Pioneer PDP-R06G User manual

ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2005
PDP-R06G
ARP3281
MEDIA RECEIVER
PDP-R06G
PDP-R06C
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model Type Power Requirement Remarks
PDP-R06G TLDFXJ AC 110V - 240V
PDP-R06C WAXU5 AC 220V - 240V
For details, refer to "Important Check Points for good servicing".
T-IZR SEPT. 2005 printed in Japan

PDP-R06G
2
1234
1234
C
D
F
A
B
E
SAFETY INFORMATION
1. SAFETY PRECAUTIONS
The following check should be performed for the
continued protection of the customer and service
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground
(water pipe, conduit, etc.) by connecting a leakage
current tester such as Simpson Model 229-2 or
equivalent between the earth ground and all exposed
metal parts of the appliance (input/output terminals,
screwheads, metal overlays, control shaft, etc.). Plug
the AC line cord of the appliance directly into a 120V
AC 60 Hz outlet and turn the AC power switch on. Any
current measured must not exceed 0.5 mA.
ANY MEASUREMENTS NOT WITHIN THE LIMITS
OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL
SHOCK HAZARD AND MUST BE CORRECTED BEFORE
RETURNING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related characteristics. These are
often not evident from visual inspection nor the protection
afforded by them necessarily can be obtained by using
replacement components rated for voltage, wattage, etc.
Replacement parts which have these special safety
characteristics are identified in this Service Manual.
Electrical components having such features are
identified by marking with a >on the schematics and on
the parts list in this Service Manual.
The use of a substitute replacement component which
does not have the same safety characteristics as the
PIONEER recommended replacement one, shown in the
parts list in this Service Manual, may create shock, fire,
or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER Service
Manual. A subscription to, or additional copies of,
PIONEER Service Manual may be obtained at a nominal
charge from PIONEER.
Leakage
current
tester
Reading should
not be above
0.5 mA
Device
under
test
Test all
exposed metal
surfaces
Also test with
plug reversed
(Using AC adapter
plug as required)
Earth
ground
AC Leakage Test
(FOR USA MODEL ONLY)
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to
cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must
be of identical designation.
REMARQUE
(POUR MODÈLE CANADIEN SEULEMENT)
Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces
de remplacement doivent avoir la même désignation.
This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.

PDP-R06G 3
5678
5678
C
D
F
A
B
E
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
3Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
7Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
0Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.

PDP-R06G
4
1234
1234
C
D
F
A
B
E
CONTENTS
1. SPECIFICATIONS ............................................................................................................................................ 5
2. EXPLODED VIEWS AND PARTS LIST ............................................................................................................ 6
2.1 PACKING SECTION .................................................................................................................................. 6
2.2 EXTERIOR SECTION................................................................................................................................ 8
2.3 FRONT PANEL SECTION ....................................................................................................................... 10
3. BLOCK DIAGRAM.......................................................................................................................................... 12
3.1 OVERALL BLOCK DIAGRAM.................................................................................................................. 12
3.2 POWER SUPPLY UNIT............................................................................................................................ 14
3.3 POWER SUPPLY SIGNAL ROUTE ......................................................................................................... 15
3.4 VOLTAGES............................................................................................................................................... 16
5. PCB PARTS LIST ........................................................................................................................................... 17
6. ADJUSTMENT ............................................................................................................................................... 23
6.1 POSSIBLE CASES WHERE READJUSTMENT IS REQUIRED ............................................................. 23
6.2 SERVICING USING ONLY THE MEDIA RECEIVER............................................................................... 24
6.3 SERVICE FACTORY MODE .................................................................................................................... 25
6.4 LIST OF RS-232C COMMANDS ............................................................................................................. 38
6.5 OUTLINE OF COMMANDS ..................................................................................................................... 39
7. GENERAL INFORMATION............................................................................................................................. 41
7.1 DIAGNOSIS ............................................................................................................................................. 41
7.1.1 TROUBLESHOOTING....................................................................................................................... 41
7.1.2 DISASSEMBLY.................................................................................................................................. 50
7.2 EXPLANATION ........................................................................................................................................ 51
7.2.1 PROCESSING IN ABNORMALITY ................................................................................................... 51
7.2.2 POWER ON SEQUENCE.................................................................................................................. 54
7.3 PARTS...................................................................................................................................................... 55
7.3.1 IC ....................................................................................................................................................... 55
8. PANEL FACILITIES ........................................................................................................................................ 86

PDP-R06G 5
5678
5678
C
D
F
A
B
E
1. SPECIFICATIONS
∗ :This conforms to HDMI1.1 and HDCP1.1.
HDMI (High Definition Multimedia Interface) is a digital interface that handles both video and audio using a single cable.
HDCP (High-bandwidth Digital Content Protection) is a technology used to protect copyrighted digital contents that use
the Digital Visual Interface (DVI).
÷Design and specifications are subject to change without notice.
Accessories
Power cord
(ADG1209: PDP-R06C) Remote control unit
(AXD1510: PDP-R06G)
(AXD1511: PDP-R06C)
AA size Battery ×2
(VEM1031: PDP-R06G)
(VEM1010: PDP-R06C)
System cable (3 m)
(ADF1027)
Operating instructions
Item Media Receiver, Model: PDP-R06G
Color System PAL/SECAM/NTSC/4.43NTSC/PAL-M/PAL-N
TV Function Receiving System PAL: B/G, D/K, I M, N SECAM: B/G, D/K NTSC: M 4.43NTSC : M
Tuner VHF/UHF 44.25-863.25 MHz
CATV Hyper-band, S1-S41ch
Auto Channel Preset 99 ch (Normal), 68 ch (Air, US type), 125 ch (Cable, US type), Auto Preset
Audio multiplex NICAM/A2/BTSC System
Terminals Rear INPUT 1 COMPONENT VIDEO in, S-VIDEO in, AV in
INPUT 2 COMPONENT VIDEO in, S-VIDEO in, AV in
INPUT 3 S-VIDEO in, AV in, HDMI in*
Antenna 75 ΩDin Type for VHF/UHF in
Front INPUT 4 S-VIDEO, AV in (Audio input is shared with PC INPUT.)
PC Analog RGB in
MONITOR OUT Terminal (Rear) AV out
PHONES OUTPUT Terminal (Front) 16 - 32 Ωrecommended
SUB WOOFER OUTPUT Terminal (Rear) Variable
Power Requirement
110 - 240 V(PDP-R06G), 220 - 240V(PDP-R06C) , 50/60 Hz, 16 W (0.4 W Standby)
Dimensions 420 (W) ×90 (H) ×299 (D) mm
Weight 3.4 kg

PDP-R06G
6
1234
1234
C
D
F
A
B
E
2. EXPLODED VIEWS AND PARTS LIST
2.1 PACKING SECTION
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to mark on product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
NOTES:
FRONT
1 (PDP-R06G)
or
2 (PDP-R06C)
13
PDP-R06C
only
11
15 15
7
16
6
10
8
14 9
12
5
3
4

PDP-R06G 7
5678
5678
C
D
F
A
B
E
(1) PACKING SECTION PARTS LIST
(2) CONTRAST TABLE
PDP-R06G/TLDFXJ and PDP-R06C/WAXU5 are constructed the same except for the following:
Mark No. Description Part No.
1Operating Instructions See Contrast table (2)
(English, Chinese, Spanish, Portuguese)
2Operating Instructions See Contrast table (2)
(Chinese)
3 Remote Control Unit See Contrast table (2)
4 Battery Cover AZA7424
NSP 5 Dry Cell Battery (R6P, AA) See Contrast table (2)
6 System Cable (3m)
ADF1027
> 7Power Cord See Contrast table (2)
8Pad L See Contrast table (2)
9Pad R See Contrast table (2)
10 Accessory Carton See Contrast table (2)
11 Manual Case See Contrast table (2)
12 Carton See Contrast table (2)
NSP 13 Catalogue Bag See Contrast table (2)
14 Laminate Sheet AHG1350
15 Air Cap Bag See Contrast table (2)
NSP 16 Catalogue Bag See Contrast table (2)
Mark No. Symbol and Description PDP-R06G/TLDFXJ PDP-R06C/WAXU5
1 Operating Instructions (English, Chinese, Spanish, Portuguese) ARE1398 Not used
2 Operating Instructions (Chinese) Not used ARC1545
3 Remote Control Unit AXD1510 AXD1511
NSP 5 Dry Cell Battery (R6P, AA) VEM1031 VEM1010
> 7Power Cord Not used ADG1209
8Pad L AHA2447 AHA2449
9Pad R AHA2448 AHA2450
10 Accessory Carton M AHD3423 Not used
10 Accessory Carton C Not used AHD3361
11 Manual Case AHD3428 AHD3429
12 Carton G AHD3449 Not used
12 Carton C Not used AHD3363
NSP 13 Catalogue Bag AHG1340 AHG1360
15 Air Cap Bag AHG1351 AHG1359
NSP 16 Catalogue Bag AHG1374 AHG1360

PDP-R06G
8
1234
1234
C
D
F
A
B
E
2.2 EXTERIOR SECTION
A
A
B
CC
B
CONTACT SIDE
NON-CONTACT
SIDE
Refer to
"2.3 FRONT PANEL SECTION".
27
29
29
29
27
29
10
29 26
26 32
32
30 32
31
33
22
12
18
12
12
2
19
6
3
5
15
21
9
12
7
28
28
28
14
17
4
13
1
28
8
34
29
29
26
16
32
20
11
23
Cleaning paper
GED-008

PDP-R06G 9
5678
5678
C
D
F
A
B
E
(1) EXTERIOR SECTION PARTS LIST
(2) CONTRAST TABLE
PDP-R06G/TLDFXJ and PDP-R06C/WAXU5 are constructed the same except for the following:
Mark No. Description Part No.
1MR MAIN Assy See Contrast table (2)
2 SR Assy AWW1037
3FRONT Assy AWW1051
> 4POWER SUPPLY Unit AXY1114
5 Flexible Cable (J201) See Contrast table (2)
6 Flexible Cable (J208) See Contrast table (2)
7 16P Housing Wire (J101) See Contrast table (2)
> 8Fan Motor (60 x 25L) AXM1045
9 Base Chassis See Contrast table (2)
10 Terminal Panel See Contrast table (2)
> 11 Shield Plate ANG2838
12 Floating Rubber 60 AEB1410
13 Front Panel Spacer AEB1429
14 Flat Clamp AEC1858
15 Circuit Board Spacer AEC1969
16 Circuit Board Spacer AEC2028
17 Re-used Wire Saddle AEC2038
18 Fan Holder 60 AMR3451
> 19 Gasket M ANK1774
20 Rubber Foot VEB1349
21 Bottom Cover See Contrast table (2)
22 Metal Bonnet See Contrast table (2)
23 Caution Label (C) See Contrast table (2)
24 • • • • •
25 • • • • •
26 Hex Head Screw BBA1051
27 Screw ABZ30P060FTC
28 Screw BBB30P080FTC
29 Screw BBZ30P060FTB
30 Screw BBZ30P100FTC
31 Screw BMZ30P060FTC
32 Screw BPZ30P080FTB
33 Screw PMZ26P060FTB
34 TERAOKA No.570F 16mm(W) GYH1001
Mark No. Description Part No.
Mark No. Symbol and Description PDP-R06G/TLDFXJ PDP-R06C/WAXU5
1 MR MAIN Assy AWV2232 AWV2234
5 Flexible Cable (J201) ADD1311 ADD1318
6 Flexible Cable (J208) ADD1328 ADD1320
7 16P Housing Wire (J101) ADX3140 ADX3147
9 Base Chassis ANA1872 Not used
9 Base Chassis (J) Not used ANA1891
10 Terminal Panel G ANC2379 Not used
10 Terminal Panel C Not used ANC2380
21 Bottom Cover (G) AAX3221 Not used
21 Bottom Cover (C) Not used AAX3222
22 Metal Bonnet ANE1653 ANE1644
23 Caution Label (C) Not used AAX3220

PDP-R06G
10
1234
1234
C
D
F
A
B
E
2.3 FRONT PANEL SECTION
CONTACT SIDE
NON-CONTACT
SIDE
22
22
20
15
9
7
21
19
16
14
12
3
2
FRONT
CN7803
1
4
6
8
5
19
10
17
18
8
8
13
11

PDP-R06G 11
5678
5678
C
D
F
A
B
E
(1) FRONT PANEL SECTION PARTS LIST
(2) CONTRAST TABLE
PDP-R06G/TLDFXJ and PDP-R06C/WAXU5 are constructed the same except for the following:
Mark No. Description Part No.
1 LED Assy AWW1043
2 Flexible Cable (J207) See Contrast table (2)
> 3 Earth Metal BNG1336
4Front Panel Assy See Contrast table (2)
5 Magnet Catcher ANG2820
6 Magnet Holder Assy AEC1077
7 Gear Damper AXA1019
8 Screw (2 x 3.5) ABA1329
9 Screw BPZ30P080FTB
10 Indicator Panel See Contrast table (2)
11 Door (GC) AAN1486
12 Front Panel AMB2863
13 Escutcheon Ring AAD4134
NSP 14 Power Button AAD4135
NSP 15 Operation Button AAD4136
16 Sealing Sheet (G) AAL2669
17 Pioneer Name Plate AAM1107
18 Door Cushion AEB1412
19 Door Cushion S AEB1425
NSP 20 LED Lens AMR3452
21 Rubber Foot VEB1349
22 Screw BPZ30P080FTB
Mark No. Symbol and Description PDP-R06G/TLDFXJ PDP-R06C/WAXU5
2 Flexible Cable (J207) ADD1314 ADD1319
4Front Panel Assy G AXG1032 Not used
4Front Panel Assy C Not used AXG1033
10 Indicator Panel (G) AAK2845 Not used
10 Indicator Panel (C) Not used AAK2846

PDP-R06G
12
1234
1234
C
D
F
A
B
E
3. BLOCK DIAGRAM
3.1 OVERALL BLOCK DIAGRAM
U4401 (AXF1150)
Front End
IC4401
MSP3455G
Antenna
Input
IC4804
R2S11002AFT
AV SW
IC5405
SDA6000
TEXT UCOM
IC6003
UPD64015GM-UEU
MAIN VDEC
IC6002
K4S161622H-TC60
16M SDRAM
(Main VDEC)
IC6001
TVP5150AM1PBS
SUB VDEC
IC6201
AD9985KSTZ-110
ADC
IC4806
R2S11001FT
RGB SW
IC5002
HD64F3684FP
IF UCOM
SF_IN
A_TUNER_V
AIR_L AIR_R
SCL_AIR
SDA_AIR
SDA_TXT
SCL_TXT
VY_TXT
BLK_TXT
BLK_TXT
MAIN_Y/C
SDA_MA
EXDIO_VDEC
SUB_Y/C
A_MUTE
HDMI_RCH/LCH
SDA_MA
SCL_MA
SDA_MA
CLP_PLS1CLP_PLS1
TXD/RXD_IF
RCR_AD
BCB_AD
CY_AD
SCL_MA
EXA_VDEC
REG_MVDEC RST_ASIC
SCL_MA
GY_MVDEC
BCB_MVDEC
RCR_MVDEC
MON_MUTE
L/R
V
YC
S2
L/R
V
YC
S2
L/R
V
YC
L/R
L/R
L/R
V
V
V
YC
S2
HP_L/R HP_L/R
SW_L/R
SW_L/R
Input1_YPbPr
Input2_YPbPr
PC_RGB
SR_EN_B
TXD/RXD
PC_H/V
SR_IN
232C_DET
Input1_PLUG
Input2_PLUG
SCL_AV
MSP_RST
SDA_AV
SCL_AV
SDA_AV
SCL_AV
SDA_AV
RCR_SG
BCC_SG
GY_SG
GY_SG
Input 1
Input 2
Input 3
Input 4
Headphone
SUB WOOFER
PC Input
SR_IN
SR_OUT
RS232C
MR MAIN ASSY
Monitor
Output
TXD1_TXT
RXD1_TXT

PDP-R06G 13
5678
5678
C
D
F
A
B
E
IC5403
K4S641632H-TC75
64M SDRAM
IC6801
K4S643232H-TC60
64M SDRAM
IC6803
PE5504B
IP
IC6802
K4S643232H-TC60
64M SDRAM
IC5404
S29AL016D70TF1010
16M FLASH
IC6601
PD6523A
DIGITAL SELECTOR
IC6405
PCM1754DBQ
AUDIO DAC
IC6404
SII9021CTU
HDMI Rx
IC7203
TC74VHC08FTS1
BUFFER
IC7201
TC74VHC08FTS1
BUFFER
IC7202
SII170BCLG64
TMDS
(DVI Tx)
CN7202
PLASMA DISPLAY
WHITE
CN7201
PLASMA DISPLAY
BLACK
IC7001
PEG121B
MULTI
IC5209
PQ200WNA1ZPH
FAN CONTROL
IC5206
MB91305PMC-G-BND
MAIN UCOM
IC5207
MBM29DL162TE70TN
16M FLASH
IC5207
MBM29DL162TE70TN
16M FLASH
DIN6_DATA
RXD1_TXT
TXD1_TXT
SDA_AV SCL_AV SDA_AIR SCL_AIR
A0-19
DQ0-15
DIN4_G
EXA_TXT
MD_A
MA
VD_M
CBCR_M
Y_M
RST_IC6
RXD_IC6
HD3
VD2 HD2
DIN2_RGB DIN2_RCR DIN2_GY
DIN3_G
VD_S
RA
GA
BA
DATAIN_HDCP
SDA_HDCP
SCL_HDCP
REM_B
MTXD
MRXD
AUDIO_L/R
HD/VD
SCL_MA
SDA_MA
RCR/GY/BCB_S
HD_S
HD_PLL
RELAY
HOLD_PLL
CLP_AD
DIN3_R
DIN3_B
TXD_IC6
RXD_IC3
RST_ASIC
REM_B
TXD_MD
RXD_MD
R1
TXD_IC3
RS1_IC2
MGA/MBA/MRA
MVD/MHD
EXA EXDIO
HD_M
MD_B
EXDIO_TXT
VD4/5
DIN5
HD4/5
DIN4_R
DIN4_B
Input 3
HDMI
: Video Signal Route
: Audio Signal Route
POWER SUPPLY
UNIT FAN
HD6/VD6
INT_HD1/VD1
EXT_HD1/VD1

PDP-R06G
14
1234
1234
C
D
F
A
B
E
3.2 POWER SUPPLY UNIT
AC IN
(3LINE)
INPUT
CONNECTOR
INPUT FILTER
LIGHTING SURGE
ABSORBER
CIRCUIT
FRAME GND
OVER CURRENT
DETECTOR
CIRCUIT
SWITCHING
DEVICE
PWM/PFM
CONTROL IC
RECTIFICATION
CIRCUIT
RECTIFICATION
CIRCUIT
RECTIFICATION
CIRCUIT
SYNCHRONOUS
PULSE
GENERATION
CIRCUIT
ON/STB
CONTROL
CIRCUIT
OUTPUT
CONNECTOR
P1
OUTPUT
CONNECTOR
P2
AC DETECTION
CIRCUIT
AC DETECTION
SIGNAL OUTPUT
CIRCUIT
SWITCHING
DEVICE
SWITCHING
DEVICE
DC/DC
CONVERTER
CIRCUIT
OVER VOLTAGE
DETECTION
CIRCUIT
ADAPTER TYPE
SHUNT REGULATOR
CIRCUIT
CHARGE PUMP
CIRCUIT
2
RELAY
12 5
12V 12V
16
35V
1
35V
7
5.1V
8
5.1V
9
5.1V
10
5.1V
10
6.8V
7
6.8V
4
3.3V ST
12
3.3V ST
6
5.1V ST
8
5.1V ST
3
GND
5
GND
9
GND
11
GND
2
GND
4
GND
6
GND
11
GND
13
GND
15
GND
1
AC DET
14
NC
3
NC
POWER SUPPLY UNIT

PDP-R06G 15
5678
5678
C
D
F
A
B
E
3.3 POWER SUPPLY SIGNAL ROUTE
POWER SUPPLY UNIT MR MAIN ASSY FAN
SR ASSY
Plasma Display
LED ASSY
FRONT ASSY
Relay
Relay
V+12V
V+35V
V+5.1V
V+6.8V
V+3.3V_STB
: Control port "H" active
: "H" active
V+3.3V_UCOM2
V+1.8V_UCOM2
V+5V_AIR
V+3.3V_VDEC
V+9V
V+5.1V_STB
SW_REG
IC5209
REG
IC4212
SW
IC4211
1.8V REG
IC4206
5V REG
IC4203
9V REG
31V REG
SW_REG
Active
Active
: at PSW1
: Control port "L" active
PSW1_1
PSW1_0
PSW1_0
Active
V+1.5V_VDEC
IC4202
1.5V REG
V+1.8V_HDMI
IC4209
1.8V REG
LED etc.
Buffer etc.
IF UCOM
BLOCK
MAIN UCOM
BLOCK
TUNER
BLOCK
AV IO
BLOCK
AV SW
BLOCK
VDEC
BLOCK
ADC
BLOCK
TEXT
BLOCK
HDMI
BLOCK
DSEL
BLOCK
IP
BLOCK
MULTI
BLOCK
MR IF
BLOCK
• 232C driver etc.
• SR interface
(Discrete)
• LED etc.
• REM, KEY etc.
RelayPSW1
IC4205
3.3V REG
PSW1_1
PSW1_0
V+3.3V_TXT
IC4204
3.3V REG
V+1.8V_VDEC
IC4208
1.8V REG
PSW1
V+2.5V_TXT
V+3.3V_D
V+1.8V_D
V+1.2V_D
IC4201
2.5V REG
U4201
DC/DC_
CONV
: at RELAY
: at ACTIVE
: PSW1_0
PSW1_1
: at constant electricity
∗}

PDP-R06G
16
1234
1234
C
D
F
A
B
E
3.4 VOLTAGES
FRONT ASSY MR MAIN ASSY SR ASSY MR MAIN ASSY
POWER SUPPLY UNIT MR MAIN ASSY
CN7601 (CKS3826) Voltage
(V)
CN4008 (AKM1233)
No. Name Name No.
12 V+5_1_STB 5.1 V+5_1_STB 1
11 V+3_3_STB 3.4 V+3_3_STB 2
10 TXD 3.4 TXD 3
9 RXD 3.4 RXD 4
8 232C_DET 0 232C_DET 5
7 SR_EN_B 3.4 SR_EN_B 6
6 GND 0 GND 7
5 REM_B 3.4 REM_B 8
4 SR_IN 3.4 SR_IN 9
3 GND 0 GND 10
2NC - NC 11
1 GND 0 GND 12
CN101 (B16B-PH-K-S) Voltage
(V)
CN4006 (KM200NA16)
No. Name Name No.
16 V+35V 35.8 V+35V 16
15 GND 0 GND 15
14 V+17V 0 V+17V 14
13 GND 0 GND 13
12 V+12V 12.2 V+12V 12
11 GND 0 GND 11
10 V+6_8V 6.6 V+6_8V 10
9 GND 0 GND 9
8 V+5_1V 5.1 V+5_1V 8
7 V+5_1V 5.1 V+5_1V 7
6 V+5_1V_STB 5.1 V+5_1V_STB 6
5 GND 0 GND 5
4 V+3_3V_STB 3.4 V+3_3V_STB 4
3 GND 0 GND 3
2 RELAY 3.4 RELAY 2
1 AC_DET 3.4 AC_DET 1
CN7004 (AKM1236) Voltage
(V)
CN4001 (AKM1236)
No. Name Name No.
1 V+3_3V_STB 3.4 V+3_3V_STB 50
2 LED_ON 0 LED_ON 49
3 LED_OFF 3.4 LED_OFF 48
4 GND[LED_MDM] 0 GND[LED_MDM] 47
5 V+5_1V_STB 5.1 V+5_1V_STB 46
6 GND[LED_FCT] 0 GND[LED_FCT] 45
7 KEY_AD1 3.4 KEY_AD1 44
8 KEY_AD2 3.4 KEY_AD2 43
9 GND 0 GND 42
10 GND[LED_HDD1] 0 GND[LED_HDD1] 41
11 GND[LED_HDD2] 0 GND[LED_HDD2] 40
12 GND[LED_HDD3] 0 GND[LED_HDD3] 39
13 PC_V 0 PC_V 38
14 GND 0 GND 37
15 PC_H 0 PC_H 36
16 GND 0 GND 35
17 PC_G 2.5 PC_G 34
18 GND 0 GND 33
19 PC_B 2.5 PC_B 32
20 GND 0 GND 31
21 PC_R 2.5 PC_R 30
22 GND 0 GND 29
23 GND 0 GND 28
24 HP_PLUG 0 HP_PLUG 27
25 NC 0 NC 26
26 GND 0 GND 25
27 GND 0 GND 24
28 HP_R 2.1 HP_R 23
29 GND 0 GND 22
30 GND 0 GND 21
31 HP_L 2.1 HP_L 20
32 GND 0 GND 19
33 GND 0 GND 18
34 INPUT4_Y 2.5 INPUT4_Y 17
35 GND 0 GND 16
36 INPUT4_C 2.2 INPUT4_C 15
37 GND 0 GND 14
38 INPUT4_SPLUG 5.0 INPUT4_SPLUG 13
39 INPUT4_S2 0 INPUT4_S2 12
40 GND 0 GND 11
41 INPUT4_V 2.5 INPUT4_V 10
42 GND 0 GND 9
43 INPUT4_L 4.5 INPUT4_L 8
44 GND 0 GND 7
45 INPUT4_R 4.5 INPUT4_R 6
46 GND 0 GND 5
47 WE_RDM 0 WE_RDM 4
48 V+3_3V_UCOM 3.4 V+3_3V_UCOM 3
49 V+5V_A 5.1 V+5V_A 2
50 V+9V_A 9.0 V+9V_A 1
FRONT ASSY LED ASSY
FAN MR MAIN ASSY
Voltage
(V)
CN4009 (AKM1274)
No. Name Name No.
–– 6.5 FAN_VCC 1
–– 0FAN_NG1 2
–– 0GND 3
CN7804 (AKM1238) Voltage
(V)
CN8001 (CKS3826)
No. Name Name No.
1 GND 0 GND 12
2 GND 0 GND 11
3 GND 0 GND 10
4 GND 0 GND 9
5 KEY_AD2 3.4 KEY_AD2 8
6 KEY_AD1 3.4 KEY_AD1 7
7 LED_TREC 0 LED_TREC 6
8 V+5_V_STB 5.1 V+5_V_STB 5
9 GND 0 GND 4
10 LED_OFF 3.4 LED_OFF 3
11 LED_ON 0 LED_ON 2
12 V+3_3V_STB 3.4 V+3_3V_STB 1

PDP-R06G 17
5678
5678
C
D
F
A
B
E
5. PCB PARTS LIST
77
77
LIST OF HOLE PCB ASSEMBLIES
AWV2232 and AWV2234 are constructed the same except for the following :
77
77
PCB PARTS LIST FOR PDP-R06G/TLDFXJ UNLESS OTHER WISE NOTED
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
561
473
R50
1R0
5621
NOTES:
560 Ω
47k Ω
0.5 Ω
1 Ω
RD1/4PU J
RD1/4PU J
RN2H K
RS1P K
56 x10
1
47 x10
3
R50
1R0
561
473
5.62k Ω RN1/4PC F562 x10
1
5621
Mark Symbol and Description PDP-R06G/TLDFXJ PDP-R06C/WAXU5
1..MR MAIN ASSY AWV2232 AWV2234
NSP 1..MR FUKUGO ASSY AWV2233 AWV2233
2..SR ASSY AWW1037 AWW1037
2..FRONT ASSY AWW1051 AWW1051
2..LED ASSY AWW1043 AWW1043
> 1..POWER SUPPLY UNIT AXY1114 AXY1114
MR MAIN ASSY
Mark Symbol and Description AWV2232 AWV2234
[MAIN UCOM BLOCK]
R5243 RS1/16SS103J Not used
R5251 Not used RS1/16SS103J
R5252 Not used RS1/10S0R0J
R5253 RS1/10S0R0J Not used
Mark No. Description Part No.
MR MAIN ASSY
[BOARD IF BLOCK]
SEMICONDUCTORS
Q4003,Q4004 2SA1586
Q4001 DTA124EUA
Q4002 TPC6104
D4001-D4003,D4005 1SS355
CAPACITORS
C4002 CKSRYB105K10
C4003,C4004 CKSSYB104K10
RESISTORS
R4021-R4023 RS1/10S0R0J
R4007 RS2LMF8R2J
Other Resistors RS1/16S###J
OTHERS
CN4008 12P FFC CONNECTOR AKM1233
CN4001 50P CONNECTOR AKM1236
CN4009 CONNECTOR 3P AKM1274
CN4006 16P CONNECTOR KM200NA16
[REG BLOCK]
SEMICONDUCTORS
IC4212 BD6522F
IC4208,IC4211 MM1661JH
IC4202 NCP1117ST15
IC4209 NCP1117ST18
IC4201 PQ025ENA1ZPH
IC4204,IC4205 PQ033ENA1ZPH
IC4206 PQ050DNA1ZPH
IC4203 PQ090DNA1ZPH
Q4201 DTC124EUA
D4201-D4206,D4208,D4209,D4211 1SS355
COILS AND FILTERS
L4201 INDUCTOR BTH1111
>
L4203-L4205 CHIP BEAD FILTER BTX1042
>
F4201-F4203,F4205,F4207 CCG1162
EMI FILTER
CAPACITORS
C4201,C4206,C4209 (10/6.3V) ACG7046
C4215,C4220,C4233 (10/6.3V) ACG7046
C4235,C4240 (10/6.3V) ACG7046
C4250,C4253 (10/6.3V) ACG7046
C4257,C4260,C4263 (10/6.3V) ACG7046
Mark No. Description Part No.

PDP-R06G
18
1234
1234
C
D
F
A
B
E
C4213 (100/16V) ACH1394
C4210,C4244,C4269 ACH1429
C4273 CCSSCH101J50
C4205,C4216,C4219,C4221,C4222 CEHVKW101M6R3
C4224,C4228,C4238,C4264 CEHVKW101M6R3
C4226 CEHVKW220M16
C4214 CKSRYB104K16
C4203,C4217,C4223 CKSRYB105K10
C4229,C4237,C4252 CKSSYB104K10
C4232,C4234 CKSSYB471K50
C4204,C4212,C4227,C4236,C4251 CKSSYF104Z16
C4261,C4262 CKSSYF104Z16
C4211,C4225,C4256 DCH1165
RESISTORS
R4221,R4226 RS1/10S0R0J
Other Resistors RS1/16S###J
OTHERS
U4201 DD CONTROL UNIT AXY1117
[TUNER BLOCK]
SEMICONDUCTORS
IC4401 MSP3455G
Q4404 2SA1586
Q4401,Q4402 2SC4116
Q4414 DTA124EUA
Q4413,Q4415 DTC124EUA
Q4407,Q4408 HN1A01FU
Q4405 HN1B04FU
Q4409 HN1C01FU
D4401 UDZS33(B)
D4403 UDZS8R2(B)
COILS AND FILTERS
L4401-L4403 CHIP COIL BTH1119
L4405,L4406 LCTAW150J2520
L4407 LCTAW4R7J2520
L4404 LCTAW8R2J2520
F4401,F4402 FERRITE BEAD VTF1080
CAPACITORS
C4404,C4407,C4410 (10/6.3V) ACG7046
C4415,C4416 (10/6.3V) ACG7046
C4429,C4459 (10/6.3V) ACG7046
C4424 (3.3/50V) ACH1385
C4449 CCSRCH680J50
C4442 CCSRCJ3R0C50
C4417,C4418 CCSSCH100D50
C4450 CCSSCH121J50
C4456 CCSSCH181J50
C4448 CCSSCH470J50
C4428,C4443 CCSSCH560J50
C4441 CCSSCH5R0D50
C4409,C4423 CEHVKW100M16
C4422 CEHVKW470M16
C4420 CKSRYB332K50
C4401,C4413 CKSRYF104Z50
C4403,C4421,C4427,C4430,C4440 CKSSYB102K50
C4444,C4455,C4461 CKSSYB102K50
C4408,C4439,C4446 CKSSYB103K16
C4438,C4454 CKSSYB472K25
Mark No. Description Part No.
C4402,C4405,C4406,C4425,C4426 CKSSYF104Z16
C4434,C4435,C4447,C4451,C4460 CKSSYF104Z16
C4465 CKSSYF104Z16
C4414,C4437,C4445 DCH1165
RESISTORS
All Resistors RS1/16S###J
OTHERS
X4401 CRYSTAL (18.432MHz) ASS1196
>
U4401 FRONT END (IBD) AXF1150
[AV IO BLOCK]
SEMICONDUCTORS
Q4614,Q4626,Q4639 2SA1586
Q4618,Q4622-Q4624,Q4637 2SC4116
Q4619,Q4620,Q4640 2SD2114K
Q4616,Q4621,Q4627 DTA124EUA
Q4617,Q4628 DTC124EUA
Q4625,Q4638 HN1A01FU
D4611,D4612,D4615 1SS301
D4606 1SS355
COILS AND FILTERS
L4601-L4606 LCTAW1R0J2520
L4607,L4608 LCTAW560J2520
CAPACITORS
C4621 (10/6.3V) ACG7046
C4657 (100/16V) ACH1394
C4623 ACH1419
C4658 CCG1205
C4643 CKSRYB104K16
C4603,C4608,C4613,C4631-C4639 CKSRYB105K10
C4641,C4642,C4645-C4648 CKSRYB105K10
C4644 CKSRYB224K10
>
C4651-C4656 CKSSYB102K50
C4601,C4604-C4606,C4609-C4611 CKSSYB103K16
C4614,C4615,C4649,C4650 CKSSYB103K16
C4602,C4607,C4612 CKSSYB473K16
C4622 CKSSYF104Z16
C4620,C4624,C4625,C4628 DCH1165
RESISTORS
R4670 RS1/10S121J
R4658 RS1/10S151J
R4602,R4603,R4605,R4606 RS1/16S75R0F
R4608-R4612,R4619-R4622 RS1/16S75R0F
R4625,R4626 RS1/16S75R0F
Other Resistors RS1/16S###J
OTHERS
JA4603 9P PIN JACK AKB1319
JA4602 9P PIN JACK AKB1330
JA4601 4P MINI DIN (S) AKP1280
JA4604 1P JACK VKB1159
[AV SW BLOCK]
SEMICONDUCTORS
IC4807 BH3544F
IC4805 NJM12904V
IC4806 R2S11001FT
IC4804 R2S11002AFT
IC4809 TC7WH123FU
Mark No. Description Part No.

PDP-R06G 19
5678
5678
C
D
F
A
B
E
Q4801,Q4802,Q4809,Q4818,Q4820 2SA1586
Q4808,Q4811-Q4813,Q4821 2SC4116
Q4814 DTA124EUA
Q4815 DTC124EUA
D4802,D4806 1SS301
CAPACITORS
C4916 (4.7/10V) ACG1122
C4821,C4835,C4871 (10/6.3V) ACG7046
C4875,C4896,C4923 (10/6.3V) ACG7046
C4877,C4880 CCSRCH181J50
C4859 CCSRCH331J50
C4861 CCSRCH680J50
C4885,C4888 CCSRCH681J50
C4822,C4862 CEHVKW101M6R3
C4898 CEHVKW470M6R3
C4802,C4805,C4806,C4808 CKSRYB105K10
C4813,C4814,C4820,C4833,C4834 CKSRYB105K10
C4836,C4838-C4841,C4847,C4848 CKSRYB105K10
C4850,C4851,C4878,C4879,C4889 CKSRYB105K10
C4894,C4895,C4922 CKSRYB105K10
C4853-C4858,C4860,C4865 CKSSYB103K16
C4869,C4870,C4890-C4893 CKSSYB103K16
C4807,C4809 CKSSYB104K10
C4801,C4819,C4845,C4846,C4864 CKSSYF104Z16
C4867,C4868,C4873,C4874 CKSSYF104Z16
C4881-C4884,C4886,C4887 CKSSYF104Z16
C4899-C4901,C4917,C4921,C4925 CKSSYF104Z16
C4844,C4863,C4866,C4872,C4876 DCH1165
RESISTORS
R4975,R4999 RD1/2LMF120J
R4784,R4786 RS1/16S1800F
R4785,R4787 RS1/16S5600F
Other Resistors RS1/16S###J
[IF UCOM BLOCK]
SEMICONDUCTORS
IC5002 HD64F3684FP
IC5003 PST9230N
IC5001 TC74VHC08FTS1
IC5004 TC7W126FU
Q5001 DTC124EUA
CAPACITORS
C5007,C5008 CCSSCH180J50
C5001 CEHVKW101M6R3
C5010 CKSSYB472K25
C5002-C5005,C5009,C5012 CKSSYF104Z16
RESISTORS
R5002,R5007,R5025-R5027 RAB4CQ103J
Other Resistors RS1/16S###J
OTHERS
X5002 CERAMIC RESONATOR ASS1168
X5001 CRYSTAL OSCILLATOR ASS1172
Mark No. Description Part No.
[MAIN UCOM BLOCK]
SEMICONDUCTORS
IC5202 BR24L64F-W
IC5206 MB91305PMC-G-BND
IC5207 MBM29DL162TE70TN
IC5210 MM1522XU
IC5209 PQ200WNA1ZPH
IC5203 PST3628UR
IC5201 TC74VHC125FTS1
Q5202 2SJ461A
Q5204 DTC124EUA
Q5201 SM6K2
D5203 1SS355
D5201 SML-311UT
CAPACITORS
C5235 CCSRCH221J50
C5244,C5245 CCSSCH120J50
C5217,C5218,C5237,C5239-C5243 CCSSCH470J50
C5246-C5249 CCSSCH470J50
C5238 CEHVKW100M35
C5201 CEHVKW101M6R3
C5261-C5263 CKSSYB102K50
C5216,C5233 CKSSYB103K16
C5215 CKSSYB472K25
C5253 CKSSYF103Z50
C5202-C5209,C5211-C5214,C5219 CKSSYF104Z16
C5222-C5232,C5234,C5252 CKSSYF104Z16
C5236 DCH1165
RESISTORS
R5262,R5268 ACN1248
R5205,R5213 RAB4CQ101J
R5253 RS1/10S0R0J
R5283 RS1/16S1001F
R5282 RS1/16S4701F
R5273 RS1/16S8201F
Other Resistors RS1/16S###J
OTHERS
CN5202 50P CONNECTOR AKM1201
K5201,K5202 TEST PIN AKX9002
X5201 CERAMIC RESONATOR ASS1178
[TEXT UCOM BLOCK]
SEMICONDUCTORS
IC5403 K4S641632H-TC75
IC5404 S29AL016D70TFI010
IC5405 SDA6000
IC5407 TC74LCX125FT
IC5402 TC7SH04FUS1
IC5406 TC7W126FU
Q5401,Q5406 DTA124EUA
Q5403,Q5407 DTC124EUA
D5404 1SS355
D5401 UDZS12(B)
D5402 UDZS3R0(B)
D5403 UDZS3R9(B)
COILS AND FILTERS
>
F5402,F5403 EMI FILTER CCG1162
Mark No. Description Part No.

PDP-R06G
20
1234
1234
C
D
F
A
B
E
CAPACITORS
C5412,C5438,C5453 (10/6.3V) ACG7046
C5422,C5423 CCSSCH200J50
C5404 CKSSYB102K50
C5403 CKSSYB103K16
C5445 CKSSYB104K10
C5405,C5406,C5408,C5410,C5413 CKSSYF104Z16
C5416,C5418,C5420,C5425,C5427 CKSSYF104Z16
C5429-C5431,C5434,C5435,C5440 CKSSYF104Z16
C5442,C5446,C5449,C5451,C5454 CKSSYF104Z16
C5456,C5458,C5460,C5476 CKSSYF104Z16
RESISTORS
R5409 ACN1251
R5404,R5428,R5429,R5434,R5435 BCN1067
R5439,R5457,R5476 RAB4CQ103J
R5432,R5460 RAB4CQ680J
Other Resistors RS1/16S###J
OTHERS
X5401 CRYSTAL ASS1193
[VDEC BLOCK]
SEMICONDUCTORS
IC6002 K4S161622H-TC60
IC6001 TVP5150AM1PBS
IC6003 UPD64015GM-UEU
Q6002 DTA124EUA
COILS AND FILTERS
>F6001,F6002,F6008-F6011,F6022 CCG1162
EMI FILTER
CAPACITORS
C6056,C6088 (10/6.3V) ACG7046
C6059,C6060 CCSSCH100D50
C6078,C6083 CCSSCH8R0D50
C6048-C6050 CKSRYB105K10
C6062,C6069 CKSSYB103K16
C6046,C6051,C6052,C6054,C6058 CKSSYB104K10
C6063,C6064,C6066,C6067 CKSSYB104K10
C6072,C6073,C6075-C6077 CKSSYB104K10
C6081,C6082,C6084,C6085 CKSSYB104K10
C6001-C6008,C6012-C6028 CKSSYF104Z16
C6031-C6045,C6047,C6053,C6055 CKSSYF104Z16
C6061,C6065,C6068,C6070,C6071 CKSSYF104Z16
C6074,C6079,C6080,C6090,C6091 CKSSYF104Z16
RESISTORS
R6010,R6062,R6068,R6072 ACN1246
R6065,R6073 BCN1067
R6007,R6023,R6030,R6071 RAB4CQ220J
R6063 RS1/16SS1001D
R6038,R6039,R6049 RS1/16SS2000F
R6054 RS1/16SS2201D
R6052 RS1/16SS6200D
Other Resistors RS1/16S###J
OTHERS
X6001 CRYSTAL ASS1189
X6002 CRYSTAL ASS1191
Mark No. Description Part No.
[ADC BLOCK]
SEMICONDUCTORS
IC6201 AD9985KSTZ-110
COILS AND FILTERS
>F6201,F6204 EMI FILTER CCG1162
CAPACITORS
C6205,C6209 CKSSYB104K10
C6207,C6210,C6218 CKSSYB473K16
C6202 CKSSYB822K16
C6201 CKSSYB823K10
C6203,C6204,C6206,C6208 CKSSYF104Z16
C6211,C6212,C6215-C6217 CKSSYF104Z16
C6222-C6224 CKSSYF104Z16
RESISTORS
R6213,R6218,R6223 BCN1067
R6202 RS1/16SS2701F
Other Resistors RS1/16S###J
[HDMI BLOCK]
SEMICONDUCTORS
IC6403 BR24L02FJ-W
IC6405 PCM1754DBQ
IC6404 SII9021CTU
Q6416 2SA1586
Q6414 DTA124EUA
Q6415 DTC124EUA
Q6405 HN1K02FU
Q6404 RN1902
D6408 1SS301
D6407 UDZS6R8(B)
COILS AND FILTERS
>F6401 EMI FILTER CCG1162
CAPACITORS
C6491 (10/6.3V) ACG7046
C6401,C6403,C6405,C6407,C6411 CCSSCH101J50
C6419,C6426,C6428,C6430,C6432 CCSSCH101J50
C6434,C6435,C6438,C6440,C6442 CCSSCH101J50
C6444,C6446,C6448,C6449,C6454 CCSSCH101J50
C6456,C6459,C6464,C6466,C6468 CCSSCH101J50
C6470,C6472,C6474,C6476,C6478 CCSSCH101J50
C6480,C6482 CCSSCH101J50
C6462,C6463 CCSSCH120J50
C6484 CEHVKW220M6R3
C6402,C6404,C6406,C6408,C6410 CKSSYF104Z16
C6412,C6414,C6416,C6418,C6420 CKSSYF104Z16
C6422,C6423,C6427,C6429,C6431 CKSSYF104Z16
C6433,C6436,C6437,C6439,C6441 CKSSYF104Z16
C6443,C6445,C6447,C6450,C6451 CKSSYF104Z16
C6455,C6457,C6458,C6460,C6461 CKSSYF104Z16
C6465,C6467,C6469,C6471,C6473 CKSSYF104Z16
C6475,C6477,C6479,C6481,C6483 CKSSYF104Z16
C6490 CKSSYF104Z16
RESISTORS
R6418,R6419,R6421 ACN1251
R6414 RAB4CQ100J
R6465 RAB4CQ103J
R6438 RAB4CQ470J
R6416 RAB4CQ680J
Mark No. Description Part No.