Potterton Paramount four User manual

United Kingdom
en
Installation manual
Gas condensing boiler
Paramount four
30 – 115 kW

Dear Customer,
Thank you very much for buying this appliance.
Please read through the manual carefully before using the product, and keep it in a safe place for later reference. In order to
ensure continued safe and efficient operation we recommend that the product is serviced regularly. Our service and customer
service organisation can assist with this.
We hope you enjoy years of problem-free operation with the product.

Contents
1 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.1 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.2 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.3 Specific safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.3.1 Liquid gas below ground level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.4 Liabilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.4.1 Manufacturer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.4.2 Manufacturer’s Declaration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1.4.3 Installer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
1.4.4 User's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2 About this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.2 Additional documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.2.1 Additional documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.3 Symbols used . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.3.1 Symbols used in the manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3 Technical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.1 Homologations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.1.1 Regulations and standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.2 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
3.2.1 Technical data – Boiler space heaters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.2.2 Technical data – Boiler space heaters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.2.3 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
3.2.4 Tables of sensor values . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
3.2.5 Total dynamic head Paramount four . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
3.3 Dimensions and connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
3.4 Dimensions and connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
3.5 Wiring diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
4 Description of the product . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
4.1 Main components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
4.1.1 Room device RGT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
4.2 Control panel description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4.2.1 Operating elements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4.2.2 Displays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4.3 Standard delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4.4 Accessories and options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4.4.1 Installation of extension module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
5 Before installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
5.1 Regulations governing installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
5.2 Installation requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
5.2.1 Corrosion protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
5.2.2 Supply air openings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
5.2.3 Heating water requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
5.2.4 Further information on the heating water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29
5.2.5 Diagram of water hardness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
5.2.6 Treating and preparing the heating water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
5.2.7 Water hardness tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
5.3 Choice of the location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
5.3.1 Requirements for the installation room . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
5.3.2 Notes for installation location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33
5.3.3 Operation in wet rooms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
6 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
6.1 Water connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
6.1.1 Connecting the heating circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
6.1.2 Safety valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
6.1.3 Condensate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Contents
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 3

6.1.4 Sealing and filling of the system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
6.2 Gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
6.2.1 Gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
6.2.2 Venting the gas line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
6.3 Air supply/flue gas connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
6.3.1 Flue gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
6.3.2 Permissible flue gas pipe lengths . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
6.3.3 General information about the exhaust gas piping system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
6.3.4 Mounting the flue gas system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
6.3.5 Outlets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
6.3.6 Chimneys already in use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
6.3.7 Cleaning and inspection openings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41
6.4 Electrical connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
6.4.1 Electrical connection (general) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
6.4.2 Cable lengths . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42
6.4.3 Strain reliefs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42
6.4.4 Replacing cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
6.4.5 Protection against contact . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
6.4.6 IP rating IPx4D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43
6.4.7 Circulating pumps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
6.4.8 Appliance fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
6.4.9 Connecting sensors/components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
7 Commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
7.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
7.2 Checklist for commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
7.3 Commissioning procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
7.3.1 Commissioning menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
7.4 Gas settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
7.4.1 Factory settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
7.4.2 Supply pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45
7.4.3 CO2 content . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
7.4.4 Changing over from natural gas to LPG and vice versa . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
7.4.5 Gas valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47
7.4.6 Manual adjustment of burner output (controller stop function) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
7.4.7 Guidance values for gas flow rate, injector pressure and CO2 content . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
7.4.8 Guidance values for the gas flow rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
7.4.9 Guidance values for the gas flow rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
7.4.10 Guidance values for injector pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
7.4.11 Guidance values for injector pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
8 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51
8.1 Changing parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
8.2 Programming procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
8.3 Tips for commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
8.4 Checking water pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
8.5 Checking the domestic water storage tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
8.6 Preparing start-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
8.7 Setting the heating mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
8.8 Adjusting domestic water mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
8.9 Adjusting comfortable room setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54
8.10 Setting reduced room setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
8.11 Pump setting (pumped heating circuit) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
8.12 Emergency mode (Manual control) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56
8.13 Chimney sweep function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56
9 Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
9.1 List of parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
9.2 Description of the parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
9.2.1 Time and date . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
9.2.2 Operator section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
9.2.3 Wireless . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81
9.2.4 Time programs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82
9.2.5 Holiday programs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82
9.2.6 Heating circuits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
9.2.7 Domestic water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Contents
4 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

9.2.8 Consumer circuits/Swimming pool circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
9.2.9 Swimming pool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
9.2.10 Primary control/feed pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93
9.2.11 Boiler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
9.2.12 Cascade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97
9.2.13 Solar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
9.2.14 Solid fuel boiler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
9.2.15 Buffer storage tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
9.2.16 DHW storage tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
9.2.17 Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
9.2.18 LPB system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
9.2.19 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .115
9.2.20 Maintenance / special operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
9.2.21 Configuration of extension modules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
9.2.22 Input/output test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .121
9.2.23 Status . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .121
9.2.24 Diagnostics cascade/heat generation/consumers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
9.2.25 Burner control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
9.2.26 Info option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
10 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
10.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
10.1.1 General instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .128
10.1.2 Inspection and service as required . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
10.1.3 Protection against contact . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
10.1.4 Approved detergents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
10.1.5 Unhooking the control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
10.1.6 At the end of the maintenance work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
10.2 Maintenance messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
10.2.1 Maintenance code table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130
10.2.2 Operating phases of the Control Centre LMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
10.3 Standard inspection and maintenance operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
10.3.1 Clean siphon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
10.3.2 Check electrodes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .131
10.4 Specific maintenance instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .131
10.4.1 Replacing air vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
10.4.2 Removing the gas burner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
10.4.3 Removing gas valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
10.4.4 Removing the heat exchanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133
11 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134
11.1 Error codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
11.1.1 Fault code table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
11.2 Fault finding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136
11.2.1 Fault switch-off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136
12 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138
12.1 Disposal/recycling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
12.1.1 Packaging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
12.1.2 Appliance disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138
13 Appendix . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139
13.1 Declaration of conformity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139
13.1.1 Declaration of conformity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .139
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Contents
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 5

1 Safety
1.1 General safety instructions
Danger
If you smell gas:
1. Do not use a naked flame, do not smoke, do not
operate electrical contacts or switches (doorbell,
light, motor, lift, etc.).
2. Shut off the gas supply.
3. Open the windows.
4. Trace possible leaks and seal them immediately.
5. If the gas leak is before the gas meter, contact the
gas supplier.
Danger
Danger to life.
Observe the warnings affixed to the gas condensing
boiler. Incorrect operation of the gas condensing boil
er can lead to considerable damage.
Danger
Danger to life.
Commissioning, settings, maintenance and cleaning
of gas condensing boilers may only be carried out by
a qualified installer.
Danger of electric shock
Danger to life due to improper work.
All electrical work in connection with the installation
may only be carried out by a trained electrician.
Danger
Risk of poisoning.
Never use water from the heating system as drinking
water. It is contaminated by deposits.
Caution
Danger of freezing!
If there is a danger of freezing do not shut down the
heating system; continue to operate it at least in econ
omy mode with radiator valves open. You should only
shut down the heating system and drain the boiler, do
mestic water storage tank and radiators if it is not pos
sible to heat in frost mode.
Caution
Secure against unintentional switch-on!
When the heating system is empty, ensure that the
boiler cannot be switched on unintentionally.
1 Safety
6 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Danger
This appliance can be used by children aged 8 years
and above and by persons with reduced physical,
sensory or mental capabilities or lack of experience
and knowledge when they have been given supervi
sion or instruction concerning the safe use of the de
vice and understand the resulting risks. Children must
not be allowed to play with the appliance. Cleaning
and user maintenance must not be carried out by chil
dren without supervision.
Danger
The heating system must not continue to be operated
if damaged.
Danger
Danger! Danger to life through modifications to the ap
pliance.
Unauthorised conversions and modifications to the
gas appliance are not permitted, as this can endanger
persons and cause damage to the appliance. The ap
pliance approval will become void if these instructions
are not observed.
Caution
Replacement of damaged parts may only be per
formed by a qualified installer.
Caution
Connections sealed with thread sealant must never be
opened or modified by a non-specialist. The seals
serve as proof that essential connections for safe,
trouble-free operation have not been tampered with.
The guarantee becomes void if the seals are dam
aged.
Warning
Risk of damage.
The gas condensing boiler may only be installed in
rooms with clean combustion air. Foreign matter such
as pollen must never filter through the inlet apertures
to reach the inside of the appliance. The boiler must
not be started up if there is heavy dust development
e.g. during construction work. There could be damage
to the boiler.
Caution
Keep the inflow area clear.
Never block or close off ventilation apertures. The in
flow area for combustion air must be kept clear.
1 Safety
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 7

Danger
Danger to life due to explosion/fire.
Do not store any explosive or easily flammable materi
als close to the appliance.
Caution
Risk of burns!
For safety reasons, the discharge pipe from the safety
valve must always be open so that water can escape
during heating operation. The operating state of the
safety valve must be checked from time to time.
1.2 Intended use
The gas condensing boilers of the Paramount four series are
intended to be used according to DIN EN 12828 as heat
generators in domestic water heating systems.
They conform to DIN EN 483 and 677.
1.3 Specific safety instructions
1.3.1 Liquid gas below ground level
The Paramount four complies with DIN EN 126 and DIN EN
298 and, therefore does not need an additional disconnector
valve for operation with liquid gas below ground level.
1.4 Liabilities
1.4.1 Manufacturer's liability
Our products are manufactured in compliance with the re
quirements of the various Directives applicable. They are
therefore delivered with the marking and any documents
necessary. In the interests of the quality of our products, we
strive constantly to improve them. We therefore reserve the
right to modify the specifications given in this document.
Our liability as manufacturer may not be invoked in the fol
lowing cases:
Failure to abide by the instructions on installing the appli
ance.
Failure to abide by the instructions on using the appliance.
Faulty or insufficient maintenance of the appliance.
1.4.2 Manufacturer’s Declaration
Meeting the protection requirements according to guideline
2004/108/EC for electromagnetic compatibility (EMC) is only
guaranteed when the boiler is operated according to pur
pose.
The ambient conditions according EN 55014 must be met.
1 Safety
8 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Operation is only allowed with the casing fitted correctly.
Correct electric earthing must be ensured by regular checks
(e.g. annual inspection) of the boiler.
When appliance parts need replacing, only original parts as
specified by the manufacturer may be used.
The gas condensing-boilers fulfil the basic requirements of
the Efficiency Guideline 92/42/EC as condensing boiler.
1.4.3 Installer's liability
The installer is responsible for the installation and initial com
missioning of the appliance. The installer must abide by the
following instructions:
Read and follow the instructions given in the manuals pro
vided with the appliance.
Install the appliance in compliance with prevailing legisla
tion and standards.
Carry out initial commissioning and any checks necessary.
Explain the installation to the user.
If maintenance is necessary, warn the user of the obliga
tion to check the appliance and keep it in good working or
der.
Give all the instruction manuals to the user.
1.4.4 User's liability
To guarantee optimum operation of the system, you must
abide by the following instructions:
Read and follow the instructions given in the manuals pro
vided with the appliance.
Call on a qualified professional to carry out installation and
initial commissioning.
Get your installer to explain your installation to you.
Have the required inspections and maintenance carried out
by a qualified installer.
Keep the instruction manuals in good condition close to the
appliance.
1 Safety
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 9

2 About this manual
2.1 General
This manual is intended for installers of Paramount four boilers.
2.2 Additional documentation
2.2.1 Additional documentation
Here is an overview of the further documents belonging to this heating
system.
Tab.1 Overview table
Documentation Contents Intended for
Technical information Planning documents
Description of function
Technical data/circuit diagrams
Basic equipment and accessories
Application examples
Call-for-tender texts
Planner, installer, customer
Installation manual
– Extended information
Intended use
Technical data/circuit diagram
Regulations, standards, CE
Notes for installation location
Application example, Standard application
Commissioning, operation and programming
Maintenance
Installer
User manual Commissioning
Operation
User settings/programming
Fault table
Cleaning/maintenance
Energy-saving tips
Customer
Asset ledger Commissioning report
Check list for commissioning
Maintenance
Installer
Abridged instructions Operation in brief Customer
Accessories Installation
Operation
Installer, customer
2.3 Symbols used
2.3.1 Symbols used in the manual
This manual uses various danger levels to draw attention to special in
structions. We do this to improve user safety, to prevent problems and to
guarantee correct operation of the appliance.
2 About this manual
10 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Danger
Risk of dangerous situations that may result in serious personal
injury.
Danger of electric shock
Risk of electric shock.
Warning
Risk of dangerous situations that may result in minor personal in
jury.
Caution
Risk of material damage.
Note
Please note: important information.
See
Reference to other manuals or pages in this manual.
2 About this manual
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 11

3 Technical specifications
3.1 Homologations
3.1.1 Regulations and standards
Beside the general technical rules, the relevant standards, regulations, or
dinances and guidelines should be followed:
DIN 4109; Noise protection in construction engineering
DIN EN 12828; Heating systems in buildings
Federal Immission Control Ordinance 3. BImSchV
DVGW-TRGI 2008 (DVGW worksheet G 600); Technical rules for gas
installation
TRF; Technical rules LPG
DVGW code of practice G 613; Gas appliances - Installation, mainte
nance and operating instructions
DIN 18380; Heating plants and central hot water plants (VOB)
DIN EN 12831; Heating plants in buildings
DIN 4753-6: Domestic hot water calorifiers Domestic hot water heating
system and storage tanks for heated water
DIN 1988; Technical Rules for drinking water installations (TRWI)
DIN EN 60335-2-102: Safety of electrical appliances for household use
and similar purposes: Special requirements for gas-, oil- und solid fuel
appliances with electrical connections
Fuel Ordinance, State Ordinances
Regulations of the local Electricity Board
Obligation to register (possibly. Group Exemption Regulation )
ATV-Code-of-practice M251 of the waste water technology association
Regulations of the public authorities for the run-off of condensate.
3.2 Technical data
3.2.1 Technical data – Boiler space heaters
Tab.2 Technical parameters for boiler space heaters
Model Paramount four
30
Paramount four
40
Condensing boiler Yes Yes
Low-temperature boiler(1) No No
B1 boiler No No
Cogeneration space heater No No
Combination heater No No
Rated heat output Prated kW 29 37
Useful heat output at rated heat output and high tem
perature mode(2)
P4 kW 29.2 36.8
Useful heat output at 30 % of rated heat output and low
temperature mode(1)
P1 kW 9.8 12.3
Seasonal space heating energy efficiency ƞs % 93 93
Useful efficiency at rated heat output and high temper
ature mode(2)(2)
ƞ4 % 87.6 87.7
Useful heat output at 30 % of rated heat output and low
temperature mode(1)
ƞ1 % 97.9 97,8
Auxiliary power consumption
At full load elmax kW 0.055 0.070
At part load elmin kW 0.021 0.025
3 Technical specifications
12 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Model Paramount four
30
Paramount four
40
In standby mode PSB kW 0.003 0.003
Other data
Standby heat loss Pstby kW 0.055 0.055
Ignition burner power consumption Pign kW 0.0 0.0
Annual energy consumption QHE GJ 90 114
Sound power level, indoors LWA dB 50 53
Emissions of nitrogen oxides NOXmg/kWh 23 23
(1) Low temperature means for condensing boilers 30°C, for low temperature boilers 37°C and for other heaters 50°C return temperature (at
heater inlet).
(2) High temperature mode means 60°C return temperature at heater inlet and 80°C feed temperature at heater outlet.
See
Contact details on the back cover.
3.2.2 Technical data – Boiler space heaters
Tab.3 Technical parameters for boiler space heaters
Model Paramount
four 50
Paramount
four 60
Paramount
four 80
Paramount
four 95
Paramount
four 115
Condensing boiler Yes Yes Yes Yes Yes
Low-temperature boiler(1) No No No No No
B1 boiler No No No No No
Cogeneration space heater No No No No No
Combination heater No No No No No
Rated heat output Prated kW 49 56 75 93 112
Useful heat output at rated heat out
put and high temperature mode(2)
P4 kW 48.7 56.4 74.9 92.5 111.7
Useful heat output at 30% of rated
heat output and low temperature
mode(1)
P1 kW 16.3 18.9 25.1 31.0 37.4
Seasonal space heating energy effi
ciency
ƞs % 93 93 – – –
Useful efficiency at rated heat output
and high temperature mode(2)
ƞ4 % 87.7 87.7 87.7 87.8 87.6
Useful heat output at 30% of rated
heat output and low temperature
mode(1)
ƞ1 % 97.9 97,8 97,8 98,0 97,8
Auxiliary power consumption
At full load elmax kW 0.088 0.100 0.112 0.170 0.200
At part load elmin kW 0,028 0,029 0.030 0,029 0.030
In standby mode PSB kW 0.003 0.003 0.003 0.003 0.003
Other data
Standby heat loss Pstby kW 0.060 0.060 0.065 0.070 0.070
Ignition burner power consumption Pign kW 0.0 0.0 0.0 0.0 0.0
Annual energy consumption QHE GJ 151 175 – – –
Sound power level, indoors LWA dB 56 55 55 58 60
3 Technical specifications
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 13

Model Paramount
four 50
Paramount
four 60
Paramount
four 80
Paramount
four 95
Paramount
four 115
Emissions of nitrogen oxides NOXmg/kW
h
18 21 23 25 30
(1) Low temperature means for condensing boilers 30°C, for low temperature boilers 37°C and for other heaters 50°C return temperature (at
heater inlet).
(2) High temperature mode means 60°C return temperature at heater inlet and 80°C feed temperature at heater outlet.
See
Contact details on the back cover.
3.2.3 Technical data
Tab.4 Technical data
Model Para‐
mount
four 30
Para‐
mount
four 40
Para‐
mount
four 50
Para‐
mount
four 60
Para‐
mount
four 80
Para‐
mount
four 95
Para‐
mount
four 115
Product ID no. CE-0085BL0514
IP rating IPx4D
Gas category II2H3+
Appliance category B23, B23P, B33, C13X, C33X, C43X, C53, C53X, C63X, C83, C93X
Software version V 4.2
Nominal heat input
range
Natural gas
E, LL
Heating
mode
kW 5,6 -
30,0
9,0 -
38,0
10,0 -
50,0
14,0 -
58,0
21,0 -
77,0
20,0 -
95,0
25,0 -
115,0
Effective rated output
range
Natural gas
E, LL
80/60°C kW 5,4 -
29,2
8,7 -
37,0
9,7 -
48,7
13,6 -
56,4
20,3 -
74,9
19,4 -
92,5
24,3 -
111,7
50/30°C kW 6,0 -
31,2
9,7 -
39,6
10,8 -
52,1
15,1 -
60,4
22,6 -
80,2
21,4 -
98,6
26,7 -
119,3
Standard operating efficiency 75/60°C 106
pH value condensate – 4 - 5 4 - 5 4-5 4-5 4-5 4 - 5 4 - 5
Volume condensate 40/30°C l/h 0,83 -
3,00
1,19 -
2,84
1,60 -
4,68
1,78 -
4,71
2,53 -
6,46
2,75 -
8,42
3,85 -
9,61
NOX standard emission factor mg/k
Wh
17 20 20 20 20 25 30
CO standard emission factor mg/k
Wh
5 10 10 10 10 20 20
Data for design of the chimney to DIN EN 13384 (room air-dependant operation)
Flue gas temperature Part load/full
load
80/60°C °C 53/66 56/75 58/69 59/71 59/73 59/73 60/77
Part load/full
load
50/30°C °C 33/46 35/53 33/50 34/54 35/54 32/51 33/57
Flue gas mass flow
rate
Natural gas
E, LL
80/60°C g/s 2,8 -
14,8
4,4 -
18,7
4,9 -
24,6
6,9 -
28,5
10,3 -
37,9
9,8 -
46,7
12,3 -
56,6
With natural gas 50/30°C g/s 2,5 -
14,1
4,1 -
18,0
4,5 -
23,5
6,4 -
27,4
9,7 -
36,4
9,1 -
44,8
11,3 -
54,4
Flue gas mass flow
rate
Propane 80/60°C g/s 2,6 -
14,1
4,2 -
17,8
5,6 -
23,5
6.6 -
27.2
9,8 -
36,1
14,1 -
44,6
16,4 -
53,9
for LPG 50/30°C g/s 2,4 -
13,4
3,9-
17,1
5,2 -
22,4
6,1 -
26,1
9,2 -
34,6
13,3 -
42,6
15,4 -
51,7
CO2 content natural
gas
Natural gas
E, LL
% Paramount four 30 - Paramount four 60: 8,3 - 8,8
Paramount four 80 - 115: 8,5 - 9,0
CO2 content LPG Propane % 10,3 - 10,8
Draft requirement mbar 0
3 Technical specifications
14 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Model Para‐
mount
four 30
Para‐
mount
four 40
Para‐
mount
four 50
Para‐
mount
four 60
Para‐
mount
four 80
Para‐
mount
four 95
Para‐
mount
four 115
Max. delivery pressure at flue gas
outlet
mbar 1,1 1,1 1,1 1,1 1,1 1,5 1,8
Flue gas/air supply
duct
mm 110 / 160
Flue gas value group to DVGW G636 – G6
Heating water
Adjustment range heating water temperature °C 20 - 85 20 - 85 20 - 85 20 - 85 20 - 85 20 - 85 20 - 85
Max. flow temperature °C 100
Water operating pres
sure
min. bar 1,0 1,0 1,0 1,0 1,0 1,0 1,0
MPa 0,1 0,1 0,1 0,1 0,1 0,1 0,1
max. bar 3.0 3,0 4,0 4,0 4,0 4,0 4,0
MPa 0,3 0,4 0,4 0,4 0,4 0,4 0,4
Gas connected loads
Supply pressure for natural gas mbar G20: min. 17 - max. 25
Connection values Natural gas E [HUB
9,45 kWh/m³]
m³/h 0,59 -
3,2
0.95 -
4.0
1,06 -
5,30
1,48 -
6,10
2,22 -
8,10
2,12 -
10,10
2,65 -
12,20
Natural gas LL [HUB
8,13 kWh/m³]
m³/h 0,69 -
3,7
1,11 -
4,7
1,23 -
6,20
1,72 -
7,10
2,58 -
9,50
2,46 -
11,70
3,08 -
14,10
Connection pressure for propane mbar min. 25 - max. 45
Propane [HU 12,87
kWh/kg]
kg/h 0,44 -
2,33
0,70 -
2,95
0,93 -
3,89
1,09 -
4,51
1,63 -
5,98
2,33 -
7,38
2,72 -
8,94
Propane [HU 24,64
kWh/m³]
m³/h 0,23 -
1,22
0,37 -
1,54
0,49 -
2,03
0,57 -
2,35
0,85 -
3,13
1,22 -
3,86
1,42 -
4,67
Electrical power consumption
Electrical connection V/Hz 230 V / 50 Hz
Max. electr. power consumption W 55 70 88 100 108 160 200
Heating mode Protection W 3 3 3 3 3 3 3
Dimensions
Weight of boiler kg 53 53 61 61 72 84 84
Boiler water content l 3,6 3,6 4,7 4,7 5,8 7,8 7,8
Height mm 852
Width mm 480
Depth mm 407 407 447 447 542 570 570
Connections
Gas connection 3/4" 1"
Heating flow 1" 1 1/2”
Heating return 1" 1 1/2”
3.2.4 Tables of sensor values
Tab.5 Resistance values for outside temperature sensor ATF
Temperature [°C] Resistance [Ω]
-20 8194
-15 6256
3 Technical specifications
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 15

Temperature [°C] Resistance [Ω]
-10 4825
-5 3758
0 2954
5 2342
10 1872
15 1508
20 1224
25 1000
30 823
Tab.6 Resistance values for flow sensor KVF, drinking water sensor
TWF, return sensor KRF, sensor B4
Temperature [°C] Resistance [Ω]
0 32555
5 25339
10 19873
15 15699
20 12488
25 10000
30 8059
35 6535
40 5330
45 4372
50 3605
55 2989
60 2490
65 2084
70 1753
75 1481
80 1256
85 1070
90 915
95 786
100 677
3 Technical specifications
16 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

3.2.5 Total dynamic head Paramount four
Fig.1 Total dynamic head Paramount four 30 - Paramount four 40
Wms [kg/h]
0 200 400 600 800 1000 1200 1400 1600 1800 2000 2200
100%
80%
67%
60%
0
1
2
3
4
5
6
7
8
50%
40%
30%
20%
Rfh [mWS]
Dmax 1
Rfh (100%)
Dmin 1/2
Dmax 2
10%
Pst
RA-0000195
Key:
Dmax 1 Paramount four 30 (max.)
Dmax 2 Paramount four 40 (max.)
Dmin 1/2 Paramount four 30 (min.)
Paramount four 40 (min.)
Pst Pumping stage
Rfh Total dynamic head
Wms Water mass flow
Note
The select min. and max. values are controlled via the program
numbers for minimum pump speed and maximum pump speed.
3 Technical specifications
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 17

3.3 Dimensions and connections
Fig.2 Dimensions and Connections Paramount four 30 / 40
1 2
3
4
5
6
7 8
260
70
97
RA-0000169
9
1HV – Heating flow
2HR – Heating return
32. HR – Heating return, heating circuit 2
4Gas – Gas connection
5SiV – Safety valve
6KA – Condensate connection
7SV – Storage tank flow (accessory)
8SR – Storage tank return (accessory)
Tab.7 Dimensions and connections
Model Paramount four 30/40
HV – Heating flow G 1"
3 Technical specifications
18 Paramount four 30 – 115 kW 7658013 - 02 - 15092016

Model Paramount four 30/40
HR – Heating return G 1"
2nd HR – Heating return, heating circuit 2 G 1"
Gas – Gas connection G 3/4"
SiV – Safety valve G 3/4"
KA – Condensate connection Ø 25 mm
Gravity lock blocked (valve opened) Operating position
Paramount four
ZA
ZA
3 Technical specifications
7658013 - 02 - 15092016 Paramount four 30 – 115 kW 19

For more information, see
Sealing and filling of the system, page 36
3.4 Dimensions and connections
Fig.3 Dimensions and Connections Paramount four 50 - 115
160
110
RA-0000310
B
C
851
883
975
12
3
4
1HV – Heating flow 2HR – Heating return
3 Technical specifications
20 Paramount four 30 – 115 kW 7658013 - 02 - 15092016