smirthwaite 4374 User manual

3/11
Ladders &
Platforms
INSTRUCTIONS FOR USE
Ladder Codes 4373 to 4375
Platform Codes 4376 to 4378

1
CONTENTS PAGE
1.0 INTRODUCTION 1
2.0 LADDER PRODUCT CODES AND TECHNICAL DATA 2
3.0 PLATFORM PRODUCT CODES AND TECHNICAL DATA 2
4.0 FOR YOUR SAFETY 2
5.0 ASSEMBLY 3
6.0 CARE & MAINTENANCE 4
7.0 GUARANTEE & SERVICE 5
8.0 CONTINUOUS IMPROVEMENT 5
9.0 WARRANTY & AFTERSALE 6
1.0 INTRODUCTION
Thank you for choosing your new Smirthwaite Product.
Our range of ladders and platforms are ideal for therapy environments, and can be used
for sitting and standing. A range of accessories are also available for additional support.
IMPORTANT!
These instructions should be read by all therapists and carers using
the equipment and should be retained for future reference. The
product should always be used under adult supervision.
Any incorrect use of the product and failure to follow the instructions
may put the user at risk or impede the function. If you have any
queries using this product or wish for further copies, please do not
hesitate to contact Customer Services department on
T: [phone].

2
2.0Ladder Product Codes & Technical Data
Size
1
2
3
Product Code
4374
4374
4375
Depth (mm)
500
500
500
Height (mm)
900
1200
1500
User Weight Limit (Kg)
50
50
50
3.0Platform Product Codes & Technical Data
Size
1
2
3
Product Code
4376
4377
4378
Depth (mm)
400
400
400
Height (mm)
250
300
350
User Weight Limit (Kg)
50
50
50
4.0 FOR YOUR SAFETY
STOP!
Please read these instructions CAREFULLY and THOROUGHLY.
The user should NOT be left unattended whilst using the product. Always ensure a
responsible adult or carer is in attendance.
In the early stages of use, assist and support the child to walk correctly from behind.
Regular maintenance checks and cleaning are essential for the safe use of this
equipment (see care and maintenance section).
If any part is loose, damaged or functioning incorrectly, do not use until rectified.
This product is intended for indoor use only.
Always keep this product away from naked flames, cigarettes and sources of heat
including open fireplaces, radiators and heaters.
If you believe this product to be faulty - DO NOT USE - Contact G&S Smirthwaite Ltd on
T: [phone].

3
5.0 ASSEMBLY
The product is supplied in THREE pieces; two skis and the ladder.
Each side ski has a hole through the base and the ladder is secured to this by one
countersunk sunk, passing through the base of the ski.
With the ladder on its side lightly screw the base screw into the end of the upper
ladder stile ensuring that the two threaded inserts in the base web are uppermost.
Secure the support battens to the base.
Do not tighten any of the screws until each has been located and lightly turned into
the threaded insert.
Tighten the screws through the base, and then stand the ladder up vertically.
Finally tighten the support batten screws with the ladder standing flat on the floor.
Should you wish to query any aspect of your product, please contact our Customer
Services department on:
T: [phone]
E: [email protected]

4
6.0 CARE AND MAINTENANCE
IMPORTANT!
Cleaning is recommended on a regular basis.
All our wooden products are easy to clean.
Clean wooden parts with a damp cloth and mild detergent.
Stubborn marks on wood work should be cleaned by using a soft brush.
Do not soak or immerse the product in water.
Store the product in a cool dry place and out of direct sunlight.
DO NOT use bleach, solvents, abrasives, synthetic detergents, wax polishes,
antibacterial sprays or wipes.
For further information please refer to MHRA or your NHS cleaning guidelines.
6.1 DAILY CHECKS
Check all parts for signs of wear and tear or damage.
Ensure all screws are present and tightened.
STOP!
The product should not be in use while the checks are carried out.
6.2 SERVICE INTERVAL
Ladders and platforms should be serviced every 3 years. Servicing must only be
undertaken by a Smirthwaite service engineer, or by a Smirthwaite trained
representative.

5
7.0 GUARANTEE & SERVICE
This product is issued with a full parts and labour guarantee for 2 years from the date of
delivery. This guarantee does not apply to accidental damage caused through
inappropriate use of the product. This guarantee is issued at the discretion of
G&S Smirthwaite Ltd on RTB (Return to Base) basis.
If you have any questions or doubts relating to the safety or use of the chair please
contact us for advice or assistance on:
T: [phone]
E: [email protected]
8.0 CONTINUOUS IMPROVEMENT
G&S Smirthwaite Ltd are committed to continuous improvement to their product range.
Should you have any suggestions or comments please send them to our product design
department at: [email protected]
G&S Smirthwaite Ltd reserve the right to change the specification or material without
prior notice.
For catalogues, help and further information on our products please contact us at:
G&S Smirthwaite Ltd
17 Wentworth Road
Heathfield
Devon TQ12 6TL
T: [phone]
F: [phone]
E: [email protected]
W: www.smirthwaite.co.uk

6
9.0 WARRANTY & AFTERSALE
9.1 Product Information
Model:
Size:
Date of Manufacture:
Serial Number:
9.2 Service & inspection record form:
Date
Procedure
Service
Personnel

7
G&S Smirthwaite, 17 Wentworth Road, Heathfield, Newton Abbot, Devon.TQ12 6TL
T: [phone] F: [phone] E: [email protected]
W: www.smirthwaite.co.uk

8