Outdoor Gourmet FSOGBG4302 Owner's manual

Customer Service: [phone]
7:00 am to 12:00 am Central Standard Time (daily)
Live Chat at: www.academy.com
Email: [e-mail]
(Made in China)
Please keep this instruction manual for future reference
Assembly Instructions &
User’s Manual
Double Basket Jet Fryer
FSOGBG4302

Table of Contents
Warnings………………………………………………………………..2-8
Tools, hardware, and Parts………………………………….……… -9
Exploded View……………………………………………………….....11
Assembly Instructions……………………………………………… 12-19
Operating/Cooking Instructions..................................................20-21
Care and Maintenance…………………………………………….......22
Frequently Asked Questions............................................................23
Warranty………………………………………………………………….23
Note: Before beginning assembly of product, make sure all
parts are present. Compare parts with package content list
and hardware contents. If any part is missing or damaged
do not attempt to assemble the unit. Contact customer
service for replacement parts
Page 1 of 23
10
.

DANGER
If you smell gas:
•Shut off gas to the appliance.
•Extinguish any open flame.
•If odor continues, keep away from the appliance and immediately call your fire department
•Failure to follow these instructions could result in fire or explosion which could cause property
damage, personal injury or death.
DANGER
•NEVER operate this appliance unattended.
•NEVER operate this appliance within 10 ft ( 3 m) of any structure, combustible material or other gas
cylinder.
•NEVER operate this appliance within 25 ft (7.5 m) of any flammable liquid.
•Do not fill cooking vessel beyond maximum fill line.
•DO NOT fill cooking vessel beyond 4.0 gallons. If a fire should occur, keep away from the appliance
and immediately call your fire department. Do not attempt to extinguish an oil or grease fire with water.
• Never allow oil/grease to get hotter than 400°F or 204°C. If the temperature exceeds 400°F
(204°C) or if oil begins to smoke, immediately turn the burner or gas supply OFF.
•Heated liquids remain at scalding hot temperatures long after the cooking process. Never touch
cooking appliance until liquids have thoroughly cooled down.
THIS APPLIANCE IS NOT FOR FRYING TURKEYS
THIS COOKER IS FOR OUTDOOR USE ONLY
THIS APPLIANCE IS NOT INTENDED FOR COMMERCIAL USE
SAFETY SYMBOLS:
When using this appliance, basic safety precautions should always be observed. Read
and understand the meaning of these symbols before assembling and using this
appliance.
DANGER
Indicates a hazardous situation, which if not avoided, will result in death or serious injury.
WARNING
Be alert to the possibility of serious personal injury if the instructions are not followed.
CAUTION
Indicates a potentially hazardous situation, which if not avoided, could result in moderate injury.
CAUTION
The instruction manual contains important information necessary for the proper assembly and safe
use of the appliance. Read and follow all warnings and instructions before assembling and using the
appliance. Follow all warnings and instructions when using the appliance. Keep this Manual for future
reference. Contact 1-888-922-2336 should you need assembly assistance or have questions.
WARNINGS
Page 2 of 23

Model No. FSOGBG4302
Equipped for use on: Propane.
Main Max. Input Rating: 54,000
BTU/H
Certified under ANSI 21.89 - CSA 1.18 -2013 Outdoor Cooking Specialty
Gas Appliance
WARNING: FOR OUTDOOR USE ONLY. If stored indoors, detach and
leave cylinder outdoors.
WARNING: This appliance and stand comes with a supplied CSA approved
regulator which must be used with this appliance. Replace only with
regulator Model No. RYQL01.
SAVE THESE INSTRUCTIONS
Read and understand all instructions before assembling and using this
appliance.
Follow all warnings while using this appliance. Failure to follow these
instructions could result in fire or explosion causing damage to property,
injury or death.
DANGER
If you smell gas: If possible, immediately turn off gas supply to the
appliance by turning the LP tank valve clockwise (right). If this cannot be
accomplished safely, immediately get away from the appliance and
contact the fire department (e.g. 911). Extinguish any open flame, use an
approved fire extinguisher (Always have an approved extinguisher on
hand when using this product. A Class “B” dry chemical OR CO2
extinguisher or preferably a Class “K” extinguisher. Special care must be
taken to understand the manufacturers instructions and be prepared to
operate the appropriate extinguisher prior to using this appliance.) If you
continue to smell gas, immediately contact the fire department (e.g. 911)
and do not go near the appliance.
WARNINGS
Page 3 of 23

WARNINGS
1.Keep cylinders out of direct sunlight and high heat.
2.Immediately call your LP dealer or fire department should you hear, smell, or see
escaping gas from the cylinder.
3.Do not insert any type of foreign objects into the valve outlet.
Page 4 of 23
1. Do not store a spare LP-gas cylinder under or near this appliance.
2. Never fill the cylinder beyond 80 percent full；This may cause release of gas from the safety release
valve.
3 If the information in (1) and (2) is not followed exactly ，a fire causing death or serious injury may
occur.
This appliance is not intended to be installed in or on a boat.
This appliance is not intended to be installed in or on recreational vehicles.
.

WARNINGS
Page 5 of 23
1. The gas supply must be turned off at the LP-gas supply cylinder when this outdoor
cooking gas appliance is not in use.
2. Storage of this fryer indoors is permissible only if the cylinder is disconnected and
removed from the fryer.
3. Cylinder must be stored outdoors out of reach of children and must not be stored in a
building，garage，or any other enclosed area.

WARNINGS
Page 6 of 23
1. Do not connect this Fryer to any unregulated sources of propane.
2. Before each use, check the gas hose for excessive abrasion, wear, or cuts. Replace hose
assembly showing those signs. The replacement hose assembly shall be that specified
model NO. RYQL01. Inspect the hose assembly underneath the side burner and following
the regulator hose up to its connection to the gas manifold assembly.
3. Always perform the Leak Test listed below before using the Fryer for the first time. If the
cylinder has been changed, any gas components have been changed, the regulator flow-
limiting device has been actived, or after a long period of non-use.
4. Do not attempt to connect to the Fryer to the LP system of a motor home or trailer.
LP Cylinder Connections
To check your local codes，see your local LP gas dealer or natural gas company. This appliance
is not intended to be connected to a natural gas supply line.
When purchasing or exchanging a cylinder for your gas cooker, it must be constructed and marked in
accordance with the specifications for LP gas cylinders by the U.S. Department of Transportation (DOT)
or the National Standard of Canada, CAN/CSA-B339,Cylinder,Spheres And Tubes for the Transportation
of Dangerous Goods as applicable with a listed over-filling device(OPD).
Disconnect LP cylinder
Turn control knobs OFF at regulators and LP tank valve Turn coupling nut
counterclockwise by hand only. Never use tools to disconnect.
Place dust cap on cylinder valve outlet when the cylinder is not is use.
.

WARNINGS
REGULATOR HOSE ASSEMBLY CHECK:
WARNING
Before each use, check to see if there is evidence of abrasion, wear, cuts or leaks on the hose. If
damage is evident, the hose must be replaced prior to appliance use.
DISCONNECTING REGULATOR FROM THE LP TANK:
•Turn control knob to the OFF position.
•Turn LP tank OFF by turning hand wheel clockwise to a full stop.
•Turn the coupling nut counterclockwise to loosen the connector.
NOTE: Loosen by hand only. DO NOT use tools.
•When disconnected, the regulator should be hung on the hook
attached to the appliance.
INSTRUCTIONS FOR LIGHTING BURNER:
•Read and understand all instructions and warnings before lighting. Only light burner outdoors.
•Confirm that the regulator control valve and LP cylinder is completely closed and in the “OFF”
position.
•Ensure a minimum of 24 inches separate the LP tank and the burner. Note that the LP hose is a
tripping hazard and special care must be observed.
•Open the LP cylinder valve fully by turning counter clockwise.
•Ensure that nothing is directly over the burner. DO NOT allow your head or arms to ever be above
the burner.
•Use an extended reach lighter or an ignited long match and allow flame to be placed directly over
the burner. Slowly turn the regulator control valve on and adjust flame .
•If the burner does not light within five (5) seconds, turn the regulator control valve back to the
“OFF” position, re-close the LP tank valve and wait five (5) minutes. After waiting five (5) minutes,
re-start the process from step one (1) above.
DANGER
NEVER allow this appliance to operate unattended. Failure to follow this Danger Statement
could result in fire, explosion or burn hazard that could cause property damage, personal injury
or even death. If a fire should occur, keep away from the appliance, move everyone to safety
and immediately contact the fire department and emergency personal (e.g 911). ALWAYS
have an appropriately rated fire extinguisher on hand when using this product. A Class “B” dry
chemical OR CO2 extinguisher or preferably a Class “K” extinguisher. Special care must be
taken to understand the manufacturers instructions and be prepared to operate the appropriate
extinguisher prior to using this appliance.
Page 7 of 23

WARNINGS
Page 8 of 23
1. Be sure the LP cylinder valve is closed. If the LP cylinder is still leaking, contact
your LP dealer or local fire department.
2. Do not use any matches, open flame or smoke during leak testing.
3. Do not light a burner during leak testing.
FOR YOUR SAFETY
1. Minimum clearance from sides and back of unit to adjacent combustible
construction below top of unit,10ft ( 3.0 m) from side and 10ft ( 3.0 m) from back.
2. Do not place the outdoor cooking gas appliance under overhead-unprotected
combustible surfaces.
APARTMENT RESIDENTS
Check with your apartment manager
regarding your regulations for Frying.
WARNING
1. Do not use this Fryer in any
enclosed area, garage, shed, or
under any type of overhead
structure or canopy.
2. Operate this Fryer only in a well-
ventilated outdoor area.
WARNING
Keep any electrical supply cord and
the fuel supply hose away from any
heated surfaces and water.

1 Adjustable wrench
(not included)
2 Phillips Screwdriver
(not included)
Tools Required
Hardware List
A Washers 2pcs B Cotter pins 2pcs C Bolt M6X15 2 pcs
D Acorn nut 6pcs E Spacer 2pcs F Bolts M6x22 1PC
Page 9 of 23
2

Parts List
①wheel 2pcs ②axle 1pc ③bottom
1pc
④front panel 1pc
⑤back panel 1pc ⑥ cross panel 2pcs ⑦fire rod 1pc ⑧ main body 1pc
⑨side table 1pc ⑩ side table handle
1pc
⑪ thermometer 1pc ⑫ lid handles 2pcs
⑬ regulator 1pc ⑭ f li ter tank 1pc ⑮ basket 2pcs ⑯ basket handle
Page 10 of 23
frame
PTFE TAPE
1pc
17

Exploded View
Page 11 of 23
1
2
3
4
6
7
5
89
10
11
12
13
15
14
16
16
15
17

Assembly Instructions
Step 1:
Insert the wheel axle
(part #②) (1PC)
through the frame
bottom (part#③ ).
Install the wheel (part
#①) to axle with
washers (A) (1
pc) ,bolt (E) (1pc) and
cotter pin (B) (1 pc).
Repeat step with
other wheel.
Step 2:
Install front panel
(part #④)
and back panel
(part#⑤) with
Bolts (C) (4pcs).
Page 12 of 23
AB
1
2
3
E
54
C

Assembly Instructions
Step 4:
Step 3:
Install cross panel
(part #⑥) (2pcs) with
Bolts (C) (8pcs).
Hang fire rod (part #⑦)
on cross panel (part
#⑥).
Page 13 of 23
6
C
C
7

Assembly Instructions
Step 5:
Install main body (part
#⑧) to frame with Bolts
(C) (4 pcs).
Step 6:
Install side table
handle (part #⑩) to
side table (part #⑨)
with bolts (C) (2
pcs).
Page 14 of 23
8
C
10
9
C

Assembly Instructions
Step 8:
Insert the thermometer
(part #⑪) to the body, then
turn right to tighten.
Step 7:
Install the side table
(part#⑨) to body with
bolts (C) (4 pcs).
Page 15 of 23
11
17
1
2
step
step
Wind the PTFE tape
thermometer as image.
Don't go beyond the threads.
(part
# )
17

Assembly Instructions
Step 10:
Install regulator (part
#⑬) on air intake with
nuts (D) (2 pcs).
Step 9:
Install lid handle ( part
#⑫) with bolts (C) (2 pcs)
and nuts (D) (2pcs).
Repeat step with other
handle.
Page 16 of 23
12
CD

Assembly Instructions
Step 12:
Step 11：
Assemble the f li ter
tank(part#⑭) into the
body.
Page 17 of 23
Assembly the basket
handle(part#⑯) to
basket (part#⑮).As
shown in the figure.
⑯

Assembly Instructions
Step 13：
Hang the two baskets
(part #⑮) inside the body,
see figure to the right.
Step 14:
Place gas cylinder
into a
o
the bolt to
secure tank in place as
shown on the image..
Page 18 of 23
the
t nk h lder
frame
ofbottom
(part#③ ).
Tighten wing

Fully Assembled
Page 19 of 23