Polar Electro GL178-A User manual

Model:
GL178-A
Refrigerated Prep
Counter
Instruction manual
GL178-A_A5_v2_20200907.indb 1GL178-A_A5_v2_20200907.indb 1 2020/9/7 11:272020/9/7 11:27

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable
surface.
• A service agent/qualified
technician should carry out
installation and any repairs if
required.
• Consult Local and National
Standards to comply with the
following:
- Health and Safety at Work
Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT immerse the
appliance in water, or use
jet/pressure washers to
clean the appliance.
• Do not store explosive
substances such as aerosol
cans with a flammable
propellant inside the
appliance.
• Do not use the appliance
for anything other than its
intended use.
• Always switch off and
disconnect the power supply to
the appliance when not in use.
• Not suitable for outdoor use.
• Keep all packaging away
from children. Dispose of
the packaging in accordance
to the regulations of local
authorities.
• If the power cord is damaged,
it must be replaced by a POLAR
agent or a recommended
qualified technician in order to
avoid a hazard.
• This appliance is not
intended for use by persons
(including children) with
reduced physical, sensory or
mental capabilities, or lack of
experience and knowledge,
unless they have been given
supervision or instruction
concerning the use of the
appliance by a person
responsible for their safety.
• Children should be
supervised to ensure that
they do not play with the
appliance.
• Polar recommend that
this appliance should be
periodically tested (at least
annually) by a Competent
Person. Testing should
include, but not be limited
to: Visual Inspection, Polarity
Test, Earth Continuity,
Insulation Continuity and
Functional Testing.
GL178-A_A5_v2_20200907.indb 2GL178-A_A5_v2_20200907.indb 2 2020/9/7 11:272020/9/7 11:27

3
AU
Telephone Helpline: 1300225960
Caution: Risk of Fire
• Do not store explosive substances such as aerosol cans
with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
• POLAR Refrigerated Prep Counter
• GN Support Bars (3 standard, 1 wide)
• Instruction Manual
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
Note: If the appliance has been stored or moved in a non-vertical position, stand
it in an upright position for approximately 12 hours before operation. If in doubt
allow to stand.
1. Remove the appliance from the packaging and remove the protective film from all surfaces.
2. When positioning, maintain a distance of 20cm (7 inches) between the appliance and walls or other
objects for ventilation. NEVER LOCATE NEXT TO OR NEAR A HEAT SOURCE.
Note: Before using the appliance for the first time, clean the interior with soapy
water.
GL178-A_A5_v2_20200907.indb 3GL178-A_A5_v2_20200907.indb 3 2020/9/7 11:272020/9/7 11:27

4
AU Telephone Helpline: 1300225960
GN Pan Layout
This unit is designed to use standard 1/3 GN and 1/6 GN pans, or combination of both (not supplied).
Common pan configuration and support bar usage (support bars supplied):
Pan layout uses 1 wide
support bar
1/3 GN 1/3 GN
1/3 GN1/3 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
Pan layout uses 3
support bars
1/3 GN 1/3 GN
1/3 GN1/3 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
1/6 GN 1/6 GN
Operation
Control panel
Refrigerant LED is on. Compressor is
running
Defrost LED is on. Unit is defrosting,
compressor is not running
Up Button
Down Button
Manual defrost button
SET Set button
I/O On/off
GL178-A_A5_v2_20200907.indb 4GL178-A_A5_v2_20200907.indb 4 2020/9/7 11:272020/9/7 11:27

5
AU
Telephone Helpline: 1300225960
Adjusting the Temperature
1. Press SET button. The set temperature is displayed.
2. Press up button or down button to change set temperature.
3. Press SET button to exit.
Manual Defrost
1. To start manual defrost press defrost button and hold for 6 seconds.
2. To stop manual or automatic defrost press defrost button .
Note: The appliance is not intended for the long term storage of food.
Cleaning, Care & Maintenance
• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible
• Do not use abrasive cleaning agents. These can leave harmful residues
• Always wipe dry after cleaning
Cleaning the Condenser
Periodic cleaning of the Condenser can extend the life of the appliance.
POLAR recommend that a POLAR agent or qualified technician clean the condenser.
Troubleshooting
If the machine malfunctions due to causes other than those listed or the proposed corrective actions do
not solve the problem please call a Polar agent or qualified technician.
Fault Probable Cause Solution
The appliance is
not working
The unit is not switched on Check the unit is plugged in correctly and switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance is
not cooling
Coolant Leak Call POLAR agent or qualified technician
Fan Motor Failed Call POLAR agent or qualified technician
Airflow to the condenser
obstructed
Increase the gap between appliance and obstacles/
heat source
Condenser is clogged Call POLAR agent or qualified technician
Error code EE4 • Restricted Airflow
• Blocked Condenser
• Increase airflow
• Call POLAR agent or qualified Technician
GL178-A_A5_v2_20200907.indb 5GL178-A_A5_v2_20200907.indb 5 2020/9/7 11:272020/9/7 11:27

6
AU Telephone Helpline: 1300225960
Technical Specifications
Model Voltage Power
(W)
Current
(A)
Capacity
(Litres) Refrigerant Dimensions H x W x D mm
Weight
(kg)
GL178-A 220-240V~
50Hz
105 0.7 67 R600a 328 x 767 x 612 22.5
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with
regulatory standards and specifications set by international, independent, and
federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
GL178-A_A5_v2_20200907.indb 6GL178-A_A5_v2_20200907.indb 6 2020/9/7 11:272020/9/7 11:27

DECLARATION OF CONFORMITY
•Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
Refrigerated Countertop Prep Counter with Chopping board
GL178 (& -E -A)
Application of Territory Legislation &
Council Directives(s)
Toepassing van Europese Richtlijn(en)
• Application de la/des directive(s) du
Conseil • Anwendbare EU-Richtlinie(n)
• Applicazione delle Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Low Voltage Directive (LVD) - 2014/35/EU
EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A2:2019
EN 60335-2-89:2010 +A1:2016 +A2:2017
EN 62233:2008
Electro-Magnetic Compatibility (EMC)
Directive 2014/30/EU - recast of
2004/108/EC
EN 61000-6-1: 2007
EN 61000-6-1: 2007+A1:2011
Restriction of Hazardous Substances
Directive (RoHS) 2015/863 amending Annex
II to Directive 2011/65/EU
Electrical Safety
EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A2:2019
EN 60335-2-89:2010 +A1:2016 +A2:2017
EN 62233:2008
Electromagnetic Compatibility
EN 61000-6-1: 2007
EN 61000-6-1: 2007+A1:2011
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Polar
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift des
Herstellers • Indirizzo del produttore •
Dirección del fabricante • Morada do
fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
42 North Point
Business Park
New Mallow Road
Cork
Ireland
15 Bagdally Road,
Campbelltown
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation,
Directive(s) and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en)
entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es)
arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data • Fecha • Data
2nd September 2020
Signature • Handtekening • Signature • Unterschrift
Firma • Firma • Assinatura
Full Name • Volledige naam • Nom et prénom •
Vollständiger Name • Nome completo
•Nombre completo • Nome por extenso
Ashley Hooper Josie Holt
Position • Functie • Fonction • Position • Qualifica
•Posición • Função
Technical & Quality Manager
Commercial Manager/
Responsible Supplier
GL178-A_A5_v2_20200907.indb 7GL178-A_A5_v2_20200907.indb 7 2020/9/7 11:272020/9/7 11:27

GL178-A_A5_v2_20200907
http://www.polar-refrigerator.com/
GL178-A_A5_v2_20200907.indb 8GL178-A_A5_v2_20200907.indb 8 2020/9/7 11:272020/9/7 11:27