Sea-doo 2000 Islandia Manual

SAFETY WARNING
Disregarding any of the safety precautions and instructions contained in
this Operator’s Guide, the Safety Handbook and on Product Warning
Labels could cause injury, including the possibility of death. The
operator has the responsibility to inform passenger(s) of safety pre-
cautions.
This Operator’s Guide , the Safety Handbook and  should
remain with the craft at the time of resale.
Gelcote† is a trademark of Gelcote International
Knight’s Spray-Nine† is a trademark of Korkay System Ltd
The following trademarks are property of Bombardier Inc. and/or its
subsidiaries:
SEA-DOO®
BOMBARDIER-ROTAX®
Bombardier Lube®
BOMBARDIER-ROTAX Formula XP-S Synthetic Injection Oil
BOMBARDIER-ROTAX Injection Oil
Sea-Doo Synthetic Grease
Printed in Canada (lmo2000-003a.fmPS)
®*Trademarks of Bombardier Inc. and/or its subsidiaries.
©1999 Bombardier Inc. All rights reserved.
lmo2000-003a.book Page 0 Tuesday, December 21, 1999 3:27 PM

1
Doin'it on your new Sea-Doo Sport Boat
Congratulations, you are now the proud owner of a Sea-Doo sport boat. Whether
you are an experienced boater or are new to the sport of boating, we ask you to
take the time to view the
Videocassette provided with the craft, to read this Op-
erator’s Guide , the Safety Handbook and familiarize yourself with the contents.
These manuals contain pertinent information which, if followed, will provide you
with the necessary knowledge to help you fully enjoy the pleasures of this craft.
We strongly recommend that any craft operator complete a safety boating
course. Check with your local Coast Guard or Power and Sail Squadron in your
area for course availability. More serious boaters may want to obtain
Chapman
Piloting
by Elbert S. Maloney, available at most book stores.
When introducing your family or friends to the sport, be sure they fully understand
the controls and operation of the craft and the importance of courteous, respon-
sible riding.
Each operator has a responsibility to ensure the passenger safety and the safety
of other water users. Please follow all safety instructions and drive with care.
We encourage you to have an Annual Safety Inspection of your craft. Please
contact your authorized Sea-Doo dealer for further details.
Finally, we urge you to visit your authorized Sea-Doo dealer regularly for regular
and safety maintenance as well as any craft accessories you may require.
Have fun and... Bon Voyage.
Please keep this
guide and Safety Handbook on board. These manuals
should remain with the craft at time of resale.
lmo2000-003a.book Page 1 Tuesday, December 21, 1999 3:27 PM

2
TABLE OF CONTENTS
FOREWORD............................................................................................ 5
mSAFETY WARNING............................................................................ 6
General................................................................................................................. 6
Operation ............................................................................................................. 6
Maintenance ........................................................................................................ 8
LIST OF DISTRIBUTORS......................................................................... 10
BOMBARDIER LIMITED WARRANTY NORTH AMERICA:
SEA-DOO®SPORT BOAT........................................................................ 11
BOMBARDIER INTERNATIONAL LIMITED WARRANTY:
SEA-DOO®SPORT BOAT........................................................................ 13
REGISTRATION NUMBER LOCATION ..................................................... 15
LOCATION OF THE IMPORTANT LABELS............................................... 16
IDENTIFICATION NUMBERS................................................................... 19
Hull....................................................................................................................... 19
Engine .................................................................................................................. 19
CONTROLS AND COMPONENTS LOCATION.......................................... 20
Cockpit ................................................................................................................. 20
Overview.............................................................................................................. 21
Front View............................................................................................................ 22
Rear View............................................................................................................. 23
COMPONENTS FUNCTIONS .................................................................. 25
1) Safety Lanyard .............................................................................................. 25
2) Steering Wheel ............................................................................................. 25
3) Throttle Lever ............................................................................................... 25
4) Shift Lever .................................................................................................... 26
5) Ignition Switch .............................................................................................. 27
6) 12-Volts Accessory Jack ............................................................................... 27
7) Navigation Light Switch........................................................................................... 27
8) Docking Light Switch.................................................................................... 28
9) Boarding Light Switch................................................................................... 28
10) Engine Compartment Light Switch............................................................... 28
11) Bilge Pump Switch........................................................................................ 28
12) Bilge Air Blower Switch........................................................................................... 29
13) Horn Switch .................................................................................................. 29
14) Deck Light Switch......................................................................................... 30
15) Low-Fuel Warning System Switch................................................................ 30
16) Low-Battery Warning System Switch........................................................... 30
17) Fuel Gauge/Low Oil Level Pilot Lamp and Beeper ....................................... 32
18) Fountain Pump Switch.................................................................................. 32
19) Main Water Pump Switch............................................................................. 33
20) Tachometer................................................................................................... 33
21) Speedometer ................................................................................................ 33
22) Windscreen................................................................................................... 34
23) Grab Handle(s) .............................................................................................. 34
24) Rear Grab Handle(s)...................................................................................... 34
25) Front/Rear Swim Platform ............................................................................ 35
26) Sun Deck/Rear Seat/Engine Cover................................................................ 35
27) Front Seat(s) ................................................................................................. 36
28) Bow Seat(s) .................................................................................................. 37
29) Cup Holders .................................................................................................. 38
30) Deck Storage Compartment ......................................................................... 38
31) Rear Storage Compartment.......................................................................... 39
32) Rear Side Storage Compartment.................................................................. 40
33) Glovebox....................................................................................................... 40
lmo2000-003a.book Page 2 Tuesday, December 21, 1999 3:27 PM

3
34) Bow and Stern Eyelet(s)..................................................................................... 40
35) Docking Lights.............................................................................................. 41
36) Boarding Lights ............................................................................................ 41
37) Engine Compartment Light .......................................................................... 41
38) Navigation Lights.......................................................................................... 41
39) Removable Stern Light (not shown)............................................................. 42
40) Deck Lights .................................................................................................. 43
41) Changing Room Light................................................................................... 43
42) Deck ............................................................................................................. 43
43) Footwell........................................................................................................ 43
44) Fountain Jet.................................................................................................. 44
45) Wash Down Valve ........................................................................................ 45
46) Table............................................................................................................. 46
47) Fuel Tank Cap............................................................................................... 47
48) Fuel Tank Vent.............................................................................................. 47
49) Main Oil Reservoir Cap................................................................................. 48
50) Potable Water Tank Cap............................................................................... 48
51) Flushing Connector ...................................................................................... 49
52) Ventilation Ducts .......................................................................................... 49
53) Jet Pump Nozzle........................................................................................... 49
54) Jet Pump Water Intake................................................................................. 49
55) Hydro Surge Grate System........................................................................... 49
56) Reverse Gate................................................................................................ 49
57) Bilge Drain Plug(s) ........................................................................................ 49
58) Retractable Ladder(s).................................................................................... 50
59) Mooring Cleat(s) ........................................................................................... 50
60) Convenience Center..................................................................................... 51
61) Changing Room with Toilet .......................................................................... 52
62) Portable Toilet............................................................................................... 52
63) Fuses............................................................................................................ 53
64) Ski Post (optional)......................................................................................... 53
65) Radio ............................................................................................................ 54
66) Speaker(s)..................................................................................................... 54
67) Access Doors(s)............................................................................................ 55
68) Fire Port........................................................................................................ 55
69) Shower ......................................................................................................... 55
70) Water Bypass System.................................................................................. 56
71) Main Battery Selector Switch....................................................................... 56
72) Bimini Top (not shown)................................................................................. 57
FUEL, WATER AND LUBRICATION......................................................... 58
Fueling Procedure................................................................................................ 58
Recommended Fuel ............................................................................................ 58
Recommended Oil............................................................................................... 58
Main Oil Reservoir Level...................................................................................... 58
Engine Mounted Oil Reservoir Level................................................................... 59
Potable Water Tank ............................................................................................. 59
BREAK-IN PERIOD ................................................................................. 60
Engine.................................................................................................................. 60
10-Hour Inspection .............................................................................................. 60
DAILY PRE-OPERATION CHECKS .......................................................... 61
Safety Lanyard and Ignition Switch ..................................................................... 62
Hull ...................................................................................................................... 62
Jet Pump Water Intake........................................................................................ 62
Inlet Grate............................................................................................................ 62
Bilge..................................................................................................................... 62
Battery ................................................................................................................. 62
Fuel Tank/Potable Water Tank/Oil Reservoir ....................................................... 62
Engine Compartment........................................................................................... 62
Fire Extinguisher.................................................................................................. 62
Steering System .................................................................................................. 62
lmo2000-003a.book Page 3 Tuesday, December 21, 1999 3:27 PM

4
Throttle System.................................................................................................... 62
Shifter System ..................................................................................................... 63
Storage Compartment Covers ............................................................................. 63
OPERATING INSTRUCTIONS.................................................................. 64
Launching/Loading ............................................................................................... 64
Trailering............................................................................................................... 64
Principle of Operation........................................................................................... 64
Boarding from a Dock .......................................................................................... 66
Boarding from the Water ..................................................................................... 67
Starting the Engine............................................................................................... 67
Rough Water or Poor Visibility Operation............................................................. 67
Crossing Waves ................................................................................................... 68
Stopping/Docking................................................................................................. 68
Beaching .............................................................................................................. 68
Shutting Off the Engine ....................................................................................... 68
POST-OPERATION CARE........................................................................ 69
General Care ........................................................................................................ 69
Additional Care for Foul Water or Salt Water....................................................... 69
SPECIAL PROCEDURE ........................................................................... 70
Engine Overheating.............................................................................................. 70
Potable Water System Disinfection ..................................................................... 70
Jet Pump Water Intake and Impeller Cleaning..................................................... 71
Capsized Boat ...................................................................................................... 71
Submerged Boat .................................................................................................. 71
Low-Charge Battery Condition............................................................................. 71
MAINTENANCE...................................................................................... 72
Lubrication............................................................................................................ 72
Periodic Inspection............................................................................................... 73
Throttle Cable....................................................................................................... 73
Fuel and Oil Filters ............................................................................................... 73
Water Filter .......................................................................................................... 73
Steering/Jet Pump Nozzle Adjustment ................................................................ 73
Reverse Gate ....................................................................................................... 73
Deck Drain(s)........................................................................................................ 73
Fuses ................................................................................................................... 73
Bilge Air Blower ................................................................................................... 74
Navigation Light Bulb Replacement..................................................................... 74
General Inspection and Cleaning.......................................................................... 76
STORAGE AND PRE-SEASON PREPARATION........................................ 77
Storage................................................................................................................. 77
Pre-Season Preparation........................................................................................ 78
PERIODIC INSPECTION CHART ............................................................. 79
SPECIFICATIONS ................................................................................... 80
SI METRIC INFORMATION GUIDE .......................................................... 82
DECLARATION CE OF CONFORMITY ..................................................... 83
Homologation and Certification............................................................................ 84
Operator’s Guide, Confirmation of Receipt.......................................................... 85
CHANGE OF ADDRESS .......................................................................... 87
lmo2000-003a.book Page 4 Tuesday, December 21, 1999 3:27 PM

5
FOREWORD
The Operator’s Guide and Safety
Handbook have been prepared to ac-
quaint the owner/operator or passen-
ger with this personal craft and its var-
ious controls, maintenance and safe
riding instructions. Each is indispens-
able for the proper use of the product,
and should be kept in a waterproof bag
with the craft at all times.
For any questions pertaining to the
warranty and its application, consult
the WARRANTY section in this guide,
and/or an authorized SEA-DOO dealer.
The information contained in this guide
should always be used in conjunction
with the information included in
Mer-
cury Marine (M
2
) Jet Drive Operator’s
Guide .
This guide uses the following symbols
to emphasize particular information.
CAUTION: Denotes an instruction
which, if not followed, may damage
the craft and/or components.
NOTE: Indicates supplementary infor-
mation needed to fully complete an in-
struction.
Although the mere reading of such in-
formation does not eliminate the haz-
ard, the understanding and application
of the information will promote its cor-
rect use.
The information and components/
system descriptions contained in this
guide are correct at the time of publi-
cation. Bombardier Motor Corporation
of America (B.M.C.A.) however, main-
tains a policy of continuous improve-
ment of its products without imposing
upon itself any obligation to install
them on products previously manufac-
tured.
Because of our ongoing commitment
to product quality and innovation,
Bombardier reserves the right at any
time to discontinue or change specifica-
tions, designs, features, models or
equipment without incurring obligation.
The illustrations in this document show
the typical construction of the different
assemblies and may not represent the
full detail or exact shape of the parts.
However, they represent parts that
have the same or similar function.
It is understood that this guide may be
translated into another language. In
the event of any discrepancy, the En-
glish version shall prevail.
Specifications are given in the SI met-
ric system with the SAE U.S. equiva-
lent in parenthesis. Where precise ac-
curacy is not required, some conversions
are rounded off for easier use.
A
Sea-Doo Sport Boat Shop Manual
can be obtained for complete service,
maintenance and more repair informa-
tion.
mWARNING
Identifies an instruction which, if
not followed, may cause serious
personal injuries including the
possibility of death.
lmo2000-003a.book Page 5 Tuesday, December 21, 1999 3:27 PM

6
m SAFETY WARNING
General
mTo fully appreciate the pleasures,
enjoyment and excitement of boat-
ing there are some basic rules that
should be observed and followed by
any boater. Some rules may be new
to you or covered in the PWC/Sport
boat
Safety Handbook and Safety
Video
, others may be common
sense or obvious… irrespective, we
ask that you please take a few min-
utes of your time to completely read
these safety instructions before
you operate your craft. Failure to fol-
low this safety information and safe
boating rules could result in injury,
including the possibility of death to
you, your passenger(s), or other wa-
ter users.
mInformation in this guide is limited.
It is strongly recommended that
you obtain further boating informa-
tion from the local Coast Guard or
Power Squadron. We also recom-
mend all operators to take a boating
safety course. Please check local
and federal boating laws applicable
to the waterways where you intend
to use the craft. Learn the local rules
of the road.
mThe performance of this craft may
significantly exceed that of other
boats you may have operated.
Therefore, use of this craft by a nov-
ice or inexperienced operator, or an
underage or disabled person, is not
recommended.
mObserve and follow all on-product
warning labels.
mBecome completely familiar with
the controls and operation of the
craft before embarking on your first
trip or taking on a passenger(s). If
you have not had the opportunity to
do so with your dealer, practice driv-
ing solo in a suitable area and feel
the response of each control. Be ful-
ly familiar with all controls before
applying the throttle above idle
speed. As the operator, you are in
control and are responsible for the
craft’s safe operation.
mAlways carry the regulatory re-
quired safety items on board. Check
with local regulations or your dealer.
mMake sure that all users of the craft
read and are aware of all warnings.
Operation
mThe operator and passenger(s) should
wear a Coast Guard approved PFD,
suitable eye and body protection as
well as deck shoes or booties.
mStore or tie-down any loose articles
or necessary boating equipment be-
fore operating the craft.
mAlways perform the pre-operation
checks as specified in this guide.
mAlways keep in mind that directional
control is reduced with decreasing
speed and lost when engine is off.
To turn the craft, both steering and
throttle are necessary. This craft
has the capability of turning more
sharply than other boats, however,
unless in an emergency, do not ne-
gotiate sharp, high speed turns. You
and your passenger(s) could be
thrown from the craft. It should also
be remembered that sun, wind, al-
cohol or drugs, may impair your
judgment and reaction time.
lmo2000-003a.book Page 6 Tuesday, December 21, 1999 3:27 PM

7
mWhile your craft has the capacity of
operating at high speeds, it is strong-
ly recommended that high speed op-
eration only be applied when ideal
conditions exist and are permitted.
Higher speed operation requires a
higher degree of skill and increases
the risk of severe injuries.
mThe forces generated on the body of
riders while turning, negotiating
waves or wakes, operating in chop-
py waters, or falling off the water-
craft, especially at higher speeds,
may cause injury including the pos-
sibility of broken legs and other
bones. Remain flexible and avoid
sharp turns.
mEnsure operator all-round visibility
is unrestricted. Always keep a con-
stant lookout for other water users
or other potential hazards especially
when turning. Make sure to keep a
safe distance from all other craft,
other water users or other objects.
mLike any other boats, this craft has
no brake. Stopping distance will
vary depending on initial speed,
load, wind, and water conditions.
Practice stopping and docking in a
safe, traffic free area to have an idea
of how long it will take to stop the
craft under varying conditions. Do
not release throttle when trying to
steer away from objects. You need
throttle to steer. Do not use the
craft’s reverse, if so equipped, to
stop.
mEnsure that all passengers know
how to swim and how to reboard
the craft from the water. The oper-
ator and passenger(s) should be
properly seated and wearing an ap-
proved PFD before starting or mov-
ing the craft and at all times when
craft is in motion. Do not start or op-
erate the craft if a person(s) is seat-
ed on the sun deck or swim plat-
form, or are nearby in the water. The
craft’s jet thrust can cause injury. Al-
ways accelerate slowly. To prevent
accidental starting or unauthorized
use, always detach the safety lan-
yard from the craft especially when
swimmers are boarding or nearby,
or during removal of any weeds or
debris from the intake grate.
mRiding with a passenger(s) or pulling
other boats, tubes, skier or wake-
boarder makes the craft handle dif-
ferently and requires greater skill. Do
not overload the craft or take on
more passengers than designated
for the particular craft. Overloading
can affect maneuverability, stability
and performance. Avoid adding on
accessories, or equipment which
may alter your control of the craft.
The craft may be fitted with tow eye-
lets which can be used to attach a ski
rope. However, do not use these
eyelets or the craft’s cleats to tow a
parasail. Severe craft damage may
occur.
mAlways respect the safety and com-
fort of your passenger(s) and per-
son being towed on skis, wake-
boards or other water products.
Always have an observer while tow-
ing a skier, proceed with only as
much speed as required, and follow
the observers instructions. Unless
absolutely necessary, do not make
tight, sharp turns.
lmo2000-003a.book Page 7 Tuesday, December 21, 1999 3:27 PM

8
mKnow the waters in which the craft
is to be operated. Current, tides,
rapids, hidden obstacles, wakes
and waves etc., can affect safe op-
eration. It is not advisable to operate
the craft in rough or inclement
weather.
mWake or wave jumping or riding the
surf line can cause severe personal
injury and damage the craft. Never
attempt to splash others with your
craft. You may misjudge the ability
of the craft or your own riding skills
and strike a boat or person.
mIn shallow water, proceed with cau-
tion and at very low speeds.
Grounding or abrupt stops may re-
sult in injury. Debris may also be
picked up and be thrown rearward
by the jet pump onto people or prop-
erty.
mRespect no wake zones, the rights
of other water users and the envi-
ronment. As the “skipper” and
owner of a boat you are responsible
for damage to other boats caused
by the wake of your craft. Allow no
one to throw refuse overboard.
mThis craft is equipped with naviga-
tion lights which should be used be-
tween sunset and sunrise. Reduce
speed and do not operate the craft
in reduced visibility. Avoid adding on
accessories or equipment which
may alter the craft’s configuration or
balance.
mRemember, gasoline fumes are in-
flammable and explosive. Always
adhere to the fueling procedure
contained in this guide and those
given to you by the marina. Always
verify fuel level before use and dur-
ing the ride. Apply the principle of
1/3 fuel to destination, 1/3 back and
1/3 reserve fuel supply. Do not carry
spare fuel or inflammable liquids in
any of the storage or engine com-
partments.
mCombustion engine needs air to op-
erate; consequently this craft can
not be totally watertight. Any man-
ouvers such as figure eights etc.,
that cause the upper deck to be un-
der water may cause severe engine
problems due to water ingestion.
Refer to “Special Procedures“ and
Limited Warranty contained in this
guide.
mDue to the close proximity of other
racers, It is recommended that an
approved personal watercraft hel-
met be used during racing events
only. Read and follow all instruc-
tions and warnings provided with
the helmet.
Maintenance
mOnly perform servicing procedures
which are detailed in this guide. Fur-
ther assistance or information can
be obtained from your authorized
Sea-Doo dealer. In many instances
proper tools and training is required
for certain servicing or repair proce-
dures.
mMaintain the craft and equipment in
top condition at all times. Adhere to
the prescribed maintenance sched-
ules. An annual inspection of the
craft is always a good recommenda-
tion that should be followed.
mThe bilge must be kept clean of oil,
water or other foreign materials.
mDo not attempt to lift the craft with-
out special equipment and training.
lmo2000-003a.book Page 8 Tuesday, December 21, 1999 3:27 PM

9
mThe engine and the corresponding
components identified in this guide
should not be utilized on product(s)
other than for those they were de-
signed. Maintenance procedures
and specified tightening torque
must be strictly adhered to. Never
attempt repairs unless the appropri-
ate tools are available. These craft
are designed with parts dimen-
sioned in both the metric and the
imperial systems. When replacing
fasteners, make sure to use only
those recommended by Bombar-
dier. If required, contact your autho-
rized Sea-Doo dealer for further ser-
vicing information.
mOperate your craft prudently and
have fun. Don’t forget that all per-
sons must assist other boaters in a
case of emergency.
lmo2000-003a.book Page 9 Tuesday, December 21, 1999 3:27 PM

10
LIST OF DISTRIBUTORS
NORTH AMERICA
If your SEA-DOO Sport Boat requires warranty service, you should take it to any
authorized SEA-DOO Sport Boat dealer. Be sure to bring your warranty registra-
tion card or other valid proof of the original date of purchase. If a question or
problem arises regarding warranty, first contact the service manager or owner of
the SEA-DOO Sport Boat dealership.
To find the nearest authorized Sea-Doo Sport Boat dealer, dial: 1-800-882-2900.
NOTE: If outside Canada and U.S.A., consult the local authorized Sea-Doo distrib-
utor.
U.S.A.
(Except Puerto Rico)
BOMBARDIER MOTOR CORPORATION
OF AMERICA
5000 STEWART
WAUSAU, WI
54401
Phone: [phone]
http://www.bombardier.com
CANADA
Alberta
British Columbia
Manitoba
North West Territories
Ontario
Quebec
Saskatchewan
Yukon
New-Brunswick
Nova Scotia
Prince Edward Island
Nunavut
BOMBARDIER INC.
RECREATIONAL PRODUCT
75, J.A. BOMBARDIER ST.
SHERBROOKE, QC
J1L 1W3
Phone: [phone]
http://www.bombardier.com
Newfoundland CHARLES R. BELL
P.O. BOX 1050
RIVERSIDE DRIVE
CORNER BROOKE, NFLD
A2H 6J3
Phone: [phone]
FAX: [phone]
lmo2000-003a.book Page 10 Tuesday, December 21, 1999 3:27 PM

11
BOMBARDIER LIMITED WARRANTY NORTH
AMERICA: SEA-DOO®SPORT BOAT
1. WARRANTY COVERAGE PERIOD
In Canada, BOMBARDIER INC. (“Bombardier”), and in the U.S.A., Bombardier on behalf
of BOMBARDIER MOTOR CORPORATION OF AMERICA (BMCA), warrants FROM THE
DATE OF DELIVERY TO THE FIRST CONSUMER that each SEA-DOO SPORT BOAT sold,
as NEW and UNUSED and PREDELIVERED by an authorized North American SEA-DOO
SPORT BOAT dealer, will be free from any defects in material and/or workmanship for a
PERIOD of:
a) For private use:
TWELVE (12) CONSECUTIVE MONTHS, with the exception of the deck and hull fiber-
glass structure; and
SIXTY (60) CONSECUTIVE MONTHS for the deck and hull fiberglass structure.
b) For commercial use:
FOUR (4) CONSECUTIVE MONTHS, with the exception of the deck and hull fiberglass
structure; and
TWELVE (12) CONSECUTIVE MONTHS for the deck and hull fiberglass structure.
All genuine Bombardier accessories, installed by an authorized SEA-DOO SPORT BOAT
dealer at the time of delivery of the new and non-current new SEA-DOO SPORT BOAT,
carry the same Warranty Coverage Period as for the SEA-DOO SPORT BOAT.
2. WHAT BOMBARDIER WILL DO
BOMBARDIER will repair or replace, at its option, all genuine BOMBARDIER part found
defective in material and/or workmanship, under normal use, maintenance and service,
with a genuine BOMBARDIER part without charge for parts and labor, at any authorized
SEA-DOO SPORT BOAT dealer during the Warranty Coverage Period.
3. CONDITION TO HAVE WARRANTY WORK VALIDATED
The customer must notify an authorized SEA-DOO SPORT BOAT dealer within two (2) days
of the appearance of the defect in material and/or workmanship and present to the servic-
ing authorized SEA-DOO SPORT BOAT dealer the SEA-DOO Warranty Registration Card
or a proof of purchase of the NEW and UNUSED SEA-DOO SPORT BOAT and must sign
the repair/work order prior to the start of the repair in order to validate a warranty repair.
All parts replaced under this limited warranty become the property of BOMBARDIER.
4. EXCLUSIONS - ARE NOT WARRANTED
• The engine and corresponding components which are warranted by Mercury Marine.
• Refer to 

 .
• Normal wear and tear items;
• Labor, parts and lubricant costs of all maintenance services.
• Damages caused by failure to provide proper maintenance and/or storage, as described
in the
“SEA-DOO SPORT BOAT Operator's Guide” ;
• Damages resulting from improper repairs, modifications or use of non-approved parts or,
repairs not performed by a authorized SEA-DOO SPORT BOAT dealer;
• Damages resulting from abuse, misuse, neglect, racing;
• Damages resulting from accident, fire, theft, vandalism or any act of God;
• Incidental or consequential damages, or damages of any kind such as but not limited
to towing charges, telephone calls or taxi;
• Water damages caused by water ingestion;
lmo2000-003b.fm Page 11 Tuesday, December 21, 1999 3:47 PM

12
• Damages related to gel coat finish including but not limited to cosmetic gel coat finish,
blisters or fiberglass delamination caused by blisters, crazing, spyder or hairline cracks;
and
• Damages resulting from improper service or maintenance.
5. LIMITATIONS OF LIABILITY
This warranty gives you specific rights, and you may also have other legal rights which may
vary from state to state, or province to province. WHERE APPLICABLE, THIS WARRANTY
IS EXPRESSLY GIVEN AND ACCEPTED IN LIEU OF ANY AND ALL OTHER WARRANTIES,
EXPRESSED OR IMPLIED, INCLUDING WITHOUT LIMITATION ANY WARRANTY OF
MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR PURPOSE.
Neither the distributor, any authorized SEA-DOO SPORT BOAT dealer nor any other person
has been authorized to make any affirmation, representation or warranty other than those
contained in this warranty, and if made, such affirmation, representation or warranty shall
not be enforceable against BOMBARDIER or any other person.
In no event shall BOMBARDIER be liable for special, consequential or incidental damages,
including but not limited to loss of use and transportation costs. Some states or provinces
do not allow the exclusion or limitation of incidental or consequential damages, or limita-
tions on how long an implied warranty lasts, so the above limitation or exclusion may not
apply.
BOMBARDIER reserves the right to modify this warranty at any time, being understood
that such modification will not alter the warranty conditions applicable to the SEA-DOO
SPORT BOAT sold while this warranty is in effect.
6. TRANSFER
If the customer sells the SEA-DOO SPORT BOAT guaranteed under the present, he shall
assign and transfer this warranty, which shall be valid for the rest of the relevant PERIOD
as defined in section 1 hereinabove, to the new customer.
7. CONSUMER ASSISTANCE
a) In the event of a controversy or a dispute arising in connection with this BOM-
BARDIER LIMITED WARRANTY, BOMBARDIER suggests that you try to re-
solve the issue at the dealership level. We recommend discussing the issue
with the authorized dealer's service manager or owner.
b) If further assistance is required, Bombardier’s service department should be
contacted in order to resolve the matter in Canada and the U.S.A.
c) If the issue has still not been resolved, please submit in writing your complaint
to:
In Canada and U.S.A.:
BOMBARDIER INC.
RECREATIONAL PRODUCTS
CUSTOMER ASSISTANCE CENTER
75, J.-A. Bombardier Street
Sherbrooke, QC
J1L 1W3
Tel.: [phone]
SEPTEMBER 1999
®Trademark of Bombardier Inc. and/or subsidiaries
lmo2000-003a.book Page 12 Tuesday, December 21, 1999 3:27 PM

13
BOMBARDIER INTERNATIONAL LIMITED
WARRANTY: SEA-DOO®SPORT BOAT
1. WARRANTY COVERAGE PERIOD
BOMBARDIER INC. (“Bombardier”), as manufacturer, warrants FROM THE DATE OF DE-
LIVERY TO THE FIRST CONSUMER that each SEA-DOO SPORT BOAT sold anywhere in
the world except the United States and Canada, as NEW and UNUSED and PREDELIV-
ERED by an authorized SEA-DOO SPORT BOAT dealer, duly appointed by an authorized
SEA-DOO International Distributor, will be free from any defects in material and/or work-
manship for a PERIOD of:
a) For private use:
TWELVE (12) CONSECUTIVE MONTHS, with the exception of the deck and hull fiber-
glass structure; and
SIXTY (60) CONSECUTIVE MONTHS for the deck and hull fiberglass structure.
b) For commercial use:
FOUR (4) CONSECUTIVE MONTHS, with the exception of the deck and hull fiberglass
structure; and
TWELVE (12) CONSECUTIVE MONTHS for the deck and hull fiberglass structure.
All genuine Bombardier accessories, installed by an authorized SEA-DOO SPORT BOAT
dealer at the time of delivery of the new and non-current new SEA-DOO SPORT BOAT,
carry the same Warranty Coverage Period as for the SEA-DOO SPORT BOAT.
2. WHAT BOMBARDIER WILL DO
BOMBARDIER through the local authorized SEA-DOO International Distributor will, during
the Warranty Coverage Period, repair or replace, at its option, all genuine BOMBARDIER
part found defective in material and/or workmanship, under normal use, maintenance and
service, with a genuine BOMBARDIER part without charge for parts and labor, at any local
authorized SEA-DOO SPORT BOAT dealer.
3. CONDITION TO HAVE WARRANTY WORK VALIDATED
The customer must notify a local authorized SEA-DOO SPORT BOAT dealer within two (2)
days of the appearance of the defect in material and/or workmanship and present to the
servicing authorized SEA-DOO SPORT BOAT dealer the SEA-DOO Warranty Registration
Card or a proof of purchase of the NEW and UNUSED SEA-DOO SPORT BOAT and must
sign the repair/work order prior to the start of the repair in order to validate a warranty
repair. All parts replaced under this limited warranty become the property of the interna-
tional SEA-DOO distributor of the specific territory and/or BOMBARDIER.
4. EXCLUSIONS - ARE NOT WARRANTED
• The engine and corresponding components which are warranted by Mercury Marine.
• Refer to 


• Normal wear and tear items;
• Labor, parts and lubricant costs of all maintenance services;
• Damages caused by failure to provide proper maintenance and/or storage, as described
in the
“SEA-DOO SPORT BOAT Operator's Guide” ;
• Damages resulting from improper repairs, modifications or use of non-approved parts
or, repairs not performed by a authorized SEA-DOO SPORT BOAT dealer;
• Damages resulting from abuse, misuse, neglect, racing;
• Damages resulting from accident, fire, theft, vandalism or any act of God;
• Incidental or consequential damages, or damages of any kind such as but not limited
to towing charges, telephone calls or taxi;
lmo2000-003b.fm Page 13 Tuesday, December 21, 1999 3:48 PM

14
• Water damages caused by water ingestion;
• Damages related to gel coat finish including but not limited to cosmetic gel coat finish,
blisters or fiberglass delamination caused by blisters, crazing, spyder or hairline cracks; and
• Damages resulting from improper service or maintenance.
5. LIMITATIONS OF LIABILITY
This warranty gives you specific rights, and you may also have other legal rights resulting
from the application of mandatory national laws which may vary from country to country.
WHERE APPLICABLE, THIS WARRANTY IS EXPRESSLY GIVEN AND ACCEPTED IN LIEU
OF ANY AND ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WITH-
OUT LIMITATION ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR ANY PAR-
TICULAR PURPOSE.
In no event shall BOMBARDIER be liable for special, consequential or incidental damages,
including but not limited to loss of use and transportation costs. Some countries do not
allow the exclusion or limitation of incidental or consequential damages, or limitations on
how long an implied warranty lasts, so the above limitation or exclusion may not apply.
Neither the distributor, any authorized SEA-DOO SPORT BOAT dealer nor any other person
has been authorized to make any affirmation, representation or warranty other than those
contained in this warranty, and if made, such affirmation, representation or warranty shall
not be enforceable against BOMBARDIER or any other person.
Every SEA-DOO SPORT BOAT is sold with the English version of this warranty. Some
authorized SEA-DOO International Distributor may elect to translate this warranty into local
language, it is then understood and agreed that in the event of any discrepancies or incon-
sistencies between the two versions, the English version shall prevail.
It is the customer's responsibility to ensure that the SEA-DOO SPORT BOAT complies
with all boating regulations and standards of any country, other than the original country
of sale, where the SEA-DOO SPORT BOAT is intended to be used.
BOMBARDIER reserves the right to modify this warranty at any time, being understood
that such modification will not alter the warranty conditions applicable to the SEA-DOO
SPORT BOAT sold while this warranty is in effect.
6. TRANSFER
If the customer sells the SEA-DOO SPORT BOAT guaranteed under the present, he shall
assign and transfer this warranty, which shall be valid for the rest of the relevant PERIOD
as defined in section 1 hereinabove, to the new customer.
7. CONSUMER ASSISTANCE
a) In the event of a controversy or a dispute arising in connection with this BOMBARDIER
INTERNATIONAL LIMITED WARRANTY, BOMBARDIER suggests that you try to re-
solve the issue at the dealership level. We recommend discussing the issue with the
authorized dealer's service manager or owner.
b) If further assistance is required, the authorized local SEA-DOO INTERNATIONAL DIS-
TRIBUTOR's Service Department should be contacted in order to resolve the matter.
c) If the issue has still not been resolved, please submit in writing your complaint to:
BOMBARDIER INC.
RECREATIONAL PRODUCTS
CUSTOMER ASSISTANCE CENTER
75, J.-A. BOMBARDIER STREET
SHERBROOKE, QUEBEC
J1L 1W3
PHONE: [phone]
SEPTEMBER 1999
®Registered trademark of Bombardier Inc. and/or subsidiaries
lmo2000-003a.book Page 14 Tuesday, December 21, 1999 3:27 PM

15
REGISTRATION NUMBER LOCATION
All craft are required by federal law to be registered and legally numbered.
Due to space availability for proper display of registration number, refer to the
following illustration for location. The registration number should appear on each
side of the craft.
TYPICAL
1. Registration number location
F14L01L
1
lmo2000-003a.book Page 15 Tuesday, December 21, 1999 3:27 PM

16
LOCATION OF THE IMPORTANT LABELS
Please read the following labels carefully before operating this craft.
F14L02L
7
10
9
3
4
13
6
1
2
12
5
11
7
146
7
14
lmo2000-003a.book Page 16 Tuesday, December 21, 1999 3:27 PM

17
Label 1
Label 2
TYPICAL — REFER TO ACTUAL LABEL ON
CRAFT
Label 3
TYPICAL — REFER TO ACTUAL LABEL ON
CRAFT
Label 4
Label 5
Label 6
Label 7
Label 8
F00L30L
F13L0GY
F13L0EY
m
F04LACY
F04LADY
F04LAEY
F04LAPY
F04LAGY
lmo2000-003a.book Page 17 Tuesday, December 21, 1999 3:27 PM

18
Label 9
Label 10
Label 11
Label 12
Label 13
Label 14
F00L2IY
F14L28Y
F14L29Y
F14L2AY
F14L2BY
F14L2CY
lmo2000-003a.book Page 18 Tuesday, December 21, 1999 3:27 PM