Sony TA-V606 User manual

Inputs
S/N (weighting
Sensitivity Impedance network, input
level)
75 dB*
PHONO 2.5mV 50 kilohms (A, 2.5mV)
82 dB*
TUNER 150mV 50 kilohms (A, 150mV)
82 dB*
CD 200mV 50 kilohms (A, 200mV)
TAPE/MD,VIDEO1, 2, 3 150mV 50 kilohms 82 dB*
TV/LD (AEP, UK model) 150mV (A, 150mV)
TV/LD 82 dB*
(EXCEPTAEP, UK model) 250mV 50 kilohms (A, 250mV)
82 dB*
5.1 INPUT 200mV 50 kilohms (A, 200mV)
* ’78 IHF
Outputs VIDEO 1, 2, 3, AUDIO OUT :
Voltage : 150 mV, Impedance : 10 kilohms
WOOFER :
Voltage : 2 V
Impedance : 1 kilohms
PHONES :
Accepts low and high impedance headphones
BASS BOOST +10 dB at 70 Hz
TONE ± 8 dB at 100Hz and 10 kHz
MICROFILM
Manufactured under license from Dolby Laboratories Licensing
Corporation.
“Dolby”, the double-D symbol aand “Pro Logic” are trademarks
of Dolby Laboratories Licensing Corporation.
INTEGRATED AV AMPLIFIER
Photo :TA-VE610
AEP Model
UK Model
E Model
TA-VE610
Chinese Model
TA-V606
SERVICE MANUAL
TA-V606/VE610
SPECIFICATIONS
Amplifier section
POWER OUTPUT
Stereo mode V606 : (6 ohms 1kHz, THD 0.7 %)
110 W + 110W
VE610 :(4 ohms 1kHz, THD 0.7 %)
100 W + 100W
Surround mode V606 : (6 ohms at 1kHz, THD 0.7 %)
Front : 110 W/ch
Center* : 110 W
Rear* : 110 W/ch
VE610 :(4 ohms at 1kHz, THD 0.7 %)
Front : 100 W/ch
Center* : 100 W
Rear* : 100 W/ch
*Depending on the sound field settings and the
source, sound will not be output.
5.1 mode V606 : (6 ohms at 1kHz, THD 0.7 %)
Front : 110 W/ch
Center : 110 W
Rear : 110 W/ch
VE610 :(4 ohms at 1kHz, THD 0.7 %)
Front : 100 W/ch
Center : 100 W
Rear : 100 W/ch
Harmonic distortion at rated output
Less than 0.09% (with DIRECT PASS on)
Frequency respones PHONO : RIAA equalization curve
± 0.5dB
CD, TAPE, DAT/MD, VIDEO 1, 2 :
+0
10Hz – 50 kHz – 1 dB (with DIRECT PASS on) – Continued on page 2 –

– 2 –
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK !OR DOTTED LINEWITH
MARK !ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS
LIST ARE CRITICALTO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY.
TABLE OF CONTENTS
Specifications ........................................................................... 1
1. GENERAL
Location and Function of Controls .................................... 3
2. DIAGRAMS
2-1. IC Pin Function........................................................... 5
2-2. Circuit Boards Locations ............................................ 7
2-3. Printed Wiring Boards – Surround Section – ............. 8
2-4. Schematic Diagram – Surround Section –............... 11
2-5. Schematic Diagram – AMP Section – ..................... 15
2-6. Printed Wiring Boards – AMP Section –.................. 19
2-7. Printed Wiring Boards – Display Section – ............. 23
2-8. Schematic Diagram – Display Section – .................. 27
3. EXPLODED VIEWS
3-1. Front Panel Section................................................... 32
3-2. Chassis Section ......................................................... 33
3-3. Back Panel Section ................................................... 34
4. ELECTRICAL PARTS LIST ........................................ 35
Video section
Inputs 1 Vp-p 75 ohms
Outputs 1 Vp-p 75 ohms
General
System Preamplifier section :
Low-noise NF type equalizer
Power amplifier section :
Pure-complementary SEPP
Power requirements AEP, Singapore, Malaysia model :
230 V AC, 50/60Hz
UK model : 240 V AC, 50/60Hz
Chinese model : 220 V AC, 50/60Hz
Power consumption 240W
AC outlets EXCEPT Chinese model :
1 switched, maximum 100W
Chinese model : 2 switched, total 100 W
Dimensions 430 x 155 x 350 mm
including projecting parts and controls
Mass (Approx.) 9.8 kg
Supplied accessories Remote commander (remote) RM-U501 (1)
Size AA (R6) batteries (2)
Design and specifications are subject to change without notice.

– 3 –
SECTION 1
GENERAL
LOCATION AND FUNCTION OF CONTROLS
This section is extracted from
instruction manual.
[FRONT PANEL]
!™ SOUND FIELD ON/OFF button
!£ MODE button
!¢ GENRE button
!∞ DIRECT PASS, SET UP, 5.1/DVD INPUT buttons
!§ AUDIO FUNCTION buttons
!¶ VIDEO FUNCTION buttons
!• DISPLAY button
!ª DIMMER button
@º PHONES jack
@¡ SPEAKERS switch
1DPC MODE button
2POWER switch
3SUR, TONE, INDEX indicators
4Digital processing control buttons
5Function indicators
6DIRECT PASS indicator
75.1 INPUT indicator
8MASTER VOLUME control
9BALANCE control
!º VIDEO 3 INPUT jacks
!¡ BASS BOOST button/indicator
1 8532
!™!¶ !§ !£!¢!∞!•!ª@º@¡ !º 9
674
!¡

– 4 –
!¡ MASTER VOL +/–
!™ MUTING
!£ DPC MODE
!¢ DIGITAL PROCESSING CONTROL
!∞ DIRECT
!§ EQ/TONE
!¶ SOUND FIELD ON/OFF/GENRE/MODE
!• BACKGROUND
!ª Numeric buttons
@º TV CONTROL ON
1SLEEP
2SYSTEM OFF
3SYSTEM CONTROL/FUNCTION
45.1 INPUT
5TV/VIDEO
6ENTER
7TEST TONE
8CENTER LEVEL +/–
9REAR LEVEL +/–
!º BASS BOOST
[REMOTE]
[REAR PANEL]
15.1 INPUT
2TV/LD
3VIDEO 2
4VIDEO 1
5MONITOR
6WOOFER
7SURROUND SPEAKERS (REAR)
8SURROUND SPEAKERS (CENTER)
9WIRELESS REAR SPEAKER
!º AC OUTLET
(Outlet shape and position varies
according to destination)
!¡ AC power cord
!™ FRONT SPEAKERS (A/B)
!£ TAPE/MD
!¢ CD
!∞ TUNER
!§ PHONO
!¶ ySIGNAL GND

– 5 –
IC103 µPD780205GF-032-3BA (SYSTEM CONTROL)
Pin No. Pin name I/O Description
1 –––– – Not used (Connect to VDD).
2 to 4 –––– – Not used (Connect to ground).
5 F/C/W. MUTE O Front, Center, Woofer mute drive.
6 SL MUTE O Surround L-CH mute drive.
7 SR MUTE O Surround R-CH mute drive.
8 AC MUTE O AC mute drive.
9 D LATCH O Data latch output.
10 RESET I Reset terminal.
11 X2 O System clock (4.19MHZ).
12 X1 I System clock (4.19MHZ).
13 VSS – Ground.
14 NP – Not used (Open).
15 –––– – Connect to reset terminal.
16 VDD – Power supply (+5V).
17 T LATCH O Tuner function latch output.
18 S CLOCK O Serial clock output.
19 S DATA O Serial data output.
20 S LATCH O Serial latch output.
21 AUTO STOP – Not used (Connect to ground).
22 V MUTE O Video mute output.
23 STEREO – Not used (Connect to ground).
24 IF DATA IN – Not used (Open).
25 GND A/D – Ground for A/D converter.
26 SIRCS I Remote control signal input.
27 POWER KEY I Power key input.
28 VERSION I Destination select input.
29 KEY 5 I Key input.
30 KEY 4 I Key input.
31 KEY 3 I Key input.
32 KEY 2 I Key input.
33 KEY 1 I Key input.
34 VDD A/D – Power supply (+5V) for A/D converter.
35 VREF A/D I Reference voltage for A/D converter.
36 V-A O Video switch control output.
37 V-B O Video switch control output.
38 V-E O Video switch control output.
39 STOP O Power ON/OFF control output.
40 VSS – Ground.
41 DIRECT PASS O Direct pass relay drive.
42 SUR RY O Surround relay drive.
43 CENTER RY O Center relay drive.
44 FRONT RY O Front relay drive.
45 MIX SUB RY O Woofer relay drive.
SECTION 2
DIAGRAMS
2-1. IC PIN FUNCTION

– 6 –
Pin No. Pin name I/O Description
46 VDD – Power supply (+5V).
47 PROTECTOR IN I Protector operation input.
48 POWER RY O Power relay drive.
49 BASS BOOST O Bass boost ON/OFF control.
50 SP OFF I Speaker switch input.
51 VOL – O Volume down control output.
52 VOL + O Volume up control output.
53 VOL LED O Volume LED drive.
54 STANDBY LED – Not used (Open).
55 ––––– – Not used (Open).
56 BASS BOOST LED O BASS BOOST LED drive.
57 5.1 INPUT LED O 5.1 INPUT LED drive.
58 DIRECT PASS LED O DIRECT PASS LED drive.
59 SUR LED O SUR LED drive.
60 TONE LED O TONE LED drive.
61 VIDEO 1 LED O VIDEO 1 LED drive.
62 INDEX LED O INDEX LED drive.
63 PHONO LED O PHONO LED drive.
64 TUNER LED O TUNER LED drive.
65 DAT MD LED O CD LED drive.
66 CD LED O TAPE/MD LED drive.
67 TAPE LED O TV/LD LED drive.
68 TV/DBS LED O VIDEO 3 LED drive.
69 VIDEO2 LED O VIDEO 2 LED drive.
70 to 78 P1 – P9 O FL segment drive.
79 V LOARD – FL power supply (– 35V).
80 to 87 P10 – P17 O FL segment drive.
88 to 100 G1 – G13 O FL grid drive.

– 7 –
2-2. CIRCUIT BOARDS LOCATIONS
S.VIDEO board
5.1 IN board
AUDIO board
AU-VIDEO board
SURR AUDIO board
VOL board
SP SW board
VIDEO board
VIDEO (3) board BALANCE board
HP board
DISPLAY board
SW board
L. B. SW board
SP board
REAR AMP board
CONT (AS-2) boar
d
AUDIO SW board
SURR board
CONT (AS-1) board
AMP board
SECONDARY board
STANDBY board
S-A-SP board

– 32 –
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.
SECTION 6
EXPLODEDVIEWS
NOTE :
•-XX, -X mean standardized parts, so they may
have some difference from the original one.
•Items marked “ * ”are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
•The mechanical parts with no reference number
in the exploded views are not supplied.
•Hardware (# mark) list and accessories and packing
materials are given in the last of this parts list.
•Abbreviation
SP : Singapore
CH : Chinese
MY : Malaysia
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
3-1. FRONT PANEL SECTION
1
2
3
4
5
6
7
8
9
10
11
12
12
12
12
13
14
14
15
16
16
16
16
16
17
18
19
22
23
23
24
not
supplied
not
supplied
supplied with
RV401
not
supplied
#1
#1
#1
#1
#1
VE610
#1
FL
101
4 A
21
25
4 A : L. B.SW board
1 4-980-639-01 KNOB (R14) (VE610)
1 4-980-639-31 KNOB (R14) (V606)
2 X-4946-873-1 KNOB (R48) ASSY (VE610)
2 X-4948-385-1 KNOB (R48) ASSY (V606)
3 X-4948-326-1 PANEL ASSY, FRONT (VE610)
3 X-4948-327-1 PANEL ASSY, FRONT (V606)
4 4-989-850-01 BUTTON (BB) (VE610)
4 4-989-850-11 BUTTON (BB) (V606)
5 4-989-842-01 INDICATOR (BB)
6 4-989-852-01 RING (SUR) (VE610)
6 4-989-852-11 RING (SUR) (V606)
7 4-982-083-01 COVER (V3) (VE610)
8 3-008-600-11 EMBLEM (5-AR), SONY (VE610)
8 3-008-600-21 EMBLEM (5-AR), SONY (V606)
9 4-980-109-01 BUTTON (P-M) (VE610)
9 4-980-109-41 BUTTON (P-M) (V606)
10 4-957-383-01 KNOB (F14) (VE610)
10 4-957-383-21 KNOB (F14) (V606)
*11 1-665-470-11 SP.SW BOARD
12 3-704-366-01 SCREW (CASE) (M3X8) (VE610)
12 3-704-366-11 SCREW (CASE) (M3X8) (V606)
13 X-4947-722-1 CASE ASSY (VE610)
13 X-4947-723-1 CASE ASSY (V606)
14 4-985-642-01 CUSHION
*15 4-989-878-01 BRACKET (VOL)
16 4-951-620-01 SCREW (2.6X8), +BVTP
*17 1-665-478-11 BALANCE BOARD (SP,MY,CH)
*17 1-665-467-11 BALANCE BOARD (AEP,UK)
*18 1-665-466-11 VOL BOARD (AEP,UK)
*18 1-665-477-11 VOL BOARD (SP,MY,CH)
19 1-773-130-11 WIRE (FLAT TYPE) (19 CORE) (100mm)
*21 A-4392-858-A DISPLAY BOARD, COMPLETE
22 1-773-115-11 WIRE (FLAT TYPE) (19 CORE) (320mm)
*23 4-921-941-01 CUSHION (FL)
*24 3-386-245-11 HOLDER (FL)
*25 1-665-496-11 SW BOARD
FL101 1-517-672-11 INDICATOR TUBE, FLUORESCENT

– 33 –
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
#1
CNJ909
#1 #1
#1 #1 #1
#1 #1 #1
#1#1 #1
#1
#1
#1 #2
51
52
53
54
55
56
57
58
59
60
61
62
63
64 67
65
66
not supplied
not
supplied
supplied with
J701
UK Model
68
UK Model
AEP, UK, SP,
MY Model
3-2. BACK PANEL SECTION
*51 A-4392-864-A AUDIO BOARD, COMPLETE (SP,MY,CH)
*51 A-4392-865-A AUDIO BOARD, COMPLETE (AEP,UK)
*52 1-665-469-11 AU-VIDEO BOARD
*53 1-665-503-11 S-A-SP BOARD
*54 A-4392-886-A SP BOARD, COMPLETE
*55 1-665-468-11 HP BOARD
*56 A-4392-874-A SURR BOARD, COMPLETE (AEP,UK)
*56 A-4392-875-A SURR BOARD, COMPLETE (SP,MY,CH)
57 1-773-108-11 WIRE (FLAT TYPE) (19 CORE) (160mm)
*58 1-665-495-11 AUDIO SW BOARD
*59 3-703-244-00 BUSHING (2104), CORD
!60 1-769-744-11 CORD, POWER
61 4-956-370-12 BAND, PLUG FIXED (UK)
*62 4-989-880-01 PANEL, BACK (VE610:AEP)
*62 4-989-880-11 PANEL, BACK (VE610:UK)
*62 4-989-880-21 PANEL, BACK (VE610:SP,MY)
*62 4-989-880-31 PANEL, BACK (V606)
*63 1-665-473-11 5.1 IN BOARD
*64 A-4392-866-A VIDEO BOARD, COMPLETE
*65 1-667-721-11 SURR AUDIO BOARD
*66 A-4392-885-A S.VIDEO BOARD, COMPLETE
67 1-769-878-11 WIRE (FLAT TYPE) (7 CORE)
!68 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (UK)
!CNJ909 1-526-794-11 OUTLET, AC (AC OUTLET) (VE610)
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.

– 34 –
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#3
#3
#1
#1
#1
#1
#1#1
#1
#1
F951
T902
F950
F901 F902
101
103
103
104 105
106
107
108
108
109
110
101
not supplied
not
supplied
not
supplied
not supplied
not supplied
not
supplied
not
supplied
not
supplie
d
102
3-3. CHASSIS SECTION
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
101 X-4947-207-1 FOOT ASSY (F50150S) (VE610)
101 X-4947-547-1 FOOT ASSY (F50150S) (V606)
*102 A-4392-888-A STANDBY BOARD, COMPLETE (AEP,UK)
*102 A-4392-890-A STANDBY BOARD, COMPLETE (SP,MY)
*102 A-4403-723-A STANDBY BOARD, COMPLET (CH)
103 1-533-217-31 HOLDER, FUSE
*104 1-665-497-11 SECONDARY BOARD
*105 A-4392-871-A AMP BOARD, COMPLETE (AEP,UK)
*105 A-4392-872-A AMP BOARD, COMPLETE (SP,MY,CH)
*106 1-665-459-11 CONT (AS-2) BOARD
*107 1-665-462-11 CONT (AS-1) BOARD
108 3-905-609-01 SCREW (TRANSISTOR)
*109 A-4392-861-A REAR AMP BOARD, COMPLETE (AEP,UK)
*109 A-4392-862-A REAR AMP BOARD, COMPLETE (SP,MY,CH)
*110 1-665-502-11 VIDEO(3) BOARD
!F901 1-532-504-51 FUSE, TIME LAG (T4AL/250V)
!F902 1-532-464-51 FUSE, TIME LAG (T2.5AL/250V)
!F950 1-532-506-51 FUSE, TIME LAG (T6.3AL/250V)
!F951 1-532-506-51 FUSE, TIME LAG (T6.3AL/250V)
!T902 1-431-273-11 TRANSFORMER, POWER
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.

– 35 –
NOTE :
•Due to standardization, replacements in the
parts list may be different from the parts speci-
fied in the diagrams or the components used on
the set.
•-XX, -X mean standardized parts, so they may
have some difference from the original one.
•RESISTORS
All resistors are in ohms
METAL : Metal-film resistor
METAL OXIDE :Metal oxide-film resistor
F : nonflammable
•Items marked “ * ”are not stocked since they
are seldom required for routine service. Some
delayshouldbeanticipatedwhenorderingthese
items.
•SEMICONDUCTORS
In each case, u : µ, for example :
uA.... : µA.... , uPA.... : µPA....
uPB.... : µPB.... , uPC.... : µPC....
uPD.... : µPD....
•CAPACITORS
uF : µF
•COILS
uH : µH
•Abbreviation
SP : Singapore
CH : Chinese
MY : Malaysia
When indicating parts by reference
number, please include the board.
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.
SECTION 4
ELECTRICAL PARTS LIST
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
*1-665-473-11 5.1 IN BOARD
************
< CAPACITOR >
CC15 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC16 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC17 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC65 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC66 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC67 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
< CONNECTOR >
CNP305 1-564-524-11 PLUG, CONNECTOR 9P
< JACK >
J306 1-779-355-11 JACK, PIN 6P (5.1 DVD INPUT)
< RESISTOR >
R317 1-249-421-11 CARBON 2.2K 5% 1/4W
R325 1-249-421-11 CARBON 2.2K 5% 1/4W
R326 1-249-421-11 CARBON 2.2K 5% 1/4W
R327 1-249-429-11 CARBON 10K 5% 1/4W
R328 1-249-429-11 CARBON 10K 5% 1/4W
R329 1-249-429-11 CARBON 10K 5% 1/4W
R367 1-249-421-11 CARBON 2.2K 5% 1/4W
R375 1-249-421-11 CARBON 2.2K 5% 1/4W
R376 1-249-421-11 CARBON 2.2K 5% 1/4W
R377 1-249-429-11 CARBON 10K 5% 1/4W
R378 1-249-429-11 CARBON 10K 5% 1/4W
R379 1-249-429-11 CARBON 10K 5% 1/4W
************************************************************
*A-4392-871-A AMP BOARD, COMPLETE (AEP,UK)
*A-4392-872-A AMP BOARD, COMPLETE (SP,MY,CH)
*******************
< CAPACITOR >
C520 1-126-967-11 ELECT 47uF 20% 16V
C521 1-107-597-11 CERAMIC 22PF 10% 500V
C522 1-107-597-11 CERAMIC 22PF 10% 500V
C523 1-162-286-31 CERAMIC 220PF 10% 50V
C524 1-126-964-11 ELECT 10uF 20% 50V
C525 1-136-157-00 FILM 0.022uF 5% 50V
C526 1-136-153-00 FILM 0.01uF 5% 50V
C570 1-126-967-11 ELECT 47uF 20% 16V
C571 1-107-597-11 CERAMIC 22PF 10% 500V
C572 1-107-597-11 CERAMIC 22PF 10% 500V
C573 1-162-286-31 CERAMIC 220PF 10% 50V
C574 1-126-964-11 ELECT 10uF 20% 50V
C575 1-136-157-00 FILM 0.022uF 5% 50V
C576 1-136-153-00 FILM 0.01uF 5% 50V
C590 1-126-935-11 ELECT 470uF 20% 6.3V
C598 1-126-965-11 ELECT 22uF 20% 50V
C620 1-126-967-11 ELECT 47uF 20% 16V
C621 1-107-597-11 CERAMIC 22PF 10% 500V
C622 1-107-597-11 CERAMIC 22PF 10% 500V
C623 1-162-286-31 CERAMIC 220PF 10% 50V
C803 1-117-203-11 ELECT 10000uF 20% 63V
C804 1-117-203-11 ELECT 10000uF 20% 63V
C807 1-126-967-11 ELECT 47uF 20% 16V
C808 1-126-967-11 ELECT 47uF 20% 16V
C811 1-126-952-11 ELECT 1000uF 20% 35V
C812 1-126-951-11 ELECT 470uF 20% 35V
C817 1-126-967-11 ELECT 47uF 20% 50V
C818 1-126-967-11 ELECT 47uF 20% 50V
CC48 1-136-153-00 FILM 0.01uF 5% 50V
(AEP,UK)
CC49 1-136-153-00 FILM 0.01uF 5% 50V
(AEP,UK)
CC98 1-136-153-00 FILM 0.01uF 5% 50V
(AEP,UK)
CC99 1-136-153-00 FILM 0.01uF 5% 50V
(AEP,UK)
< CONNECTOR >
CNP701 1-564-320-00 PIN, CONNECTOR (B2P-VH) 2P
CNP702 1-695-091-11 PIN, CONNECTOR (PC BOARD) 15P
CNS502 1-770-404-11 HOUSING,CONNECTOR (PC BOARD)11P
CNS602 1-770-404-11 HOUSING,CONNECTOR (PC BOARD)11P
CNS701 1-569-323-11 SOCKET, CONNECTOR 19P
5.1 IN AMP

– 36 –
< DIODE >
D501 8-719-987-63 DIODE 1N4148M
D502 8-719-010-06 DIODE UZ-2.2BS
D503 8-719-010-06 DIODE UZ-2.2BS
D504 8-719-987-63 DIODE 1N4148M
D505 8-719-987-63 DIODE 1N4148M
D506 8-719-987-63 DIODE 1N4148M
D512 8-719-987-63 DIODE 1N4148M
D545 8-719-987-63 DIODE 1N4148M
D546 8-719-987-63 DIODE 1N4148M
D547 8-719-987-63 DIODE 1N4148M
D548 8-719-815-85 DIODE 1S1585
D549 8-719-815-85 DIODE 1S1585
D551 8-719-987-63 DIODE 1N4148M
D552 8-719-010-06 DIODE UZ-2.2BS
D553 8-719-010-06 DIODE UZ-2.2BS
D554 8-719-987-63 DIODE 1N4148M
D555 8-719-987-63 DIODE 1N4148M
D556 8-719-987-63 DIODE 1N4148M
D601 8-719-987-63 DIODE 1N4148M
D602 8-719-010-06 DIODE UZ-2.2BS
D603 8-719-010-06 DIODE UZ-2.2BS
D604 8-719-987-63 DIODE 1N4148M
D608 8-719-987-63 DIODE 1N4148M
D611 8-719-987-63 DIODE 1N4148M
D651 8-719-987-63 DIODE 1N4148M
D711 8-719-987-63 DIODE 1N4148M
D716 8-719-987-63 DIODE 1N4148M
D807 8-719-934-22 DIODE HZS30-2L
< TERMINAL, EARTH >
*EB701 1-537-738-21 TERMINAL, EARTH
*EB702 1-537-738-21 TERMINAL, EARTH
*EB703 1-537-738-21 TERMINAL, EARTH
< IC >
IC801 8-759-391-87 IC BA78M12P
IC803 8-759-604-45 IC M5F79M12
< COIL >
L501 1-411-906-11 COIL, AIR-CORE
L551 1-411-906-11 COIL, AIR-CORE
< TRANSISTOR >
Q504 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q505 8-729-209-15 TRANSISTOR 2SD2012
Q506 8-749-010-25 IC MN2488-OPY-M
Q507 8-749-010-26 IC MP1620-OPY-M
Q508 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q509 8-729-281-53 TRANSISTOR 2SC1815-GR
Q510 8-729-900-63 TRANSISTOR DTA124ES
Q511 8-729-900-63 TRANSISTOR DTA124ES
Q546 8-729-119-79 TRANSISTOR 2SC2785-FEK
Q547 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q548 8-729-119-79 TRANSISTOR 2SC2785-FEK
Q549 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q554 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q555 8-729-209-15 TRANSISTOR 2SD2012
Q556 8-749-010-25 IC MN2488-OPY-M
Q557 8-749-010-26 IC MP1620-OPY-M
Q558 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q559 8-729-281-53 TRANSISTOR 2SC1815-GR
Q560 8-729-900-63 TRANSISTOR DTA124ES
Q561 8-729-900-63 TRANSISTOR DTA124ES
Q596 8-729-119-79 TRANSISTOR 2SC2785-FEK
Q601 8-729-119-79 TRANSISTOR 2SC2785-FEK
Q604 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q605 8-729-209-15 TRANSISTOR 2SD2012
Q606 8-749-010-25 IC MN2488-OPY-M
Q607 8-749-010-26 IC MP1620-OPY-M
Q608 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q613 8-729-281-53 TRANSISTOR 2SC1815-GR
Q616 8-729-900-36 TRANSISTOR DTC124ES
Q801 8-729-140-97 TRANSISTOR 2SB734-34
< RESISTOR >
R521 1-247-840-00 CARBON 2.4K 5% 1/4W
R523 1-249-414-11 CARBON 560 5% 1/4W
!R524 1-249-408-11 CARBON 180 5% 1/4W F
!R525 1-249-408-11 CARBON 180 5% 1/4W F
!R526 1-233-352-41 ENCAPSULATED COMPONENT F
R527 1-247-850-11 CARBON 6.2K 5% 1/4W
R528 1-249-419-11 CARBON 1.5K 5% 1/4W
R529 1-247-866-11 CARBON 30K 5% 1/4W
R530 1-249-419-11 CARBON 1.5K 5% 1/4W
R531 1-249-433-11 CARBON 22K 5% 1/4W
R532 1-249-437-11 CARBON 47K 5% 1/4W
!R533 1-249-393-11 CARBON 10 5% 1/4W F
!R534 1-249-389-11 CARBON 4.7 5% 1/4W F
R535 1-249-431-11 CARBON 15K 5% 1/4W
R539 1-249-427-11 CARBON 6.8K 5% 1/4W
R540 1-249-417-11 CARBON 1K 5% 1/4W
R541 1-249-429-11 CARBON 10K 5% 1/4W
R547 1-249-425-11 CARBON 4.7K 5% 1/4W
R548 1-249-429-11 CARBON 10K 5% 1/4W
!R549 1-249-393-11 CARBON 10 5% 1/4W F
R550 1-249-429-11 CARBON 10K 5% 1/4W
R571 1-247-840-00 CARBON 2.4K 5% 1/4W
R573 1-249-414-11 CARBON 560 5% 1/4W
!R574 1-249-408-11 CARBON 180 5% 1/4W F
!R575 1-249-408-11 CARBON 180 5% 1/4W F
!R576 1-233-352-41 ENCAPSULATED COMPONENT F
R577 1-247-850-11 CARBON 6.2K 5% 1/4W
R578 1-249-419-11 CARBON 1.5K 5% 1/4W
R579 1-247-866-11 CARBON 30K 5% 1/4W
R580 1-249-419-11 CARBON 1.5K 5% 1/4W
R581 1-249-433-11 CARBON 22K 5% 1/4W
R582 1-249-437-11 CARBON 47K 5% 1/4W
!R584 1-249-389-11 CARBON 4.7 5% 1/4W F
R585 1-249-431-11 CARBON 15K 5% 1/4W
R586 1-249-429-11 CARBON 10K 5% 1/4W
R587 1-249-425-11 CARBON 4.7K 5% 1/4W
!R588 1-249-393-11 CARBON 10 5% 1/4W F
AMP
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.

– 37 –
R589 1-249-420-11 CARBON 1.8K 5% 1/4W
R590 1-249-420-11 CARBON 1.8K 5% 1/4W
R597 1-249-420-11 CARBON 1.8K 5% 1/4W
R598 1-249-420-11 CARBON 1.8K 5% 1/4W
R621 1-247-840-00 CARBON 2.4K 5% 1/4W
R623 1-249-414-11 CARBON 560 5% 1/4W
!R624 1-249-393-11 CARBON 10 5% 1/4W F
!R625 1-249-393-11 CARBON 10 5% 1/4W F
!R626 1-233-352-41 ENCAPSULATED COMPONENT F
R627 1-247-850-11 CARBON 6.2K 5% 1/4W
R628 1-249-419-11 CARBON 1.5K 5% 1/4W
R632 1-249-437-11 CARBON 47K 5% 1/4W
!R642 1-216-454-11 METAL OXIDE 390 5% 2W F
R643 1-249-441-11 CARBON 100K 5% 1/4W
R650 1-249-425-11 CARBON 4.7K 5% 1/4W
R651 1-249-429-11 CARBON 10K 5% 1/4W
!R652 1-249-393-11 CARBON 10 5% 1/4W F
R655 1-249-441-11 CARBON 100K 5% 1/4W
!R739 1-215-868-00 METAL OXIDE 680 5% 1W F
!R765 1-249-393-11 CARBON 10 5% 1/4W F
!R789 1-215-868-00 METAL OXIDE 680 5% 1W F
!R802 1-249-401-11 CARBON 47 5% 1/4W F
R803 1-247-843-11 CARBON 3.3K 5% 1/4W
RR48 1-249-393-11 CARBON 10 5% 1/4W
(AEP,UK)
RR49 1-249-393-11 CARBON 10 5% 1/4W
(AEP,UK)
RR98 1-249-393-11 CARBON 10 5% 1/4W
(AEP,UK)
RR99 1-249-393-11 CARBON 10 5% 1/4W
(AEP,UK)
< RELAY >
RY501 1-515-920-11 RELAY (24V)
RY502 1-515-920-11 RELAY (24V)
RY602 1-515-793-11 RELAY
< TERMINAL >
*TM501 1-537-519-11 TERMINAL BOARD (SP) (FRONT SPEAKERS)
************************************************************
*1-665-469-11 AU-VIDEO BOARD
**************
< CONNECTOR >
CNP305 1-695-087-11 PIN, CONNECTOR (PC BOARD) 7P
CNS305 1-695-092-11 SOCKET, CONNECTOR 7P
************************************************************
*A-4392-864-A AUDIO BOARD, COMPLETE (SP,MY,CH)
*A-4392-865-A AUDIO BOARD, COMPLETE (AEP,UK)
*********************
< CAPACITOR >
C398 1-162-282-31 CERAMIC 100PF 10% 50V
C399 1-162-294-31 CERAMIC 0.001uF 10% 50V
CC09 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC10 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC11 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC12 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC13 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC59 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC60 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC61 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC62 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
CC63 1-162-282-31 CERAMIC 100PF 10% 50V
(AEP,UK)
< CONNECTOR >
CNS302 1-695-096-11 SOCKET, CONNECTOR 15P
CNS304 1-695-087-11 PIN, CONNECTOR (PC BOARD) 7P
< IC >
IC303 8-759-805-14 IC LC7822
< JACK >
J303 1-573-028-31 JACK, PIN 4P
(TV/LD AUDIO IN,VIDEO 2 AUDIO OUT)
J304 1-770-015-11 JACK, PIN 6P
(VIDEO 2 AUDIO IN,VIDEO 1 AUDIO IN OUT)
< RESISTOR >
R318 1-249-417-11 CARBON 1K 5% 1/4W
R319 1-249-417-11 CARBON 1K 5% 1/4W
R320 1-249-417-11 CARBON 1K 5% 1/4W
R321 1-249-417-11 CARBON 1K 5% 1/4W
R322 1-249-417-11 CARBON 1K 5% 1/4W
R368 1-249-417-11 CARBON 1K 5% 1/4W
R369 1-249-417-11 CARBON 1K 5% 1/4W
R370 1-249-417-11 CARBON 1K 5% 1/4W
R371 1-249-417-11 CARBON 1K 5% 1/4W
R372 1-249-417-11 CARBON 1K 5% 1/4W
R388 1-249-437-11 CARBON 47K 5% 1/4W
R389 1-249-437-11 CARBON 47K 5% 1/4W
R398 1-249-417-11 CARBON 1K 5% 1/4W
R399 1-249-425-11 CARBON 4.7K 5% 1/4W
************************************************************
*1-665-495-11 AUDIO SW BOARD
***************
< CAPACITOR >
C407 1-126-795-11 ELECT 10uF 20% 50V
C408 1-164-159-11 CERAMIC 0.1uF 50V
C409 1-126-795-11 ELECT 10uF 20% 50V
C411 1-126-795-11 ELECT 10uF 20% 50V
C412 1-164-159-11 CERAMIC 0.1uF 50V
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
The components identified by mark !
or dotted line with mark !are critical
for safety.
Replaceonly with part number specified.
AMP AUDIOAU-VIDEO AUDIO SW