OFYR 90 User manual

MANUAL
OFYR BUTCHER BLOCK STORAGE 90

2OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
TABLE OF CONTENT
1. INTRODUCTION 3
1.1 OFYR® Butcher Block Storage 90, parts and intended use 3
2. SAFETY AND SETUP INSTRUCTIONS 3
3. DISCLAIMERS 4
3.1 Safety and setup-, intended use- and maintenance instructions/tips 4
3.2 Corten steel 4
3.3 Black-coated steel 4
4. WARRANTY TERMS PER ELEMENT 5
5. WOODEN BLOCKS 5
5.1 Intended use 5
5.2 Maintenance tips 6
6. CERAMIC BLOCKS 6
6.1 Intended use 6
6.2 Maintenance tips 6
7. ASSEMBLY INSTRUCTIONS 7
7.1 Butcher Block Storage 90 Corten 7
SYMBOLS AND ICONS
Danger! Risk of serious or deadly injury or severe product damage.
Warning! Risk of injury or product damage.
Notice! Useful information.

3OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
EN
1. INTRODUCTION
THANK YOU SO MUCH FOR BUYING AN OFYR®PRODUCT. THIS MANUAL CONTAINS
ASSEMBLY INSTRUCTIONS, WARRANTY CONDITIONS, AND ADDITIONAL INFORMATION
ABOUT YOUR OFYR®BUTCHER BLOCK STORAGE 90.
1.1 BUTCHER BLOCK STORAGE 90, PARTS AND INTENDED USE
OFYR®Butcher Block Storage 90 includes a Teak wooden or Ceramic dark grey chopping board for
food preparation, handy accessories tray and options for under-counter wood storage.
OFYR®Butcher Block
Storage Corten 90
Teak wood
OFYR®Butcher Block
Storage Black 90
Teak wood
OFYR®Butcher Block
Storage Corten 90
Ceramic Dark Grey
OFYR®Butcher Block
Storage Black 90
Ceramic Dark Grey
2. SAFETY AND SETUP INSTRUCTIONS
Due to the considerable weight of the elements unpacking and placing of the product
should be done by at least 2 people.
While the corrosion is still superficial, the Corten steel elements may cause orange
stains on clothes, skin, and the surface they stand on. When it rains, corrosive water
may also run off these elements, which may permanently stain light-toned stone or
wooden surfaces.
The OFYR®Butcher Block Storage 90 Black is more sensitive to damage during setup
and use because of its coating.
Only place your OFYR®Butcher Block Storage 90 on a hard, leveled and stable surface.
Do not shift the OFYR®Butcher Block Storage 90 units after they are set up. This may
cause damage to the adjustable feet or the rivet nuts with which they are attached.
Do not use the adjustable feet to change the overall height of the OFYR®Butcher
Block Storage 90. The units may become unstable if the adjustable feet are extended by
more than 10 mm.
We strongly advise against leaving the Teak wooden board on the table outdoors.
This because wood is a natural product and is always liable to warp somewhat.

4OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
3. DISCLAIMERS
3.1 SAFETY AND SETUP-, INTENDED USE- AND MAINTENANCE INSTRUCTIONS/TIPS
We are not liable for any injuries or damages as a consequence of not following our Safety and setup-,
intended use- and maintenance instructions/tips.
3.2 CORTEN STEEL
OFYR®Butcher Block Storage 90 Corten are made of Corten steel: a metal with a natural layer of
corrosion that protects against rust perforation. OFYR®Butcher Block Storage 90 Corten come with
the additional service that the corrosion process has already started by the time they are delivered.
Upon delivery, it takes another 6-12 months for the initial corrosion to turn into a fully protective
layer.
The unit’s color may change over time as the corrosion process may not yet have fully
unfolded. We are not liable for any color changes.
Any Corten steel components that are less corroded than others upon delivery are
not eligible for replacement. All components will corrode naturally over time under
influence of the weather. We are not liable for any differences of corrosion between
different elements.
While the corrosion is still superficial, the Corten steel elements may cause orange
stains on clothes, skin, and the surface they stand on. When it rains, corrosive water
may also run off these elements, which may permanently stain light-toned stone or
wooden surfaces. We are not liable for stains as a consequence of corrosion.
3.3 BLACK-COATED STEEL
Please note that the OFYR®Butcher Block
Storage Black has a coating and is thus more
sensitive to damage during setup and use.
We are not liable for any damage or
consequential damage resulting from the
setup or use of your OFYR®Butcher Block
Storage 90 Black. For small repairs the
OFYR®Butcher Block Storage 90 Black
comes with a free Repair Bottle.
Due to weather and sunlight the coating can be subject to discolouration.
We are not liable for such discolouration.

5OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
EN
4. WARRANTY TERMS PER ELEMENT
A limited lifetime guarantee applies to the material and construction of the OFYR®Butcher Block
Storage 90 for the original buyers or owners, provided that they purchased their unit from an
authorised dealer and registered their warranty in the required manner through OFYR Club at
www.ofyr.club.
This warranty covers manufacturing defects. It applies to the original buyers or owners of
an OFYR®Butcher Block Storage 90, provided that
•They purchased their unit from an authorized dealer
•They assembled, used and maintained the OFYR®Butcher Block Storage 90
according to the instructions in this manual.
NOT COVERED BY WARRANTY
•Wear, corrosion, deformation and discolouration of parts exposed to fire;
•Corrosion and discolouration caused by external influences;
•Visual irregularities inherent to the manufacturing process.
•Damages caused by not following our safety and setup-,
intended use and maintenance instructions/tips.
B2C B2B
Corten steel parts 5 years 3 years
Coated parts 2 years 1 year
Wooden blocks 2 years 1 year
Ceramic blocks 2 years 1 year
5. WOODEN BLOCKS
All wooden blocks are made from Teak wood. Teak’s high oil content, high tensile strength and tight grain
make it particularly suitable where weather resistance is desired.
5.1 INTENDED USE
•Wood is a natural product and should therefore be stored indoors.
•Do not use the wooden boards as a chopping board.
Using sharp objects causes irreparable damage.
•Do not use heavy objects as exerting large forces on the wooden block
can cause irreparable damage.

6OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
5.2 MAINTENANCE TIPS
• Before the rst use: Clean the worktop thoroughly with a mild detergent.
•Use a damp cloth and mild detergent for daily cleaning.
Make sure to clean the block after every use.
•Cleaning of persistent stains: use a damp cloth or a sponge (no scourer)
with a mild detergent.
•Clean the wood in the direction of the nerve to retain the quality of the material.
•Dry the block after cleaning.
•All teak wooden boards have been treated with vegetable oil in order to protect them against
dirt and humidity. We recommend that users of these products will also treat these boards at
least once a year with such oil and in case of frequent use more often.
Do not clean the wooden boards with corrosive substances or clean them in a dishwasher.
After use the wooden blocks should be stored indoors, in a dry place with low humidity.
Large dierences in temperature and humidity may cause the wood to warp.
6. CERAMIC BLOCKS
Ceramics are industrially manufactured, baked products. A print is added to the top layer of clay, the main
component, which then is baked on an extremely high temperature. Distinctive element of ceramics are its
very practical characteristics: it is hygienic and resistant to stains, scratches and heat.
6.1 INTENDED USE
•Ceramics are weather proof and can be stored outdoors on a permanent basis.
•Ceramics are a very compact and tough mass, making it relatively vulnerable for
impact damaging. Therefore, be careful with for example heavy objects,
because the impact of these falling on a worktop might cause irreparable damage.
•We recommend using a cutting board to prevent your knives from getting blunt.
•Avoid contact with acetone and with extremely aggressive cleaning agents
such as metal cleaners, drain cleaners and other products with a
pH-value <2 or >12.
•Never stand on the ceramic block.
6.2 MAINTENANCE TIPS
• Before the rst use: remove possible glue residues with a plastic scraper
and clean the worktop thoroughly with a mild detergent.
•Use a damp cloth with a mild detergent for daily cleaning.
Make sure to clean the block after use.
•Clean the block more intensive a few times a year.
• Cleaning of persistent stains: use a mild detergent with a damp cloth
or sponge (no scourer).
•Do not clean the blocks in the dishwasher.

7OFYR®MANUAL - OFYR® BUTCHER BLOCK STORAGE 90
EN
A
PARTS LIST
A. Wooden/Ceramic board
B. Butcher Block Storage 90 base
C. Tooltray
D. Tooltray Skewer
E. Rubber feet
F. Skewer feets
G. Help card
B
2x
7. ASSEMBLY INSTRUCTIONS
7.1 BUTCHER BLOCK STORAGE 90
C
1x2x
D
4x 4x 1x
E F G
D
choose the right place for
your tooltray
G
4x 4x
E
1x
F
G

For further information, please contact one of
our ocial distributors or dealers.
www.ofyr.com/store-locator
Copyright OFYR.
All rights reserved.
OFYR Global B.V.
Gewenten 43A
4704 RE Roosendaal
Nederland
[phone]
[email protected]
www.ofyr.com
DEC 2020 - V01
The design of some OFYR products have EU registration
under no 02580431-0001/2, no 003122373-0001 and
no 007454590-0001. US Design Patents are registered
under no US D798099 S and no US D830095 S.
Your language
not found? Please
take a view with
this QR-code