Nexgrill 720-0324 User manual

STAINLESS STEEL GAS GRILL
USE AND CARE GUIDE
MODEL NO:720-0324 ®
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE.

MESSAGE TO OUR CONSUMERS
Thank you for selecting our stainless steel gas grill.
Because this appliance contains features which may not found on other grills, we recommend that you read this
entire booklet before your first use. Keep it in a handy place as it has answers to questions that may occur
during future use.
Please read this booklet carefully and be sure your gas grill is properly assembled, installed and maintained. Failure to
follow these instructions could result in serious bodily injury and/or property damage. This gas grill in intended for
outdoor use only and is not intended to be installed in or on recreational vehicles or boats.
NOTE TO INSTALLER: Leave these instructions with the consumer after installation.
NOTE TO CONSUMER: Retain for future reference.
TABLE OF CONTENTS
SECTION ONE
Precaution ……………………………. 1
Placement of the grill ………………… 3
SECTION TWO
Assembly instructions ………………... 4
SECTION THREE
Gas hook-up ………………………… 20
Leak testing ……….……………….....22
Installer final check list ………………22
Operation instructions ………………..23
Grill lighting instructions …………… 24
SECTION FOUR
Using side burner …………………… 25
SECTION FIVE
Care and maintenance …………………. 26
Lighting Illustration…………………… 27
To match light the grill………………….29
Care and maintenance……………… ….30
Troubleshooting ……………………….. 30
SECTION SIX
Enlarge view …………………….…….. 32
Parts list ……………………………….. 33
Ordering parts ………………………….. 35
Grill hints ………………………………. 38
SECTION SEVEN
Grill cooking chart …………………… 35
SECTION EIGHT
Grill recipe suggestions ……………….. 38
SECTION NINE
Warranty ………………………………. 41

PRECAUTIONS
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, immediately call your gas
supplier.
WARNING
Do not try to light this appliance without first
reading the “LIGHTING INSTRUCTIONS”
section in this manual.
FOR YOUR SAFETY
1. Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance..
TESTED IN ACCORDANCE WITH ANSI Z21.58
/ CGA 1.6 STANDARD FOR OUTDOOR
COOKING GAS APPLIANCES. THIS GRILL IS
FOR OUTDOOR USE ONLY.
Check your local building codes for the proper
method of installation. In the absence of local codes,
this unit should be installed in accordance with the
National Fuel Gas Code ANSI Z223.1/NFPA 54,
ANSI/NFPA 58 OR CGA B149.1 Natural Gas and
Propane Installation Code, and the National Electrical
Code, ANSI/NFPA 70, or the Canadian Electrical
Code, CSA C22.1.
CALIFORNIA PROPOSITION 65-WARNING
The burning of gas fuel generates some by-products,
which are on the list of substances, which are known by
the State of California to cause cancer or reproductive
harm. California law requires businesses to warn
customers of potential exposure to such substances. To
minimize exposure to these substances, always operate
this unit according to the use and care manual, ensuring
you provide good ventilation when cooking with gas.
SAFETY PRACTICES TO AVOID
PERSONAL INJURY
When properly cared for, your stainless steel grill will
give safe, reliable service for many years. However,
extreme care must be used since the grill produces
intense heat and that can increase accident potential.
When using this appliance basic safety practices must
be followed, including the following:
Read this Care and Use Manual carefully and
completely before using your grill to reduce the risk of
fire, burn hazard or other injury.
Do not repair or replace any part of the grill unless
specifically recommended in this manual. All other
service should be referred to a qualified technician.
CHILDREN SHOULD NOT BE LEFT ALONE OR
UNATTENDED IN AN AREA WHERE THE GRILL
IS BEING USED. NEVER ALLOW THEM TO SIT,
STAND OR PLAY ON OR AROUND THE GRILL AT
ANY TIME.
1

PRECAUTIONS
Moist or damp potholders on hot surfaces may cause
burns from steam. Do not use a towel or bulky cloth in
place of potholders. Do not let potholders touch hot
portions of the grill rack.
Grease is flammable. Let hot grease cool before
attempting to handle it. Avoid letting excess grease
deposits collect in the grease tray at the bottom of the
grill’s firebox. Clean often.
DO NOT USE ALUMINUM FOIL TO LINE THE
GRILL RACKS OR GRILL BOTTOM. This can severely
upset combustion air flow or trap excessive heat in the
control area.
For proper lighting and performance of the burners keep
the burner ports clean. It is necessary to clean them
periodically for optimum performance. The burners
will only operate in one position and must be mounted
correctly for safe operation.
Clean the grill with caution. Avoid steam burns; do not
use a wet sponge or cloth to clean the grill while it is hot.
Some cleaners produce noxious fumes or can ignite if
applied to a hot surface.
INSECT WARNING!!! Spiders and insects can nest in
the burners of this and any other grill, and cause the gas
to flow improperly. This is a very dangerous condition
which can cause a fire to occur behind the valve panel,
thereby damaging the grill and making it unsafe to
operate. Inspect the grill twice a year.
Be sure all grill controls are turned off and the grill is
cool before using any type of aerosol cleaner on or
around the grill. The chemical that produces the
spraying action could, in the presence of heat, ignite or
cause metal parts to corrode.
DO NOT STORE ITEMS THAT ATTRACT CHILDEN
AROUND OR BELOW THE GRILL OR IN THE CART.
NEVER ALLOW CHILDREN TO CRAWL INSIDE OF
THE CART.
Never let clothing, pot holders or other flammable
materials come in contact with or too close to any
grate, burner or hot surface until it has cooled. Fabric
may ignite and result in personal injury.
For personal safety, wear proper apparel. Loose fitting
garments or sleeves should never be worn while using
this appliance. Some synthetic fabrics are highly
flammable and should not be worn while cooking.
Only certain types of glass, heat-proof glass ceramic,
earthenware, or other glazed utensils are suitable for
grill use. These types of materials may break with
sudden temperature changes. Use only on low or
medium heat settings according to the manufacturer’s
directions.
Do not heat unopened food containers as a build-up of
pressure may cause the container to burst.
Use a covered hand when opening the grill lid. Never
lean over an open grill.
WHEN LIGHTING A BURNER, ALWAYS PAY
CLOSE ATTENTION TO WHAT YOU ARE DOING.
BE CERTAIN YOU ARE TURNING THE IGNITER
LABELED FOR THE BURNER YOU INTEND ON
USING.
When using the grill, do not touch the grill rack,
burner grate or immediate surroundings as these
areas become extremely hot and could cause burns.
Use only dry potholders.
2

PRECAUTIONS
Do not use the grill for cooking excessively fatty
meats or products which promote flare-ups. Do not
operate the grill under unprotected combustible
construction. Use only in well ventilated areas. Do not
use in buildings, garages, sheds, breezeways or other
such enclosed areas. THIS UNIT IS FOR OUTDOOR
USE ONLY.
Keep the area surrounding the grill free from
combustible materials, trash, or combustible fluids and
vapors such as gasoline or charcoal lighter fluid. A
minimum of 24” clearance away from combustible
material. Do not obstruct the flow of combustion and
ventilation air. If the unit is stored indoors ensure that
it is cool. If propane is used, the cylinder must be
unhooked and the propane cylinder stored outside in a
well ventilated area, out of the reach of children.
DO NOT USE BRIQUETTES OF ANY KIND IN THE
GRILL.
This stainless steel grill is designed for optimum
performance without the use of briquettes. Do not place
briquettes on the radiant as this will block off the area
for the grill burners to vent. Adding briquettes can
damage ignition components and knobs, and void the
warranty.
Keep the back of the cart free and clear from debris.
Keep any electrical supply cord, or the rotisserie motor
cord away from the heated areas of the grill.
Never use the grill in extremely windy conditions. If
located in a consistently windy area (oceanfront,
mountaintop, etc.) a windbreak will be required (see
below). Always adhere to the specified clearance.
NEVER USE A DENTED OR RUSTY PROPANE TANK.
PLACEMENT OF THE GRILL
CLEARANCE
To Non-Combustible Construction
A minimum of 3” clearance from the back of the grill
to non-combustible construction is required for the lid
to open fully.
DO NOT INSTALL THIS UNIT INTO COMBUSTIBLE
ENCLOSURES!
LOCATION
When determining a suitable location take into
account concerns such as exposure to wind, proximity
to traffic paths and keeping any gas supply lines as
short as possible.
Locate the grill only in a well-ventilated area. Never locate
the grill in a building, garage, breezeway, shed or other such
enclosed areas without an approved ventilation system.
During heavy use, the grill will produce a lot of smoke. After
the grill is placed in a suitable position, lock the wheels
according to the sticker located beneath the right door. Keep
any electrical supply cord and the fuel supply hose away from
any heated surfaces. Storage of an outdoor gas cooking
appliance indoor is permissible only if the cylinder is
disconnected and removed from the appliance.
This outdoor cooking gas appliance shall be used only
outdoors and shall not be used in a building, garage or any
other enclosed area. This appliance is not intended to be
installed on recreational vehicles and/or boats.
3

ASSEMBLY INSTRUCTIONS
PLEASE READ THE INSTRUCTIONS THROUGHLY AND FOLLOW STEP
BY STEP.
HARDWARE PACK DESCRIPTION SPECIFICATION QUANTITY
A TRUSS HEAD SCREW 1/4”X10MM 4PCS
SPLIT LOCK 1/4” 4PCS
B TRUSS HEAD SCREW 5/32”X10MM 9PCS
SPLIT LOCK 5/32” 9PCS
C TRUSS HEAD SCREW 1/4” X15MM 49PCS
SPLIT LOCK 1/4” 49PCS
REMARK: EXTRA 2 MORE PICECS IN EACH HARDWARE PACK.
WRENCH: USED FOR STEP 10 SIDE BURNER VALVE ASSEMBLY.
Pack A Pack B Pack C
STEP 1: Take out bottom panel and four casters from the carton, Use 16 pcs of truss head screw
(1/4”x15mm ) and 16 pcs of 1/4”split lock (pack C) to lock two casters which in the right of bottom
panel and two casters with brake which in the left of bottom panel as shown figure below.
Pack C
4

ASSEMBLY INSTRUCTIONS
STEP 2: Use 6 pcs of truss head screw(1/4”x15mm ) and 6 pcs of split lock (pack C), to
Screw the left and right side panels to the bottom panel as shown figure below. When installing
the right and left panel, the flat side must face outside.
Pack C
STEP 3: Assemble back panel to bottom panel with 3 pieces of truss head screw(1/4”x15mm ) and
3pieces of 1/4” split lock (Pack C). When installing the back panel, the flat side must face outside.
5

ASSEMBLY INSTRUCTIONS
STEP 4: Assemble the two side panels with 2 pcs of truss head screw (1/4”x15mm)and
2 pieces split lock (pack C) to the back panel.
Pack C
Pack B
6
Step 5: Assemble the leg of clapboard with 2pcs of truss head 5/32”x10mm screw and 2pcs split lock
(pack B ) to the bottom panel as shown figure below.

STEP 7:Assemble the cart frame with 4 pieces of 1/4”x15mm truss head screw and 4 pieces of split
lock(pack C) to the side panels as shown figure below.
Step 6: Assemble the clapboard with 2pcs of 5/32”x10mm truss head screw and 2pcs of split lock
(Pack B) to the leg as shown figure below.
Pack C
Pack B
ASSEMBLY INSTRUCTIONS
7

ASSEMBLY INSTRUCTIONS
Step 8:Use 2pcs of 5/32”x10mm truss head screw and 2pcs split lock(pack B) to screw the
Individual panel to the back panel as shown figure below.
Step 9: Fix the individual panel with 2pcs of 5/32”x10mm truss head screw and 2pcs split lock(pack B)
to the cart frame as shown figure below.
Pack B
8