Teal HYGIENIUS User manual

Daily cleaning
1. Switch off the unit.
2. Drain the TEALtainer II completely and dispose of
all water to a sluice or foul water drain.
3. Flush out the waste compartment (red cap) with
fresh water.
4. Re-ll the fresh water compartment (white cap).
5. Wipe all surfaces with a soft cloth using a mild
detergent.
6. Switch on and the unit will automatically run a 10
second cold water purge.
Disinfection
It is recommended that your Hygienius is disinfected
every 48 hours. Fill the fresh water compartment, add
500ppm chlorate solution and switch on. After the
automatic 10 second purge, press the purge button.
The unit will run for 5 minutes effectively disinfecting
the complete system. Dispose of all the water and
then ush through with clean water.
Storage
Before placing in storage:-
• Operate the purge button until water ow stops.
• Empty the TEALtainer II completely, clean and
wipe down.
• Ensure that the unit is protected from frost.
HYGIENIUS user manual
Getting started
Your Hygienius provides a hot water hand wash
without external plumbing or drainage. It is entirely
self contained, with the TEALtainer II holding 10 litres
of fresh water. The waste water is contained within
a heavy duty polyethytene bag - when the fresh is
used up the waste bag will be full. The Hygienius
provides up to 50 ten second washes per lling of the
TEALtainer II.
Please note:- The Hygienius has nothing to adjust.
Both the water temperature (approx. 42ºC) and the 10
second wash are factory set.
Unpacking
Check that the component parts and specication are
correct. Check for damage and retain packaging.
Notify Teal immediately if damage is found.
Setup
Disconnect the water delivery pipe from the blue
ringed connector and remove TEALtainer II. Fill with
cold water though the large opening up to the side
indentation. Place the TEALtainer II into the unit and
feed the waste pipe back into the red waste cap hole
and connect up the water delivery pipe.
Connect the 13 amp plug into the 230V mains socket
and switch the unit on by means of the ON/OFF switch
located on the underside of the power box behind the
door. The Bluesensor will light up and the unit will run
a 10 second cold water purge. The Hygienius is now
ready for use.
Operation
To operate, place your hands in the bowl by the
sensor and the Bluesensor will start to ash, indicating
that the water is being heated. After 3-5 seconds, the
Bluesensor will extinguish and the hot water spray will
run for 10 seconds. To reset, remove the hands from
the bowl and the Bluesensor will light up indicating
that your Hygienius is ready for further use.
Purge button
Fresh water
compartment
Bluesensor
TEALtainer II
Fresh water
delivery
connector
Red cap
waste water
bag

HYGIENIUS user manual
Important safety instructions - read rst
Do use only as a hand wash - DO NOT DRINK the
water.
Do use an electrical supply matching the product
rating.
Do get your Hygienius electrically tested annually by a
qualied electrician.
Do unplug before removing the TEALtainer II.
Do only use cold fresh water to ll your TEALtainer II.
Do TAKE CARE when handling the TEALtainer II -
when full it weighs 11KG. If you suffer from a medical
condition that could be adversely effected, GET
ASSISTANCE.
Do dispose of all waste water into a sluice or foul-
water drain
Do disinfect the unit regularly - see cleaning
procedure.
Do not use the unit if it is damaged - contact Teal.
Do not create a trip hazard with the mains cable.
Do not use if the mains cable is damaged - contact
TEAL.
Do not use the Hygienius for the disposal of any other
uids or waste liquids.
Do not throw away packaging - retain for storage.
Do not store your unit in freezing conditions.
TEAL support Monday-Friday 8-5 (Fri 1pm)
Helpline 0121 770 0593
TEAL Patents Ltd, Unit 2 Waterloo Avenue
Chelmsley Wood Industrial Estate, Birmingham B37 6QQ
Tel: [phone]. Fax: [phone]
Email: [email protected] www.tealwash.com
Do not drink Do not operate
without water
Do not freeze
Maintenance and troubleshooting
Problem: The unit will not work and there is
no illuminated blue tap ring.
1. Check that the appliance is plugged into and
switched on to a mains supply that corresponds to
the rating plate at the rear of the unit.
2. Check that the unit itself is switched on. Open the
door and locate the on/off switch on the underside
of the power box. The blue tap indicator will
illuminate and the automatic purge will start.
3. Check the fuse in the plug (use only a 13 Amp fuse
to BS1362). For US models, check the fuse located
next to the on/off switch.
Problem: The unit seems to he working but
there is a reduced/no water ow?
1. Open the door and switch off the unit, unclip and
remove the TEALtainer II. Disconnect the pickup
pipe by pushing the grey tab whilst pulling upwards.
2. If the waste bag is fully inated, empty it into a
sluice or foul water drain. Withdraw the fresh water
pickup pipe and check the lter for obstructions.
New bags and lters are available from Teal.
3. Ensure that the fresh water compartment is lled
with cold fresh water to the side indentation. Take
care when handling the full container. Locate the
TEALtainer II into the unit.
4. Ensure that the pickup pipe connector snaps on to
the white spout. Switch on the unit: it will perform a
10 second cold water purge to prime the system.
5. If water still does not ow, check the tap nozzle for
blockages. Clean with a pin or carefully lever out
and contact Teal for a replacement.
Warranty
TEAL PATENTS LTD warrants that under normal use and correct
maintenance, it will replace at no cost to the customer any defect
in material or workmanship for a period of 2 years from the date of
purchase on a return to factory basis.
Exclusions: Normal use must follow the guidelines given. Repairs
required as a result of incorrect maintenance, accidental damage or
use outside of the recommended parameters. Repairs required as a
result of non-approved third parties maintaining the product, or any
unapproved modications. Repairs required to any unit which has
been parties by a purchaser. See our terms and conditions available
on request.
This does not effect your statutory rights.
Important: always unplug your handwash before inspecting it.
If a problem persists, contact the Teal hotline on [phone].