic Connector)(4 req'd)
JUMPER:
JU500 thru 503 Not Used
JUS04,505 0605021K01 0Q
COIL, RF: unless stated
L1 2405452C64 1500nH+5%
L2 2462575A05 Choke; 4.7uH
L3 2405452C49 360nNHt5%
L4 2405452C09 50nHt5%
L200 thru 206 Not Used
L207 thru 210 2405452C49 360nNHL5%
L400_ ~- ~2460578C43 _ _
33uH
PLUG:
P1 Not Used
P2 2805520001 Connector
P3,4 Not Used
P5 3905446003 Contact, Antenna
P6 3905445003 Contact, RF Wireform
TRANSISTOR: See Note I'
Q1 4805128M16 PNP; SOT-23
Q2 Not Used
Q200,201 4805128M44 NPN; SOT-23
Q202 4805128M27 PNP; SOT-89
Q203 4805128M16 PNP; SOT-23
Q204 4805218N13 PNP;.SOT-
Q205 Not Used
Q206 4805128M16 PNP; SOT-23
Q207,208 4805128M29 PNP; SOT-23
Q400 Not Used
Q401 4805128M27 PNP; SOT-89
Q402 thru 405 4805128M44 NPN; SOT-23
R2 Not Used
R3 0660076E76 13k+t1%
R4 0660078T24 91k
R5 0660078T01 10k
R6 Not Used
R7 0660078J80 49.9k+1%
R8 Not Used
R9 0660078G33 2kt1%
R10 Not Used
R11 0660078G33 2kt1%
R12 0660076A49 1k
R13 thru 15 Not Used
R16 0660079V28 130k
R17 0660076E73 10kt1%
R18 0660076E89 47ki1%
R19 0660076A49 1k
R20,21 Not Used
R22 0660076A92 62k
R23 thru 59 Not Used
R60 0660076A29 10
R61 0660076A77 15k
R62 0660076B01 10
R63, 64 Not Used
R65 0660076A25 100k
R200 thru 208 Not Used
R209 0660076A49 1k
R210 0660078J80 49.9kt1%
R211 0660076A75 12k
R212 0660078G33 2kt1%
R213 0660076A75 12k
R214 0660076B01 100k
R215 Not Used
R216,217 0660076A73 10k
R218 0660076E73 10k£1%
R219 0660076E85 20k+1%
R220. 0660076B01 100k
47kt1%
R221 0660076E89
R222 0660076A73 10k
R223,224 Not Used
R225 10k
R400
0660076A73
Not Used
R401 0660076A65 *47k
R402 0660076B25 1IMt5%
R403 0660076B01 100k
R404 Not Used
R405 0660076A73 10k
R406 0660076A73 10k
R407 0660076A65 4.7k
R408 0660076B01 100k
R409 0660076A29 150°
R410 0660076A41 470
R411 0660079J33
R412,413 0660078L01
R414 0660078T01 10k
R415 0660076B01 100k
0660078L01 100k1+1%
R416
R417 0660076B01 100k
R41 8thru 424 Not Used
R425 0660076A73 10k
R426 thru 429 Not Used
R430 15 0660076A29
NotUsed
R431,432...0.
R433 0660076A21
R434 Not Used
R435 0660076A49 1k
R436 0660076A41 470
R437 0660076N49 1k
R500 0660076A73 10k
R501 thru 506 Not Used
R507 0660076B01 100k
R700 0660078J80 49.9kt1%
R701 0660076A49 1k
R702 Not Used
R703 0660076E89 47kt1%
R800 RPX4690A Potentiometer, Kit, On/Off/Volume
(includesS800)
_
R801_-.
_
-~ }- 0660076B08 ... 200k ..
R802 0660076A93 68k-
R803 Not Used
R804 0660076A85 33k
R805 0660076A49 1k
($804)(Standard) and
Emergency (S801)(Optional)
$802 Not Used
$803
-
RPX4694A Kit, Contact Snapdome, PTT
$805 RPX4694A Kit, Contact Snapdome, Monitor
$806 thru 822 Not Used
$823 RPX4689A Kit, Frequency
CIRCUIT MODULE: See Note |
U1 Not Used
U2 NLE9432A Filter/Amp/Mixer
U100 0105958P77 IC, I-F
U101 0105958P80 IC, Audio Filter, CMOS
U102 0105958P74 IC, Audio, Bipolar
U103 5105469E65 IC, Regulator
U200 0105953N05 IC, Digital/Analog Converter, CMOS
U201 0105959P66 Transmit Automatic Level Control
U202 NLE9472A 5w-Power Amplifier
U203 NFE6061A Filter/Detector/Switch
U300 NLE9462A Synthesizer (440-470 MHz)
U301 NXN6269A Oscillator, Reference; 16.8MHz
U400 0105956S06 Microcomputer, MC68HC11; Binary
U700 01 05954S43 Signal Filter, Phase Il, CMOS
U900 NTN4720A SECURENET Bypass Module
or Optional Encryption Module
DIODE: See Note |
VR800 4805129M35 Zener, 5.6V
VR801 4805129M49 Zener, 16V
VR802 Not Used
VR803 thru 807 4805129M35 Zener, 5.6V
VR808 4805129M49 Zener, 16V
VR809thru 812 4805129M35 Zener, 5.6V
VR813 Not Used
VR814 4805129M49 Zener, 16V
VR815 Not Used
VR816 4805129M35 Zener, 5.6V
CRYSTAL:
Y400 4805664G32 7.3728MHz
NONREFERENCED ITEMS
0905287007 SOCKET, Printed Circuit
(for all modules)(71 req'd)
1405881R01 BOOT, Crystal (For ¥400)
7505934Q01 PAD, Oscillator (For U301)
PC BOARD, Main
8405334T01
CAPACITOR, Fixed:
pF+30%; 50V
unless stated
C500,501 Not Used
C502 thru 505 2113740F51 100
C506 2113740A55 100
C507 thru 510 2113740F51 100
C511 2311049A37 1pF +20%
C512 2113741B69 1pF
C513,514 2113740A38 24
C515 2113740A13 2.7+.25pF
C516 2113741A45 O1pF
C517 thru 519 2113741B69
DIODE: See Note |
CR501 502 4805729G37 LED; Green SMD (See Note 2)
CRS03 4805129M06 Dual; SOT-23 (See Note 2)
JACK:
J7 0905287010 Socket, Keypad; (qty 9)
J8 0905287010 Socket, LCD; (qty 10)
COIL, RF: Uniess stated
L501,502 2462575A23 -1pH
L503 2460578C43 33HH
TRANSISTOR: See Note |
Q501 48051 28M12 NPN; BCW60B (RH) (See Note 2)
Q502 4805218N50 NPN; SOT-23
Q503 4805128M12 NPN; BCW60B (RH) (See Note 2)
RESISTOR, Fixed: 0+5%;1/8W
unless stated
R501 0660076A09 22 (See Note 2)
R502 0660076A69 6.8k (See Note 2)
R503 0660079V13
R504,505 Not Used
R506 0660079V13 33k
0660076N49 1K
R507,508
R509 0660079V13 33k
R510 0660076N39 390
R511 0660076N49 1k
R512 0660076A39 390
R513 0660076N85 33k
R514 0660076N39 390
4.7k
R515 0660079U89
R516 0660076B12 300k
R517 0660079U89 4.7k
R518 0660076A73 10k
R519 0660079V13 33k
R520 0660079V25 100k (See Note 2)
0660079V13
R521,522 33k (See Note 2)
R523 0660076A73 10k (See Note 2)
R524 0660079U73 1k (See Note 2)
R525 0660076F08 200k+1%
R526 thru 533 0660079V13 33k
(See Note 2)
R534 0660076A73 10k
33k
R535._ _ ._.0660076N85
R536 0660076A73 10k
R537 0660079U89 4.7k
0660076N73 10k
R538 hu 547
CIRCUIT MODULE: See Note |
U501 510541 4938 Microprocessor, HCMOS
U502 5105226P50 LCD Driver (See Note 2)
U503 5105226P39 RAM; 8k x8
U504 5105165R24 EEPROM; 8k x8
U505 5195007D01 EPROM; 128k x8
CRYSTAL:
7.3728 MHz
Y501 4860875A01
NONREFERENCED ITEMS
8405543U01 PCB (See Note 2)
1305321R02 BEZEL (See Note 2)
6105534T01 LIGHTPIPE (See Note 2)
5105892T01 LCD (See Note 2)
2805397L.06 ELASTOMER (See Note 2)
NOTE I: For optimum performance, order replacement diodes, transistors,
and circuit modules by Motorola part number only.
NOTE 2: Placed on SYSTEMS SABER III radios only.
CAPACITOR, Fixed: 25V
unless stated
C1 Not Used
C2 2113741A25 1500pF+5%
C3 2160521H41 .22+80-20%
2160521G37 0.1+80-20%
C5 2113741A17 680pF
C6 2362998B68 4.7; 10V
C7 2160521H41 .22+80-20%
2160521G37 0.1+80-20%
C9 2362998B73 10; 16V
C10 2160521H39 .15 10%; 35V
C11 2362998B64 2.2; 20V
C12 2113741A17 680pF 15%
C13 2113741A45 .01
C14 0.1+80-20%
2160521 G37
C15 Not Used
C16 2113740A46 47pFt£5%
C17 2160521G37 0.1+80-20%
C18 2160521H41 .22+80-20%
C19 2362998B1 63.3£10%; 16V
C20 2362998B59 1; 16V
2362998B68
C21 4.7; 10V
C22 2160521G37 0.1+80-20%
C23 2113741A33 3300pF+5%
C24 2362998B69 4.7; 20V
C25 Not Used
C26 2113741A37 4700pF+£5%
C27 2113741A59 .039145%
C28 thru 30 2362998B59 1; 16V
C31 Not Used
C32 2113741A59 .03915%
C33 2160521H43 .33+80-20%
C34 Not Used
C35 2160521H43 .33+80-20%
C36,37 2160521G37 0.1+80-20%
C38 2113740A55 100pF +5%
C39,40 Not Used
C41 2113740A55 100pF+5%
C42,43 Not Used
2160521G37 0.1+80-20%
Not Used
2113740A55 100pF+£5%; 50V
C47 2113741A45 .01
2113741A53 .02245%
C49 thru 60 Not Used
C61 2113741A53 .02245%
C62 2362998B68 4.7; 10V
C63 2160521G37 0.1+80-20%
C64 thru 66 2113740A55 100pF+5%; NPO
C67 thru 69 Not Used
C70 2113741A51 .018
C71 2113740A54 91pF+25%; NPO
C72 thru 74 Not Used
C75 2113740A55 100pF+5%
C76 Not Used
C77 2113741A45 .01
C201 Not Used
C202 2113741A51 .018
Not Used
C203,204
C205 2362998B05 47410%
C206 thru 211 Not Used
C212,213 2113741A51 018 .
C214 Not Used
C215 2362998B16 3.3£10%; 16V
C216 2362998B73 10; 16V
C217 2113740A55 100pF+5%
C218 2160521C21 4700pF 00%
C219,220 Not Used
C221 2362998B68 4.7; 10V
C222 2160521A19 3300pF+5%
C223 2113740A55 100pF£5%
C224 2113741A33 3300pF15%
C225 2113740A55 100pF+5%
-
C226 2362998B73 10; 16V
C227 2113741A51 .018
C228 2113740A55 100pF1+5%
C229 Not Used
C230 thru 232 2113740A55 100pFt45%
33k
C45
16
SYSTEMS SABER UHF SECURENET TPLF-3925-A
Electrical Parts List
SYSTEMS SABER Controller Board TPLF-3926-0
Electrical Parts List
SWITCH:
RPX4690A Kit, On/Of/Volume (includes R800)
$801/S804 4005221R01 Dual-Function, Clear/Code
RESISTOR, Fixed: 015%;1/8W
unless stated
R1 0660079V23 82k
C233 2362998B16 3.3+10%; 16V
C234 2113740A55 jOOpF+5%
C235. 236 Not Used
REFERENCE MOTOROLA
PART NO. DESCRIPTION
SYMBOL
REFERENCE MOTOROLA
SYMBOL PART NO. DESCRIPTION
NOTE:
I. For optimum performance, order replacement diodes, transistors, and
circuit modules by Motorola part number only.
C237 2160521H41 .22+80-20%
C251 thru 253 2113740A55 AOOpF+5%
C400,401 2113740A38 24
C402 2362998B73 410; 16V
pF+5%; 50V; NPO
.
C403 2362998B68 4.7; 10V
C404 Not Used
C405 2113741A45 °01
C406 Not Used
C407,408 2160521G37 0.1+80-20%
C409 2113740A13
C410
2.7pF
Not Used
C411,412 2160521G37 0.1+80-20%
C413 thru 415 2113740F51 100pF
C500 Not Used
C501 thru 514 2113740A55 100pF+5%
C515 Not Used
C516 thru 520 2113740A55 100pF+5%
C521 2113741F25 1000pF
C700,701 2160521G37 0.1+80-20%
C702 2362998B16 3.3410%; 16V
C703 2362998B05 A7+H10%
C704 2362998B68 4.7; 10V
C705 2160521G37 0.1+80-20%
Not Used
C706 thru 709
C710 21 13740A55 100pF+5%
C800 Not Used
C801 2113740A55 100pFt5%
DIODE: See Note |
CR200 Not Used
CR201 4805129M05 SOT
CR400 4805729G34 LED, Red
CR401 4805729G35 LED, Yellow
FUSE:
F900 01 05955P27 ASSEMBLY, 5Amp
FILTER:
FL1 Not Used
FL2 9105685005 Ceramic; 450kHz; 20kHz BW
FL3 9105685006 Ceramic; 450kHz; 1SkHz BW
JACK:
J1 0905287C05 Socket, Printed Circuit
(LCD Interconnect)(10 req'd)
J2 0905287C05 Socket, Printed Circuit
(PTT Controls Flex)(11 req'd)
J3 Socket, Printed Circuit 0905287C05
(Speaker/Mic Connector)(4 req'd)
JUMPER:
JU500 thru 503 Not Used
JUS04,505 0605021K01 0Q
COIL, RF: unless stated
L1 2405452C64 1500nH+5%
L2 2462575A05 Choke; 4.7uH
L3 2405452C49 360nNHt5%
L4 2405452C09 50nHt5%
L200 thru 206 Not Used
L207 thru 210 2405452C49 360nNHL5%
L400_ ~- ~2460578C43 _ _
33uH
PLUG:
P1 Not Used
P2 2805520001 Connector
P3,4 Not Used
P5 3905446003 Contact, Antenna
P6 3905445003 Contact, RF Wireform
TRANSISTOR: See Note I'
Q1 4805128M16 PNP; SOT-23
Q2 Not Used
Q200,201 4805128M44 NPN; SOT-23
Q202 4805128M27 PNP; SOT-89
Q203 4805128M16 PNP; SOT-23
Q204 4805218N13 PNP;.SOT-
Q205 Not Used
Q206 4805128M16 PNP; SOT-23
Q207,208 4805128M29 PNP; SOT-23
Q400 Not Used
Q401 4805128M27 PNP; SOT-89
Q402 thru 405 4805128M44 NPN; SOT-23
R2 Not Used
R3 0660076E76 13k+t1%
R4 0660078T24 91k
R5 0660078T01 10k
R6 Not Used
R7 0660078J80 49.9k+1%
R8 Not Used
R9 0660078G33 2kt1%
R10 Not Used
R11 0660078G33 2kt1%
R12 0660076A49 1k
R13 thru 15 Not Used
R16 0660079V28 130k
R17 0660076E73 10kt1%
R18 0660076E89 47ki1%
R19 0660076A49 1k
R20,21 Not Used
R22 0660076A92 62k
R23 thru 59 Not Used
R60 0660076A29 10
R61 0660076A77 15k
R62 0660076B01 10
R63, 64 Not Used
R65 0660076A25 100k
R200 thru 208 Not Used
R209 0660076A49 1k
R210 0660078J80 49.9kt1%
R211 0660076A75 12k
R212 0660078G33 2kt1%
R213 0660076A75 12k
R214 0660076B01 100k
R215 Not Used
R216,217 0660076A73 10k
R218 0660076E73 10k£1%
R219 0660076E85 20k+1%
R220. 0660076B01 100k
47kt1%
R221 0660076E89
R222 0660076A73 10k
R223,224 Not Used
R225 10k
R400
0660076A73
Not Used
R401 0660076A65 *47k
R402 0660076B25 1IMt5%
R403 0660076B01 100k
R404 Not Used
R405 0660076A73 10k
R406 0660076A73 10k
R407 0660076A65 4.7k
R408 0660076B01 100k
R409 0660076A29 150°
R410 0660076A41 470
R411 0660079J33
R412,413 0660078L01
R414 0660078T01 10k
R415 0660076B01 100k
0660078L01 100k1+1%
R416
R417 0660076B01 100k
R41 8thru 424 Not Used
R425 0660076A73 10k
R426 thru 429 Not Used
R430 15 0660076A29
NotUsed
R431,432...0.
R433 0660076A21
R434 Not Used
R435 0660076A49 1k
R436 0660076A41 470
R437 0660076N49 1k
R500 0660076A73 10k
R501 thru 506 Not Used
R507 0660076B01 100k
R700 0660078J80 49.9kt1%
R701 0660076A49 1k
R702 Not Used
R703 0660076E89 47kt1%
R800 RPX4690A Potentiometer, Kit, On/Off/Volume
(includesS800)
_
R801_-.
_
-~ }- 0660076B08 ... 200k ..
R802 0660076A93 68k-
R803 Not Used
R804 0660076A85 33k
R805 0660076A49 1k
($804)(Standard) and
Emergency (S801)(Optional)
$802 Not Used
$803
-
RPX4694A Kit, Contact Snapdome, PTT
$805 RPX4694A Kit, Contact Snapdome, Monitor
$806 thru 822 Not Used
$823 RPX4689A Kit, Frequency
CIRCUIT MODULE: See Note |
U1 Not Used
U2 NLE9432A Filter/Amp/Mixer
U100 0105958P77 IC, I-F
U101 0105958P80 IC, Audio Filter, CMOS
U102 0105958P74 IC, Audio, Bipolar
U103 5105469E65 IC, Regulator
U200 0105953N05 IC, Digital/Analog Converter, CMOS
U201 0105959P66 Transmit Automatic Level Control
U202 NLE9472A 5w-Power Amplifier
U203 NFE6061A Filter/Detector/Switch
U300 NLE9462A Synthesizer (440-470 MHz)
U301 NXN6269A Oscillator, Reference; 16.8MHz
U400 0105956S06 Microcomputer, MC68HC11; Binary
U700 01 05954S43 Signal Filter, Phase Il, CMOS
U900 NTN4720A SECURENET Bypass Module
or Optional Encryption Module
DIODE: See Note |
VR800 4805129M35 Zener, 5.6V
VR801 4805129M49 Zener, 16V
VR802 Not Used
VR803 thru 807 4805129M35 Zener, 5.6V
VR808 4805129M49 Zener, 16V
VR809thru 812 4805129M35 Zener, 5.6V
VR813 Not Used
VR814 4805129M49 Zener, 16V
VR815 Not Used
VR816 4805129M35 Zener, 5.6V
CRYSTAL:
Y400 4805664G32 7.3728MHz
NONREFERENCED ITEMS
0905287007 SOCKET, Printed Circuit
(for all modules)(71 req'd)
1405881R01 BOOT, Crystal (For ¥400)
7505934Q01 PAD, Oscillator (For U301)
PC BOARD, Main
8405334T01
CAPACITOR, Fixed:
pF+30%; 50V
unless stated
C500,501 Not Used
C502 thru 505 2113740F51 100
C506 2113740A55 100
C507 thru 510 2113740F51 100
C511 2311049A37 1pF +20%
C512 2113741B69 1pF
C513,514 2113740A38 24
C515 2113740A13 2.7+.25pF
C516 2113741A45 O1pF
C517 thru 519 2113741B69
DIODE: See Note |
CR501 502 4805729G37 LED; Green SMD (See Note 2)
CRS03 4805129M06 Dual; SOT-23 (See Note 2)
JACK:
J7 0905287010 Socket, Keypad; (qty 9)
J8 0905287010 Socket, LCD; (qty 10)
COIL, RF: Uniess stated
L501,502 2462575A23 -1pH
L503 2460578C43 33HH
TRANSISTOR: See Note |
Q501 48051 28M12 NPN; BCW60B (RH) (See Note 2)
Q502 4805218N50 NPN; SOT-23
Q503 4805128M12 NPN; BCW60B (RH) (See Note 2)
RESISTOR, Fixed: 0+5%;1/8W
unless stated
R501 0660076A09 22 (See Note 2)
R502 0660076A69 6.8k (See Note 2)
R503 0660079V13
R504,505 Not Used
R506 0660079V13 33k
0660076N49 1K
R507,508
R509 0660079V13 33k
R510 0660076N39 390
R511 0660076N49 1k
R512 0660076A39 390
R513 0660076N85 33k
R514 0660076N39 390
4.7k
R515 0660079U89
R516 0660076B12 300k
R517 0660079U89 4.7k
R518 0660076A73 10k
R519 0660079V13 33k
R520 0660079V25 100k (See Note 2)
0660079V13
R521,522 33k (See Note 2)
R523 0660076A73 10k (See Note 2)
R524 0660079U73 1k (See Note 2)
R525 0660076F08 200k+1%
R526 thru 533 0660079V13 33k
(See Note 2)
R534 0660076A73 10k
33k
R535._ _ ._.0660076N85
R536 0660076A73 10k
R537 0660079U89 4.7k
0660076N73 10k
R538 hu 547
CIRCUIT MODULE: See Note |
U501 510541 4938 Microprocessor, HCMOS
U502 5105226P50 LCD Driver (See Note 2)
U503 5105226P39 RAM; 8k x8
U504 5105165R24 EEPROM; 8k x8
U505 5195007D01 EPROM; 128k x8
CRYSTAL:
7.3728 MHz
Y501 4860875A01
NONREFERENCED ITEMS
8405543U01 PCB (See Note 2)
1305321R02 BEZEL (See Note 2)
6105534T01 LIGHTPIPE (See Note 2)
5105892T01 LCD (See Note 2)
2805397L.06 ELASTOMER (See Note 2)
NOTE I: For optimum performance, order replacement diodes, transistors,
and circuit modules by Motorola part number only.
NOTE 2: Placed on SYSTEMS SABER III radios only.
CAPACITOR, Fixed: 25V
unless stated
C1 Not Used
C2 2113741A25 1500pF+5%
C3 2160521H41 .22+80-20%
2160521G37 0.1+80-20%
C5 2113741A17 680pF
C6 2362998B68 4.7; 10V
C7 2160521H41 .22+80-20%
2160521G37 0.1+80-20%
C9 2362998B73 10; 16V
C10 2160521H39 .15 10%; 35V
C11 2362998B64 2.2; 20V
C12 2113741A17 680pF 15%
C13 2113741A45 .01
C14 0.1+80-20%
2160521 G37
C15 Not Used
C16 2113740A46 47pFt£5%
C17 2160521G37 0.1+80-20%
C18 2160521H41 .22+80-20%
C19 2362998B1 63.3£10%; 16V
C20 2362998B59 1; 16V
2362998B68
C21 4.7; 10V
C22 2160521G37 0.1+80-20%
C23 2113741A33 3300pF+5%
C24 2362998B69 4.7; 20V
C25 Not Used
C26 2113741A37 4700pF+£5%
C27 2113741A59 .039145%
C28 thru 30 2362998B59 1; 16V
C31 Not Used
C32 2113741A59 .03915%
C33 2160521H43 .33+80-20%
C34 Not Used
C35 2160521H43 .33+80-20%
C36,37 2160521G37 0.1+80-20%
C38 2113740A55 100pF +5%
C39,40 Not Used
C41 2113740A55 100pF+5%
C42,43 Not Used
2160521G37 0.1+80-20%
Not Used
2113740A55 100pF+£5%; 50V
C47 2113741A45 .01
2113741A53 .02245%
C49 thru 60 Not Used
C61 2113741A53 .02245%
C62 2362998B68 4.7; 10V
C63 2160521G37 0.1+80-20%
C64 thru 66 2113740A55 100pF+5%; NPO
C67 thru 69 Not Used
C70 2113741A51 .018
C71 2113740A54 91pF+25%; NPO
C72 thru 74 Not Used
C75 2113740A55 100pF+5%
C76 Not Used
C77 2113741A45 .01
C201 Not Used
C202 2113741A51 .018
Not Used
C203,204
C205 2362998B05 47410%
C206 thru 211 Not Used
C212,213 2113741A51 018 .
C214 Not Used
C215 2362998B16 3.3£10%; 16V
C216 2362998B73 10; 16V
C217 2113740A55 100pF+5%
C218 2160521C21 4700pF 00%
C219,220 Not Used
C221 2362998B68 4.7; 10V
C222 2160521A19 3300pF+5%
C223 2113740A55 100pF£5%
C224 2113741A33 3300pF15%
C225 2113740A55 100pF+5%
-
C226 2362998B73 10; 16V
C227 2113741A51 .018
C228 2113740A55 100pF1+5%
C229 Not Used
C230 thru 232 2113740A55 100pFt45%
33k
C45
16

(AA) MOTOROLA INC.
MANUAL REVISION
for
Service Manual No. 68P81066C95-O
SYSTEMS SABER" and SABER ATS" UHF
Handie-Talkie® Portable Radios
This revision outlines changes that have occurred since the printing of your manual. Use this information to
supplement your manual. Installation of these changes in earlier equipment is not necessary except as
recommended in Motorola Service and Repair Notes (SRN's).
REVISION DETAILS
CHANGE AFFECTS
SPECIFICATIONS
MODEL CONFIGURATION
FOR USE IN HAZARDOUS ATMOSPHERES
SYSTEMS SABER UHF SECURENET Electrical Parts List TPLF-3925-O
SYSTEMS SABER Controller Board Electrical Parts List TPLF-3926-0
SYSTEMS SABER |SECURENET UHF Exploded View Parts List TPLF-3923-0
SYSTEMS SABER IIl SECURENET UHF Exploded View Parts List TPLF-3924-0
Table 2. Modulation/Squelch Modes
CHANGES
On page 1, add the following information to the SPECIFICATIONS table:
TRANSMITTER
CURRENT DRAIN (with 7.5V Supply)
Low Power (1-2 Watts) 1900 mA
High Power (2-5 Watts) 3300 mA
CHANNEL
SPACING: DEVIATION PL DEVIATION
25 kHz +5 kHz +1.0 kHz
12.5 kHz +2.5 kHz +0.5 kHz
©1991, 1992 by Motorola Inc., Radio Products Group
8000 W. Sunrise Blvd., Ft. Lauderdale, Florida 33322-9934
Printed in U.S.A. 5/92. All Rights Reserved.
-
1of6
-
RECEIVER
CURRENT DRAIN (with 7.5V Supply)
Receive (500mW Audio) 225mA
Standby 95 mA
FMR1483-10
NO.
1
2
3
4
5
6
7
8
1

On page 1, change existing information in the SPECIFICATIONS table to read as follows:
TRANSMITTER RECEIVER
RF POWER OUTPUT SENSITIVITY
Low-Power Models 1-2W 12.5kHz 25 kHz
High-Power Models 2-5W 20dBS: 0.4uV
12dBS: 0.5yV 0.3nV
FREQUENCY STABILITY Squeich (Programmable): 0.54V Max.
(25°C to +55°C; +25°C REF.):
25 kHz +.0002% SELECTIVITY
12.5 kHz +.0002% Adjacent Channel: 25 kHz -70dB
12.5 kHz -60dB
MODULATION
(+5kHz for 100% Types 20K0F3E FREQUENCY STABILITY
modulation @1000Hz) 20K0F1D (-25°C to +55°C; +25°C REF.):
(+2.5kHz for 100% 20K0F2D 25 kHz +.0003%
modulation @1000Hz 12:5 kHz +.0002%
{12.5kHz only))
CHANNEL SPACING: 25, 12.5kHz
SPURIOUS EMISSION
(CONDUCTED AND RADIATED)
1.0W -67dBc
2.0W: -70dB
5.0W: -74dBc
On page 1, change the existing intormation below the SPECIFICATIONS table to read as follows:
All specifications are per ELA RS316B, unless noted.
All radio parameters for 12.5kHz channel spacing models are measured per CEPT 84 methods.
Specifications are subject to change without notice.
2Onpage 2, change the MODEL CONFIGURATION table to read as follows:
FACTORY RADIO POWER
ID TYPE LEVEL FREQUENCY |SUBMERSIBLE KEYPAD DISPLAY 42.SkHz
H34TUN5170CN SYS. SABER! +-2W 403-512MHz No No No No
H44TUN5170CN SYS. SABER 2-5W 403-512MHz No No No No
H44TUN5570CN SYS. SABER! 2-5W 403-51 2MHz No No No Yes.
H34YUN5170CN SYS. SABER |1-2W 403-51 2MHz Yes No No No
H44YUN5170CN SYS. SABER |2-5W 403-51 2MHz Yes No No No
H44YUN5570CN SYS. SABER |2-5W 403-512MHz Yes No No Yes
H34TUK5170CN SYS. SABER III 1-2W 403-512MHz No 3x8 Yes No
H44TUK5170CN SYS. SABER III 2-5W 403-512MHz No 3x5 Yes No
H44TUK5570CN SYS. SABER III 2.5W 403-512MHz No 3x5 Yes Yes
H44TUBS170CN SABER ATS 2-5W 403-512MHz No No No No
H44YUB5170CN SABER ATS 25W 403-512MHz Yes No No No
H44TUB5570CN SABER ATS 2-5W 403-512MHz No No No Yes
H44YUB5570CN SABER ATS 2-5W 403-512MHz Yes No No Yes
May 07, 1992
-
2of6
_
FMR>1483-10

3. Onpage 3, add the following:
FOR USE IN HAZARDOUS ATMOSPHERES
Factory Mutual Non-Incendive and Intrinsically Safe Approved Models
The SYSTEMS SABER and Ili, and SABER ATS portable radios must be properly equipped with aFactory
Mutual (FM) Corporation approved battery to be considered "intrinsically safe."
The FM options for the radio provide alabel which lists the Class/Division/Group, verifies the radio as being
FM approved, and states the type of battery to be-used with the radio.
The intrinsically safe rating by Factory Mutual states that electrical equipment is incapable of releasing suffi-
cient electrical or thermal energy, under normal or abnormal operating conditions, to cause ignition of specific
hazardous atmospheres designated on the radio label.
WARNING
Substitution of components may impair the intrinsic safety of the radio.
Note
Radios must be shipped from the Motorola factory equipped with the hazardous atmosphere
option; they cannot be modified in the field.
Failure to use the radio with an approved battery will negate the FM approval. Factory Mutual approved
radios can be used in those applications requiring reliable, two-way hand-held radios in the listed specific haz-
ardous atmospheres. Motorola approved equipment and accessories are listed in the approval guide published
yearly by Factory Mutual Corporation.
4Onpage 10, change Table 2. Modulation /Squelch Modes to read as follows:
Mode Audio Display Transmit Receiver
Indication Indication Modulation Functions Squelch Function
RF Carrier
11bonk Mode 1Mic Noise Squelch
22bonks Mode 2Mic with PL PL Squelched
33bonks Mode 3 Mic with DPL DPL Squelch
Mic with Trunking PL Connect
44bonks Mode 4connect Tone Tone 105.88 Hz
High-Speed RF Carrier
55bonks Mode 5Trunking Data; Noise Squeich
900 Hz Square Wave
66bonks Mode 6 MDC Encode Data, RF Carrier
1500 Hz Tone Noise Squelch
May 07, 1992 -3 of 6- FMR-1483-10
3. Onpage 3, add the following:
FOR USE IN HAZARDOUS ATMOSPHERES
Factory Mutual Non-Incendive and Intrinsically Safe Approved Models
The SYSTEMS SABER and Ili, and SABER ATS portable radios must be properly equipped with aFactory
Mutual (FM) Corporation approved battery to be considered "intrinsically safe."
The FM options for the radio provide alabel which lists the Class/Division/Group, verifies the radio as being
FM approved, and states the type of battery to be-used with the radio.
The intrinsically safe rating by Factory Mutual states that electrical equipment is incapable of releasing suffi-
cient electrical or thermal energy, under normal or abnormal operating conditions, to cause ignition of specific
hazardous atmospheres designated on the radio label.
WARNING
Substitution of components may impair the intrinsic safety of the radio.
Note
Radios must be shipped from the Motorola factory equipped with the hazardous atmosphere
option; they cannot be modified in the field.
Failure to use the radio with an approved battery will negate the FM approval. Factory Mutual approved
radios can be used in those applications requiring reliable, two-way hand-held radios in the listed specific haz-
ardous atmospheres. Motorola approved equipment and accessories are listed in the approval guide published
yearly by Factory Mutual Corporation.
4Onpage 10, change Table 2. Modulation /Squelch Modes to read as follows:
Mode Audio Display Transmit Receiver
Indication Indication Modulation Functions Squelch Function
RF Carrier
11bonk Mode 1Mic Noise Squelch
22bonks Mode 2Mic with PL PL Squelched
33bonks Mode 3 Mic with DPL DPL Squelch
Mic with Trunking PL Connect
44bonks Mode 4connect Tone Tone 105.88 Hz
High-Speed RF Carrier
55bonks Mode 5Trunking Data; Noise Squeich
900 Hz Square Wave
66bonks Mode 6 MDC Encode Data, RF Carrier
1500 Hz Tone Noise Squelch
May 07, 1992 -3 of 6- FMR-1483-10

5On page 11, change existing information in Table 3. Transmitter Performance Checks in Air Test
Mode to read as follows:
Instructions Specifications
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation 12.5 kHz channel spacing)
Apply 1kHz tone (25 kHz channel
spacing) or 1.5 kHz tone (12.5 kHz
channel spacing). Adjust audio input
level for 3.0 kHz deviation.
0.5-1.0 kHz deviation (25 kHz channel spacing)
0.2-0.5 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacing)
0.8-1.2 kHz deviation (25 kHz channel spacing)
0.4-0.6 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacin
0.5-1.0 kHz deviation (25 kHz channel spacing)
0.2-0.5 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacin
2.4-3.6 kHz deviation (25 kHz channel! spacing)
1.2-1.8 kHz deviation (12.5 kHz channel spacing)
Test Name
Tx Modulator
Limiting
Tx Modulator
Sensitivity
Tx PL Deviation
Tx Modulator Limiting
with PL and Voice
Tx Connect
Tone Deviation
Tx Modulator Limiting
with DPL and Voice
Tx DPL Deviation
Tx Modulator Limiting
with DPL and Voice
Tx High Speed
Data Deviation
6Onpage 12, change existing information in Table 4. Receiver Performance Checks in Air Test Mode
to read as follows:
Test Name
Rx Sensitivity
Specifications
0.35V maximum (-116dBm)(25 kHz channel spacing)
0.5uV maximum (-113dBm)(12.5 kHz channel spacing)
7On page 13, change existing information in Table 5. Alignment Setup and Specifications to read as
follows:
Test Name
Deviation Limit
Tune Target Test Limits
3.9-4.8 kHz (25 kHz channel spacing)
2.0-2.4 kHz (12.5 kHz channel spacing)
Signalling Deviations
DTMF with Connect Tone
DTMF Only:
DTMF with PL.
ISW Only:
DVP Only
25 kHz Channel 125 kHz Channel 25 kHz Channel 12.5 kHz Channel
Spacing Spacing Spacing Spacing
4.0 kHz Nominal 2.0 kHz Nominal 3.3-4.7 kHz 1.8-2.2 kHz
3.0 KHz Nominal 1.5 kHz Nominal 2.5-3.5 kHz 1.2-1.8 kHz
3.75 kHz Nominal 1.8 kHz Nominal 3.0-4.5 kHz 1.5-2.3. kHz
3.0 kHz Nominal 1.5 kHz Nominal 2.4-3.6 kHz 1.2-1.8 kHz
4.0 kHz Nominal Not Applicable 3.5-4.5 kHz Not Applicable
May 07, 1992
-
4of6
_
FMR+1483-10
5On page 11, change existing information in Table 3. Transmitter Performance Checks in Air Test
Mode to read as follows:
Instructions Specifications
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation 12.5 kHz channel spacing)
Apply 1kHz tone (25 kHz channel
spacing) or 1.5 kHz tone (12.5 kHz
channel spacing). Adjust audio input
level for 3.0 kHz deviation.
0.5-1.0 kHz deviation (25 kHz channel spacing)
0.2-0.5 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacing)
0.8-1.2 kHz deviation (25 kHz channel spacing)
0.4-0.6 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacin
0.5-1.0 kHz deviation (25 kHz channel spacing)
0.2-0.5 kHz deviation (12.5 kHz channel spacing)
5kHz maximum deviation (25 kHz channel spacing)
2.5 kHz maximum deviation (12.5 kHz channel spacin
2.4-3.6 kHz deviation (25 kHz channel! spacing)
1.2-1.8 kHz deviation (12.5 kHz channel spacing)
Test Name
Tx Modulator
Limiting
Tx Modulator
Sensitivity
Tx PL Deviation
Tx Modulator Limiting
with PL and Voice
Tx Connect
Tone Deviation
Tx Modulator Limiting
with DPL and Voice
Tx DPL Deviation
Tx Modulator Limiting
with DPL and Voice
Tx High Speed
Data Deviation
6Onpage 12, change existing information in Table 4. Receiver Performance Checks in Air Test Mode
to read as follows:
Test Name
Rx Sensitivity
Specifications
0.35V maximum (-116dBm)(25 kHz channel spacing)
0.5uV maximum (-113dBm)(12.5 kHz channel spacing)
7On page 13, change existing information in Table 5. Alignment Setup and Specifications to read as
follows:
Test Name
Deviation Limit
Tune Target Test Limits
3.9-4.8 kHz (25 kHz channel spacing)
2.0-2.4 kHz (12.5 kHz channel spacing)
Signalling Deviations
DTMF with Connect Tone
DTMF Only:
DTMF with PL.
ISW Only:
DVP Only
25 kHz Channel 125 kHz Channel 25 kHz Channel 12.5 kHz Channel
Spacing Spacing Spacing Spacing
4.0 kHz Nominal 2.0 kHz Nominal 3.3-4.7 kHz 1.8-2.2 kHz
3.0 KHz Nominal 1.5 kHz Nominal 2.5-3.5 kHz 1.2-1.8 kHz
3.75 kHz Nominal 1.8 kHz Nominal 3.0-4.5 kHz 1.5-2.3. kHz
3.0 kHz Nominal 1.5 kHz Nominal 2.4-3.6 kHz 1.2-1.8 kHz
4.0 kHz Nominal Not Applicable 3.5-4.5 kHz Not Applicable
May 07, 1992
-
4of6
_
FMR+1483-10

8Onpage 16, SYSTEMS SABER UHF SECURENET Electrical Parts List, change the following:
REF.
SYM.
C49
FL2
P5
R5
R216
R217
R219
R222
R225
R405
R406
R412
R413
R414
R416
R425
R500
U2
U202
U203
U300
MOTOROLA
PART NO.
9105685Q05
3905446Q03
0660078T01
0660076A73
0660076A73
0660076E85
0660076A73
0660076A73
0660076A73
0660076A73
0660078L01
0660078L01
0660078T01
0660078L01
0660076A73
0660076A73
NLE9432A
NLE9472A
NFE6061A
NLE9462A
8405334T01
May 07, 1992
ACTION
add
changed to
add or
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
or
or
or
or
or
changed to
or
or
or
or
or
changed to
or
changed to
or
or
or
MOTOROLA
PART NO.
2113741A21
9105685Q05
9105685Q06
REX-4166A
0660076E73
0660076E73
0660076E73
0660079J33
0660076E73
0660076E73
0660076E73
0660076E73
0660079K02
0660079K02
0660076E73
0660079K02
0660076E73
0660076E73
NLE9431A
NLE9432A
NLE9433A
NLE9434A
NLE9501A
NLE9502A
NLE9471A
NLE9472A
NLE9473A
NLE9474A
NLE9483A
NLE9741 A
NFE6061A
NFE6062A
NLE9461A
NLE9462A
NLE9463A
NLE9464A
DESCRIPTION
1000pF+5%
Ceramic; 450kHz; 20kHz BW (25kHz
channel spacing only)
Ceramic; 450kHz; 15kHz BW (12.5kHz
channel spacing only)
Plug:
Contact Antenna
Resistor:
10k
10k
10k
20k+1%
10k
10k
10k
10k
10041%
100+1%
10k
100+1%
10k
10k
Filter/Amp/Mixer (403-433MHz)
Fitter/Amp/Mixer (440-470MHz)
Filter/Amp/Mixer (446-449MHz)
Filter/Amp/Mixer (482-512MHz)
Filter/Amp/Mixer (403-433MHz)(12.5 kHz
channel spacing only)
Filter/Amp/Mixer (440-470MHz)(12.5 kHz
channel spacing only)
5W Power Amplifier (403-433 MHz)
5W Power Amplifier (440-470 MHz)
5W Power Amplifier (460-490 MHz)
5W Power Amplifier (482-512 MHz)
2W Power Amplifier (440-470 MHz)
2W Power Amplifier (403-433 MHz)
Filter/Detector/Switch (403-470 MHz)
Filter/Detector/Switch (470-512 MHz)
VCO/Synthesizer (403-433 MHz)
VCO/Synthesizer (440-470 MHz)
VCO/Synthesizer (460-490 MHz)
VCO/Synthesizer (482-512 MHz)
NONREFERENCED ITEMS
changed to 8405424U01
-
5of6
_
PC BOARD, MAIN
FMR-1483-10

9Onpage 16, SYSTEMS SABER Controller Board Electrical Parts List, change the following:
REF.
SYM.
R518
R523
R524
R534
R536
U503
U505
MOTOROLA
PART NO.
0660076A73
0660076A73
0660079U73
0660076A73
0660076A73
5105226P39
5195007D01
6105534T01
ACTION
changed to
changed to
changed to
changed to
changed to
changed to
changed to
changed to
MOTOROLA
PART NO.
0660076E73
0660076E73
0660076A49
0660076E73
0660076E73
0105951R14
5195007D05
6105520U01
DESCRIPTION
10k
10k
1k
10k
10k
RAM; 8k x8
EPROM; 128k x8
LIGHTPIPE
10 Onpage 18, SYSTEMS SABER |SECURENET UHF Exploded View! Parts List, change the
following:
REF. MOTOROLA
SYM. PART NQ.
25 NLE9911A
33 NTN4595B
59 2605682U01
60 NTN5963A
61 8405681U01
ACTION
changed to
or
changed to
changed to
changed to
changed to
MOTOROLA
PART NO.
NLE4200A
NLE4242A
NTN4595C
2605897101
0105950584
8405328T01
DESCRIPTION
ASSEMBLY, UHF Main PC Board
(25kHz Channel Spacing)
ASSEMBLY, UHF Main PC Board
(12.5kHz Channel Spacing)
BATTERY, 1500mAh
SHIELD, LCD Board
ASSEMBLY, Controller PC Board
(SYSTEMS SABER 1)
FLEX CIRCUIT, LCD Interconnect
11 On page 18, SYSTEMS SABER IIt SECURENET UHF Exploded View Parts List, change the
following:
MOTOROLA
PART NO.
NTN4595B
8460999B03
May 07, 1992
ACTION
changed to
changed to
MOTOROLA
PART NO.
NTN4595C
0105950S85
REF
-
6of6
_
DESCRIPTION
BATTERY, 1500 mAh
ASSEMBLY, Controller PC Board
(SYSTEMS SABER III)(Includes Item 48)
SYM
33
49
FMR-1483-10
49

(MA) MOTOROLA INC. MANUAL REVISION
for
Manual No. 68P81066C95-O
SYSTEM SABER ™SECURENET
Portable Radios
Service Manual
This revision outlines changes that have occurred since the printing of your manual. Use this information to
supplement your manual. Installation of these changes in earlier equipment is not necessary except as
recommended in Motorola Service and Repair Notes (SRN's).
REVISION DETAILS
NO, ee
1SPECIFICATIONS
2ELECTRICAL PARTS LIST
3CONTROLLER CIRCUIT BOARD LAYOUT DIAGRAM
CHANGES
NO,
1Onpage 1, SPECIFICATIONS, change the following as indicated:
GENERAL
FREQUENCY RANGE: 403 -512MHZ
BANDSPLITS:
403
-
433MHZ
440
-
470MHz
460
-
490MHz
482
-
512MHz
2Onpage 16, under ELECTRICAL PARTS LIST, TPLF- 3925-0, change the following:
NO, ACTION PART NO. DESCRIPTION
C409 change to 2160527B25 .01 +10%
R219 change to 0660076E80 20k +1%
3Onpage 17, CONTROLLER CIRCUIT BOARD COMPONENT LAYOUT DIAGRAM AND
CONTROLLER BOARD SCHEMATIC DIAGRAM, replace the COMPONENT LAYOUT
DIAGRAMS with the following DIAGRAMS:
April 4, 1990 1of2
-
FMR+1480A-1
(MA) MOTOROLA INC. MANUAL REVISION
for
Manual No. 68P81066C95-O
SYSTEM SABER ™SECURENET
Portable Radios
Service Manual
This revision outlines changes that have occurred since the printing of your manual. Use this information to
supplement your manual. Installation of these changes in earlier equipment is not necessary except as
recommended in Motorola Service and Repair Notes (SRN's).
REVISION DETAILS
NO, ee
1SPECIFICATIONS
2ELECTRICAL PARTS LIST
3CONTROLLER CIRCUIT BOARD LAYOUT DIAGRAM
CHANGES
NO,
1Onpage 1, SPECIFICATIONS, change the following as indicated:
GENERAL
FREQUENCY RANGE: 403 -512MHZ
BANDSPLITS:
403
-
433MHZ
440
-
470MHz
460
-
490MHz
482
-
512MHz
2Onpage 16, under ELECTRICAL PARTS LIST, TPLF- 3925-0, change the following:
NO, ACTION PART NO. DESCRIPTION
C409 change to 2160527B25 .01 +10%
R219 change to 0660076E80 20k +1%
3Onpage 17, CONTROLLER CIRCUIT BOARD COMPONENT LAYOUT DIAGRAM AND
CONTROLLER BOARD SCHEMATIC DIAGRAM, replace the COMPONENT LAYOUT
DIAGRAMS with the following DIAGRAMS:
April 4, 1990 1of2
-
FMR+1480A-1

cae @6
sen esy
PB
FROM MAIN
CIRCUIT BOARD. wa
VIA
Be
FLEX SB c
C510 s
pred 4
>
C505 *
ae *4
SIDE 2VIEWED FROM SIDE 2
April 4, 1990 -2 0f 2-
*NOT PLACED ON SYSTEMS SABER! RADIOS
o*cD e
@
J
qe
fret] ah.
32 40
41
8
a©
usod
&a
{6 20 23
a3
xwe &
5
C506
c5i4 C5) 5
aBr) 3
TAME
59
CIRCUIT U503
FROM
KEYPAD
c502
&&
OL- CEPF -20885-0
FMR-1480A-1
cae @6
sen esy
PB
FROM MAIN
CIRCUIT BOARD. wa
VIA
Be
FLEX SB c
C510 s
pred 4
>
C505 *
ae *4
SIDE 2VIEWED FROM SIDE 2
April 4, 1990 -2 0f 2-
*NOT PLACED ON SYSTEMS SABER! RADIOS
o*cD e
@
J
qe
fret] ah.
32 40
41
8
a©
usod
&a
{6 20 23
a3
xwe &
5
C506
c5i4 C5) 5
aBr) 3
TAME
59
CIRCUIT U503
FROM
KEYPAD
c502
&&
OL- CEPF -20885-0
FMR-1480A-1

SYSTEMS SABER™ service
SECURENET™
403
-
512 MHz revision
Handie-Talkie® Portable Radios manual
GENERAL:
This revision outlines changes that have occurred since the printing of your service manual. Use this information to cor-
rect your manual.
SERVICE MANUAL AFFECTED:
68P81066C95-O SYSTEMS SABER™ SECURENET™ 403
-
512 MHz Service Manual
REVISION DETAILS:
SABER has anew baseplate and conductive pad that greatly enhances its transmit capabilities. This supplement contains
new parts lists and exploded view drawings necessary for servicing the radio. Please refer to the following revisions and
change your manual accordingly.
Service Manual
Change No. Change Affects Page number
ISYSTEMS SABER Controller Board Electrical Parts List 16
2SYSTEMS SABER ISECURENET UHF Exploded View Drawing 18
3SYSTEMS SABER ISECURENET UHF Exploded View Parts List 18
4SYSTEMS SABER III SECURENET UHF Exploded View Parts List 18
5SYSTEMS SABER III SECURENET UHF Exploded View Drawing 18
CHANGE |
SYSTEMS SABER Controller Board
Electrical Parts List
REFERENCE MOTOROLA DESCRIPTION
SYMBOL PART NO.
U501 5102226020 Microprocessor, HCMOS
us02 NO CHANGE NO CHANGE
U503 5105457W48 RAM; 8k x8
U504 5105457W23 EEPROM; 8k x8
U505 5107008D07 EPROM; 128k x8
©1997 by Motorola Inc. Portable Products Division FMR-1861A-1
(A) MOTOROLA
8000 W. Sunrise Blvd., Ft. Lauderdale, FL 33322-9934 April, 1997
Printed in U.S. A. April, 1997. All Rights Reserved.
SYSTEMS SABER™ service
SECURENET™
403
-
512 MHz revision
Handie-Talkie® Portable Radios manual
GENERAL:
This revision outlines changes that have occurred since the printing of your service manual. Use this information to cor-
rect your manual.
SERVICE MANUAL AFFECTED:
68P81066C95-O SYSTEMS SABER™ SECURENET™ 403
-
512 MHz Service Manual
REVISION DETAILS:
SABER has anew baseplate and conductive pad that greatly enhances its transmit capabilities. This supplement contains
new parts lists and exploded view drawings necessary for servicing the radio. Please refer to the following revisions and
change your manual accordingly.
Service Manual
Change No. Change Affects Page number
ISYSTEMS SABER Controller Board Electrical Parts List 16
2SYSTEMS SABER ISECURENET UHF Exploded View Drawing 18
3SYSTEMS SABER ISECURENET UHF Exploded View Parts List 18
4SYSTEMS SABER III SECURENET UHF Exploded View Parts List 18
5SYSTEMS SABER III SECURENET UHF Exploded View Drawing 18
CHANGE |
SYSTEMS SABER Controller Board
Electrical Parts List
REFERENCE MOTOROLA DESCRIPTION
SYMBOL PART NO.
U501 5102226020 Microprocessor, HCMOS
us02 NO CHANGE NO CHANGE
U503 5105457W48 RAM; 8k x8
U504 5105457W23 EEPROM; 8k x8
U505 5107008D07 EPROM; 128k x8
©1997 by Motorola Inc. Portable Products Division FMR-1861A-1
(A) MOTOROLA
8000 W. Sunrise Blvd., Ft. Lauderdale, FL 33322-9934 April, 1997
Printed in U.S. A. April, 1997. All Rights Reserved.

CHANGE 2
Wer
April, 1997FMR-1861A-1
Page 2of 4
Please note the changes in the SYSTEMS SABER IUHF Exploded View Drawing:
18
19
17
55
16
20
26 15
21
25
24 14
22
13
23
12
28
10
29
7
61
6
2
4
53
62
49
51
3
ae 47
1
4
5
31
45
o44
Oxo oxo
090%"
32 43
42
33 4i
40
39
38) (87
37
8fhe
36
56
34
CEPF-20975-A
CHANGE 2
Wer
April, 1997FMR-1861A-1
Page 2of 4
Please note the changes in the SYSTEMS SABER IUHF Exploded View Drawing:
18
19
17
55
16
20
26 15
21
25
24 14
22
13
23
12
28
10
29
7
61
6
2
4
53
62
49
51
3
ae 47
1
4
5
31
45
o44
Oxo oxo
090%"
32 43
42
33 4i
40
39
38) (87
37
8fhe
36
56
34
CEPF-20975-A

CHANGE 3
SYSTEMS SABER |SECURENET UHF
Exploded View Parts List
ITEM MOTOROLA DESCRIPTION
NO. PART NO.
1through 33 NO CHANGES NO CHANGES
34 0305371J22 SCREW, Baseplate, Ph Pan Hd;
(2 req'd) (part of item 43)
35 3905253X01 CONTACT, Power (2 req'd)
(part of item 43)
36 NO CHANGE NO CHANGE
37 NO CHANGE NO CHANGE
38 6405847N05 BASEPLATE (part of item 43)
39 3205783T02 SEAL, Elastomer (part of item 43)
40 through 61 NO CHANGES NO CHANGES
62 7505262Z02 PAD, Conductive Conformable
CHANGE 4
SYSTEMS SABER Ill SECURENET UHF
Exploded View Parts List
ITEM MOTOROLA DESCRIPTION
NO. PART NO.
1through 33 NO CHANGES NO CHANGES
34 0305371J22 SCREW, Baseplate, Ph Pan Hd;
(2 reqd) (part of item 43)
35 3905253X01 CONTACT, Power (2 req'd)
(part of item 43)
36 NO CHANGE NO CHANGE
37 NO CHANGE NO CHANGE
38 6405847N05 BASEPLATE (part of item 43)
39 3205783T02 SEAL, Elastomer (part of item 43)
40 through 61 NO CHANGES NO CHANGES
62 7505262202 PAD, Conductive Conformable
April, 1997 FMR-1861A-1 Page 3of 4
CHANGE 3
SYSTEMS SABER |SECURENET UHF
Exploded View Parts List
ITEM MOTOROLA DESCRIPTION
NO. PART NO.
1through 33 NO CHANGES NO CHANGES
34 0305371J22 SCREW, Baseplate, Ph Pan Hd;
(2 req'd) (part of item 43)
35 3905253X01 CONTACT, Power (2 req'd)
(part of item 43)
36 NO CHANGE NO CHANGE
37 NO CHANGE NO CHANGE
38 6405847N05 BASEPLATE (part of item 43)
39 3205783T02 SEAL, Elastomer (part of item 43)
40 through 61 NO CHANGES NO CHANGES
62 7505262Z02 PAD, Conductive Conformable
CHANGE 4
SYSTEMS SABER Ill SECURENET UHF
Exploded View Parts List
ITEM MOTOROLA DESCRIPTION
NO. PART NO.
1through 33 NO CHANGES NO CHANGES
34 0305371J22 SCREW, Baseplate, Ph Pan Hd;
(2 reqd) (part of item 43)
35 3905253X01 CONTACT, Power (2 req'd)
(part of item 43)
36 NO CHANGE NO CHANGE
37 NO CHANGE NO CHANGE
38 6405847N05 BASEPLATE (part of item 43)
39 3205783T02 SEAL, Elastomer (part of item 43)
40 through 61 NO CHANGES NO CHANGES
62 7505262202 PAD, Conductive Conformable
April, 1997 FMR-1861A-1 Page 3of 4

CHANGE 5
Please note the changes in the SYSTEMS SABER III UHF Exploded View Drawing
18) (56
{9
17) (20
20
16
21
26 15) (13
24 14
13
12
11) (30
10
8
50
6
2
4
59
49
a
51
61
47
o
3
5
31
45
46
32
42
144
1
40
39
38
37
36 57
35
CEPF-20243-A
April, 1997
FMR-1861A-1
Page 4of 4
CHANGE 5
Please note the changes in the SYSTEMS SABER III UHF Exploded View Drawing
18) (56
{9
17) (20
20
16
21
26 15) (13
24 14
13
12
11) (30
10
8
50
6
2
4
59
49
a
51
61
47
o
3
5
31
45
46
32
42
144
1
40
39
38
37
36 57
35
CEPF-20243-A
April, 1997
FMR-1861A-1
Page 4of 4

MOTOROLA INC. SYSTEMS SABER™
SECURENET™
Handie-Talkie® Portable Radio
403
-
512 MHz
SPECIFICATIONS
GENERAL TRANSMITTER RECEIVER
FREQUENCY RANGE: 403-512MHz RF POWER OUTPUT 2or 5Watts SENSITIVITY
20dBQ: 0.4pV Max.
POWER SUPPLY: FREQUENCY STABILITY 12dBS: 0.3nV Max.
Rechargeable Nickel-Cadmium Battery (-30°C to +60°C; +25°C REF): +.0002% Squelch (Programmable) 0.25yV Max.
or Primary Battery
SELECTIVITY:
BATTERY VOLTAGE: MODULATION: Types 20K0F3E Adjacent channel: 75dB
Nominal: 7.5Vde (+5kHz for 100% 20K0F1D Fourth channel: 80dB
Range: 6to 9Vdc modulation @1000Hz) 20K0F2D
INTERMODULATION: 72dB
TEMPERATURE RANGE
Operating: -30°C to +60°C FM HUM AND NOISE USEABLE BANDWIDTH: 5kHz
-40°C to +85°C -45dB
Storage: (COMPANION RECEIVER):
FM HUM AND NOISE: 40dB
DIMENSIONS (HXWXD)
Less Battery: 4.42"x2.94"x1.18" SPURIOUS EMISSION FREQUENCY STABILITY
(112.27x74.67x29.97 mm) (CONDUCTED AND RADIATED) (-30°C to +60°C; +25°C REF.): +.0003%
2.0W: -70dBc
With Medium-Capacity Battery: 5.0W: -74dBe AUDIO SPL (AT 30 cm
7.56"x2.94"x1.18" WITH RATED AUDIO):
(192.02x74.67x29.97 mm) Weighted, 300-3000Hz
AUDIO DISTORTION: 3% Maximum 87dB Nominal
With Ultra-High-Capacity Battery:
8.32"x2.94"x1.18" AUDIO FREQUENCY RESPONSE: +1,-3dB RATED AUDIO OUTPUT:
(211.33x74.67x29.97 mm) (6dB/OCTAVE PRE-EMPHASIS; 500mW (At less than 5% distortion)
300-3000Hz)
WEIGHT CHANNEL SPACING: 25kHz
Keypad
Less Battery: 12.57 oz. (357 g) MAXIMUM FREQUENCY MAXIMUM FREQUENCY
SEPARATION: Full Bandsplit SEPARATION: Full Bandsplit
With Medium-Capacity Battery: (NO DEGRADATION) (NO DEGRADATION)
24.23 oz. (688 g)
With Ultra-High-Capacity Battery:
25.85 0z. (734 g) SECURENET
Non-Keypad SCRAMBLE TYPE: Digital
Less Battery: 12.22 02. (347 g) ENCRYPTION METHOD: Multi-Register, Non-Linear Combiner
ENCRYPTION KEY INITIALIZATION: Random
With Medium-Capacity Battery: ENCRYPTION KEY GENERATION: External, Hand-Held
23.87 oz. (678 g) Microprocessor-Controlled Key loader
KEY STORAGE: Volatile Electronic Memory
With Ultra-High-Capacity Battery: NUMBER OF KEYS PER RADIO: One
25.49 o7. (724 g) ANALOG-TO-DIGITAL CONVERSION Continuously-Variable Slope Deita
(CVSD) Modulation
VOICE SAMPLE RATE: 12 Kilobits/Second
All specifications are per EIA RS316B, unless noted
Specifications are subject to change without notice
®Motorola SYSTEMS SABER, SECURENET, Private-Line, Digital Private-Line, and Handie-Talkie are trademarks of Motorola Inc.
©1990 by Motorola Inc., Portable Products Division
8000 W. Sunrise Bivd., Ft. Lauderdale, FL 33322-9934
Service Wotan
Printed in U.S.A.3/90. All Rights Reserved. 68P81066C95-
MOTOROLA INC. SYSTEMS SABER™
SECURENET™
Handie-Talkie® Portable Radio
403
-
512 MHz
SPECIFICATIONS
GENERAL TRANSMITTER RECEIVER
FREQUENCY RANGE: 403-512MHz RF POWER OUTPUT 2or 5Watts SENSITIVITY
20dBQ: 0.4pV Max.
POWER SUPPLY: FREQUENCY STABILITY 12dBS: 0.3nV Max.
Rechargeable Nickel-Cadmium Battery (-30°C to +60°C; +25°C REF): +.0002% Squelch (Programmable) 0.25yV Max.
or Primary Battery
SELECTIVITY:
BATTERY VOLTAGE: MODULATION: Types 20K0F3E Adjacent channel: 75dB
Nominal: 7.5Vde (+5kHz for 100% 20K0F1D Fourth channel: 80dB
Range: 6to 9Vdc modulation @1000Hz) 20K0F2D
INTERMODULATION: 72dB
TEMPERATURE RANGE
Operating: -30°C to +60°C FM HUM AND NOISE USEABLE BANDWIDTH: 5kHz
-40°C to +85°C -45dB
Storage: (COMPANION RECEIVER):
FM HUM AND NOISE: 40dB
DIMENSIONS (HXWXD)
Less Battery: 4.42"x2.94"x1.18" SPURIOUS EMISSION FREQUENCY STABILITY
(112.27x74.67x29.97 mm) (CONDUCTED AND RADIATED) (-30°C to +60°C; +25°C REF.): +.0003%
2.0W: -70dBc
With Medium-Capacity Battery: 5.0W: -74dBe AUDIO SPL (AT 30 cm
7.56"x2.94"x1.18" WITH RATED AUDIO):
(192.02x74.67x29.97 mm) Weighted, 300-3000Hz
AUDIO DISTORTION: 3% Maximum 87dB Nominal
With Ultra-High-Capacity Battery:
8.32"x2.94"x1.18" AUDIO FREQUENCY RESPONSE: +1,-3dB RATED AUDIO OUTPUT:
(211.33x74.67x29.97 mm) (6dB/OCTAVE PRE-EMPHASIS; 500mW (At less than 5% distortion)
300-3000Hz)
WEIGHT CHANNEL SPACING: 25kHz
Keypad
Less Battery: 12.57 oz. (357 g) MAXIMUM FREQUENCY MAXIMUM FREQUENCY
SEPARATION: Full Bandsplit SEPARATION: Full Bandsplit
With Medium-Capacity Battery: (NO DEGRADATION) (NO DEGRADATION)
24.23 oz. (688 g)
With Ultra-High-Capacity Battery:
25.85 0z. (734 g) SECURENET
Non-Keypad SCRAMBLE TYPE: Digital
Less Battery: 12.22 02. (347 g) ENCRYPTION METHOD: Multi-Register, Non-Linear Combiner
ENCRYPTION KEY INITIALIZATION: Random
With Medium-Capacity Battery: ENCRYPTION KEY GENERATION: External, Hand-Held
23.87 oz. (678 g) Microprocessor-Controlled Key loader
KEY STORAGE: Volatile Electronic Memory
With Ultra-High-Capacity Battery: NUMBER OF KEYS PER RADIO: One
25.49 o7. (724 g) ANALOG-TO-DIGITAL CONVERSION Continuously-Variable Slope Deita
(CVSD) Modulation
VOICE SAMPLE RATE: 12 Kilobits/Second
All specifications are per EIA RS316B, unless noted
Specifications are subject to change without notice
®Motorola SYSTEMS SABER, SECURENET, Private-Line, Digital Private-Line, and Handie-Talkie are trademarks of Motorola Inc.
©1990 by Motorola Inc., Portable Products Division
8000 W. Sunrise Bivd., Ft. Lauderdale, FL 33322-9934
Service Wotan
Printed in U.S.A.3/90. All Rights Reserved. 68P81066C95-

MODEL CONFIGURATION
FACTORY POWER
ID LEVEL FREQ. SUBMERSIBLE KEYPAD DISPLAY
H34TUN5170CN 1W-2W 403-512MHz NO None None
H44TUN5170CN 2w-5W 403-512MHz NO None None
H34YUN5170CN 1W-2W 403-512MHz YES None None
H44YUN5170CN 2w-5W 403-512MHz YES None None
H34TUK51 70CN 1W-2W 403-512MHz NO 3x5 LCD
H44TU K51 70CN 2w-5W 403-512MHz NO 3x6 LCD
SPECIALIZED TOOLS AND TEST EQUIPMENT
SERVICE AIDS
NTN4720A SECURENET Bypass Module
REN-4001A Housing Eliminator (Allows key loading through the cable)
RPX-4665A Field Modification Kit/RTX-4005A
RSX-4043A Rototorq Tool
RTK-4203A Program/Test Cable
RTK-4208A RF Coaxial Probe
RTL-4224A Battery Eliminator
RTL-4238A RF Cable
RTX-4005B Portable Products Test Set
TKN8506A Keyload Cable (Hand-held key loader to radio)
0180370B85 thru B86 Ungar Tabie Fixtures
0180386A81 Micro-Tip Soldering tron
0180386A82 Static Protection Kit
5880348B33 SMA-BNC Adapter for RTL-4208A Probe
6680321B79 Phillips-Head Rototorq Bit
6680334B48 thru B52 Ungar Service Heads
6680370B88 Frequency and On/Off Switch Spanner Nut Rototorq Bit
6680370B89
6680370B90
Baseplate Spanner Nut Rototorq Bit
Antenna Bushing Spanner Nut Rototorq Bit
6680385A11 Module Extractor
6680387A59 Leadless Component Extractor
6680387A64 Heat Controller With Safety Stand
8407264N02 SYSTEMS SABER Controller Extender Cable (10-pin)
TEST EQUIPMENT
R-1053A
R-2045D
Dual-Trace Oscilloscope
Communications Systems Analyzer with Secure Voice Option
S-1339A RF Millivoltmeter
$-1347D Power Supply
RTK-4237A Battery Tester
RTL-4223A Charger Tester
FIELD PROGRAMMING EQUIPMENT
RVN-4051A SYSTEMS SABER Field Programmer Software on 51/4-inch 360k
RVN-4052A
Double-Density Disk
SYSTEMS SABER Field Programmer Software on 31/2-inch Disk
0180353A74 Radio Interface Box (RIB)
0180357A57 RIB Wall-Mounted Power Supply
3080369B71 Computer Interface Cable (PC-AT) 25-pin
3080369B72 Computer Interface Cable (PC-XT), 9-pin
68P81 060C25 SYSTEMS SABER Field Programmer User's Guide
2
MODEL CONFIGURATION
FACTORY POWER
ID LEVEL FREQ. SUBMERSIBLE KEYPAD DISPLAY
H34TUN5170CN 1W-2W 403-512MHz NO None None
H44TUN5170CN 2w-5W 403-512MHz NO None None
H34YUN5170CN 1W-2W 403-512MHz YES None None
H44YUN5170CN 2w-5W 403-512MHz YES None None
H34TUK51 70CN 1W-2W 403-512MHz NO 3x5 LCD
H44TU K51 70CN 2w-5W 403-512MHz NO 3x6 LCD
SPECIALIZED TOOLS AND TEST EQUIPMENT
SERVICE AIDS
NTN4720A SECURENET Bypass Module
REN-4001A Housing Eliminator (Allows key loading through the cable)
RPX-4665A Field Modification Kit/RTX-4005A
RSX-4043A Rototorq Tool
RTK-4203A Program/Test Cable
RTK-4208A RF Coaxial Probe
RTL-4224A Battery Eliminator
RTL-4238A RF Cable
RTX-4005B Portable Products Test Set
TKN8506A Keyload Cable (Hand-held key loader to radio)
0180370B85 thru B86 Ungar Tabie Fixtures
0180386A81 Micro-Tip Soldering tron
0180386A82 Static Protection Kit
5880348B33 SMA-BNC Adapter for RTL-4208A Probe
6680321B79 Phillips-Head Rototorq Bit
6680334B48 thru B52 Ungar Service Heads
6680370B88 Frequency and On/Off Switch Spanner Nut Rototorq Bit
6680370B89
6680370B90
Baseplate Spanner Nut Rototorq Bit
Antenna Bushing Spanner Nut Rototorq Bit
6680385A11 Module Extractor
6680387A59 Leadless Component Extractor
6680387A64 Heat Controller With Safety Stand
8407264N02 SYSTEMS SABER Controller Extender Cable (10-pin)
TEST EQUIPMENT
R-1053A
R-2045D
Dual-Trace Oscilloscope
Communications Systems Analyzer with Secure Voice Option
S-1339A RF Millivoltmeter
$-1347D Power Supply
RTK-4237A Battery Tester
RTL-4223A Charger Tester
FIELD PROGRAMMING EQUIPMENT
RVN-4051A SYSTEMS SABER Field Programmer Software on 51/4-inch 360k
RVN-4052A
Double-Density Disk
SYSTEMS SABER Field Programmer Software on 31/2-inch Disk
0180353A74 Radio Interface Box (RIB)
0180357A57 RIB Wall-Mounted Power Supply
3080369B71 Computer Interface Cable (PC-AT) 25-pin
3080369B72 Computer Interface Cable (PC-XT), 9-pin
68P81 060C25 SYSTEMS SABER Field Programmer User's Guide
2

CLEANING
¢Clean all external radio surfaces with a0.5% solution of amild dishwashing detergent in water (one teaspoon
of detergent per gallon of water).
¢Stronger cleaning agents may only be used to remove soldering flux from circuit boards after making repairs.
¢Clean internal surfaces with water-activated optical wipes.
RELATED PUBLICATIONS AVAILABLE SEPARATELY
SYSTEMS SABER Ill SECURENET OPERATING INSTRUCTIONS 68P81060C10
SYSTEMS SABER SECURENET THEORY/ MAINTENANCE MANUAL 68P81060C20
SYSTEMS SABER FIELD PROGRAMMER USER'S GUIDE 68P81060C25
SYSTEMS SABER SECURENET SERVICE MANUAL (VHF) 68P81067C10
3
CLEANING
¢Clean all external radio surfaces with a0.5% solution of amild dishwashing detergent in water (one teaspoon
of detergent per gallon of water).
¢Stronger cleaning agents may only be used to remove soldering flux from circuit boards after making repairs.
¢Clean internal surfaces with water-activated optical wipes.
RELATED PUBLICATIONS AVAILABLE SEPARATELY
SYSTEMS SABER Ill SECURENET OPERATING INSTRUCTIONS 68P81060C10
SYSTEMS SABER SECURENET THEORY/ MAINTENANCE MANUAL 68P81060C20
SYSTEMS SABER FIELD PROGRAMMER USER'S GUIDE 68P81060C25
SYSTEMS SABER SECURENET SERVICE MANUAL (VHF) 68P81067C10
3