Rinnai Q175S User manual

Q175S / Q205S Condensing Boiler
Q175S / Q205S SP 2/2011
© 2011 Rinnai Corporation
SPECIFICATIONS
Rinnai is continually updating and improving products; therefore, specifications are subject to change without prior
notice. Local, state, provincial and federal codes must be adhered to prior to installation.
Standard Features
• Onboard outdoor reset control system with sensor standard
• Prebuilt plumbing kit with insulated Low Loss Header
• Priority DHW standard (3 way valve not included)
• Domestic hot water plate warming
• Modulating Ceramic premix burner
• 5:1 turn down ratio
• Spark ignition
• Exceeds SCAQMD 1146.2 Low NOxrequirements
• Stainless Steel Water tube condensing heat exchanger
• Direct Vent sealed combustion
• Concentric and twin pipe venting adapters included
• Approved for room and closet installations
Optional Accessories
• 3 way valve DHW kit
• RS100 Single zone controller
• Flue Gas temperature sensor
• Room Air Filter
• NG to LP conversion Kit
• LP to NG Conversion Kit
General Specifications
Boiler
Model Boiler Model
Q175S Q205S
Water content gal 1.8 1.8
Max. supply boiler
temperature °F 176 176
Max operating pressure psi 45 45
Relief valve rating MBH 375 375
Relief valve pressure rating psi 30 30
Dry weight lbs 141 141
Min inlet gas pressure NG "W.C. 4.0" 4.0"
Max inlet gas pressure NG "W.C. 10.5" 10.5"
Min inlet gas pressure LP "W.C. 8.0" 8.0"
Max inlet gas pressure LP "W.C. 14.0” 14.0”
Max equivalent exhaust
vent length ft 80 40
Max equivalent combustion
air vent length ft 80 40
Approved venting materials Polypropylene, Stainless Steel,
PVC, CPVC
Units
Performance Specifications
Units
Q175S Q205S
Fuel Type NG/LP NG/LP
Input MBH 175 205
Heating Capacity MBH 161 189
AFUE (I=B=R) % 95.7 95.7
Part Load Efficiency
(EN677) % 98.5 98.5
Boiler Model
Electrical Specifications
Units
Q175S Q205S
Electrical Voltage Mains V/Hz 120/60 120/60
Electrical Voltage Controls V 24 24
Power Consumption Max
Load W 210 234
Power Consumption Stand
by Load W 14 14
Recommended Circuit
breaker rating A 15 15
Boiler Model

Q175S / Q205S
Rinnai Corporation • 103 International Drive • Peachtree City, GA 30269 • Toll-Free: 1-800-621-9419 • Fax: [phone] • www.rinnai.us
DIMENSIONS
inch / mm
A Height 26.8 / 680
B Width 26 / 660
C Depth 15.2 / 385
D Left side / vent 19.5 / 495
E Center to center / vent and air
supply 4.7 / 120
F Back / vent 10.6 / 270
G Left side / gas pipe 2.6 / 65
H Left side / supply pipe 7.3 / 185
J Left side / return pipe 17.5 / 445
K Left side / condensate pipe 20.9 / 530
P Pipe length of g 0.7 / 18
Q Pipe length of c 2 / 50
R Pipe length of e, f, k, r, and w 2.3 / 60
S Back / center of pipe c 1 / 25
T Back / Center of pipe g 1.6 / 40
U Back, / center of pipe e, f, k, r,
and w 2 / 50
V Pipe length vent co-axial
Pipe length vent parallel 2.6 / 65 5.8 / 147
Q175S, Q205S
Top 2 / 50 10 / 250
Back 0 0
Front 6 / 150 24 / 600
Left side 2 / 50 2 / 50
Right
side 2 / 50 2 / 50
Floor /
Ground 12 / 300 30 / 762
Vent 0 0
inch / mm
Minimum required
clearance to
combustibles and
non-combustibles
Recom-
mended
service
clearances
inch / mm
Clearances
2.0”
50mm
2.1”
54mm [5.6”
142mm
10.2”
260mm
12”
305mm
15”
381mm
4.7”
120mm
5.2”
133mm 17.2”
438mm 19.7”
501mm
18.6”
474mm