Sportsman GEN4KDF User manual

1
2
3
Remove Generator From Package
Add Oil
Add Fuel
4,000 Surge / 3,500 Running Watts
POWERED BY UNLEADED
GASOLINE ORPROPANE FUEL
Oil Type: SAE10W-30 Oil (Must add BEFORE first use)
Oil Capacity: 20 fluid oz
Because this generator includes Low Oil Shut Off, the
generator will not start with low oil. Start out with 18.6 oz,
then fill until almost overflowing.)
If using Gasoline, add Unleaded gasoline only
octane rating of 87 or higher. Maximum Capacity:
3.6 Gallon gasoline fuel tank
If using Propane, connect Regulator Hose to
Propane Tank and the LP Gas Inlet on Generator.
4Start The Generator
Use the generator OUTDOORS in a WELL VENTILATED AREA.
DO NOT CONNECT electrical devices until AFTER the generator
is started.
Turn Engine Power Switch to ON
A. If using GASOLINE, Turn FUEL PETCOCK to ON (Figure A)
B. If using PROPANE, turn FUEL PETCOCK to OFF first, then
connect regulator hose and turn Tank Valve to ON (Figure B)
Adjust the CHOKE to CLOSED TO START position (Figure C)
Start the generator manually with the Recoil (Pull) Start.
Once the engine has started, GRADUALLY move the choke lever
to the “OPEN TO RUN” position until the engine levels off. Then let
the engine run approximately 5 minutes BEFORE adding
appliances or tools.
You can now connect electrical devices.
(Figure A) Fuel Petcock
TOLL-FREE NATIONWIDE HELP LINE! 866-460-9436
On
Closed To Start
Read and understand instruction manual
before using generator.
OIL IS NOT INCLUDED WITH THIS
GENERATOR. IT IS SOLD SEPARATELY.
3Add Gasoline
Add Oil
Engine
Switch
4
2
Recoil
Start
4
PROPANE FUEL VS USING GASOLINE.
• If you are using a generator 3,000 ft. above
sea level, the generator may not function
properly because of air flow getting through
the carburetor.
• High Altitude Use: This generator is not
recommended for high altitude use 3,000 ft.
above sea level.
LP Gas Inlet (Figure B)
Step-By-Step Quick Start
Guide To Using Your Generator
GEN4KDF CO
GENERATOR SPECIFICATIONS:
• 7.0 HP Engine, 4 Stroke OHV
• Recoil Start
• 3.6 Gallon Fuel Tank
• Low Oil Shut Off
• AVR Automatic Voltage Regulation
• UL Listed Electrical Components
• Engine Shut Off Switch
• Circuit Breaker & Power Outlets
• 1 - 12V D/C Outlet
Choke Position (Figure C)
Open To Run
• 4 - 120V A/C Outlets
• 1 - 120V RV Outlet
• Complies with EPA emissions
• Run time = 10 hours @ 50% load
MAY BE REDUCED BY 10% WHEN USING
• Decibel Rating < 69 db @ 0% load
• Warranty: 2 YEAR Limited Emissions
• Warranty: 1 YEAR Limited
* SURGE WATTS / RUNNING WATTS
sportsmangenerators.com
Need Help? Call Customer Service!
Monday-Friday 8:00-4:00 Central Time

WARNING
Always follow Warning labels placed on the
generator, and read and follow all Warning
labels included inside the Product Manual.
WARNING: NEVER use a generator inside
a home or a garage, EVEN IF the doors
and windows are open.
ONLY USE OUTSIDE and far way from
windows, doors and vents leading into an
enclosed area.
Using a generator indoors can kill you in
minutes. The generator produces an
exhaust that contains carbon monoxide.
This is a poison you cannot see or smell.
Do not attach a chain or rope to secure the
generator to a post as this can be difficult to
remove in the event of an emergency.
IF THERE IS ANY QUESTION ABOUT A
CONDITION BEING SAFE OR UNSAFE,
DO NOT OPERATE THIS PRODUCT!
DO NOT CONNECT electrical devices until AFTER the generator is started.
TOLL-FREE NATIONWIDE HELP LINE! 866-460-9436
GEN4KDF
4,000 Surge / 3,500 Running Watts
Engine
Switch 120V A/C
12V D/C 120V A/C RV AC Reset
D/C Reset
Need Help? Call Customer Service!
Monday-Friday 8:00-4:00 Central Time
www.sportsmanseries.com/generators
POWERED BY UNLEADED
GASOLINE ORPROPANE FUEL
ATTENTION
ALERT!
This generator includes
a built-in Carbon Monoxide
Warning Alert! The generator
will automatically shut-off if
dangerous levels of Carbon
Monoxide i
s detected.
NOTE: The indicator will light RED and the engine will shutdown if
dangerous Carbon Monoxide levels are detected. The engine will not
restart for 5 minutes. If an error in the carbon monoxide system is detected,
the indicator will blink YELLOW and the engine will shutdown for five minutes.
MOVE TO FRESH AIR AND GET MEDICAL HELP IF SICK, DIZZY OR
WEAK. MOVE GENERATOR TO AN OPEN, OUTDOOR AREA.
POINT EXHAUST AWAY. DON’T RUN GENERATOR IN ENCLOSED
AREA (E.G. NOT IN HOUSE OR GARAGE).
Carbon monoxide (also known as CO) can be
dangerous for humans and pets. Carbon monoxide poisoning can lead to death in a
very short time. It is called “the silent killer” because it is odorless, tasteless and
invisible: you may be exposed without knowing it.