Raypak XFYRE 500 User manual

Catalog No.: 2000.17 Effective: 6-22-09 Replaces: New
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor:
Up to 94% Thermal Efficiency at Full Rate
100% Factory Fire Tested
Maximum Outlet Water Temperature: 210°F
Maximum System Temperature: 200°F
Full Safety Diagnostics with History
Footprint: Less Than 9-1/2 ft2
Limited Twenty-Year Thermal Shock Warranty
Limited Ten-Year Heat Exchanger Warranty
Full Electronic Modulation, Constant Ratio 5:1 Turndown
Soft-Start Modulating Controller with LCD Display
Status and Full Diagnostics Display
Heat Exchanger
All Stainless Steel Construction
Gasketless Heat Exchanger Design
ASME H Stamped
160 PSIG Working Pressure
National Board Approved
ASME Pressure Relief Valve
60 PSIG – Standard
PSIG – Optional
Temperature and Pressure Gauge,
Shipped Loose
Control
120V, 60Hz, 1Ø, Power Supply
Digital Operating Control with LCD
display.
Outdoor reset with Indirect Priority
0-10 VDC input for BMS
Cascade up to 8 boilers
Spark Ignition (IID)
Remote Flame Sensor
High Limit, Manual Reset, Fixed,
200ºF
Auto Limit, Fixed, 210ºF
Alarm Dry Contact Connection
On/Off Power Switch
Flow Switch
Blocked Vent Pressure Switch
Boiler, DHW & System Pump
Contacts
Water Temperature Sensors (3)
Burner
Ultra-Low NOx: Less than 20 PPM
Gas Train
Fuel
Natural Gas
Propane
Zero Governor Regulator
Dual-Seat Combination Valve
Electronic Modulating Firing Mode (H7)
Construction
Indoor/Outdoor Construction
Front Controls Enclosed
PolyTuf Powder Coat Finish
Rear Connections (Electrical, Gas, Vent,
Combustion Air)
Top Connections (Water)
Design Certified ANSI Z21.13/
CSA 4.9
Venting (PVC-CPVC-Stainless.)
Vent Termination
Indoor, Vertical – Option D-11
Indoor, Horizontal – Option D-15
Outdoor
Extractor - Optional
By others
Not required
Multi-Boiler System Controllers
B-36 TempTracker Mod+ Digital
Controller, 2-4 Boilers, OA Reset
B-37 TempTracker Mod+ Digital
Controller, 5-10 Boilers, OA Reset
B-38 TempTracker Mod+ Digital
Controller, 11-16 Boilers, OA Reset
Options
D-21 TruSeal™ Combustion Air Inlet
P- Pump: HP, 120V, 1∅, 60Hz
Cast Iron Bronze
S-1 Low Gas Pressure Switch,
Manual Reset
S-2 High Gas Pressure Switch,
Manual Reset
Z-12 Condensate Neutralizer Kit
Regulatory Agency Requirements
XFyre™- Type H
Condensing Heating Boilers
Models 300-850

Catalog No.: 2000.17 Effective: 6-22-09 Replaces: New
XFyre – Type H
Models 300-850 Model
Dimensions (in.)
MBTUH
Model
(H7-) Input Output A
Length F Mounting G NPT H NPT K Flue Ø N C/A Ø
Ship
Weight
(Lbs.)
Foot-
print
(Ft2) Amps*
300 300 282 28-1/4 27-9/16 3/4 1-1/2 4 4 410 6.6 3
500 500 470 37-1/4 36-1/4 1 1-1/2 4 4 505 7.9 4
850 850 799 54-1/4 53-9/16 1-1/4 2 6 6 580 9.5 5
Ratings shown are for elevations up to 2,000 feet. For installations at elevations
above 2,000 feet, please consult the factory for additional instructions. * Current draw is for heater only.
(Supply breaker must have delayed trip.)
RATES OF FLOW AND PRESSURE DROPS
20ºF ∆T 30ºF ∆T 40ºF ∆T Min Flow Max Flow
Model
(H7-) GPM ∆P GPM ∆P GPM ∆P GPM ∆P ∆T GPM ∆P ∆T
300 28 17 19 8 14 5 14 5 40 36 27 17
500 47 16 31 7 24 4 24 4 40 56 24 18
850 80 40 53 17 40 10 40 10 40 80 40 20
* Closed systems only
CLEARANCES
Certified
Minimum
Recomm.
Service
Front 24” 24”
Rear 24” 24”
Right 1” 1”
Left 1” 1”
Top 12” 24”
Floor 0” --
Vent 1” --