Proficient Audio Systems VC60AW User manual

VC60AW
Outdoor Volume Control
When deciding where the volume control will be mounted onto
the wall, consider the various ways it will be used. The primary
listening area and the ease of running the wire to your chosen
location are the important things to keep in mind. The most com-
mon locations for outdoor volume controls are on the wall or
on a PVC stub-out at ground level. If you do not understand any
part of these instructions, please contact your Proficient dealer.
Improper wiring could cause damage to your audio system.
Do not put the volume control into the same box as a 110V AC
circuit. (i.e. light switch, electrical outlet, etc.). Speaker wires
can act as an “antenna” for electrical noise. Locating speaker wires
too close to a light switch or dimmer may cause a buzzing or pop-
ping sound to be heard through the speakers. If you must locate
the VC60AW near electrical devices, use a separate electrical box.
VOLUME CONTROL PLACEMENT
NOTE: The rotary switch is shipped with the control turned as
far counterclockwise as it will turn (off). If you have changed this,
return it to the full counterclockwise position before starting
installation.
1. Run the ¾" PVC conduit and speaker wires appropriate for your
outdoor application, using a PVC junction box or a T-coupling for
the speaker and amplifier connections. Proficient recommends
running the wires from the amplifier to the junction box, and
then branching the wires out to the VC60AW and speakers. In the
alternative, you may simply use T-couplings on the PVC conduit
as needed.
2. Attach the speaker wires to the VC60AW using crimps, crimp
caps, or by soldering. Proficient highly recommends using heat
shrink crimps to keep out moisture and to reduce corrosion.
3. Since the wiring will be sealed inside the conduit, be sure to
test all of your connections by activating the amplifier and
toning the speakers.
4. Once the speakers are connected, put the wiring back into the
conduit and seal the conduit with silicone.
5. Use PVC adhesive to attach the VC60AW to the conduit.
DO NOT spill the adhesive onto the VC60AW, as it may mar
the finish. Proficient highly recommends applying a bead of
silicone at the conduit seam for maximum weatherproofing.
6. To wall mount the VC60AW, simply use four screws and wall
anchors, if applicable.
CAUTION: If the input and output connections are reversed,
the minimum setting on the volume control would present a
short across the amplifier or receiver output terminals. This may
seriously damage your amplifier or receiver. Please double check
steps 1 - 6. This volume control cannot be connected in series
with another volume control.
WIRING THE VC60AW
Audio Systems
OWNER’S MANUAL
The VC60AW is a 60 watt outdoor surface-mount rotary volume control, which connects
between a pair of speakers and the speaker level output of an amplifier, receiver or speaker
selector. It offers real convenience for the homeowner, since adjustments can be made
the moment the listener enters the outdoor listening area. A Multi-Room system uses one
VC60AW volume control, hard-wired as a “home run” or off the master speaker-wire line for
each pair of speakers.
Featuring stainless steel hardware and a PVC enclosure, the VC60AW can be mounted
onto ¾" PVC conduit, and may be used either fastened onto a wall or freestanding. Diagram 1:
VC60AW
INTRODUCTION

Proficient Audio Systems warrants to the original retail purchaser
only that this product will be free from defects in materials and
workmanship for a period of ten years, provided the speaker was
purchased from a Proficient Audio Systems Authorized Dealer.
Defective products must be shipped, prepaid and insured,
together with proof of purchase, to the Proficient Audio Systems
Authorized Dealer from whom they were purchased, or to
Proficient Audio Systems at the address listed on this installation
instruction manual. Freight collect shipments will be refused. It is
preferable to ship this product in the original shipping container
to lessen the chance of transit damage. In any case, the risk of loss
or damage in transit is to be borne by the purchaser.
If, upon examination at the Factory or Proficient Audio Systems
Authorized Dealer, it is determined that the unit was defective
in materials or workmanship at any time during this warranty
period, Proficient Audio Systems or the Proficient Audio Systems
Authorized Dealer will, at its option, repair or replace this product
at no additional charge, except as set forth below. If this model is
no longer available and can not be repaired effectively, Proficient
Audio Systems, at its sole option, may replace the unit with a cur-
rent model of equal or greater value. In some cases where a new
model is substituted, a modification to the mounting surface may
be required. If mounting surface modification is required, Proficient
Audio Systems assumes no responsibility or liability for such modi-
fication. All replaced parts and product become the property of
Proficient Audio Systems. Products replaced or repaired under this
Warranty will be returned to the original retail purchaser, within a
reasonable time, freight prepaid.
This Warranty does not include service or parts to repair damage
caused by accident, disaster, misuse, abuse, negligence, inad-
equate packing or shipping procedures, commercial use, voltage
inputs in excess of the rated maximum of the unit, or service,
repair or modification of the product which has not been autho-
rized or approved by Proficient Audio Systems. This Warranty also
excludes normal cosmetic deterioration caused by environmental
conditions. This warranty will be void if the Serial Number on the
product has been removed, tampered with or defaced.
This Warranty is in lieu of all other expressed warranties. If the
product is defective in materials or workmanship as warranted
above, the purchaser’s sole remedy shall be repair or replacement
as provided above. In no event will Proficient Audio Systems be
liable for any incidental or consequential damages arising out of
the use or inability to use the product, even if Proficient Audio
Systems. or a Proficient Audio Systems Authorized Dealer has
been advised of the possibility of such damages, or for any claim
by any other party. Some states do not allow the exclusion or
limitation of consequential damages, so the above limitation and
exclusion may not apply.
All implied warranties on the product are limited to the duration of
this expressed Warranty. Some states do not allow limitation on the
length of an implied warranty. If the original retail purchaser resides
in such a state, this limitation does not apply.
LIMITED TEN-YEAR WARRANTY
1300-34320
Should you have any questions regarding this, or any other Proficient Audio Systems product, please call our service hotline at
800.448.0976. We are available to assist you every weekday, except holidays, between the hours of 7:00 a.m. and 5:00 p.m. PST.
Audio Systems
940 Columbia Avenue, Riverside, CA 92507
800.448.0976 • Fax [phone] • proficientaudio.com