Ohio Medical 233625-ES User manual

255564 (Rev. 1) 02.2015

255564 (Rev. 1) 02.2015

Page 3
1 General Information
This manual is copyrighted, all rights reserved. It may not, in whole or in part, be copied,
photocopied, reproduced, translated, or reduced to any electronic medium or machine
readable from without prior consent in writing from Ohio Medical Corporation . It may not
be distributed through the internet or computer bulletin board systems without prior
consent from Ohio Medical Corporation .
1.1 Document Introduction
This manual provides factory prescribed installation and maintenance procedures for an
Ohio Medical Corporation compressed air dryer. The procedures illustrated in this
document are only to be performed by authorized personnel. For further information
regarding the procedures outlined in this document contact Ohio Medical Corporation
before proceeding.
Read this document carefully before attempting to install or operate the dryer. This
document should be permanently available at the dryer installation site and be kept
document should be permanently available at the dryer installation site and be kept
in an easily accessible place alongside the dryer.
Ohio Medical Corporation
1111 Lakeside Drive
Gurnee, Il. 60031
Ph: 1-800-448-0770
Fax: [phone]
www.ohiomedical.com
1.2 Support
CAUTIONS: Indicate any situation or operation that may result in
injury to the user, damage to the product, or render the product
unsafe.
NOTES: Highlight important sections of information where
particular care and attention should be paid.
255564 (Rev. 1) 02.2015

Page 4
1.3 Warranty Guidelines
1.4 Packaging
All products are supplied with a 2 year manufacturer’s warranty from the date of purchase,
when purchased with or without an ES (Energy Saving) system and installed and
maintained in accordance with the manufacturer’s guideline. Only genuine service parts
should be used and no modifications made. For further information please contact
Ohio Medical Corporation .
Damaged Packaging
Check immediately to established whether damage has occurred to the external
packaging and if the damage extends to the product inside.
If there is damage to a product, contact the the relevant supplier immediately.
In no circumstances must a damaged product be used in operation.
Using damaged products can lead to irreparable functional faults or
cause serious physical harm.
The support packing box permits limited longitudinal stacking, however
the central section of the packing box should not be considered
load bearing.
255564 (Rev. 1) 02.2015

Page 5
255564 (Rev. 1) 02.2015

233625-ES thru 233627-ES 233628-ES thru 233635-ES
ISO 8573
Minimum working pressure
Maximum working pressure
Power Supply
Minimum inlet working temperature
Maximum inlet working temperature
Ambient Temperature
I
IP Rating
Power
Noise
ISO 8573 - 2: 2001 Quality Classes
Class 2: Water: -40 C
Class 2: Dirt: 1 micron
o
ISO 8573 - 1: 2001 Quality Classes
Class 2: Water: -40 C
Class 2: Dirt: 1 micron
o
58 psig (4 bar)
IP54 / NEMA 3
Specification
38W
<80dB (A)
232psig (16 bar)
100 - 240v AC / 50 - 60 Hz
contact [e-mail]
o o oo
122 F (50 C)
oo
34 - 122 F (1-50 C)
o
o
50 F (10 C)34.7 F (1.5 C)
Page 6
255564 (Rev. 1) 02.2015

Page 7
255564 (Rev. 1) 02.2015

17
26
41
(1097)
255564 (Rev. 1) 02.2015

Page 9
255564 (Rev. 1) 02.2015

Page 10
255564 (Rev. 1) 02.2015

Page 11
255564 (Rev. 1) 02.2015

Page 12
255564 (Rev. 1) 02.2015

Page 13
255564 (Rev. 1) 02.2015

Page 14
255564 (Rev. 1) 02.2015

Page 15
255564 (Rev. 1) 02.2015

Page 16
Only certified Ohio Medical approved replacement parts should be used.
255564 (Rev. 1) 02.2015

Page 17
Only certified Ohio Medical approved replacement parts should be used.
255564 (Rev. 1) 02.2015

MODEL
233625-ES
233626-ES
233627-ES
233628-ES
233629-ES
233630-ES
233631-ES
233631-ES
233632-ES
233633-ES
233634-ES
233635-ES
NDK-030 + NVK050
NDK-040 + NVK050
NDK-050 + NVK050
NVK090 (EVK130 + CVK130 + IVK90)
NVK090 (EVK130 + CVK130 + IVK90)
NVK090 (EVK130 + CVK130 + IVK90)
NVK090 (EVK130 + CVK130 + IVK90)
NVK090 (EVK130 + CVK130 + IVK90)
NVK130 (EVK130 + CVK130 + PVK131)
NVK130 (EVK130 + CVK130 + PVK131)
NVK130 (EVK130 + CVK130 + PVK131)
NVK130 (EVK130 + CVK130 + PVK131)
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NSK-130
NDK-030
(NDK-030 F)
NDK-040
(NDK-040 F)
NDK-050
(NDK-050 F)
NDK-060
NDK-060
(NDK-060 F)
NDK-070
(NDK-070 F)
NDK-080
(NDK-080 F)
NDK-090
(NDK-090 F)
(NDK-090 F)
NDK-010
(NDK-100 F)
NDK-010
(NDK-110 F)
NDK-010
(NDK-120 F)
NDK-010
NDK-010
(NDK-130 F)
SERVICE B SERVICE C
SERVICE A
Without Pre-Filter Element
(With Pre-filter Element)
255564 (Rev. 1) 02.2015

Page 19
255564 (Rev. 1) 02.2015

Page 20
255564 (Rev. 1) 02.2015