Polanik PP-170 User manual

TECHNICAL SPECIFICATION
USER MANUAL
Competition one-piece aluminium hurdle
PP- 70
S-0 8
File: 20 4-04-07
PRODUCT SUPPORT
Pawel Ciechanowski
[e-mail]

Technical specification and user manual PP- 70 (S-0 8) 2/7
Contents
Chapter Page
I. General description and use 2
II. Technical specification 3
III. Operation and maintenance 3
IV. Packing and transport 5
V. Product image 5
VI. IAAF Certificate (PP- 70) 6
VII. Declaration (S-0 8) 7
I. General description and use
PP- 70 (S-0 8) is a highly resistant to weather, very much durable competition hurdle, which is designed for hurdle
race in national and international competitions. Main features:
•very durable construction – anodized one-piece aluminium frame, anodized telescope tubes and highly
durable plastic top board made of ribbed profile
•easy to stack up because of special square feet
•spring-loaded button systems of height adjustment and counterweight selection
•special cut-outs for mounting crossbars
•it meets the international quality standards
•PP- 70 has got the IAAF certificate E-01-0331

Technical specification and user manual PP- 70 (S-0 8) 3/7
II. Technical specification
*There may be differences in hue among the telescope tubes within one production batch.
Code PP- 70 S-0 8
Hurdle type one piece, competition, certified one piece, competition
(A) Top board plastic, with inside ribbing plastic, with inside ribbing
(B) Telescope tube anodized aluminium and dyed in blue*, spring-
loaded button system of height adjustment
anodized aluminium and dyed in blue*, spring-
loaded button system of height adjustment
(C) Frame aluminium anodized aluminium anodized
(D) Feet aluminium anodized, permanently fixed to
hurdle frame, spring-loaded button system of
toppling force selection, counterweights
equipped with guide rolls, special square profile
makes it easy to stack up
aluminium anodized, permanently fixed to
hurdle frame, spring-loaded button system of
toppling force selection, counterweights
equipped with guide rolls, special square profile
makes it easy to stack up
Heights [mm] - 686
762 762
840 840
9 4 9 4
990 990
067 067
Weight [kg] 2 2
A
B
C
D

Technical specification and user manual PP- 70 (S-0 8) 4/7
III. Operation and maintenance
The hurdle is ready for use immediately after delivery.
The height adjustment is done as follows:
a) while holding the telescope tubes press the
spring-loaded buttons simultaneously,
b) slide the telescopes down or up to adjust the
height until the buttons click,
c) next the hurdle toppling force should be
adjusted accordingly, so pull and hold the knob
in the hurdle foot,
d) then slide the counterweight to the
corresponding height according to the label,
then release the knob, do the same with the
other hurdle foot.
During idle periods the hurdles must be stored in a roofed dry place. For optimal performance they should be stored
and transported on Polanik hurdle carts: HC-23 and HC-34. After every athletics season the hurdles must be cleaned
from sand (mud, dust and etc).
Even the best technical solutions cannot substitute for common sense. The usage of the product must take place
under the supervision of qualified coaches. The producer shall not be liable for any incidents caused by its misuse.

Technical specification and user manual PP- 70 (S-0 8) 5/7
IV. Packing and transport
The hurdles are put on pallets ( 5 pcs on one pallet) and wrapped with foil for short distances or sent overseas in
cases.
V. Product image
PP- 70 © 20 4 Polanik Sp. z o. o. The producer reserves the right to introduce without warning changes in product
constructions and colours.
Packing type foiled pallet case
Package’s
dimensions [cm]
contents
5 hurdles
5 hurdles
length
22
27
width
08
3
height
75
87
Volume [ m3] 2,3 2,68
Gross weight [kg] 2 0 250

Technical specification and user manual PP- 70 (S-0 8) 6/7
VI. I F Certificate (PP-170)

Technical specification and user manual PP- 70 (S-0 8) 7/7
VII. Declaration (S-018)
)No. 20 4-04-07
2)Issuer’s name: POLANIK
Issuer’s address: Zyczliwa , 97-300 Piotrkow Tryb.
3)Object of declaration:
4)The object of declaration described above is in conformity with the requirements of the following documents:
Articles Document title Issuer
Rule 68
IAAF Competition Rules
20 4-20 5
International Association of Athletics Federations
7, rue Princesse Florestine
BP 359 – MC 98007 Monaco Cedex
Tel. [phone]
Fax [phone]
www.iaaf.org
Additional Information
5)Declaration for:
Buyer/Distributor/User
Signed for and in behalf of:
POLANIK
20 4-04-07 Piotrków Tryb.
(Date and place of issue)
6)Pawel Ciechanowski
Product Manager
…………………….………………….. ……………………………………………………………………………
(Name, function) (Signature or equivalent authorized by the issuer)
No. Description of goods Code
Competition one-piece aluminium hurdle S-018