Philips AZ385 User manual

Version 1.0
3141 785 39520
Published by LZ 1302 Subject to modification
©Copyright 2012 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
AZ385/05/12/96
CD-Soundmachina
CONTENTS
--------------------------------------------------1-1--1-8
Version variation
Technical specification
---------------------------------------------------------------2-1
Block diagram-------------------------------------------------------------------3-1
Wiring diagram ----------------------------------------------------------------3-2
Circuit diagram-----------------------------------------------------------4-1--4-3
MAIN +USB+KEY POWER BOARD
TOP & BOTTOM LAYOUT
----------------------------------------- 5-1--5-4
Exploded diagram -------------------------------------------------------------6-1
Safety Instruction -------------------------------------------------------------2-2

1-1
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check: DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
.soPnoitpircseD.soP
ELDNAH1
ANNETNA2
BONKEMULOV3
BONKBBD4
ROODDC5
TENIBACPOT6
YEKMODNAR7
YEKTPER8
9 SPEAKER GRILLE(L)
YEKSUOIVERP01
11 PLAY/PAUSE KEY
12
N
YEKTXE
YEKPOTS31
YEKGORP41
SNELTNORF51
16 SPEAKER GRILLE(R)
TENIBACTNORF71
18 BOTTOM CABINET
19 FUNCTION KNOB
KCAJXUA02
BONKGNINUT12
Description
Battery location:BOTTOM CABINET
CABINET
Dimensions with Boxes (L x W x H): 281*261*144MM Material: ABS / HIPS
Dimensions without Boxes (L x W x H): 261X245X125MM Finishing:
Spray
Weight (including packing):. 2KG Unit in Master carton:
N/A
Weight (excluding packing and batteries): 1.63KG Units in Dealer carton:
tes1
INTERCONNECTION POSSIBILITIES
Pos. Connection/Function Connector type Electrical data (input or R.O.P)
73
83
93
04
14
24
34
44
54
64
ACCESSORIES :

1-2
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check:
DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
REMARKS :
General description:
1
LIFETIME : 5 YEARS (ACC. TO UAN-D1611) 2
PERFORMANCE CLASSES :
TUNER SUPPLY,
AMPLIFIER
SPEAKER
BOXES RECORDER CLOCK CD DCC TELEPHONE REC.
PLAYER
I x x 3
II x 4
III 5
SAFETY REQUIREMENTS:
EN 60065 (IEC 65) CE ,
6
RADIATION, IMMUNITY REQUIREMENTS: (EMC)
EN55013, .EN55020 , (Version 05/12/61 approbation CB only )
EN61000-3-2:2006 EN61000-3-3:1995 (Version /61 approbation CB only )
7
CLIMATIC REQUIREMENTS: (acc. to UAN-D1590)
All climates: -10 C till +50 C (Functional); Set has to be pre-conditioned for 2 hour, except CD function 8
For all measurements: 25 C9
POWER SUPPLY:
reffuBpukcaB/noitarepo).txero.tni(CDnoitarepo)CA(SNIAM
Voltage selection: See table below Battery type: R14, UM2, C-cell x 6; nom.: 9V
minimum operating voltage : 5V for CD / Tape
3.3V for TU
10
Selection: See table below Lifetime: CD 10 hours, TU 20 hours,
(R14 ‰˝ıalkaline batteries)
11
Frequency: See table below External DC: No 12
POWER CONSUMPTION:
Power off mode: 5W typ. Standby: <0.5W (power off mode) 13
Maximum: 15 W 41:mumixaM
General:
Q and R according to production division rules : Q < 1% (Major), Q < 4% (Minor)
<R:otgnidroccaderusaeM 3% (CE52)
NOITABORPPA:SNOISREVDEVIRED
Version
AC Voltage/
Frequency on
typeplate
Safety
Tolerance
Tuner
/05
UK
230VAC
50HZ
+/-10% FM,
230VAC
50HZ
/12
Europe
+/-10%
FM,
/61
Korea
220VAC
60HZ
+/-10% FM
15

1-3
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check: DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
REMARKS:
For operation and thermal stability test :
220/230/240Vac setting : 198Vac to 264Vac
120Vac setting : 99Vac to 140Vac
dual voltage ac setting (120Vac / 230Vac) : 99Vac to 140Vac and 196Vac to 264Vac
16
TUNER PART
TECHNICAL description:
AM (circuitry) FMAM (active components) FM
RF 2290TK 1
IF 1 2
Detector 3
Decoder 4
GENERAL part:
CNARELOTEGNAREVAW ES TUNING STEP
5
6
FM (05/96/12/61
version)
87.5 –108MHZ LOW : +0.3/-0.3MHZ
HIGH: +0.4/-0.4MHZ
7
8
9
01
AERIAL:
FM telescope : 430 mm 11
FM wire : N/A Execution - N/A 21
INDICATORS:
31:retniopnoitucexE:ekortsretnioP
41:htgnertSdleiF:revonoitacidnibonK
ELECTRICAL DATA:
AM:
N
om. limit FM: nom. limit
RATED OUTPUT POWER 10%
THD 80%Mod 120dB / / 51//noisserppuSMA
61fBd8121tniopgnitimilBd3-
71Bd2-/+2evresernoitacifilpmAevresernoitacifilpmA
81)egareva(egnargnidlohCFAtiremfoerugifCGA
Distortion (RF 74 to 94 dBuV/m,
m=80%)
Distortion
(RF 32 to 72 dBuV,
mono f 100kHz, Stereo : 90% + 9%)
5 7 % 19
Stereo -46dB quieting ¡]20KHz LPF¡^ 40 44 dBuV 20
Cross-talk (RF 1mV, f 40kHz,
400Hz /1kHz / 5kHz)
21/25/18 18/20/15 dB 21
Strong S/N radio
RF 94dBuV/m, m=80%
S/N radio (A-Weighted, RF 4mV) 53 50 dBA 22
Channel difference Channel unbalance (250Hz to 6300Hz) 0 3 dB 23
Modulation hum (30% mod) Modulation hum (22.5kHz dev) £¤A-Weighte£' 44 40 dB 24
2, 3th IF harmonics rejection
(RF 64 to 94dBuV/m)
8, 9,10th 52Bd0353eltsihwscinomrah
Overall frequency response (-
3dB)
Overall frequency response (+/- 3dB, 1kHz ref)
- 50us
-
70
12k
80 Hz
10k Hz
26
Oscillator stop voltage
120V setting
230V setting
Oscillator stop voltage
120V setting
230V setting
90
190
96 Vac
192 Vac
27

1-4
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check:
DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
Search tuning sensitivity / N/A
Search tuning sensitivity
/ N/A 28
Search tuning stop accuracy
RF 26 to 1mV
RF 1V/m
/
/
/
/
N/A
Search tuning stop accuracy
- 20uV ~ 20mV
- 20mV ~ 500mV with step size = 50kH
- 20mV ~ 500mV with step size > 50kHz
/
/
/
N/A
29
Search time of total tuning range / N/A Search time of total tuning range N/A 30
IF
455KHZ 3kHz 13FI
Frequency drift vs temp.
-10 C to 10 C
10 C to 30 C
30 to 50 C
0.7 / 1000 * operating
frequency
Frequency drift vs temp.
15KHZ/¡ªC
10KHZ/¡ªC
15KHZ/¡ªC
32
Dial calibration 5 7% Dial ca 33zHM5.1-/+2.1-noitarbil
43VuBd5.5141)zHk6:noitaivedtoliP(tniopnOoeretS
53Bd6–nognihctiwS
wave range Sensitivity for
50mW
noise limited sensitivity
(26dB)
Image
rejection
IF rejection
large
signal
Selectivity
S9/300kHz
bandwidthB+3dB
nom.
13 21 55 130dBf 21 36
FM lim.
15 19 50 125dBf 19 37
nom.
MW lim.
unit
V/m
V
dBf
V/m
dBf dB dB dB
mV/m
dB kHz
REMARKS:
SUPPLY, AF-AMPLIFIER & LOUDSPEAKER PART:
TECHNICAL description:
rekaepsduoLreifilpmA-FAlortnoCenoTylppusrewoP
Active components D8227 1
Passive components 2 X 1 W, 8ohm 2
3
GENERAL part:
Headphone type
N
4eno
Loudspeaker filter, high pass
N
5eno
Loudspeaker filter, low pass
N
6eno
Power stage protection AC – NO; DC - NO; Temperature – YES; Short circuit – NO 7
Public address
N
8o
INDICATORS:
Output power or VU-meter
N
9:stigid:o
Frequency response
N
01:stigid:o
Low power (battery)
N
11o
ELECTRICAL DATA: £¤ALL 20KHz LPF£'
TONE/EQUALIZER/DBB
lortnocecnalaB
N
21o
31)6991OSI(esionlacinahceM
N
41)OSI(llarevoesio
51Wm05taecnereffidlennahC
Hum (vol.max.-20dB to vol.min.) Limit: 260 nW 16
Residual noise (volume minimum) Limit: 350 nW 17

1-5
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1
CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check:
DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
Input sens.: Nom. 650mV mV
for 50mW Limit: mV
Line outp.: Nom. mV
voltage Limit: mV
OUTPUT POWER:
Mains operation: D=10% 2 X 1W Limit: - 1dB 18
Battery operation: D=10% 2 X 1W Limit: - 1dB 19
Music power (MPO) / Peak-MPO (PMPO): (acc. to DIN45324) 20
12)51-86206CEIot.cca(W2.1*2-:rewoptuptuomumixammrettrohS
22)51-86206CEIot.cca(-:rewoptuptuomumixammretgnoL
32:rewop/egatlovtuptuoenohpdaeH
Bandwidth FTC – 1dB at 42)234/D/1/61/CTFot.cca(.a.n:
Bandwidth DIN – 3dB at 52)51-86206CEIot.cca(-:
Frequency response at Vol. max – 20dB: typ. 60Hz to 16kHz ( 3dB) 62
21kcarT924CBScsiDbd02-xamlovzh521tabd4levelesiarBBD
LOUDSPEAKER (output):
Low pass crossover frequency: - kHz tolerance: Hz 27
High pass crossover frequency: - kHz tolerance: Hz 28
Short term maximum output power: - W (acc. to IEC 60268-15) 29
03)51-86206CEIot.cca(W-:rewoptuptuomumixammretgnoL
Frequency response at: - Hz kHz 31
REMARKS:
27 : Measured in Tuner mode; 28: CD Mode.
32
CD-PART:(SANYO DA11B3VF CD MECHANISM) (BALL type)
Technical description:
Input Output Motor/control Logic control 1
Active components SCA4720 Ali-M5677-ALAA 2
Passive components 3
Signal processing D/A converter HF-preamplifier Servoprocessor 4
Active components CD:
Ali-M5677-ALAA
CD:
Ali-M5677-ALAA 5
Passive components 6
Indicators/Display/Keys:
7tigiD3yalpsid.oNkcarTrofDCL:yalpsiD
Keys: Slide switches & tact switches 8
Playability: (acc. to AHR-82-Gbu-00-4201)
9csidtseTlacipyTtimiL
Wedge 600 m 900 mTNO 7,9 of SBC 444A (7104 099 24990) 10
Eccentric 150 m 200 m TNO 1,24 of 200 m disc (7104 099 24960) 11
Fingerprint
N
o audible defec
t
TNO 11of Subchassis 8A 12
Black dot 500 m 600 mTNO 13, 14 of SBC 444A (7104 099 24990) 13
Double black dot
N
o failure TNO 9 of Subchassis 8A 14
Skew 0.6 deg, 8cm
N
o audible defec
t
TNO 1,6 of 0.6deg C, 8cm skew disc 15
Bad HF track
N
o audible defec
t
TNO 8 of Subchassis 8A 16
Heavy fingerprint
N
o track jumps/plops TNO 10 of Subchassis 8A 17
Maximum diameter
N
o audio effect Last TNO of Subchassis 8A 18

1-6
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1
CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT
Check:
DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
Input sens.: Nom. 650mV mV
for 50mW Limit: mV
Line outp.: Nom. mV
voltage Limit: mV
OUTPUT POWER:
Mains operation: D=10% 2 X 1W Limit: - 1dB 18
Battery operation: D=10% 2 X 1W Limit: - 1dB 19
Music power (MPO) / Peak-MPO (PMPO): (acc. to DIN45324) 20
12)51-86206CEIot.cca(W2.1*2-:rewoptuptuomumixammrettrohS
22)51-86206CEIot.cca(-:rewoptuptuomumixammretgnoL
32:rewop/egatlovtuptuoenohpdaeH
Bandwidth FTC – 1dB at 42)234/D/1/61/CTFot.cca(.a.n:
Bandwidth DIN – 3dB at 52)51-86206CEIot.cca(-:
Frequency response at Vol. max – 20dB: typ. 60Hz to 16kHz ( 3dB) 62
21kcarT924CBScsiDbd02-xamlovzh521tabd4levelesiarBBD
LOUDSPEAKER (output):
Low pass crossover frequency: - kHz tolerance: Hz 27
High pass crossover frequency: - kHz tolerance: Hz 28
Short term maximum output power: - W (acc. to IEC 60268-15) 29
03)51-86206CEIot.cca(W-:rewoptuptuomumixammretgnoL
Frequency response at: - Hz kHz 31
REMARKS:
27 : Measured in Tuner mode; 28: CD Mode.
32
CD-PART:(SANYO DA11B3VF CD MECHANISM) (BALL type)
Technical description:
Input Output Motor/control Logic control 1
Active components SCA4720 Ali-M5677-ALAA 2
Passive components 3
Signal processing D/A converter HF-preamplifier Servoprocessor 4
Active components CD:
Ali-M5677-ALAA
CD:
Ali-M5677-ALAA 5
Passive components 6
Indicators/Display/Keys:
7tigiD3yalpsid.oNkcarTrofDCL:yalpsiD
Keys: Slide switches & tact switches 8
Playability: (acc. to AHR-82-Gbu-00-4201)
9csidtseTlacipyTtimiL
Wedge 600 m 900 mTNO 7,9 of SBC 444A (7104 099 24990) 10
Eccentric 150 m 200 m TNO 1,24 of 200 m disc
(7104 099 24960)
11
Fingerprint
N
o audible defec
t
TNO 11of Subchassis 8A 12
Black dot 500 m 600 mTNO 13, 14 of SBC 444A (7104 099 24990) 13
Double black dot
N
o failure TNO 9 of Subchassis 8A 14
Skew 0.6 deg, 8cm
N
o audible defec
t
TNO 1,6 of 0.6deg C, 8cm skew disc 15
Bad HF track
N
o audible defec
t
TNO 8 of Subchassis 8A 16
Heavy fingerprint
N
o track jumps/plops TNO 10 of Subchassis 8A 17
Maximum diameter
N
o audio effect Last TNO of Subchassis 8A 18

1-7
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT
Check: DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
CD-RW playability
1 Fingerprint “K” TNO 18 No audible disturbance
2 Black dot “K” 13, 17 um 800 400
3 Low reflection “L” No audible disturbance
4 High reflection “M” Startup
MP3 playablity : See specification on CD-DA
MP3 - Data-format-check
Remark :support ISO-9660, Joliet format and UDF 1.0 & 2.0
1 File format check Html file of “N” File in non supported
formats are skipped.
2 Sample rate check “N” No audible disturbance
3 Bitrate check
32,40, 48, 56, 64, 80,
96, 112, 128, 160,
192, 224, 250, 320
kbps, VBR (variable
bit rate)
“N” No audible disturbance
4 Multissession “O” All titles accessible, no
audible disturbance
5 Iso9660 “N” All titles accessible, no
audible disturbance
detroppustoNu3mtsilyalP6
7 Id3 check “N” Text in display ok
8 CD-Extra (1 audio
seesion + 1
digitalsession)
“Q”
Remark : selectable
by mode button
No audible disturbance.
9 Direct CD “R” No audible disturbance
10 Mixed CD “P” No audible disturbance
detroppustoNkcabyalp-CAA11
12 WMA-playback Not supported
13 Max. titles /
directories
“S”
max. 350 titles and
directories, avg.
length of
filename/foldername
is 20 characters
All titles accessible, no
audible disturbance.

1-8
TECHNICAL SPECIFICATION
SET SPECIFICATION
VER 1 CD/MP3/FM/USB
AZ385/05/12
/
96
Prepared: Supers: 10 Sh. 190 4A
KT Check: DATE: © PHILIPS Electonics Hong Kong Ltd., BU-PORTABLE AUDIO
USB-PART ELECTRICAL CHARACTERISTICS MEASUREMENT DATA SHEET
Item Description condition Unit Norminal Limit
1max. Output current mA
250 500
2Output Voltage V5
,+0.2/-.01
4Frequency Response dB +/-6dB
100Hz-10K
5Distortion 1KHz THD% <3%
6S/N £¤A-Weighte£'
1KHz dB 60 >50dB
7channel seperation 1KHz dB 40 >30dB
8Working current mA 130mA <180
9
charge current during
play song mA 0-200 >300
10 output power W11
USB Compatibility Test
Support MSC/MTP dual mode USB device .
Test requirement and method follow attached file as below:
"USB Direct
Compatibility tes
5

2- 1VERSION VARIATION
Type /Versions:
Features
Boardi nu sed:
AZ385
Service policy
Main BOARD
*T IPS :C -- Component Lever Repair.
M -- Module Lever Repair
-- Used
/12
Feature diffrence
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK
Type /Versions:
/12
Key BOARD
M
M
Power BOARD M
AZ385
USB BOARD M