Nexgrill 720-0686 User manual

ITEM/ARTICLE/ARTICULO #0297983
STAINLESS STEEL CHARCOAL GRILL
BARBECUE AU GAZ EN ACIER INOXYDABLE
(page17 )
PARRILLA A DE ACERO INOXIDABLE (página33 )
MODEL/MODÈLE/MODELO #720-0686
K15Y08P-1
Example only: SERIAL # ________ MFG. DATE ________ PURCHASE DATE: _________
Questions, problems, missing parts? Before returning to your retailer, call our customer
service department at 1-877-323-5263, 8 a.m. - 6 p.m., PST, Monday - Friday, 8 a.m. – 12 p.m.
Saturday.
WARNING
READ ALL INSTRUCTIONS AND WARNINGS
CAREFULLY. FAILURE TO FOLLOW PROPER
PROCEDURES AND WARNINGS MAY RESULT
IN SERIOUS INJURY AND PROPERTY DAMAGE
WARNING
FOR OUTDOOR USE ONLY
WARNING
This grill is not intended to be
installed in or on recreational
vehicles and/or boats.

2
Safety Information……………………………………………………..........................................3
Package Contents List……….……………………………………………………………………….5
Hardware Contents…….…………………. ……………………….…………….……………….....6
Preparation...............................................................................................................................6
Assembly Instructions…………………………………………………………………….…..……6
Operating Tips ……………………………………………………………….....…….……..........11
Charcoal Grill Information ………………………………………………………………….………14
Warranty……………………….………….…………………………………………..…………..….15
Replacement Parts List………………….…....……………………………………..…….….…….16
TABLE OF CONTENTS

3
SAFETY INFORMATION
WARNING – Hazards or unsafe
practices which COULD result in severe
personal injury or death.
CAUTION – Hazards or unsafe
practices which COULD result in minor
personal injury.
CAUTION
This unit is heavy. Two people required for safe
assembly.
Some parts may contain sharp edges. Wear
protective gloves if necessary.
Read and follow all safety statements, warning,
assembly instructions and use and care instructions
before attempting to assemble and use.
WARNING
If for any reason you do not understand any of these instructions, contact customer service at
1-877-323-5263.
WARNING
Keep a fire extinguisher near this unit at all times. WARNING
This grill is for outdoor use only, in well-ventilated
areas..
WARNING
The use of alcohol, prescription or non-prescription
drugs may impair the user’s ability to properly
assemble and safely operate this unit
WARNING
DO NOT Operate the unit near or under flammable
or combustible materials such as decks, porches or
carports. A minimum clearance of 36 in. (92 cm) is
recommended. DO NOT operate the unit under
overhead construction.
WARNING
This product is not to be used as a heater.
WARNING
Use caution when lifting and moving the unit to
avoid back strain or back injury. Use two people
to lift or move the unit. Do not move the unit
while it is in use.
WARNING
Operate the unit on a stable, level, non-
flammable surface such as asphalt, concrete or
solid ground. DO NOT operate the unit on
flammable material such as carpet or wood deck.
WARNING
DO NOT use this product in a manner other than
its intended a purpose. It is NOT intended for
commercial use. It is not intended to be installed or
used in or on a recreational vehicle and/or boats.
WARNING
Use caution when assembling and operating this
unit to avoid cuts and scrapes from edges.
WARNING
DO NOT Store this unit near gasoline or other
combustible liquids or where other combustible
vapors may be present.
WARNING
Carbon monoxide hazard.
Burning charcoal inside can kill you. It gives off carbon monoxide, which has no odor. NEVER burn charcoal
inside homes, vehicles or tents.

4
SAFETY PRACTICES TO AVOID INJURY
When properly cared for, your grill will provide safe, reliable service for many years. However, use extreme care
as the grill produces intense heat that can increase accident potential.
When operating this appliance, practice these basic safety precautions:
Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service
should be referred to a qualified technician.
Do not install the grill in or on recreational vehicles and/or boats.
Do not leave children alone or unattended in an area where the grill is being used. Do not allow children to sit,
stand or play on or around the grill at any time.
Do not store items of interest to children around or below the grill or cart. Do not allow children to crawl inside
the cart.
Do not use aluminum foil to line the grill racks or grill bottom. This can severely upset combustion air flow or trap
excessive heat in the control area.
Do not use the grill to cook excessively fatty meats or other products, which promote flare-ups.
This unit is intended for outdoor use only.
Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront,
mountaintop, etc.), a windbreak will be required. Always adhere to the clearance specifications
WARNING
DO NOT store or operate this product in an area
accessible to children or pets. Store this unit in a
dry, protected location.
WARNING
DO NOT leave the unit unattended while in use..
WARNING
The grill head is heavy and will require two or
more people to lift and position onto grill cart.
WARNING
DO NOT leave hot ashes unattended until the
g
rill cools com
p
letel
y
.
WARNING
DO NOT move the unit while in use or while ashes
are still hot. Allow the unit to cool completely before
moving or storing.
WARNING
NEVER use gasoline or other highly volatile
fluids as a starter.
WARNING
Always cook your food on the grade after the flame
is burned out.
WARNING
Dispose of cold ashes by wrapping them in a
heavy-duty aluminum foil and placing in a
noncombustible container. Make sure that there
are no other combustible materials in or near the
container.
WARNING
If you must dispose of ashes in less time than it
takes for the ashes to completely cool down, then
remove the ashes from the unit, keeping them in
the heavy-duty foil, and soak them completely with
water before disposing of them in a
noncomb
ustible container
.
WARNING
Allow the unit to cool completely before
conducting any routine cleaning or maintenance.

5
PACKAGE CONTENTS LIST
A. Bottom Panel -----------1pc B. Caster ------------------2pcs C. Swivel Caster with brake--
1pc
D. Swivel Caster ----------1pc
.
E. Left Side Panel --------1pc F. Right Side Panel---------1pc
G. Back Panel ----------1pc
H. Charcoal grill firebox with
main lid ---1pc
I. Crank Handle ----------1pc
J. Charcoal Tray ----------1pc
.
K. Drawer A ----------1pc . L. Drawer B ----------1pc
M. Push Bar ----------------1pc
N. Side shelf, left-----------1pc
O. Side Shelf, right--------1pc
P．Grate Lifter--------------1pc
Q. Drawer clapboard ---------1 pc

6
Pack Description Required for
assembly
Extra
hardware Total
AA 1/4-in. x 15-mm Truss Head Screw With Locking Washer (PDC) 22 2 24 pcs.
BB 1/4-in. x 12-mm Truss Head Screw With Locking Washer(Stainless
Steel) 18 2 20 pcs.
CC 5/32. x10mm Truss Head Screw With Locking Washer(Stainless Steel) 2 1 3 pcs.
DD 1/4-in. Flat Washer(PDC) 22 2 24 pcs.
Before beginning assembly, installation or operation of product, make sure all parts are present. Compare
parts with package contents list and diagram above. If any part is missing or damaged, do not attempt to
assemble, install or operate the product. Contact customer service for replacement parts.
yEstimated Assembly Time: 50 minutes
yTools Required for Assembly:
Phillips Screwdriver (not included) and Wrench (not included)
yNote: The right and left sides of the grill are designated as if you are standing and facing the grill.
1. Swivel Caster Assembly
Mount the caster onto the bottom panel (A) using sixteen
1/4-in. x15-mm truss head screw with locking washers (AA)
and sixteen 1/4-in. flat washers (DD).
Position the swivel caster with brake (C) under the left
rear of the cart bottom (A), and position the swivel caster
(D) under left front as shown in Fig. 1.
Position the two stationary casters (B) should be positioned
under the right side.
NOTE: Turn over the bottom panel to mount the cast.
HARDWARE CONTENTS
PREPARATION
ASSEMBLY INSTRUCTIONS
Fig. 1
AA BB CC DD
1/4-in.x15-mm truss head screw with locking
washers (AA) 16 x
1/4-in. flat washers (DD) 16 x
A
C
AA
DD
D
B

7
2. Side Panel Assembly
Use two 1/4-in.×12-mm truss head screw with locking
washers (BB) to connect the bottom of the left side
panel (E) to the bottom panel (A). Make the left side
panel flush with rear of bottom panel and tighten the
screws as shown in Fig. 2.
Repeat steps for the right side panel (F)
3. Back Panel Assembly
Remove the back panel (G) from the carton. Position the
back panel (G) with the flat side facing outward. Attach the
back panel to the bottom panel (A) with two 1/4-in. x 12-mm
truss head screw with locking washers (BB) as shown in Fig. 3
Use four 1/4-in.×12-mm truss head screw with
locking washers (BB) to connect the back panel (G)
to the right and left side panels as shown in Fig. 4
Fig. 4
Fig. 2
Fig. 3
1/4-in.×12-mm truss head screw with locking
washers (BB) 4 x
1/4-in.x12-mm truss head screw with
locking washers (BB) 2 x
1/4-in.x12-mm truss head screw with locking
washers (BB) 4 x
BB E
A
G
A
BB
BB
G
F

8
4. Drawer Clapboard assembly
Insert the drawer clapboard (Q) into the slot which under
the first line of glides, attached the clapboard with two
5/32-in. x 10-mm truss head screw with locking
washers (CC) as shown in Fig.5.
5. Firebox Assembly
Remove the firebox with main lid (H) from the carton
and carefully place onto the grill cart as shown in Fig. 6
Note: Take care when moving the firebox assembly
as the bottom flanges can be bent, which would misalign
the holes.
Attach the firebox with main lid (H) to the grill cart using
four 1/4-in. x 12-mm truss head screw with locking washers(BB)
Note: Two screws and two washers for each side of cart
as shown in Fig. 7.
Screw the back of firebox using two 1/4-in. x 12-mm truss
head screw with locking washers (BB) as shown in Fig. 7.
Note: To screw all the above screws from outside to inside.
Grill cart
Q
CC
BB
Fig. 5
CAUTION The firebox with main lid is heavy
and will require two or more people to lift and
position onto grill cart. Failure to do so may result
in back injury.
1/4-in. x 12-mm truss head screw with
locking washer (BB) 6 x
Fig. 6
Grill cart
H
5/32-in.x10-mm truss head screw with
locking washers (CC) 2 x
Fig. 7
H

9
6. Charcoal Tray and Drawers Assembly
Insert the charcoal tray (J), drawer A (K) and drawer B
(L) to the glides. and then push them in as shown in Fig. 8.
7. Charcoal Handle Assembly
Remove the charcoal handle (I) from the carton, and then screw it
into the hole on the charcoal door by turning the handle clockwise
as shown in Fig. 9.
8. Right Side Shelf Assembly
Loose the two screws on the right panel of firebox as shown
in Fig.10.
Fig. 9
Fig. 10
Fig. 8
J
K
L
I

10
Align the bottom key holes on right side shelf (O) with two
loosened screws, and tighten these two screws as shown
in Fig. 11.
.
Use three 1/4-in. x 15-mm truss head screws with locking
washer (AA) and three 1/4-in. Flat Washer(DD), to keep
the right side shelf(O) in place.
Note: Screw the three 1/4-in. x 15-mm truss head
screws with locking washer (AA) to align the right side
shelf from inside to outside. Screw the two screws on the
right panel of firebox from outside to inside.
9. Left Side Shelf Assembly
Repeat step 8 for the left side shelf.
10. Push Bar Assembly
Take out the push bar (M) from carton, align it to the left
flange of left side shelf with two1/4-in. x 12-mm screw
with locking washers (BB) as shown in Fig. 13.
Note: These two screws are tighten from under the
left side shelf.
Fig. 13
Fig. 11
Fig. 12
1/4-in. x 15-mm truss head screw with locking
washer (AA) 3 x
1/4-in. Flat Washer(DD) 3 x
1/4-in. x 12-mm truss head screw with
locking washers (BB) 2 x
O
M
BB
AA
DD
O