Sony ICF-C211 - Am/fm Clock Radio User manual

Ver 1.0 2000.04
ICF-C211/C211L
SERVICE MANUAL
ICF-C211
FM/AM CLOCK RADIO
ICF-C211L
FM/LW CLOCK RADIO
SPECIFICATIONS
UK Model
E Model
Australian Model
ICF-C211
AEP Model
ICF-C211/C211L
Time display: 12 hour (Central & South America, Australian, UK model)
24 hour (AEP, Italian, East European & Russian,Argentina,
Singapore model)
Frequency range
FM: 87.5 – 108 MHz
AM: 530 – 1,710 kHz (ICF-C211:Central & South America model)
AM: 531 – 1,602 kHz (ICF-C211: AEP, UK, East European &
Russian, Argentina, Australian, Singapore model)
AM: 526.5 – 1,606.5 kHz (ICF-C211:Italian model)
LW: 153 – 255 kHz (ICF-C211L)
Speaker: Approx. 6.6 cm (2 5/8 inches) dia., 8 ohm
Power output: 150 mW (at 10 % harmonic distortion)
Power requirements:
Central & South America model
120 VAC, 60 Hz
AEP, UK, Italian, East European & Russian, Argentina, Australian,
Singapore model
220 - 230 VAC, 50 Hz
For the power back-up function: 9 V DC, one 6F22 battery
Battery life:Approx. 80 hours, using Sony S-006P(U) battery
Dimensions:Approx. 170 x 65 x 149.5 mm (w/h/d)
(6 3⁄4 x 2 5⁄8 x 6 inches) incl. projecting parts and controls
Mass:
EXCEPT UK model:Approx. 520 g (1 lb 3 oz) not incl. battery
UK model:Approx. 570 g (1 lb 4 oz) not incl. battery
Design and specifications are subject to change without notice.
Photo : ICF-C211
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 2 –
TABLE OF CONTENTS
Specifications ........................................................................... 1
1. GENERAL
Location and Function of Controls .................................... 3
2. DISASSEMBLY
2-1. Cabinet (Upper) .......................................................... 5
2-2. Transformer Board...................................................... 5
2-3. Main Board ................................................................. 5
Installation Power Cord ..................................................... 6
3. ELECTRICAL ADJUSTMENT ................................ 7
4. DIAGRAMS
4-1. Printed Wiring Boards ................................................ 9
4-2. Schematic Diagram .................................................... 11
5. EXPLODED VIEW ..................................................... 15
6. ELECTRICAL PARTS LIST ................................... 17
MODEL NO.
MODEL IDENTIFICATION
–Model Number Portion –
Carved on lower cabinet
ICF-C211
ICF-C211L
Central & South America model :
AC : 120V -60Hz 5W
AEP, UK, Italian, East European & Russian, Argentina,
Australian, Singapore model : AC : 220 –230V-50Hz 5W
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0OR DOTTED LINE WITH
MARK 0ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY.
• HOW TO CHANGE THE CERAMIC FILTER
This model is used two ceramic filters of CF2 and CF3.
You must use same type of color marked ceramic filters in
order to meet same specifications.
Therefore, the ceramic filter must change two pieces together
since it's supply two pieces in package as a spare parts.
mark mark
CF3
CF2
no mark
blue
orange
black
white
10.70MHz
10.67MHz
10.73MHz
10.64MHz
10.76MHz
Mark Center
frequency
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 3 –
SECTION 1
GENERAL
LOCATION AND FUNCTION OF CONTROLS
This section is extracted from
instruction manual.
BAND
C211
AM
TUNING VOL
FMLW
C211L
Function selector
AC power cord
FM wire antenna
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

–4 –
Setting the Clock
1. Plug in the unit.
The display will flash “AM 12:00”.
2. To set the hour, while holding down CLOCK, press TIME
SET H. When the correct hour appears in the display, release
CLOCK.
3. To set the minute, while holding down CLOCK, press TIME
SET M. When the correct minute appears in the display,
release CLOCK. The clock will begin to operate when you
release TIME SET M.
• Each press on TIME SET H or TIME SET M advances the
displayed number by one.
• The minute digits advance to “00” after “59”. The hour digits
do not advance by pressing TIME SET M.
• To adjust the time exactly to the second, release TIME SET M
simultaneously with the time signal.
Playing the Radio
1. Set the Function selector to RADIO ON to turn on the radio
and adjust VOL. (volume)
2. Select BAND and tune in a station using TUNING.
• To turn off the radio, set the Function selector to OFF.
• To improve radio reception
FM: Extend the FM wire antenna fully to improve reception.
AM: Reorient the unit for optimum reception.
A ferrite bar antenna is built into the unit.
Do not operate the unit over a steel desk or metal surface, as
this may lead to interference of reception.
Setting the Alarm
To set the radio alarm, first tune in a station and adjust the
volume.
1. To set the hour for alarm, while holding down ALARM,
press TIME SET H. When the desired hour appears in the
display, release ALARM.
2. To set the minute for alarm, while holding down ALARM,
press TIME SET M. When the desired minute appears in the
display, release ALARM.
3. Set the Function selector to ALARM MODE RADIO or
ALARM MODE BUZZER.
The alarm will come on at the presettime and automatically
turn itself off after 119 minutes.
• To shut off the alarm, set the Function selector to OFF.
To sound the alarm at the preset time the next day, set the
Function selector to ALARM MODE RADIO or ALARM
MODE BUZZER again.
• To cancel either alarm, set the Function selector to OFF.
• To doze a few more minutes, press SNOOZE/SLEEP OFF.
The alarm will shut off, but will come on again after about 9
minutes. You can repeat this process as many times as you like.
• To adjust the radio alarm volume, turn VOL. The buzzer
volume is fixed.
• To check the preset time, press ALARM.
Setting the Sleep Timer
Enjoy falling asleep to the radio using the built-in sleep timer that
shuts off the radio automatically at a preset time.
1. While listening to the radio, set the Function selector to OFF.
2. Press SLEEP.
The radio turns on. It will go off after 59 minutes.
• To turn off the radio before the preset time, press SNOOZE/
SLEEP OFF.
• Every time you press SLEEP, the sleep timer is reset to 59
minutes.
• When you set the Function selector to ALARM MODE
RADIO or ALARM MODE BUZZER, if the preset alarm time
comes while the sleep timer is operating, the radio or buzzer
sounds depending on which you set.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 5 –
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. CABINET (UPPER)
2-2. TRANSFORMER BOARD
rThe equipment can be removed using the following procedure.
Cabinet (upper)
Transformer board
Set
Main board
1Screws +P 3x14
3Claw
2Claw
3Claw 5Claw
6
4
Cabinet (upper)
Cabinet (lower
)
Panel
1Remove solder
2
Transformer board
Cabinet (lower
)
Red
1Claws
2
3
Main board
Snap, battery
Cabinet (lower
)
2-3. MAIN BOARD
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 6 –
INSTALLATION POWER CORD
NOTE FOR INSTALLATION (KNOB (VOL), KNOB (TUNE))
2Turn RV1 fully in the
arrow direction.
1Turn the shaft of CV1
fully in the arrow direction.
5Turn the knob (VOL)
fully in the arrow direction
Ato be the warking
between arrows Aand B.
3Pointer
4Knob (tune)
6
Main board
Cabinet (lower)
Marking
CV1
B
A
RV1
RV1
Knob (VOL)
Cabinet (lower
)
Power cord
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 7 – – 8 –
SECTION 3
ELECTRICAL ADJUSTMENTS
TUNER SECTION
AM/LW Section
Procedure :
BAND : AM (C211)
LW (C211L)
VOLUME : MIN
FM Section
Procedure :
BAND : FM
VOLUME : MIN
AM RF signal
generator
30% amplitude modulation by 400Hz
signal.
Output level : as low as possible
Put the lead-wire
antenna close to
the set.
FM RF signal
generator
22.5kHz frequency deviation by
400Hz signal.
Output level : as low as possible
antenna
terminal
(JW1)
0.01µF
set
32 Ω
speaker terminal
level mete
r
• Repeat the procedures in each adjustment several times, and the
frequency coverage and tracking adjustments should be finally
done by the trimmer capacitors.
< > : Italian model
AM IF ADJUSTMENT
Adjust for a maximum reading on level meter.
T1 455kHz
C211
AM FREQUENCY COVERAGE ADJUSTMENT
Adjust for a maximum reading on level meter.
L4 520kHz <516.5kHz>
CT4 1,750kHz <1631.5kHz>
AM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L1 620kHz
CT1 1,400kHz
C211L
LW FREQUENCY COVERAGE ADJUSTMENT
Adjust for a maximum reading on level meter.
L4 145kHz
CT6 265kHz
LW TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L1 145kHz
CT5 265kHz
FM FREQUENCY COVERAGE ADJUSTMENT
Adjust for a maximum reading on level meter.
L3 86.5MHz <87.35MHz>
CT3 109.5MHz <108.25MHz>
FM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L2 86.5MHz <87.35MHz>
CT2 109.5MHz <108.25MHz>
CT3 : FM Frequency Coverage Adjustment
L3: FM Frequency Coverage Adjustment
CT6 : LW Frequency Coverage Adjustment
L4 : LW Frequency Coverage Adjustment
L1 : LW Tracking Adjustment
T1 : AM IF Adjustment
CT2 : FM Tracking Adjustment
CT5 : LW Tracking Adjustment
L2 : FM Tracking Adjustment
CT3 : FM Frequency Coverage Adjustment
L3 : FM Frequency Coverage Adjustment (Except IT model)
L3 : FM Frequency Coverage Adjustment (IT model)
L4 : AM Frequency Coverage Adjustment
CT4 : AM Frequency Coverage Adjustment
L1 : AM Tracking Adjustment
T1 : AM IF Adjustment
CT1 : AM Tracking Adjustment
CT2 : FM Tracking Adjustment
L2 : FM Tracking Adjustment
JW1
JW1
ICF-C211L
ICF-C211
Adjustment Location : Main board (Component side)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

23 4 5 6 7 8
A
1
B
C
D
[MAIN BOARD]
TRANSFORMER
BOARD
11
(11)
1-678-190-
11
(11)
1-678-188-
E C B
Q2 E
C
B
Q3
B C E
Q1
D8
D4
D3
D1
D5
D6
D2
C14
C28
C10
C17
C27
JW12
JW11
JW1
JW2
JW9
JW8
JW7
JW10
JW4
JW5
JW6
CV1
CV4
CV2
CV3
CT2
CT3
CT1
CT4
R10
L1
AM
FERRITE-ROD
ANTENNA
DRY BATTERY
"S-006P"
(IEC DESIGNATION 6F22)
1PC, 9V
(POWER BACK UP FOR CLOCK)
SP1
SPEAKER
+
–
T2
POWER TRANSFORMER
- AC IN
C2
C4
C15
C12
C6C7
C18
C19
C24
C25
C22 R6
R14
R9
R8
R13
C21
R12
C9
C3
C1
C31
C16
C32 C20
C23
R5
R1
R3
R2
R4
R11
R7
1
1
5
5
10
10 15 16
14
15
20
25
28
IC2
D7
LED
DISPLAY
C26
C29
1234
1234
JW14
C11C13
W1
1
510 15
20 16
25
30
IC1
CF1
CF2
BPF1
C5
EXCEPT IT
MODEL
IT MODEL L3
L3
W2
BLK
S8
SNOOZE/SLEEP OFF
C8
S6
CLOCK
S5
TIME SET
H
S4
TIME SET
M
S3
ALARM
CV1-4
TUNING
S7
SLEEP
CF3
L4
CT6
C211L CT5
C211L
C211 C211L
IT, C211L
C211L
C211L
C211L
C211L
L2 S1
BAND
AM
R
FM
S1
BAND
LW
R
FM
RV1
VOL
w
S2
OFF TRADIO
t
RADIO
t BUZZER
ALARM MODE
ON
S2
RV1 ANT1
FM WIRE
ANTENNA
EXCEPT C&SA
MODEL
AEP, IT, CET,
AR, SP, C211L
02
T1
– 9 – – 10 –
ICF-C211/C211L
4-1. PRINTED WIRING BOARDS
SECTION 4
DIAGRAMS
D1 B-5
D2 C-4
D3 C-3
D4 C-3
D5 C-4
D6 C-4
D7 A-4
D8 B-3
Ref. No. Location
zSemiconductor Location
Ref. No. Location
IC1 C-6
IC2 B-4
Q1 B-6
Q2 B-3
Q3 C-4
Note:
•X: parts extracted from the component side.
•f: internal component.
•b: Pattern from the side which enables seeing.
• Abbreviation
AUS : Australian SP :Singapore
AR : Argentine IT :Italian
CET : East European & Russian
C&SA : Central & South America
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 11 – – 13 –– 12 –
ICF-C211/C211L
4-2. SCHEMATIC DIAGRAM zRefer to page 14 for IC Block Diagrams.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ωand 1/4W or less unless otherwise
specified.
•f: internal component.
Note: The components identified by mark 0or dotted
line with mark 0are critical for safety.
Replace only with part number specified.
•U: B+ Line.
• Voltages are dc with respect to ground under
no-signal conditions.
no mark : FM
( ) : AM/LW
• Voltages are taken with a VOM (Input imped-
ance 10 MΩ).
Voltage variations may be noted due to normal
production tolerances.
• Signal path.
F: FM
• Abbreviation
AUS : Australian SP :Singapore
AR : Argentine IT :Italian
CET : East European & Russian
C&SA : Central & South America
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 14 – – 16 –– 15 –
zIC Block Diagrams
IC1 CXA1019S
IC2 LM8560N
GND GND
FM DISCRI
NF
VOL
AM OSC
AFC
FM OSC
REG OUT
FM RF
AM RF IN
N. C
FM RF IN
FE GND
MIX OUT
21222324252627
2829
30
235
4678910
111 12 13 14 15
16
17
18
1920
AF POWER AMP
AM IF DET AGC
AM FE
FM
DISCRIMINATOR
FM FE
TUNING
METER
FM IF
GND GND AF OUT Vcc RIPPLE FILTER AF IN DET OUT AFC AGC AFC AGC IF GND METER N. C FM IF IN AM IF IN FM/AM BAND SELECT
OSC
CTR
GATE
GATE
D
OUTPUT
CONTROL
COMPARATOR
STAND
BY DET
BLANK
&
FLASH
OUTPUT
DECODER/
DRIVER
INPUT
CONTROL
PWR
UP
1/2
SEC
CTR
RESET
CONTROL
1/25 OR 1/30
DISPLAY
CONTROL
TIME
HR CTR
CONTROL
ALARM
HR CTR
D D D D D
SLEEP
CTR
ALARM
MIN CTR
TIME
MIN CTR
SEC RSTYHLD
TIME
SEC
ALARM
SLEEP
28 27 26 25 24 23 22 21 20 18
14
1 – 13
16 15 17
PWR UP
TONE
PWR
UP
50/60Hz 50/60Hz 50/60Hz 50/60Hz50/60Hz50/60Hz
2Hz
50/60Hz
T.DISP &
S.SAMPLE
T.RST
AL.RST
SEC DISP
T.DISP
AL.DISP
SL.DISP
TIME &
S.SAMPLE
TIME &
F.SAMPLE
ALARM &
F.SAMPLE
ALARM &
S.SAMPLE
2Hz
F.SAMPLE
S.SAMPLE
50/60Hz
12/24 SELECT CR INPUT 50/60 SELECT 50/60 INPUT SNOOZE INPUT SLEEP INPUT HOUR SET MIN SET
VSS
ALARM OFF SLEEP OFF ALARM OUTPUT SLLEP INPUT
19
ALARM DISPLA
Y
COL ON
OUT
SEGMENT
OUTPUT
PF.
DET
1kHz
SECTION 5
EXPLODED VIEW
NOTE :
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Color indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ••• (RED)
↑↑
Parts color Cabinet's color
• Items marked “ * ”are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• The mechanical parts with no reference
number in the exploded views are not
supplied.
• Accessories and packing materials are given
in the last of this parts list.
• Abbreviation
IT : Italian AR : Argentine
AUS : Australian SP : Singapore
C&SA : Central & South America
CET : East European & Russian
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
SP1
L1
D7
W2
W1
1
15
2
3
4
6
5
8
7
12
910
11
18
16
14
14
14
14
14
not supplied
AR Model
UK Model
C&SA Model
AEP, CET,
IT, SP Model,
C211L
AUS Model
19 13
17
T2
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 3-369-135-21 LID,BATTERY CASE
2 3-919-268-01 KNOB(VOL)
3 3-044-213-01 CABINET (LOWER) (BLACK) (C&SA)
3 3-044-213-11 CABINET (LOWER) (WHITE) (C&SA)
3 3-044-213-21 CABINET (LOWER) (BLACK)
(C211:AEP,CET,IT,UK,AR,SP,AUS)
3 3-044-213-31 CABINET (LOWER) (WHITE)
(C211:AEP,CET,IT,UK,AR,SP,AUS)
3 3-044-213-41 CABINET (LOWER) (BLACK) (C211L)
3 3-044-213-51 CABINET (LOWER) (WHITE) (C211L)
4 7-685-649-79 SCREW+P 3X14 TYPE2 NON-SLIT
5 3-044-217-01 POINTER
*6 1-678-190-11 TRANSFORMER BOARD
*7 1-535-771-11 TERMINAL (EXCEPT C&SA)
8 3-044-214-01 PANEL(C&SA,UK,AUS)
8 3-044-214-11 PANEL(C211:AEP,CET,AR,SP)
8 3-044-214-21 PANEL(IT)
8 3-044-214-31 PANEL(C211L)
9 3-044-216-01 BUTTON (SNOOZE) (BLACK)
9 3-044-216-11 BUTTON (SNOOZE) (WHITE)
10 3-044-219-01 KNOB (FUNCTION) (BLACK)
10 3-044-219-11 KNOB (FUNCTION) (WHITE)
11 3-044-218-01 INDICATOR
12 3-044-212-01 CABINET (UPPER) (BLACK)
(EXCEPT C211L)
12 3-044-212-11 CABINET (UPPER) (WHITE)
(EXCEPT C211L)
12 3-044-212-21 CABINET (UPPER) (BLACK) (C211L)
12 3-044-212-31 CABINET (UPPER) (WHITE) (C211L)
13 3-044-215-01 BUTTON (CLOCK) (BLACK)
13 3-044-215-11 BUTTON (CLOCK) (WHITE)
014 1-555-795-00 CORD, POWER (C211:AEP,CET,IT,SP,C211L)
014 1-696-572-11 CORD, POWER (UK)
014 1-790-124-11 CORD, POWER (AR)
014 1-790-431-11 CORD, POWER (AUS)
014 1-769-339-22 CORD, POWER (C&SA)
15 3-044-228-01 KNOB (TUNE)
16 3-044-220-01 HOLDER (ANT)
17 1-754-135-11 ANTENNA (WIRE)
*18 A-3683-197-A MAIN BOARD, COMPLETE (C211:C&SA)
*18 A-3683-198-A MAIN BOARD, COMPLETE
(C211:AEP,CET,AR,SP)
*18 A-3683-199-A MAIN BOARD, COMPLETE (C211:IT)
*18 A-3683-200-A MAIN BOARD, COMPLETE (C211L)
*18 A-3683-201-A MAIN BOARD, COMPLETE (C211:UK,AUS)
19 3-049-753-01 PLATE, BACK
D7 8-749-016-85 DIODE SL-1998-79T
(AEP,CET,IT,AR,SP,C211L)
D7 8-749-016-84 DIODE SL-1998-78T (C&SA,UK,AUS)
L1 1-419-535-11 COIL, FERRITE-ROD ANTENNA
(LW TRACKING)(C211:IT,C211L)
L1 1-419-532-11 COIL, FERRITE-ROD ANTENNA
(AM TRACKING)(EXCEPT C211:IT,C211L)
0T2 1-435-400-11 TRANSFORMER, POWER (C&SA)
0T2 1-435-401-11 TRANSFORMER, POWER
(C211:AEP,CET,IT,UK,AR,SP,AUS,C211L)
SP1 1-529-456-11 SPEAKER (6.6cm)
W1 1-535-804-21 SNAP, BATTERY
*W2 1-769-137-11 CORD, CONNECTION (16 CORE)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 17 –
NOTE :
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms
METAL : Metal-film resistor
METAL OXIDE :Metal oxide-film resistor
F : nonflammable
• Items marked “ * ”are not stocked since
they are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example :
uA.... : µA.... , uPA.... : µPA....
uPB.... : µPB.... , uPC.... : µPC....
uPD.... : µPD....
• CAPACITORS
uF : µF
• COILS
uH : µH
• Abbreviation
IT : Italian AR : Argentine
AUS : Australian SP : Singapore
C&SA : Central & South America
CET : East European & Russian
When indicating parts by reference num-
ber, please include the board.
SECTION 6
ELECTRICAL PARTS LIST
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
*A-3683-197-A MAINBOARD, COMPLETE (C&SA)
*A-3683-198-A MAINBOARD, COMPLETE (AEP,CET,AR,SP)
*A-3683-199-A MAINBOARD, COMPLETE (IT)
*A-3683-200-A MAINBOARD, COMPLETE (C211L)
*A-3683-201-A MAINBOARD, COMPLETE (UK,AUS)
********************
< FILTER, BAND PASS >
BPF1 1-236-022-11 FILTER, BAND PASS
< CAPACITOR >
C1 1-163-220-11 CERAMIC CHIP 3PF 0.25PF 50V
(IT)
C1 1-163-239-11 CERAMIC CHIP 33PF 5% 50V
(C211L)
C2 1-163-233-11 CERAMIC CHIP 18PF 5% 50V
(EXCEPT IT)
C2 1-163-102-00 CERAMIC CHIP 24PF 5% 50V
(IT)
C3 1-163-103-00 CERAMIC CHIP 27PF 5% 50V
(EXCEPT IT)
C3 1-163-105-00 CERAMIC CHIP 33PF 5% 50V
(IT)
C4 1-163-086-00 CERAMIC CHIP 3PF 50V
(EXCEPT IT,C211L)
C4 1-163-089-00 CERAMIC CHIP 6PF 50V
(IT)
C4 1-163-255-11 CERAMIC CHIP 150PF 5% 50V
(C211L)
C5 1-104-664-11 ELECT 47uF 20% 10V
C6 1-163-031-11 CERAMIC CHIP 0.01uF 50V
(C211)
C6 1-163-035-00 CERAMIC CHIP 0.047uF 50V
(C211L)
C7 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C8 1-126-960-11 ELECT 1uF 20% 50V
C9 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C10 1-126-963-11 ELECT 4.7uF 20% 50V
C11 1-126-964-11 ELECT 10uF 20% 50V
C12 1-163-033-91 CERAMIC CHIP 0.022uF 50V
(EXCEPT C211L)
C12 1-163-035-00 CERAMIC CHIP 0.047uF 50V
(C211L)
C13 1-126-956-11 ELECT 0.1uF 20% 50V
C14 1-104-664-11 ELECT 47uF 20% 10V
C15 1-164-505-11 CERAMIC CHIP 2.2uF 16V
C16 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V
C17 1-104-665-11 ELECT 100uF 20% 10V
C18 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C19 1-163-019-00 CERAMIC CHIP 0.0068uF 10% 50V
C20 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C21 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C22 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C23 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C24 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C25 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C26 1-126-934-11 ELECT 220uF 20% 16V
C27 1-126-916-11 ELECT 1000uF 20% 6.3V
C28 1-126-916-11 ELECT 1000uF 20% 6.3V
C29 1-126-961-11 ELECT 2.2uF 20% 50V
(C211L)
C31 1-163-038-91 CERAMIC CHIP 0.1uF 25V
C32 1-163-038-91 CERAMIC CHIP 0.1uF 25V
< FILTER >
CF1 1-578-677-11 FILTER, CRYSTAL (C211L)
CF1 1-781-790-11 FILTER AM, CERAMIC (EXCEPT C211L)
CF2 1-781-861-71 FILTER, CERAMIC (COMBINATION)
CF3 1-781-861-71 FILTER, CERAMIC (COMBINATION)
< TRIMMER >
CT1 1-141-620-11 CAP, VAR (AM TRACKING)
CT2 1-141-620-11 CAP, VAR (FM TRACKING)
CT3 1-141-620-11 CAP, VAR (FM FREQUENCY COVERAGE)
CT4 1-141-620-11 CAP, VAR (AM FREQUENCY COVERAGE)
CT5 1-141-604-11 CAP, ADJ (LW TRACKING)(C211L)
CT6 1-141-604-11 CAP, ADJ (LW FREQUENCY COVERAGE)
(C211L)
< VARIABLE CAPACITOR >
CV1 1-141-620-11 CAP, VAR (TUNING)
CV2 1-141-620-11 CAP, VAR (TUNING)
CV3 1-141-620-11 CAP, VAR (TUNING)
CV4 1-141-620-11 CAP, VAR (TUNING)
< DIODE >
D1 8-719-911-19 DIODE 1SS119-25TD
D2 8-719-911-19 DIODE 1SS119-25TD
D3 8-719-911-19 DIODE 1SS119-25TD
D4 8-719-911-19 DIODE 1SS119-25TD
MAIN
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

– 18 –
ICF-C211/C211L
9-927-903-11
Sony Corporation
Personal Audio Division Company 2000D0267-1
Printed in Japan © 2000.4
Published by General Engineering Dept.
D5 8-719-911-19 DIODE 1SS119-25TD
D6 8-719-052-88 DIODE 1N4002
D7 8-749-016-85 DIODE SL-1998-79T
(AEP,CET,IT,AR,SP,C211L)
D7 8-749-016-84 DIODE SL-1998-78T (C&SA,UK,AUS)
D8 8-719-911-19 DIODE 1SS119-25TD (C211L)
< IC >
IC1 8-752-037-02 IC CXA1019S
IC2 8-759-821-46 IC LM8560N
< COIL >
L1 1-419-535-11 COIL, FERRITE-ROD ANTENNA
(LW TRACKING) (C211L)
L1 1-419-532-11 COIL, FERRITE-ROD ANTENNA
(AM TRACKING) (C211)
*L2 1-422-320-11 COIL, AIR-CORE (FM TRACKING)
L3 1-422-131-00 COIL, FM OSCILLATION
(FM FREQUENCY COVERAGE) (EXCEPT IT)
L3 1-406-957-11 COIL (WITH CORE)
(FM FREQUENCY COVERAGE) (IT)
L4 1-419-533-11 COIL, OSC (MW)
< TRANSISTOR >
Q1 8-729-026-39 TRANSISTOR 2SA933AS-QRT
Q2 8-729-029-86 TRANSISTOR DTC124ESA-TP (C211L)
Q3 8-729-029-21 TRANSISTOR DTA114ESA-TP (C211L)
< RESISTOR >
R1 1-216-061-00 METAL CHIP 3.3K 5% 1/10W
(EXCEPT IT)
R2 1-216-013-00 METAL CHIP 33 5% 1/10W
R3 1-216-097-91 RES-CHIP 100K 5% 1/10W
(C211)
R3 1-216-085-00 METAL CHIP 33K 5% 1/10W
(C211L)
R4 1-216-109-00 METAL CHIP 330K 5% 1/10W
(C211)
R4 1-216-097-91 RES-CHIP 100K 5% 1/10W
(C211L)
R5 1-216-037-00 METAL CHIP 330 5% 1/10W
R6 1-216-057-00 METAL CHIP 2.2K 5% 1/10W
R7 1-216-081-00 METAL CHIP 22K 5% 1/10W
R8 1-216-105-91 RES-CHIP 220K 5% 1/10W
R9 1-216-097-91 RES-CHIP 100K 5% 1/10W
R10 1-247-791-91 CARBON 22 5% 1/4W
R11 1-216-041-00 METAL CHIP 470 5% 1/10W
(C211L)
R12 1-216-073-00 METAL CHIP 10K 5% 1/10W
R13 1-216-073-00 METAL CHIP 10K 5% 1/10W
R14 1-216-013-00 METAL CHIP 33 5% 1/10W
< VARIABLE RESISTOR >
RV1 1-228-790-00 RES, VAR, CARBON 50K (VOL w)
< FLAT CABLE >
W1 1-535-804-21 SNAP, BATTERY
*W2 1-769-137-11 CORD, CONNECTION (16 CORE)
< SWITCH >
S1 1-771-905-11 SWITCH,SLIDE (BAND)
S2 1-771-904-11 SWITCH,SLIDE
(OFF/RADIO ON/RADIO/BUZZER)
S3 1-771-906-11 SWITCH,KEY BOARD (ALARM)
S4 1-771-906-11 SWITCH,KEY BOARD (TIME SET M)
S5 1-771-906-11 SWITCH,KEY BOARD (TIME SET H)
S6 1-771-906-11 SWITCH,KEY BOARD (CLOCK)
S7 1-771-906-11 SWITCH,KEY BOARD (SLEEP)
S8 1-771-906-11 SWITCH,KEY BOARD (SNOOZE/SLEEP OFF)
**************************************************************
*1-678-190-11 TRANSFORMER BOARD
*******************
*1-535-771-11 TERMINAL (EXCEPT C&SA)
< TRANSFORMER >
T1 1-404-790-11 TRANSFORMER, IF (AM IF) (C211L)
T1 1-435-399-11 TRANSFORMER, IF (AM IF)
**************************************************************
MISCELLANEOUS
***************
*6 1-678-190-11 TRANSFORMER BOARD
*7 1-535-771-11 TERMINAL(EXCEPT C&SA)
014 1-555-795-00 CORD, POWER (C211:AEP,CET,IT,SP, C211L)
014 1-696-572-11 CORD, POWER (UK)
014 1-790-124-11 CORD, POWER (AR)
014 1-790-431-11 CORD, POWER (AUS)
014 1-769-339-22 CORD, POWER (C&SA)
D7 8-749-016-85 DIODE SL-1998-79T (C211:AEP,CET,IT,AR,SP,
C211L)
D7 8-749-016-84 DIODE SL-1998-78T (C&SA,UK,AUS)
L1 1-419-535-11 COIL, FERRITE-ROD ANTENNA
(LW TRACKING) (C211:IT,C211L)
L1 1-419-532-11 COIL, FERRITE-ROD ANTENNA
(AM TRACKING) (C211:IT,C211L)
0T2 1-435-400-11 TRANSFORMER, POWER (C&SA)
0T2 1-435-401-11 TRANSFORMER, POWE (C211:AEP,CET,IT,UK,
AR,SP,AUS,C211L)
SP1 1-529-456-11 SPEAKER (6.6cm)
**************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
3-047-717-11 MANUAL, INSTRUCTION (ENGLISHI,FRENCH,
GERMAN,SPANISH,DUTCH,SWEDISH,ITALIAN,
PORTUGUESE) (C211:AEP,IT,UK,C211L)
3-047-717-31 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
PORTUGUESE,SIMPLIFIED CHINESE)
(C211:C&SA,AR,SP,AUS)
3-047-717-41 MANUAL, INSTRUCTION (DANISH,FINNISH,
CZECH,HUNGALIAN,RUSSIAN,SLOVAK)
(C211:CET)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
MAIN TRANSFORMER
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com