RevoAce GBT2226W User manual

Table of Contents
Important Safeguard s.................... Page 2
Expanded View & Hardware ................... 6
Assembly Instructions.........................8
Operating Instructions........................ 9
Cleaning and Care ......................... 11
Limited Warranty .......................... 12
Troubleshooting ........................... 13
The use and installation must conform with local
codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural
Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2, or the
Standard for Recreational Vehicles, ANSI A 119.2/NFPA
1192, and CSA Z240 RV Series, Recreational Vehicle
Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT
SAFETY INFORMATION. PLEASE READ AND KEEP FOR
FUTURE REFERENCE.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
OWNER’SOWNER’S MANUALMANUAL
Outdoor LP Gas Barbecue Grill
Model No. GBT2226WModel No. GBT2226W WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
DANGER
Do not leave this appliance
unattended, especially cooking the
fatty meat and close lid too long time.
Failure to follow the dangers,
warnings and cautions in this manual
may result in serious bodily injury
or death, or in a fire or an explosion
causing damage to property.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only! (outside any enclosure)
DANGER
If you smell gas:
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance and immediately
call your fire department. Failure
to follow these instructions could
result in fire or explosion which
could cause property damage,
personal injury or death.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
1.833.908.2025 GBT2226W-OM-E-F100

2
FOR YOUR SAFETY
WWARNINGS:
1. Improper installation, adjustment, alteration, service or maintenance can
cause injury or property damage.
2. Read the installation, operation, and maintenance instructions thoroughly
before installing or servicing this equipment.
3. Failure to follow these instructions could result in fire or explosion, which
could cause property damage, personal injury, or death.
4. This instruction manual contains Important information necessary for the
proper assembly and safe use of the appliance.
5. Read and follow all warnings and instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when using the appliance.
7. Keep this manual for future reference.
IMPORTANT SAFEGUARDS
Failure to follow these istructions could result in fire or explosion which
could cause property damage, personal injury or death.
WThis grill is for outdoor use only, and should not be used in a building, garage or any other enclosed area.
WDo NOT operate, light or use this appliance within ten feet (3.05 m) of walls, structures or buildings.
WFor residential use only. This grill is NOT for commercial use.
WThis grill is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause
asphyxiation.
WThis grill is safety certified for use in the United States and/or Canada only. Do NOT modify for use in any
other location. Modification will result in a safety hazard and will void your warranty.
WThis grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in
this LP gas grill is dangerous, may cause bodily harm and will void your warranty.
WLP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before
using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles/pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten
cabbage.
d. Contact with LP gas can cause freeze burns to skin.
WApartment dwellers: Check with management to learn the requirements and fire codes for using a LP gas
grill in your apartment complex. If allowed, use outside on the ground floor with a ten foot (3.05 m) clearance
from any structure. Do NOT use on or under balconies.
WLP gas cylinder needed to operate. Only cylinders marked “propane” may be used.
WThe LP gas cylinder must be constructed and marked in accordance with the Specifications for LP-
gas Cylinders of the U.S. Department of Transportation (D.O.T.), Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods; and Commissionor the National Standard of Canada, CAN/CSA-B339 .
WLP gas cylinder must be arranged for vapor withdrawal.
WThe LP gas cylinder must have a listed overfilling prevention device (OPD).

3
IMPORTANT SAFEGUARDS
WOnly use LP gas cylinders equipped with a cylinder connection device compatible with the connection for
outdoor cooking appliances.
WThe LP gas cylinder must have a cylinder collar to protect the cylinder valve.
WNever use an LP gas cylinder with a damaged body, valve, collar or footing.
WDented or rusted LP gas cylinders may be hazardous and should be checked by your LP gas supplier prior to
use.
WThe LP gas cylinder should not be dropped or handled roughly.
WLP gas cylinders must be stored outdoors out of the reach of children and must not be stored in a building,
garage or any other enclosed area. Your cylinder must never be stored where temperatures can reach over
125°F.
WDo NOT insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve
and cause a leak. Leaking propane may result in an explosion, fire, severe personal injury or death.
WDo NOT block holes in sides or back of grill.
WNever keep an LP gas cylinder in a hot car or trunk. Heat will cause the gas pressure to increase, which may
open the relief valve and allow gas to escape.
WPlace dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in
leakage of propane.
WIf grill is not in use, the gas must be turned off at the supply cylinder and disconnected.
WDo NOT store a spare LP gas cylinder under or near this appliance.
WNever fill the cylinder beyond 80 percent full.A fire causing serious injury or damage to property may occur if
the above is not followed exactly.
WNever attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home or
house.
WNever use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with this product.
WYour grill has been checked at all factory connections for leaks. Re-check all connections as described in the
“Operating Instructions” section, as shipping can loosen connections.
WCheck for leaks even if your unit was assembled for you by someone else.
WDo NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion.
WYou must follow all instructions in the “Checking for Leaks” section before operating. To prevent fire or
explosion hazard when testing for a leak:
a. Always perform a leak test before lighting the grill and each time the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly
assemble or safely operate the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and
common sense when testing for leaks.
g. Do NOT use grill until any and all leaks are corrected.
If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your
local LP gas supplier.
WThis grill is designed to operate at an inlet pressure of: 11 inches water column.
WDo NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

4
IMPORTANT SAFEGUARDS
WDo NOT use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline
and other flammable vapors and liquids.
WMinimum clearance from sides and back of unit to combustible construction is 21 inches (53.3 cm). Do NOT
use this appliance under any type of overhang or roof.
WIt is essential to keep the grill’s valve compartment, burners and circulating air passages clean.
WInspect grill before each use.
WDo NOT alter grill in any manner. Any alteration will void your warranty.
WDo NOT use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.
WDo NOT build this model of grill in any built-in or slide-in construction. Ignoring this warning could cause a
fire or an explosion that can damage property and cause serious bodily injury or death.
WThis grill should be thoroughly cleaned and inspected on a regular basis.
WClean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or
leaks, the hose must be replaced prior to operation.
WUse only the regulator and hose assembly provided. Use only the replacement regulator and hose assembly
specified by RevoAce Inc. Limited
WUse only RevoAce Inc. Limited factory-authorized parts. The use of any part that is not factory-authorized can
be dangerous and will void your warranty.
WDo NOT operate this appliance without reading “Operating Instructions” in this manual.
WDo NOT touch metal parts of grill until they have completely cooled to avoid burns, unless you are wearing
protective gear (pot holders, gloves, BBQ mittens, etc.).
WDo NOT install or use in or on boats or recreational vehicles.
WWhen cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do
NOT attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand
or baking soda.
WDo NOT use grill in high winds.
WNever lean over the grill when lighting.
WDo NOT leave a lit grill unattended. Keep children and pets away from grill at all times.
WDo NOT leave grill unattended while preheating or burning off food residue on high. If grill has not been
cleaned, a grease fire can occur that may damage the product.
WDo NOT place empty cooking vessels on the appliance while in operation.
WUse caution when placing anything on the grill while the appliance is in operation.
WDo NOT attempt to move grill when in use. Allow the grill to cool before moving or storing.
WLP gas cylinder must be properly disconnected and removed prior to moving this grill.
WStorage of grill indoors is permissible only if the cylinder is disconnected, removed from the grill and properly
stored outdoors.
WAlways open grill lid carefully and slowly as heat and steam trapped within grill can cause severe burns.
WDo NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the grill is in use.
WAlways place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be
acceptable for this purpose.
WMove gas hoses as far away as possible from hot surfaces and dripping hot grease.
WKeep all electrical cords away from a hot grill.
WAfter a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion,
wear or cuts to the hose.
WFailure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the

5
IMPORTANT SAFEGUARDS
grill does not light, may result in an explosive flame-up.
WNever operate grill without its heat plates installed.
WAlways use a meat thermometer to ensure food is cooked to a safe temperature.
WUse protective gloves when assembling this product.
WDo NOT force parts together as this can result in personal injury or damage to the product.
WNever cover entire cooking area with aluminum foil.
WDeaths, serious injury or damage to property may occur if the above is not followed exactly.

6
Expanded View
1Handle (3) G2226-020
2Brand Plate* G2226-030
3Cooking Grid G2226-050
4Lid* G2226-010
5Bottom Bowl* G2226-040
6Control Knob (2) G0900-010
7Left Burner* G2226-060
8Right Burner* G2226-070
9Igniter* G2226-110
10 Grease Cup G2226-080
11 Regulator G2226-090
* Pre-assembled
Parts List
5
2
1
4
3
7
8
911
101
1
66

7
Assembly Instructions
1
Attach Grease Cup
4
Insert Cooking Grid and Attach Control Knob
3
Attach Handles
2
Please have your owner’s manual and model number
available for reference.
Note: The model number can be found on the back or side
of the grill.
Assembly Tips:
1. Select an area where you will assemble this
product. To protect components, choose a smooth
surface that’s free of cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first.
Then, before completing each step, go back and
fully tighten all hardware. Be careful not to over-
tighten. That could damage surfaces or strip
threads.
4. For best results, complete each step in the order
presented.
To complete assembly you will need:
• (1) Leak Detection Solution (instructions on how
to make solution are included in “Operating
Instructions” section).
• (1) 14.1 oz or (1) 16.4 oz LP gas tank (not included).
Typical assembly is approximately 8 minutes.
DO NOT RETURN TO PLACE OF PURCHASE.

8
Attach Regulator
5

9
Operating Instructions
This grill is designed to operate with a 1 lb.7.75 in. or 10.6 in. high disposable / 16.4 oz. or 14.1
oz. propane gas tank (DOT 39 Cylinder) (Figure 1).
DO NOT ATTEMPT TO REFILL ANY 1 lb. (16.4 oz. or 14.1 oz.)
PROPANE GAS TANKS!
CAUTION
Connecting LP Gas Tank
Only cylinders marked “propane” may be used.
Note: 1 lb cylinders may form frost when near empty.
1. Make sure the control knob is in the “OFF” position (Figure 2).
2. Lubricate the threads of the regulator with petroleum jelly. Line up threads on LP gas tank with
regulator.
3. Insert and rotate LP gas tank clockwise until they fit snugly together. HAND TIGHTEN ONLY. Be
careful not to crossthread when screwing in tank (Figure 3).
4. Perform leak test per “Checking for Leaks” section.
Disconnecting LP Gas Tank
1. Turn the control knob to the “OFF” position (Figure 2).
2. Rotate LP gas tank counterclockwise until it is detached (Figure 4).
3. Store the LP gas tank in a proper location, per instructions on the LP gas tank.
Checking for Leaks
Burner Connections
1. Make sure the regulator and valve connections are securely fastened to the burner and the tank.
2. Visually check the connection between the burner / venturi tube and orifice.
3. Make sure the burner / venturi tube fits over the orifice.
WWARNING: Failure to inspect this connection or follow these instructions
could cause a fire or an explosion which can cause death, serious bodily
injury or damage to property.
4. Please refer to the diagram for proper installation (Figure 5).
5. If the burner / venturi tube does not rest flush to the orifice, as shown, please contact
1.833.908.2025 for assistance.
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three parts
water.
2. Make sure control knob is in the “OFF” position (Figure 2).
3. Turn on the control knob.
4. Spoon the leak detection check solution on all “X” locations (Figure 6).
a. If any bubbles appear, remove the LP gas tank per “Disconnecting LP Gas Tank” section and
reconnect, making sure the connection is secure and repeat the checking process.
b. If you continue to see bubbles after several attempts, remove the LP gas tank per
“Disconnecting LP Gas Tank” section, and contact 1.833.908.2025 for assistance.
5. If no bubbles appear after 20 seconds, turn control knob to the “OFF” position, wipe away solution
and proceed.
First Use
1. Make sure all labels, packaging and protective films have been removed from the grill.
2. Remove manufacturing oils before cooking on this grill for the first time by operating the grill for
at least 15 minutes on (HIGH) with the lid closed. This will “heat clean” the internal parts and
dissipate odors.
Figure 1
1 lb
453 g
7.75 in. / 19,7 cm
3.875 in. / 9,8 cm
2.9 in. / 7,4 cm
1 lb
465 g
10.6 in. / 27 cm
Figure 2
OFF
Figure 3
Figure 4
Figure 5
Figure 6

10
Operating Instructions (Continued)
Lighting Instructions
WCAUTION: Keep outdoor gas cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and liquids.
WCAUTION: Do NOT obstruct the flow of combustion and ventilation air.
WCAUTION: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire.
WCAUTION: Attempting to light the burner with the lid closed may cause an
explosion.
WCAUTION: Always open legs completely and secure in place before opening
lid or lighting grill.
1. Open lid.
2. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/
venturi tube. A clogged burner/venturi tube can lead to a fire.
3. Connect LP gas tank per “Connecting LP Gas Tank” section.
4. Turn the control knob to (HIGH).
5. Press the igniter button quickly 3 to 4 times to light burner.
6. If ignition does not occur in 5 seconds, turn regulator/control knob to “OFF” position, wait 5
minutes and repeat lighting procedure.
7. If igniter does not light burner, use a lit match to light burner manually. Access the burner through
the hole in bottom bowl or side as indicated (Figure 7). Turn the regulator/control knob to (LOW)
and position the lit match near side of the burner.
8. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 8).
WCaution: If burner flame goes out during operation, immediately turn the regulator/control knob “OFF” and
open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
1. Turn regulator/control knob to the “OFF” position (Figure 2).
Note: A “poof” sound is normal as the last of the LP gas is burned.
2. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
Cooking
WDo NOT leave grill unattended while preheating or burning off food residue on (HIGH). If grill has not been cleaned,
a grease fire can occur.
1. Open lid and ignite the side burner per “Lighting Instructions” section.
2. Close lid and preheat grill on (HIGH).
3. Adjust regulator/control knob to desired flame height.
4. Wear protective gloves and use long handle tongs to place food onto cooking grids above the lit burner.
5. With lid open or closed, cook until desired internal food temperatures are achieved.
6. Turn grill off per “Turning Off” section.
Controlling Flare-ups
WCAUTION: PUTTING OUT GREASE FIRES BY CLOSING THE LID IS NOT POSSIBLE.
• If a grease fire develops, turn regulator/control knob
“OFF.” Do NOT use water on a grease fire. This can cause the grease to splatter and could result in
serious burns, bodily harm or other damage.
• Do NOT leave grill unattended while preheating or burning off food residue on (HIGH). If grill has not
been cleaned, a grease fire can occur that may damage the product.
WWARNING: When cooking, fire extinguishing materials should be readily accessible. In the event of an oil/
grease fire, use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda. Do NOT
attempt to extinguish with water.
Flare-ups are a part of cooking meats on a grill and add to the unique flavor of grilling.
Figure 7
Match
Figure 8
Burner
Flame Slight
Yellow
Slight
Blue
Dark
Blue

11
Operating Instructions (Continued)
Excessive flare-ups can over-cook your food and be dangerous.
Important: Excessive flare-ups result from the build-up of grease in the bottom of your grill.
If a grease fire occurs, close the lid AND turn regulator/control knob to “OFF,” until the grease burns out. Use caution when opening the lid as
sudden flare-ups may occur.
If excessive flare-ups occur, do NOT pour water onto the flames.
Minimize Flare-ups:
1. Trim excess fat from meats prior to cooking.
2. Cook high fat content meats on (LOW) setting or indirectly.
3. Ensure that your grill is on a hard, level, non-combustible surface and the grease is allowed to drain into a grease receptacle.
Figure 9
Burner Flame Conditions
Use this chart to see if your burners
need to be cleaned.
1-2 in. /
25.4 - 50.8 mm
Normal: Soft blue flames with yellow
tips between 1 in. - 2 in. height.
Needs cleaning: Noisy with hard
blue flames.
Has to be replaced: Wavy with
yellow flames.
Cleaning and Care
WCAUTION:
1. All cleaning and maintenance should be done when grill is cool and with the fuel supply disconnected.
2. Do NOT clean any grill part in a self-cleaning oven. The extreme heat will damage the finish.
3. Do NOT enlarge valve orifices or burner ports when cleaning the valves or burners.
Notices
1. This grill should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
Before Each Use
1. Keep the grill area clean and free from any combustible materials, gasoline, and other flammable
vapors and liquids.
2. Do NOT obstruct the flow of the combustion of LP gas and the ventilation of air.
3. Keep the ventilation opening(s) of the LP gas tank area free and clear from debris.
4. Visually check the burner flames to make sure your grill is working properly (Figure 9).
5. See below for proper cleaning instructions.
6. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/
venturi tube. A clogged burner/venturi tube can lead to a fire.
Cleaning Surfaces
1. Wipe surfaces clean with mild dishwashing detergent or baking soda mixed with water.
2. For stubborn surfaces, use a citrus-based degreaser and a nylon scrubbing brush.
3. Rinse clean with water.
4. Allow to air dry.
Cleaning Main Burner
1. Turn control knob to “OFF”.
Note: A “poof” sound is normal as the last of the LP gas is burned.
2. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
3. Remove regulator/control knob.
4. Remove cooking grid and heat plate.
5. Disconnect wire from igniter, if applicable.
6. Remove burner.
7. Remove all food residue and dirt from burner surface.
8. Disconnect wire from spark electrode.
9. Clean inlet of burner with small bottle brush or compressed air.
10. Clean any clogged ports with a stiff wire (such as an opened paper clip).

12
Limited Warranty
RevoAce Inc. Limited (“RA”) warrants to the original retail purchaser of this product, and to no other person, that if
this product is assembled, maintained, and operated in accordance with the printed instructions accompanying it,
then for a period of one (1) year for all remaining parts from the date of purchase, all parts in such product shall be
free from defects in material and workmanship. RA may require reasonable proof of your date of purchase. Therefore,
you should retain your sales slip or invoice. This Limited Warranty shall be limited to the repair or replacement of
parts, which prove defective under normal use and service and which RA shall determine in its reasonable discretion
upon examination to be defective. Before returning any parts, you should contact RA’s Customer Care Department
using the contact information listed below. If RA conforms, after examination, a defect covered by this Limited
Warranty in any returned part, and if RA approves the claim, RA will replace such defective part without charge. If
you return defective parts, transportation charges must be prepaid by you. RA will return replacement parts to the
original retail purchaser, freight or postage prepaid. This Limited Warranty does not cover any failures or operating
difficulties due to accident, abuse, misuse, alteration, misapplication, improper installation or improper maintenance
or service by you or any third party, or failure to perform normal and routine maintenance on the product as set out in
this owner’s manual. In addition, the Limited Warranty does not cover damage to the finish, such as scratches, dents,
discoloration, rust or other weather damage, after purchase.
This Limited Warranty is in lieu of all other express warranties. RA disclaims all warranties for products that are
purchased from sellers other than authorized retailers or distributors, including the warranty of merchantability or the
warranty of fitness for a particular purpose. RA ALSO DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING
WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
RA SHALL HAVE NO LIABILITY TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDIRECT, PUNITIVE,
INCIDENTAL, OR CONSEQUENTIAL DAMAGES. RA further disclaims any implied or express warranty of, and assumes
no responsibility for, defects in workmanship caused by third parties. This Limited Warranty gives the purchaser
specific legal rights; a purchaser may have other rights depending upon where he or she lives. Some jurisdictions
do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long a
warranty lasts, so the above exclusion and limitations may not apply to everyone. RA does not authorize any person or
company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return,
or replacement of its equipment, and no such representations are binding on RA.
Manufactured in China for: RevoAce Inc. Limited
Flat/RM 1204, Yu Sung Boon Bldg., 107-111 Des Voeux Road Central, Hong Kong, China
1.833.908.2025
Cleaning and Care
11. Inspect burner for any damage (cracks or holes). If damage is found, replace with a new burner from manufacturer.
12. Reinstall burner. Reconnect igniter (if applicable), wind guard and regulator/control knob.
13. Replace heat plate and cooking grid.
14. Connect LP gas tank per “Installing LP Gas Tank” section.
15. Perform leak test per “Checking for Leaks” section.
Before Storing
1. Turn LP gas tank valve to “CLOSED.”
2. Turn control knob to “OFF.”
Note: A “poof” sound is normal as the last of the LP gas is burned.
3. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
4. Clean all surfaces.
5. Lightly coat the burner(s) and cooking grid with cooking oil to prevent excess rusting.
6. If storing the grill indoors, disconnect the LP tank per “Disconnecting LP Gas Tank” section.
7. Place the protective cap cover on the LP tank and store the tank outdoors in a well-ventilated area out of direct sunlight.
8. If storing the grill indoors, cover the grill and store in a cool dry place.
9. If storing the grill outdoors, cover the grill with a grill cover for protection from the weather.

13
Troubleshooting
Problem Possible Cause Prevention/Cure
Burner will not light using
igniter
(if included)
LP gas tank is low or empty Replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “OFF”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Wires or electrode covered with cooking residue Clean wire and/or electrode with rubbing alcohol
Electrode and burners are wet Wipe dry with cloth
Electrode cracked or broken - sparks at crack Replacement part(s) may be needed - contact Customer
Care at 1.833.908.2025
Wire loose or disconnected Reconnect wire or replacement part(s) may be needed -
contact Customer Care at 1.833.908.2025
Wire is shorting (sparking) between igniter and
electrode
Replacement part(s) may be needed - contact Customer
Care at 1.833.908.2025
Bad igniter Replacement part(s) may be needed - contact Customer
Care at 1.833.908.2025
Burner will not light with
match
No gas flow
Check if LP gas tank is empty
A. If empty, replace
B. If LP gas tank is not empty, refer to “Sudden drop in
gas flow or reduced flame height” below
LP gas tank is low or empty Replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “OFF”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Coupling nut and regulator not fully connected
Turning the coupling nut about one-half to three-quarters
additional turn until solid stop. Tighten by hand only – do
NOT use tools.
Obstruction of gas flow Clear burner/venturi tube
Spider webs or insect nest in venturi Clean burner/venturi tube
Burner ports clogged or blocked Clean burner ports
Sudden drop in gas flow or
reduced flame height Out of gas Replace LP gas tank
Irregular flame pattern –
flame does not run the full
length of burner
Burner ports are clogged or blocked Clean burner ports
Flame is yellow or orange
New burner may have residual manufacturing
oils Operate grill for 15 minutes on (HIGH) with the lid closed
Spider webs or insect nest in burner/venturi tube Clean burner/venturi tube
Food residue, grease, etc. on burners Clean burner
Poor alignment of valve to burner/venturi tube Ensure burner/venturi tube is properly engaged with valve
Flame goes out
High or gusting winds Do not use grill in high winds
Low on LP gas Replace LP gas tank
Overflow valve tripped Refer to “Sudden drop in gas flow or reduced flame height,”
above
Flare-up
Grease buildup Remove and clean all grill parts per “Cleaning and Care”
section
Excess fat in meat Trim fat from meat before grilling
Excessive cooking temperature Adjust (lower) cooking temperature
Persistent grease fire Grease trapped by food buildup around burner
system
1. Turn control knob to “OFF”
2. Leave lid in closed position and let fire burn out
3. After grill cools, remove and clean all grill parts per
“Cleaning and Care” section
Flashback (fire in burner
tube(s)) Burner and/or burner tubes are blocked Clean burner and/or burner/venturi tube
Inside of lid is peeling (like
paint peeling)
Baked on grease buildup has turned to carbon
and is flaking off. Clean all grill parts per “Cleaning and Care” section.

14