RCE SC-1527 User manual

Super Capacitor Manual
Warranty
SC-1527
SC-1520

Dealer Stamp
Delivery date：
Web:www.rce.com.tw
Add：23854新北市樹林區佳園路3段55號
RoHS
Tell:[phone] Fax[phone]
Mail:[email protected]
No.55, Sec. 3, Jiayuan Rd., Shulin Dist.,
New Taipei City 238, Taiwan (R.O.C.)

Positive Negative
Producot ID：SC-1520
Capacity：15V/20F
Life cycle：Over 500,000
Self-discharge current：<1mA
Applicable temperature：-30℃~+70℃
Instantaneous current：75A/15V/1S
Dimension：154mm*68mm*32mm
Weight：600g
Warranty：3-year
Motorcycle Super Capacitor
SC-1520

Note
Please check the alternator before installtion, if the output voltage is
15V we do not recommend you to install.
Please follow the installation guide for the first time using.
Please follow the manual and warning to avoid serious damage.
Don't attempt to repair the product by yourself. Please contact with the
technical person.
This product must be recycled or disposed of separately from
household waste. Don't incinerate the product. For information about
recycling and replacement, please contact and refer to local law.
Please to do not put the battery into fire. It would cause the explosion.
Slightly heat up during charging is normal.
Please place the product in dry.
This product can be damaged if dropped, burned, punctured, or
crushed.
Please follow the manual to make sure the product is used in correct
and safety way.
This product is for auxiliary use and might not activate if the original
battery fails to discharge completely.
Except for the following conditions, this product has a 3-year
warranty under normal use:
１.Human-caused damage and inappropriate handling, such as
external short circuit, impact, drop and flood.
２.Unauthorized disassembling and repair, and damaged tear-proof
stickers on the side.
３.Cleaning the product with soap or cleanser.
４.The product is contacted with high temperature, fire or corrosive
substance.
５.The product is damaged due to incorrect connection of the rescue
cable to the positive/negative terminal.
For more information, please call + 886-2-2680-1999

Producot ID：SC-1572
Capacity：15V/72F
Life cycle：Over 500,000
Self-discharge current：<2mA
Applicable temperature：-30℃~+70℃
Instantaneous current：190A/15V/1S
Dimension：210mm*84mm*48mm
Weight：1000g
Warranty：3-year
Car Super Capacitor
SC-1572
PositiveNegative

Resistor Parts
Connect to super capacitor terminal
Connect to
battery terminal
１‧Upon activation, it can provide large instantaneous current to reduce
the load and prolong the service life of starter battery.
２‧After activation, it can absorb instantaneous surge generated by the
generator and provide steady voltage for the optimized operation of
oil supply computer.
３‧It can constantly provide large instantaneous current for the ignition
system to function effectively with best performance.
４‧It is the best choice for hardcore audio enthusiasts to improve the
audio performance.
５‧Start-stop model which can effectively enhance starting capability and
prolong battery life.
６‧It is equipped with ultra-low temperature starting capability such that
it can be started even with the temperature at 20c.c below zero.
７‧It is equipped with the longest service life of 500,000 cycles.
８‧It is filled with Epoxy to ensure shockproof, waterproof, and high
temperature resistance.
Performance
For Cars
※Cables are 25cm and 50cm in random color.
For
Motorcycle

Installation Guide
Step.1 Step.5
Step.2
Step.3
Step.4
Step.6
Step.7
1
2

Step1：After the positive and negative terminal are correctly connected,
two eyelets wires will be penetrating out from both sides, and
the super capacitor should be placed in the shockproof pack.
Step2：The positive electrode of the super capacitor should be fastened to
the positive electrode of the battery.
Step3：Please make sure the capacitor is firmly fastened the connect the
resistor to the battery.
Step4：The clamp should be connected to the resistor before being
connected to the negative electrode of the battery.
Step5：When the red light of the correctly installed resistor is on, it
indicates the super capacitor is being charged. When the red light
is off, it indicates the charging of super capacitor is completed.
The temperature of resistor will become rather high during
charging. Do not touch it, or you may get burned.
Please check the terminals of capocitor and battery if the red light
on the resistor has been lit for a long time.
Step6：After the red light is off, the clamp and resistor can be removed. Be
carefully not to touch the aluminum case of resistor
because you may get burned due to the high temperature.
Step7：The negative electrode should be fastened to the battery to
complete the installation. The super capacitor should be surely
fastened to prevent it from being loosened during driving thus
causing short circuit.
Please handle super cap certainly to avoid short circuit.
Charge time：
SC-1572: 10-12 minutes.
SC-1520: 2-3 minutes.