red lion G3CN User manual
GENERAL DESCRIPTION
e iet esi st ies i see e itete
tt etes te tiit eibiit te seies is
ws te seies t ee et wit te test es i
itis sts witt siii ee is i
bwit e s siiit ete tt we e t te
titi ete sei tew
e ti is esi iste b ei te e e
et itee tti te si tee sews eti
sie be i tis ies te et itee e
itis t t is bit wit iit isti t tet te et
itee te e bs ie es t ies te biit t
ite t i see e eie e ti b s
teiti esist biti is seetbe t e setti
et si is ie t ti s sti eie te wies tt
teite it te ie siti et e et is be es
e te et itee te e bs witt istbi
itis wit te eies te bs
SAFETY SUMMARY
set ete etis es isttis tt e i te
itete eiet st be bsee t ese es set t
eet e t eite te istet eiet ete t it
eiet is se i e t seiie b te te te teti
ie b te eiet be iie
t se te te t iet ts es te
tts t eie wit ses s be teti t
ess eiet i te eet t t te te
CONTENTS OF PACKAGE
ti wit be et
be e tte t ti
we sisti tee sews et si te
be et
is we beti
ORDERING INFORMATION
se tis t be t se is wit ite
be R be tewise w
Rei website
MODEL G3CN - CANopen OPTION CARD FOR G3 OPERATOR
INTERFACE TERMINALS
Bulletin No. G3CN-D
Drawing No. LP0587
Released 10/10
CAUTION: Risk of Danger.
Read complete instructions prior to
installation and operation of the unit.
Connector
(side 2)
mounting holes, 3 plcs.
MODEL NO. DESCRIPTION PART NUMBER
G3CN G3CN0000
SFCRM2 Crimson 2.0 1SFCRM200
CONFIGURED USING CRIMSON SOFTWARE (VERSION 2.0 OR
LATER)
DIGITALLY ISOLATED CANOPEN PORT CAPABLE OF
COMMUNICATING WITH ANY CANopen DEVICE
POWERED AND CONFIGURED FROM G3 OPERATOR
INTERFACE TERMINAL
BUILT-IN TERMINATION RESISTOR SELECTABLE THROUGH
JUMPER SETTING
INSTALLATION AND CONNECTION HARDWARE INCLUDED
WITH CARD
CANopen option card for G3 operator
interfaces with isolated high speed
communications ports
WARNING - EXPLOSION HAZARD - SUBSTITUTION OF ANY
COMPONENT MAY IMPAIR SUITABILITY FOR CLASS I,
DIVISION 2
THIS EQUIPMENT IS SUITABLE FOR USE IN CLASS I,
DIVISION 2, GROUPS A, B, C, D, HAZARDOUS LOCATIONS,
OR NON-HAZARDOUS LOCATIONS ONLY
WARNING - EXPLOSION HAZARD - DO NOT DISCONNECT
EQUIPMENT WHILE THE CIRCUIT IS LIVE OR UNLESS THE AREA
IS KNOWN TO BE FREE OF IGNITABLE CONCENTRATIONS.
POWER REQUIREMENTS
we is sie t te ti te i b et
itee
COMMUNICATIONS
CANopen Port e e t s t b tes tt e
stwe be t b e iit iste is t
be ie is e ts e Rei website
et ste ts
Isolation from G3CN Communication ports to G3 operator interface
ite
ENVIRONMENTAL CONDITIONS
Operating Temperature Range t
Storage Temperature Range t
Operating and Storage Humidity i etie iit
esi t
Altitude t etes
CERTIFICATIONS AND COMPLIANCES
ELECTROMAGNETIC COMPATIBILITY
issis it t eti iet eseet
t bt se
Immunity to Industrial Locations: Reeee it eissis
iit seiitis
CONSTRUCTION stti te ti eee
INSTALLATION REQUIREMENTS st be iste isie te
e e et itee wit te we ie ee
sti te ti e etis
INSTALLING THE G3CN OPTION CARD
SPECIFICATIONS
INSTALLATION INSTRUCTIONS
ti es wit be itis tee
sews tti te ti t te isie te et itees
e e
ist te ti ee we itis bes
te it e et itee itete tis isttis
ei te e e Ree t te tte ie eei seti
si te tee sews ie et te ti t te e e s
sw i ie
et te be te ti t te i b te
et itee s sw i ie e se bt es te be e i
sete it tei ite et sis
e ee te e e b eesi te isttis ei te
e e
THE OPTION CARD LABEL
e te ti be e e i te se iite b te
se ies bee
POWER SUPPLY REQUIREMENTS
NEW AND EXISTING INSTALLATIONS
e ti ws its we te i b
et itee e seiitis et itee t
te we ees ti
Figure 1
Figure 2
Caution e ti i iit bs ti stti
sesitie ets ee i te s ise
stti es b b ti e be
et bet e e te s t stti te e
wstti s e te s b te ees it i
te tits tt tt te s ese
et iit eti
Warning eei te et itee i te
be eset isie te et itee e se t ee
we bee ei te e e te et itee
COMMS EXPANSION MODULE
RS232 RS485 RS232
CONFIGURING A G3CN OPTION CARD
e is ie si is stwe is is ibe s ee
w Rei website it be ee tes t
is ew etes ies e ste te website s te bee
ibe ii te si te test esi is e
sse tt it s te st tte ete set is stwe
ie te t te R t t teet t
ts set et itee iti iti
be i we beti te is se
CANopen PORT PROTOCOLS
e ti s e e t is t be ie
is e ts e Rei website et
ste ts
TERMINATION RESISTOR
b teiti esist is seetbe t e setti e
teiti esist is te t ieet teiti esiste
is esie se te e setti teiti esist t tis it
wi be eie t et w teiti esist betwee sitis
te ie siti et
CAN GND
siti te be et ies eti
is tei is iste te it
CAN-
siti te be et ies te bs ie tie
w is tei is iste te it
SHLD (OPTIONAL CAN SHIELD)
siti te be et is ie ti sie
etis is siti is ibe t tie sie wies tete t et
ee is ite eti t et e siti is t
ete t iit ite t te ti it
CAN+
siti te be et ies te bs ie tie
i is tei is iste te it
V+ (OPTIONAL 24 VDC)
siti te be et is ie ti
etis is siti is ibe t tie wies tete e
eite ies we ses we t
tis eti e siti is t ete t iit ite t te
ti it
COMMUNICATING WITH THE G3CN OPTION CARD
G3CN PORT PIN OUTS
TERMINATION
LED
RESISTOR
(124 Ω, 1W)
TERMINATION RESISTOR
YES
NO
SHLD (N/C)
V+ (N/C)
GND
CAN-
CAN+
Figure 3
TX/RX
2
4
1 CAN GND
CAN +
CAN -
+
-
ISOLATING
DC : DC
SOFTWARE/UNIT OPERATION
LED
e wi iite ee we te ti estbises
iti wit te e eies R e wi iite
e i itis e bee estbise wit te e eies
RRR
CRIMSON SOFTWARE
is stwe is ibe s ee w Rei website
it be se see ei ti t be e
test esi te stwe is ws ibe te web site ti
is ee
TROUBLESHOOTING YOUR G3CN OPTION
CARD
es e tbe eti eti si e
estis ei ew ti tt Re is tei
st tt iti ee t te b e tis beti e
bes
LIMITED WARRANTY
e wts te ts it tes ist eets i teis wsi
ei iite t tw es te te siet ie te ts e bee ste
e iste se e e itis e s ibiit e tis iite
wt s ete t te ei eeet eetie t t e s
ti e isis ibiit iti ise eesetti wit
eset t te ts
e ste ees t Re i ts ess ee iei R ist
es is eeses isi t sbseet ses R ts ts
tii ets te b R bse es iies ets et
e st its te ttes wi e its eees sbtts e be
t etet ibe ii witt iitti eties ise b te se t et
t ibiit ise es st t te sss t
t s w i eet s ee eete
wties eesse iie e ete wit eset t e s ts eet tse
eess tie eei e ste wees te isies iittis tie
eei eies te wties itis
Other red lion Recording Equipment manuals
