NJ Cassette Cooker Series User manual

MODEL: GAS BBQ
ONLY FOR OUTDOOR USE
NOT FOR COMMERICAL USE
IMPORTANT: Read these instrucons for use carefully.
Familiarize yourself with the appliance before connecng it to
Its gas container. Keep these instrucons for future reference.

CARBON MONOXIDE HAZARD
ONLY USE IN WELL-VENTILATED AREAS.
Using this appliance in an enclosed space may
cause death.
Do not use in caravans, tents, marine cra, cars,
mobile homes or similar locaons.
FOR YOUR SAFETY
If you smell gas:
1.Do not aempt to light appliance.
2.Exnguish any open flame
3.Disconnect from fuel supply
4.Evacuate area, call for professional help
FOR YOUR SAFETY
Do not store or use gasoline or other liquids
with flammable vapours in the vidnity of this
or any other appliance.
This stove s equipped for use with butane
gas only. Do not aempt to operate this stove
at temperatures below freezing( 0 degrees C).
5-1
DANGER
This appliance shall only be used in an above ground open air
situaon with natural venlaon, without stagnant areas where
gas leakage and products of combusion are rapidly dispersed by
wind and natural convecon.

This appliance shall only be used with a butane gas cartridge cerfied to EN417 or UL147B
IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPE OF GAS CONTAINERS.
*REMOVE ANY TRANSIT PROTECTION MATERIAL.
4
2
3
6
5
8
9
1.Make sure the control knob is turned all the way clockwise to the “OFF”
posion. (Fig.1)
2.Open the gas cartridge compartment and slightly push the gas canister
inside by align slot of the gas cartridge with the valve tab.(Fig.2)
DO NOT use this appliance if it has damaged or worn seals.
DO NOT use this appliance if it is leaking, damaged or dose not operate properly.
3.Turn on the knob to “ON”positon.(Fig.3)
NOTE: if there is a leak from your appliance(smell of gas ) and you can not
stop the gas flow, remove the appliance to a well-venlated locaon away
from any ignions source. Check for leaks using soapy water.
Do not try to detect leaks using a flame.
CAUTION:when connecng or disconnecng the gas cartridge, be sure that
no external sources of ignion are present.
5.HOW TO REMOVE THE GAS CARTRIDGE
Turn the knob to the “off” posion to exnguish the fire.
Remove the gas cartridge by li up the boom of the gas bole, and take it out carefully.
4.HOW TO REPLACE A NEW GAS CATRIDGE
Check that burners are exnguished before disconnecng the gas cartridge. Be careful the gas cartridge may be hot.
Check the seals before connecng a new gas cartridge to the appliance.
Repeat above steps from 1-3.
WARNING
THE OPENINGS AT THE BASE OF THE BURNER PROVIDE AIR FOR COMBUSTION, THEY
SHOULD NEVER BE OBSTRUCTED. IF THE FLAME BECOMES SIGNIFICANTLY ORANGE CHECK
THESE OPENINGS FOR A BLOCKAGE.
IF THE APPLIANCE CAN NOT BE ADJUSTED TO PERFORM CORRECTLY IT SHOULD NOT BE
USED UNTIL SERVICED OR REPAIRED.
2. FITTING THE GAS CTRTRIDGE
1. NAME OF SPARE PARTS
5-2
1
1. Flat pan
2. Fluid tray
3. Pan supporters
4. Gas can side cover
5. Overpressure safety device
6. Switch knob
7. Heat dissipaon hole
8. U shape burner
(Fig.1)
(Fig.3)
(Fig.2)
SLOT
VALVE TAB

4. LIGHTING THE STOVE
5-3
(Fig.4)
(Fig.5)
*Never leave the stove unaended when hot or when in use.
*Do not modify this appliance
*CAUTION: accessible parts may become very hot.
*Keep young children away from the appliance at all mes.
*Keep the stove area clear and free of combusble materials, gasoline one other flammable vapors and liquids.
* Do not obstruct the flow of venlaon and combuson air around he appliance.
*It is recommended to service yearly if the injector gets blocked, it should be replace by an authorised person.
8. MAINTENANCE AND CUTIONS
*In case the pressure sensive safety device triggers it means that a crical pressure level is reached in the
cartridge so the appliance must not be used before it has completely cool down.
Do not bypass the pressure sensive safety device
*Remove the gas cartridge from the compartment.
If the stove had been in use and was working properly, the butane can should be cold to touch.
Go back to the “Precauons” on the stove use secon and
confirm if you are using he stove correctly.
*Turn the ignion knob to “IGNITION”to release any excess gas inside the regulator.
Repeat the 3 steps of inserng the gas cartridge aer it has cooled down.
IMPORTANT WARNING: IF YOU CAN NOT FIND THE CAUSE OF THE SAFETY DEVICE ACTIVATION,
DISCONINUE USE AND CONTACT US FOR CUSTOMER SERVICE.
7. THE AUTOMATIC SAFETY SHUT-OFF DEVICE ACTIVATION
1.Replace the cap on the gas cartridge aer removing it from the unit. Store upright in a cool dry place.
2.Make sure the burner is cool to touch before packing unit away.
3.Any service or any necessary replacement parts can be obtained from local distributor.
6. AFTER USE
Flame can be controlled by turning eh ignion knob between the “INGITION” and “OFF” posion.
EXTINGUISHING
1.Turn the ignion knob to “OFF”to shut off fuel supply (Fig.5), Wait unl the flame
is fully exnguished before performing the next step.
NOTE:Do not lever the gas cartridge inside the unit when not in use.
5. TO ADJUST HEAT
NOTE: Closed the cartridge cover before lighng. Not closing the cover can cause the cartridge
to overheat.
*Turn the control knob counter clockwise unl you hear a click indicang that
a spark has been produced.(Fig 4)
*If the stove dose not light, turn the control knob back to OFF posion and repeat.
*If aer three failed aempts, the stove dose not light, turn the control knob to the “OFF”
posion and move the cartridge lever to the “UNLOCK” posion.
*Open the cartridge cover and remove the cartridge, Shake the cartridge to see if it is empty.
If empty, replace the cartridge and begin from Fig.1

5-4
*Keep your stove dean using a sff brush to clean the burner head.
*Use a so cloth to dean greasy parts of the stove with a soap and water.
*Keep the igniter and the burner head gap free from debris for easy lighng.
*Clean stove frequently to avoid grease build up and as necessary.
*Burner flame should be blue with hint if yellow p.
9. CAUTIONS FOR APPLIANCE
1).Do not use and put it on the inducon or ceramic cooker
2).Do not use it on household stove area, nearby fire sources and any
high temperature environment.
3).Do not use in narrow and small spaces without air circulang.
(it may causes carbon monoxide poisoning )
4).Do not use it on any unstable locaons or places that
easy to fall to the ground.
5).Do not close to any heat resource equipments or machine
(Please keep at least 2 meters from open fire)
6).Do not burning empty pans on the stove.
7).Do not connect 1 more stove for cooking
8).Do not use under overheat environment.
9).Avoid place of heavy wind.
10).Do not move or slope the stove during cooking (it may fall and
causes scald or fire accident)
11). Do not use under vulnerable place that may drop objects.
12). The appliance shall be operated on a horizontal surface non likely
to impair its operaon (free from dry grass, sand,…)
14). Do not leave the places while flame is on.
15). Do not leave children alone with the burning stove.
16). Do not use the stove nearby inflammable stuff.
17). Do not place any spare gas canister or hair spray close to the stove.
18). Do not place gas cartridge under the appliance during transportaon,
storage and operaon.
19).The appliance shall be used away from flammable materials,like
curtains ,wooden furniture or other objects that are easy to catch fire.
1. Read the cauon printed on the gas cartridge before using.
2. Never store butane gas cartridge near a heat source, open flame or any source of ignion.
3. Check the cartridge is empty before remove it.
4. Never store cartridge in direct sunlight.
5. keep cartridge away from children when not use.
6. Never re-fill the gas cartridge.
7. Gas cartridge shall be changed in a well-venlated locaon,Preferably outside away from people and any sources of ignion,
Such as naked flame, pilot flames, electric heaters or other equipment.
8. Gas cartridge can be purchased at most sporng goods and camping stores.
Gartridges must be butane gas. The gas cartridge need approved by EN 417 or UL 147B.
10. CAUTIONS FOR USE CARTRIDGE
11. CLEANING
* Take out the cartridge before cleaning the appliance
* Use damp dishcolth with a cleanser to clean the appliance, then wipe the appliance with a dry dishcloth
* If the holes around the burner are blocked, use a toothpick to wipe off the dirness.
* Clean the gas container inside with the brush.
* Visually check the general aspect of the appliance and clean it if necessary and remove any contaminaon
(sand, insects, grass, …).
Keep safety distance during use
Keep more than 50cm from
wooden furniture and wall,
Keep more than 150cm from
ceiling, shelve and electric
equipment.

5-5
Product name: Grill gas stove
Model numebr: GAS BBQ
Ignion type: Piezo-electric
Dimension: 460x345x128mm
Single stove weight: 2.1 kgs
Flat pan weight: 5.1 kgs
Normal gas consumpon: 160g/h
Heat output: 2.2kW（Hs）
Type of gas : Butane gas
Ingector size: 0.6mm
13. SPECIFICATE
12.HOW TO DEAL WITH PROBLEMS
Made for: Fontron Ltd, Bulgaria; www.fontron.com
Distributor: NJ Commerce Ltd
Unit C2, Old Church Road, CV6 7NB Coventry, UK
www.nj-commerce.com